SUBMISSION FROM CONSTITUENT RE ISSUES WITH FORD F-350 TRUCK (FULL DOCUMENT NOT IMAGED). *SMD THE DEALER HAD THE CONSUMERS VEHICLE FOR 12 DAYS. THE VEHICLE WAS RETURNED TO HIM DAMAGED. WHEN HE ATTEMPTED TO START THE TRUCK, THERE WAS METALLIC ENGINE RATTLE. HE SHUT THE TRUCK OFF AND INSPECTED THE ENGINE, BUT FOUND NO PROBLEM. …
Read full complaint
SUBMISSION FROM CONSTITUENT RE ISSUES WITH FORD F-350 TRUCK (FULL DOCUMENT NOT IMAGED). *SMD THE DEALER HAD THE CONSUMERS VEHICLE FOR 12 DAYS. THE VEHICLE WAS RETURNED TO HIM DAMAGED. WHEN HE ATTEMPTED TO START THE TRUCK, THERE WAS METALLIC ENGINE RATTLE. HE SHUT THE TRUCK OFF AND INSPECTED THE ENGINE, BUT FOUND NO PROBLEM. AS THE CONSUMER DROVE HOME, THE TRUCK STALLED SEVERAL TIMES, THE TRANSMISSION WOULD NOT SHIFT PROPERLY AND THE STEERING WHEEL STARTED TO SHAKE VIOLENTLY AT 30 MPH. THE CONSUMER ALSO STATED THE HEAD LIGHTS DID NOT PROVIDE ADEQUATE LIGHTING OF THE ROAD, THE SEAT BELTS DID NOT RETRACT PROPERLY; THEY WOULD TIGHTENED AS HE WAS DRIVING, WHICH PREVENTED HIM FROM MOVING, THERE CRUISE CONTROL DID NOT ENGAGE PROPERLY, IT WAS DIFFICULT TO MANEUVER THE STEERING WHEEL, THE FUEL GAUGE WAS NOT READING ACCURATELY, THERE WERE NOISES COMING FROM THE DRIVE TRAIN, THE EMERGENCY BRAKE WAS INOPERATIVE, THE VEHICLE SEVERELY PULLED TO THE RIGHT, THE ENGINE LACKED TORQUE AND POWER, THE SUSPENSION WAS NOT ADEQUATE FOR THE VEHICLE, EVERY TIME HE HIT A POT HOLE OR BUMP IN THE ROAD, HE WOULD LOOSE STEERING ABILITY AND THE TIRES WOULD START BOUNCING. IT WOULD TAKE TOO LONG FOR THE VEHICLE TO TAKE OFF, WHEN THE ACCELERATOR WAS APPLIED, THERE WAS AN INSTANT SHUDDER FROM THE VEHICLE, WHEN HE APPLIED THE ACCELERATOR PEDAL. *JB
NHTSA ODI #10652253
68,000 miles · Feb 12, 2014
Exterior Lighting
SINCE 2012 THE LOW BEAM HEADLIGHTS (BOTH SIDES) INTERMITTENTLY TURN OFF. IT HAPPENS WITH THE LIGHT SWITCH TURNED BOTH TO "ON" AND "AUTO". UP UNTIL THIS WEEK, I COULD ALWAYS SWITCH THEM OFF AND BACK ON, OR FROM THE PULLED-OUT POSITION (FOR THE FOG LAMPS TO TURN ON) TO THE PUSHED IN POSITION, AND THE LIGHTS WOULD TURN RIGHT BACK…
Read full complaint
SINCE 2012 THE LOW BEAM HEADLIGHTS (BOTH SIDES) INTERMITTENTLY TURN OFF. IT HAPPENS WITH THE LIGHT SWITCH TURNED BOTH TO "ON" AND "AUTO". UP UNTIL THIS WEEK, I COULD ALWAYS SWITCH THEM OFF AND BACK ON, OR FROM THE PULLED-OUT POSITION (FOR THE FOG LAMPS TO TURN ON) TO THE PUSHED IN POSITION, AND THE LIGHTS WOULD TURN RIGHT BACK ON. THERE APPEARS TO BE NOT PATTERN OF SPEED. I HAVE USED AUTO LAMPS WITH THE LIGHT SENSOR ON THE DASH COVERED UP AND COMPLETELY CLEAR OF ANY BLOCKAGE OF LIGHT. ALL OF A SUDDEN THIS WEEKEND, THE LOW BEAM HEADLIGHTS HAVE COMPLETELY STOPPED WORKING. I CHANGED THE BULBS AND THEY TOO DON'T WORK. THIS ISSUE HAS BEEN BROUGHT TO THE ATTENTION OF THE LOCAL DEALER IN THE PAST WITH NO RESOLUTION. *TR
Palfleet Truck Equipment Company, LLC (Palfleet) is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 super duty vehicles modified by Palfleet and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Palfleet will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on July 29, 2014. Owners may contact Palfleet customer service at 1- 502-376-2458.
Iowa Mold Tooling Co., Inc. will notify owners and dealers to inspect the Muncie PTO pressure switch to determine if it is from the range of defective switches and if required, remove the pressure switch assembly and put a plug in the port where the PTO switch had been installed. This switch was never being utilized. This will be done free of charge. The recall is expected to begin in mid-July 2014. Owners may contact Iowa Mold Tooling Co., Inc. at 1-800-247-5958.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Iowa Mold Tooling Co., Inc. will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on July 28, 2014. Owners may contact Iowa Mold Tooling Co., Inc. at 1-800-247-5958.
Stahl is recalling certain model year 2009-2014 Ford F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty vehicles modified by Stahl and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Stahl will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. Owners may contact Stahl customer service at 1-800-277-8245, or Muncie at 1-800-367-7867.
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-550 vehicles. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Utility Truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in June 2014. Owners may contact Utility Truck customer service at 1-254-857-8813.
Additional source detail variants (2)
Equipment
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-550 vehicles. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Utility Truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in June 2014. Owners may contact Utility Truck customer service at 1-254-857-8813.
Engine And Engine Cooling:engine:gasoline
Utility Truck Equipment Company, LLC (Utility Truck) is recalling certain model year 2010-2013 UTLI41A, 2011 UTLN41, and 2012 UTLN46 aerial trucks manufactured December 2010 to September 2013 equipped with certain Muncie Power Products PTO Assemblies installed on 2010-2013 Ford F-350, F-450 and F-550 vehicles. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Utility Truck will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began in June 2014. Owners may contact Utility Truck customer service at 1-254-857-8813.
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.
Additional source detail variants (2)
Equipment
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.
Engine And Engine Cooling:engine:gasoline
Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.
Tactical Vehicle Outfitters (Tactical) is recalling certain model year 2010-2014 Ford F-350 and F-550 vehicles modified by Tactical and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.
Consequence & remedy
Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.
Remedy: Tactical will notify owners, and dealers will install a new PTO pressure switch, free of charge. The recall began on August 1, 2014. Owners may contact Tactical customer service at 1-405-603-6700.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2010 Ford F-350 Sd Problems, Complaints & Recalls | Skip That Year
Illustration