NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
93 reportsClear category filterMileage unknown · Jun 3, 2025
Unknown Or Other
Since my truck was brand new, the infotainment screen very often blacks out so that I can not see navigation, back up camera, radio, etc. It keeps resetting itself until it comes back on. A couple of times when I brought it in for service I asked them to check it out and it was always "Seems to be working fine". Today I backed i…
Read full complaint
Since my truck was brand new, the infotainment screen very often blacks out so that I can not see navigation, back up camera, radio, etc. It keeps resetting itself until it comes back on. A couple of times when I brought it in for service I asked them to check it out and it was always "Seems to be working fine". Today I backed into a sign as the back up camera was frozen and I did not notice that it was not real time. After I hit the sign, the screen went black and then the Ford insigna came up and it repeated 3 times and then everything was fine. Ford service has never been able to fix it as the don't see it when they start the vehicle. I will start taking videos with my phone. Anyway now that the extended warranty just ran out, it is getting worse where it happens almost all the time. I talked to some friends and they tell me they have the same issue so you need to be aware that this dangerous situation might be a common problem.
NHTSA ODI #11664614
Mileage unknown · May 30, 2025
Unknown Or Other
The step bar that come out whenever a door opens ro assist with getting inside the truck does not come out everytime. Sometime the bar will come down once door is open and remain down when the door closes. The bar is supposed to go ba k in once the door is closed. This happens several times in a week.
NHTSA ODI #11663859
Mileage unknown · May 28, 2025
Unknown Or Other
I was driving my 62000 miles truck on the highway while trying to pass another car which was driving slower, I was at a speed close to 60mph, the engine ran at 5000 and I lost power, a truck just behind me has to swerve to avoid me. No warning lamp was on. No accident occurred hopefully. Went to the dealership and they said that…
Read full complaint
I was driving my 62000 miles truck on the highway while trying to pass another car which was driving slower, I was at a speed close to 60mph, the engine ran at 5000 and I lost power, a truck just behind me has to swerve to avoid me. No warning lamp was on. No accident occurred hopefully. Went to the dealership and they said that the issue was caused by a defective transmission. Ford had denied to pay for the repair or replacement as the warranty is a only covering the first 60000 miles.
NHTSA ODI #11663489
Mileage unknown · May 14, 2025
Electrical SystemUnknown Or Other
I drove approx 50 miles. Parked, Return to truck approx 45 mins later and the battery was DEAD. No turn over at all.Called AAA purchased new battery which was installed roadside in a parking lot. Upon starting the engine I noticed the ac was not blowing and hot air only if it did. I took vehicle to Mac Maik Ford. I was told th…
Read full complaint
I drove approx 50 miles. Parked, Return to truck approx 45 mins later and the battery was DEAD. No turn over at all.Called AAA purchased new battery which was installed roadside in a parking lot. Upon starting the engine I noticed the ac was not blowing and hot air only if it did. I took vehicle to Mac Maik Ford. I was told the ac was in need of new parts and $FREON$ ? The repair was approx $4500.00 then add freon fee. I declined. Returned to Gullo Ford where I purchased truck and I was told it would take up to a week or more to leave it for just evaluation. They offered a rental vehicle for $65/ day .i was not going to pay$800 In rental fees to wait for an evaluation not even repair?! I returned home in the hot truck and stopped by the private garage in neighborhood.RUSTYS.They kept it half a day&said upon investigation numerous complaints were filed for the same situation.Rusty stated he would order the part and be completed in abt 3-4 days max>.OK, order parts. I get in the truck after the small independent garage guys went over it in 1/2 a day & THE AC WAS WORKING.I again refused to leave it at Rustys garage. He said he would order the part because site stated numerous ppl had the same thing I had had.battery dying and a/c malfunction combo. IF I HAD NOT BEEN INFORMED OF THE RECALL POTENTIAL OF THE TYPE OF REOCCURRING INCIDENT ON VEHICLES LIKE MINE I WOULD HAVE BEEN RIPPED OFF FOR THOUSANDS!! Rusty ordered the part but kept part b/c my ac is good but tapping the battery? 3 days after his diagnosis being different from the dealers my a/c is still witking..However, The potential remains high for ac failure at this point to reoccur.There is obviously a malfunction in the a/c that kills the battery. I AM NOT THE ONLY PERSON WITH THIS ISSUE. This warrants a recall on whatever it is that drains the battery and kills the a/c function and lets the dealers profit! Please address & recall. Bust the dealers who want THOUSANDS TO FIX THIS TOO! Recall the ripoff...
NHTSA ODI #11660966
Mileage unknown · Apr 28, 2025
EngineUnknown Or Other
Trucks been in to Ford for repairs 38 times for force motor shuts down while driving. Ford wasn’t able to duplicate so they kept blowing me off. Finally morries of Okemos actually drove truck 45 minutes like I requested because it only shuts down after truck warms up. They have got it to finally shut down and have realized the p…
Read full complaint
Trucks been in to Ford for repairs 38 times for force motor shuts down while driving. Ford wasn’t able to duplicate so they kept blowing me off. Finally morries of Okemos actually drove truck 45 minutes like I requested because it only shuts down after truck warms up. They have got it to finally shut down and have realized the panic of not being able to start back up until it’s in park and how dangerous it is to be driving 70 on highway and if you break it does force motor shut down. Ford refuses buy back and vehicles not safe to drive. They still have no answers. At this point I’ve went 245 days without a vehicle while being in and out of shop. Mine isn’t the only one out there. There telling people if they can’t duplicate when they drive it they can’t fix it. Problem is these dealerships aren’t driving consecutive enough to fix it. Thankfully mirrors did thinking I was crazy and dealership says they have never seen this actually happen. Just from talking I know several people with same issue.
NHTSA ODI #11657129
Mileage unknown · Apr 22, 2025
Unknown Or Other
Had ac on on the way out of town when the air from the vents smelled like mold and mildew and the smell is not healthy for any human beings and the ac drain has no elbow on it witch is the cause of water getting back into the system the smell made me sick and called ford and was told I would have to pay for it since it was pass …
Read full complaint
Had ac on on the way out of town when the air from the vents smelled like mold and mildew and the smell is not healthy for any human beings and the ac drain has no elbow on it witch is the cause of water getting back into the system the smell made me sick and called ford and was told I would have to pay for it since it was pass 3 years truck has 29k miles on it should not be making that smell at so little miles it is a health Hazzard
NHTSA ODI #11656207
Mileage unknown · Apr 9, 2025
Unknown Or Other
The plastic clips that hold the keypad on the driver’s side door to the truck have failed allowing access to the trucks wiring and potentially gaining entry to the truck. Concerned with break