Service Brakes, Hydraulic. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Suspension. Review the 3 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

1 crash reports0 fire reports1 injury reports

Steering complaints

3 reports

Clear category filter

145,228 miles · Apr 8, 2016

Steering

WHEN DRIVING ABOUT 55 MPH AND HIT A BUMP FRONT END SHAKES VIOLENTLY. (KNOWN AS THE DEATH WOBBLE). HAS HAPPENED 3 TIMES IN PAST MONTH. WE WILL BE TAKING IT TO MECHANIC. AFRAID TO DRIVE IT.

NHTSA ODI #10854446

144,975 miles · Jan 11, 2015

SteeringSuspensionWheels

Read full complaint

HIT ROAD BUMP & THE 'DEATH WOBBLE' OCCURRED CAUSING THE TRUCK TO SHAKE UNCONTROLLABLY & FORCE US TO THE SIDE OF THE ROAD. I TOOK IT TO FORD DEALERSHIP & THEY QUOTED ME OVER $7K TO FIX VIRTUALLY EVERYTHING SUSPENSION RELATED. I TOOK IT 2 LOCAL DIESEL MECHANICS WHO EVENTUALLY FIXED IT AFTER REPLACING APX $700 IN PARTS. THE PART THAT FIXED IT WAS THE TRACK BAR BALL JOINT & TRACK BAR BUSHING. IN SEARCHING ONLINE AMONGST FORD ENTHUSIAST AS WELL AS OTHER DIESEL TRUCK OWNERS....THIS IS A SCARY, DANGEROUS & SOMEWHAT COMMON PROBLEM. FORDS RESPONSE IN A LOT OF INSTANCES IS THAT TIRE PRESSURE, TIRE WEAR, ETC... IS THEIR COMMON RESPONSE. ALL I KNOW IS WITH AS MANY GUYS THAT I'VE SEEN HAD THIS, THIS IS A DESIGN FLAW THAT IS DANGEROUS. IF SOMEONE HASN'T BEEN KILLED BECAUSE OF THIS ALREADY, I'D BE SHOCKED. *TR

NHTSA ODI #10671655

70,000 miles · May 13, 2013

SteeringSuspension

Read full complaint

I AM THE ORIGINAL OWNER OF A 2009 FORD F350 SRW DIESEL CREW CAB. AT APPROXIMATELY 70,000 MILES I BEGAN TO EXPERIENCE A STRONG FRONT END VIBRATION; DEATH WOBBLE. WHEN I GO OVER UNEVEN ROADS AT SPEEDS ABOVE 55 MPH. THE VIBRATION IS SO GREAT THAT THE STEERING WHEEL REQUIRES A TIGHT HOLD TO KEEP CONTROL OF THE TRUCK. THE VIBRATION CONTINUES UNTIL I SLOW DOWN TO AROUND 40 MPH. THIS BECOMES EVEN SCARIER WHEN I AM ON A FREEWAY FLY OVER THAT TURNS AND I HIT AN EXPANSION JOINT. THE TRUCK SHAKES AND TRIES TO PUSH AWAY FROM THE TURN. I TOOK MY TRUCK TO THE DEALER ON FOUR OCCASIONS. THE FIRST VISIT THEY SAID THEY COULD NOT DUPLICATE THE PROBLEM AND THAT I NEEDED NEW TIRES. I BOUGHT NEW TIRES AND IT DID NOT CORRECT THE PROBLEM. I TOOK IT BACK THE SECOND TIME AND THEY CHANGED OUT THE BALL JOINTS, TIE RODS, STEERING DAMPER, DID A FRONT END ALIGNMENT AND BALANCED MY WHEELS. IT SEEMED TO WORK FOR A SHORT TIME UNTIL A PART FELL OFF THE FRONT END OF MY TRUCK AND HIT ANOTHER ONE BEHIND ME IN THE CAR POOL LANE. I TOOK IT BACK TO THE DEALER TO FIND OUT WHAT I LOST. I WAS TOLD A PART FELL OFF BUT THEY DID NOT WORK NEAR IT. FUNNY THING, IT BEGAN TO VIBRATE AGAIN AFTER THAT. I RECENTLY TOOK IT BACK AND TALKED TO THE TECHNICIAN BEFORE I LEFT THE TRUCK SO HE WOULD UNDERSTAND WHAT IT WAS DOING. HE TOOK IT FOR A DRIVE BUT DID NOT GET IT TO VIBRATE AS I REPORTED TO HIM. HE TOLD ME THAT MY TRUCK DRIVES JUST LIKE ALL F350'S WITHOUT A LOAD. I HAVE PUT MY SLIDE IN CAMPER IN THE BED OF MY TRUCK, 3,500 LBS. AND IT STILL VIBRATES VIOLENTLY. I THINK THAT WOULD BE CONSIDERED A LOAD AND IT TRULY FEELS LIKE A DEATH WOBBLE AS DESCRIBED BY MANY INTERNET POSTINGS. THE FORD REP I SPOKE TO SAID THEY ARE NOT AWARE OF ANY PROBLEMS. I AM IN THE PROCESS OF FILING A FORMAL COMPLAINT WITH FORD.

NHTSA ODI #10512156

Official recalls

14V360000 · Equipment

Jun 23, 2014

Palfleet Truck Equipment Company, LLC (Palfleet) is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 super duty vehicles modified by Palfleet and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.

Consequence & remedy

Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

Remedy: Palfleet will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on July 29, 2014. Owners may contact Palfleet customer service at 1- 502-376-2458.

14V328000 · Equipment

Jun 13, 2014

Iowa Mold Tooling Co., Inc. will notify owners and dealers to inspect the Muncie PTO pressure switch to determine if it is from the range of defective switches and if required, remove the pressure switch assembly and put a plug in the port where the PTO switch had been installed. This switch was never being utilized. This will be done free of charge. The recall is expected to begin in mid-July 2014. Owners may contact Iowa Mold Tooling Co., Inc. at 1-800-247-5958.

Consequence & remedy

Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

Remedy: Iowa Mold Tooling Co., Inc. will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began on July 28, 2014. Owners may contact Iowa Mold Tooling Co., Inc. at 1-800-247-5958.

14V327000 · Equipment

Jun 12, 2014

Stahl is recalling certain model year 2009-2014 Ford F-350 Super Duty, F-450 Super Duty, and F-550 Super Duty vehicles modified by Stahl and equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.

Consequence & remedy

Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

Remedy: Stahl will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. Owners may contact Stahl customer service at 1-800-277-8245, or Muncie at 1-800-367-7867.

14V382000 · Engine And Engine Cooling:engine:gasoline; Equipment

Jun 10, 2014

Somerset Welding & Steel, doing business as J&J Truck equipment (J&J), is recalling certain model year 2009-2013 Ford F-350, F-450, and F-550 Super Duty chassis with 6.8L gasoline engines modified by J&J to be equipped with certain Muncie Power Products PTO Assemblies. In the affected vehicles, oil may leak from the PTO pressure switch onto a thermal blanket covering the exhaust.

Consequence & remedy

Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.

Additional source detail variants (2)

Equipment

Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

Remedy: Somerset will notify owners, and dealers will install a new pressure switch kit that moves the switch away from the exhaust system, free of charge. The recall began August 2014. Owner's may contact Somerset customer service at 1-800-777-2671.

Engine And Engine Cooling:engine:gasoline

Consequence: The leaking oil may soak into the thermal blanket covering the exhaust, which when combined with heat from exhaust, may result in an increased risk of fire.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

No exact-year investigations in this snapshot.