IllustrationWHEN STATIONARY EXHAUST FUMES ARE DRAWN INTO CAB OF TRUCK BY THE AIR HANDLING SYSTEM. THIS IS AN ONGOING PROBLEM.
2011 Ford F-250
Owner reports · Recalls · Investigations
More warning signs than most F-250 years
Owner complaints for the 2011 Ford F-250 are substantially higher than the model-year median of 119.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-250 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
390–25K
3525–50K
3750–75K
3275–100K
38100–150K
31150K+
212 reports with mileage · 36 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Suspension. Review the 111 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Steering. Review the 102 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 30 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
6 crash reports3 fire reports1 injury reports
What owners actually said
248 reportsMY TRUCK STARTED SHAKING VIOLENTLY AFTER HITTING A BUMP IN THE ROAD. THE INTERNET CALLS THIS THE DEATH WOBBLE AND APPARENTLY IT IS AFFECTING A LOT OF FORD F250 TRUCKS.
TRUCK DEVELOPED WHAT IS CALLED "DEATH WOBBLE". WHEN I HIT A BUMP ON HIGHWAY, USUALLY AT SPEEDS AROUND 65 MPH THE STEERING WHEEL AND WHOLE TRUCK SHAKE VIOLENTLY UNTIL I SLOW DOWN TO 35. REPLACED TRACKBAR, DRAGLINK, TIE RODS, STEERING DAMPNER, HAD THE FRONT END ALIGNED BY TWO DIFFERENT SHOPS, STILL DOES IT. THIS HAS BEEN HAPPEN…
Read full complaint
TRUCK DEVELOPED WHAT IS CALLED "DEATH WOBBLE". WHEN I HIT A BUMP ON HIGHWAY, USUALLY AT SPEEDS AROUND 65 MPH THE STEERING WHEEL AND WHOLE TRUCK SHAKE VIOLENTLY UNTIL I SLOW DOWN TO 35. REPLACED TRACKBAR, DRAGLINK, TIE RODS, STEERING DAMPNER, HAD THE FRONT END ALIGNED BY TWO DIFFERENT SHOPS, STILL DOES IT. THIS HAS BEEN HAPPENING FOR SEVERAL YEARS, I WILL PUT THE DATE OF THE LATEST BELOW.
WHEN HITTING A BUMP OR A BRIDGE AT SPEEDS IN EXCESS OF 50 MPH THE VEHICLE WOULD GO INTO WHAT IS CALLED A "DEATH WOBBLE" OR SUSTAINED STEERING WHEEL OSCILLATION. THIS WAS MORE LIKELY TO OCCUR WHEN THE FRONT DRIVERS SIDE HIT THE BUMP FIRST OR IN A SLIGHT LEFT HAND TURN WHEN HITTING THE BUMP IN THE ROAD. I HAVE TO IMMEDIATELY LET O…
Read full complaint
WHEN HITTING A BUMP OR A BRIDGE AT SPEEDS IN EXCESS OF 50 MPH THE VEHICLE WOULD GO INTO WHAT IS CALLED A "DEATH WOBBLE" OR SUSTAINED STEERING WHEEL OSCILLATION. THIS WAS MORE LIKELY TO OCCUR WHEN THE FRONT DRIVERS SIDE HIT THE BUMP FIRST OR IN A SLIGHT LEFT HAND TURN WHEN HITTING THE BUMP IN THE ROAD. I HAVE TO IMMEDIATELY LET OFF OF THE THROTTLE AND SOFTLY APPLY THE BREAKS TO ABOUT 25 MPH TO GET THE VERY AGGRESSIVE WOBBLING TO QUIT. DURING WHICH TIME, THE VEHICLE IS VERY DIFFICULT TO CONTROL. I HAVE HAD STABILIZER SHOCKS, TRACK BAR ASSEMBLY, BALL JOINTS, TIRES, ALIGNMENTS, ETC COMPLETED AND STILL EXPERIENCE THIS DEATH WOBBLE ALMOST DAILY. IT APPEARS BY READING ABOUT EVERY FORUM AVAILABLE ONLINE, FORD IS AWARE OF THIS PROBLEM FOR YEARS, BUT HAS FAILED TO DO ANYTHING TO CORRECT THE PROBLEM. (SEE TSB 18-2268) FOR VEHICLES 2017-2019, BUT THIS IS CLEARLY A PROBLEM FOR OLDER MODEL VEHICLE ALSO. SOMEONE IS GOING TO DIE FROM THIS PROBLEM. IT SHOULD BE ADDRESSED.
WHILE DRIVING AT HIGHWAY SPEEDS AND HITTING A ROUGH PATCH OF ROAD, THE VEHICLE WILL START TO SHAKE VIOLENTLY UNTIL I AM ABLE TO PULL OFF TO THE SHOULDER. THIS IS EXTREMELY DANGEROUS AND HAS HAPPENED WHILE TOWING AS WELL AS WITHOUT A LOAD. TRUCK WAS "FIXED" 2 YEARS AGO AND THE PROBLEM WASN'T AS BAD, BUT STILL PRESENT. AFTER A REC…
Read full complaint
WHILE DRIVING AT HIGHWAY SPEEDS AND HITTING A ROUGH PATCH OF ROAD, THE VEHICLE WILL START TO SHAKE VIOLENTLY UNTIL I AM ABLE TO PULL OFF TO THE SHOULDER. THIS IS EXTREMELY DANGEROUS AND HAS HAPPENED WHILE TOWING AS WELL AS WITHOUT A LOAD. TRUCK WAS "FIXED" 2 YEARS AGO AND THE PROBLEM WASN'T AS BAD, BUT STILL PRESENT. AFTER A RECENT TIRE ROTATION, THE PROBLEM RETURNED. THE TRUCK IS CURRENTLY IN THE SHOP WAITING FOR A NEW DIAGNOSIS.
WHEN THE VEHICLE HITS A HARD BUMP IN THE ROAD AT HIGHWAY SPEED, THE FRONT TIRES BEGIN TO WOBBLE. THIS IS CAUSES THE WHOLE VEHICLE TO SHAKE VIOLENTLY AND IT WILL NOT STOP UNTIL THE VEHICLE IS BROUGHT TO A STOP. THE INTERNET CALLS THIS EVENT A DEATH WOBBLE.
THE TRUCK RANDOMLY GOES INTO NEUTRAL FOR VERY EXTENDED AMOUNT OF TIME AND AND HAS NO THROTTLE CONTROL DURING WHILE STANDER-ED DRIVING. THE TRUCK ONLY HAS 61000 MILES ON IT JUST OUT OF WARRANTY AND I HAVE CONTACTED FORD. AND THEY DO NOT HELP
PURCHASED VEHICLE 11-2018 HAVE TAKEN TO TWO SERVICE SHOPS ENGINE KNOCK. METAL IN FILTER. CYLINDER #1 LOW COMPRESSION DUE TO BAD MACHINING OF THE ENGINE BLOCK. VEHICLE NON DRIVABLE.
I CAN NOT GET THIS SOFT BREAK TO GO AWAY! IT NEVER HAD A SOLID BREAK BUT I BOUGHT IT USED AND FIGURED IT NEEDED A BREAK JOB. I HAD CALIPERS TO START LOCKING UP ONE AFTER THE OTHER WITHIN A COUPLE DAYS OF EACH OTHER, SO I REPLACE THEM ALL. THEN THE NEW ONES STARTED GETTING HOT. SO I REPLACE ALL THE BREAK LINES AND MASTER CYL…
Read full complaint
I CAN NOT GET THIS SOFT BREAK TO GO AWAY! IT NEVER HAD A SOLID BREAK BUT I BOUGHT IT USED AND FIGURED IT NEEDED A BREAK JOB. I HAD CALIPERS TO START LOCKING UP ONE AFTER THE OTHER WITHIN A COUPLE DAYS OF EACH OTHER, SO I REPLACE THEM ALL. THEN THE NEW ONES STARTED GETTING HOT. SO I REPLACE ALL THE BREAK LINES AND MASTER CYLINDER. AFTER ALL THAT I STILL HAVE A VERY SOFT BREAK, ALMOST AS IF THERE IS AIR IN THE LINES. I KNOW AIR CAN'T BE THE ISSUE BECAUSE THE BREAK SYSTEM WAS BLEED USING A MACHINE. NOW AFTER DOING RESEARCH ONLINE I HAVE COME ACROSS A LOT OF PEOPLE TALKING ABOUT THIS EXACT ISSUE. THIS NEEDS TO GET FIXED, THERE IS NO WAY TO TELL WHEN YOU ARE ACTUALLY HAVING BREAK ISSUE COME UP BECAUSE THEY FEEL SPONGY WHEN THEY ARE WORKING AT THERE BEST.
THE LEFT REAR BRAKE GETS HOT AND SMOKES AND WONT RELEASE. WE TOOK IT TO OUR FORD DEALERSHIP WHILE IT WAS STILL UNDER WARRANTY. THEY DROVE IT AND SAID THERE WAS NOTHING WRONG WITH IT. WE'VE HAD TO REPLACE THE BRAKES ON THAT TIRE ONLY NOW 3 TIMES. EACH TIME THE BRAKES ARE COMPLETELY WORN THROUGH THE METAL, THE ROTOR HAS HAD TO…
Read full complaint
THE LEFT REAR BRAKE GETS HOT AND SMOKES AND WONT RELEASE. WE TOOK IT TO OUR FORD DEALERSHIP WHILE IT WAS STILL UNDER WARRANTY. THEY DROVE IT AND SAID THERE WAS NOTHING WRONG WITH IT. WE'VE HAD TO REPLACE THE BRAKES ON THAT TIRE ONLY NOW 3 TIMES. EACH TIME THE BRAKES ARE COMPLETELY WORN THROUGH THE METAL, THE ROTOR HAS HAD TO BE REPLACED AS WELL AS THE CALIPERS. AGAIN THIS HAS ONLY HAPPENED WITH THE LEFT REAR TIRE. THE OTHER TIRES HAVE THE ORIGINAL BRAKES ON THEM. SOMETHING HAS BEEN WRONG WITH THIS TIRE SINCE THE TRUCK WAS BRAND NEW.
Official recalls
211V128000 · Electrical System:software
Feb 24, 2011
FORD IS RECALLING CERTAIN MODEL YEAR 2011 FORD F-150, F-250, F-350, F-450, F-550, EDGE, AND LINCOLN MKX TRUCKS MANUFACTURED FROM OCTOBER 25, 2010, THROUGH NOVEMBER 20, 2010. THESE VEHICLES WERE INSPECTED USING INTEGRATED DIAGNOSTIC SYSTEM (IDS) THAT HAD A CUSTOM SOFTWARE ROUTINE TO READ THE SUSPECT BODY CONTROL MODULE (BCM) SERIAL NUMBER. BASED ON THE SERIAL NUMBER THE BCM WAS EITHER NOT AFFECTED OR REPLACED. THE CUSTOM SOFTWARE ROUTINE WAS NOT READING THE CORRECT SET OF CHARACTERS, AND WAS NOT ABLE TO IDENTIFY A BCM THAT REQUIRED REPLACEMENT AFFECTED BCMS MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.
Consequence & remedy
Consequence: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH COULD RESULT IN A VEHICLE FIRE.
Remedy: DEALER WILL INSPECT THE BODY CONTROL MODULE AND IF NECESSARY REPLACE IT FREE OF CHARGE. THE SAFETY RECALL BEGAN ON MARCH 7, 2011. OWNERS MAY CONTACT FORD MOTOR COMPANY CUSTOMER RELATIONSHIP CENTER AT 1-866-436-7332.
10V659000 · Structure:body
Dec 29, 2010
FORD IS RECALLING CERTAIN MODEL YEAR 2011 F-150, F-250, F-350, F-450, F-550, EDGE AND LINCOLN MKX VEHICLES. DURING A SIX-DAY PRODUCTION PERIOD, THE SUPPLIER OF THE BODY CONTROL MODULE MANUFACTURED MODULES THAT MAY HAVE THE POTENTIAL FOR AN INTERNAL SHORT.
Consequence & remedy
Consequence: IF AN ELECTRICAL SHORT DEVELOPS, AN OVERHEATING CONDITION MAY OCCUR WHICH CAN RESULT IN AN UNATTENDED VEHICLE FIRE.
Remedy: DEALER WILL REPLACE THE BODY CONTROL MODULE IF NECESSARY FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 11, 2011. OWNERS MAY CONTACT FORD AT 1-866-436-7332.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ14005 · Vehicle Commanded Engine Shutdown
Opened Jan 13, 2015 · Closed Mar 15, 2016
Status: closed (inferred from source dates) · Electrical System:software; Engine; Engine And Engine Cooling:engine:diesel; Engine And Engine Cooling:exhaust System; Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Additional source detail variants (5)
Electrical System:software
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:engine:diesel
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System:emission Control
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine And Engine Cooling:exhaust System
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.
Engine
The Office of Defects Investigation (ODI) opened this RQ to investigate allegations that the scope and remedy of safety recall 13V-535 were inadequate. Recall 13V-535 was limited to a relatively small population of Ambulance Package vehicles and ODI received complaints of pickup trucks and Fire Engine Prep Package vehicles being affected by the same defect. Ford manufactured approximately 555,985 subject vehicles between February 22, 2010 and January 30, 2015 that may be affected by defective EGT sensors and Powertrain Control Module (PCM) software calibration. The subject vehicles are equipped with four (4) EGT sensors to monitor engine operating conditions. An EGT sensor fault may produce false exhaust over-temperature signals. If these signals are produced, the Powertrain Control Module (PCM) implements a Failure Management Effects Mode (FMEM) and the driver receives a Stop Safely Now (SSN) system warning on the instrument cluster message center. The FMEM triggers a 70% reduction in available engine power over a period of no more than 45 seconds, during which it may not be possible to accelerate or maintain vehicle speed. The PCM then commands the engine to shut down when vehicle speed reaches approximately 1 mph. There is no immediate restart capability. Depending on the PCM software calibration, ignition key position and ambient temperature conditions, the engine may not restart until the end of a 10-60 minute cool down period.Ford and its component supplier(s) made numerous changes to the PCM software calibration and the design, material and manufacture of the EGT sensors over the period of subject vehicle production. This continuous product improvement affected vehicle performance regarding the alleged defect. Ford acknowledges the defect condition in the subject vehicles but argues that an unreasonable risk to motor vehicle safety is limited to Ambulance Package and Fire Engine Prep Package vehicles where commanded shutdown could impact emergency response and patient care. Ford also argues that the defect trend is in decline. Ford also initiated a new safety recall (15V-175) to address the 13V-535 remedy concerns in the Ambulance Package vehicles and Fire Engine Prep Package vehicles. The 15V-175 remedy reprograms the PCM with a new software calibration that stops a single EGT sensor fault to cause the vehicle to enter the FMEM shutdown mode.Ford also initiated an EPA emissions recall (14E03) for all subject vehicles that reprograms the PCM with the software calibration employed in safety recall 15V-175. Finally, Ford initiated a Customer Satisfaction Program (15M01) providing extended warranty coverage of 8 years or 80,000 miles for the the EGT sensors on certain MY2011-2012 subject vehicles.Due to the EPA emissions recall, that had a 66.6% completion rate in Ford's December 2015 progress report to the EPA, the defect trend is in decline. ODI is not aware of any crashes, deaths or injuries related to the alleged defect.ODI believes the alleged defect poses a safety risk but notes that the EPA emissions recall is addressing the safety problem.Compelling issuance of a duplicate recall would not represent a wise use of agency resources.Accordingly, this Recall Query is closed.This action is not a finding that no defect exists and NHTSA will take further action if such action is warranted.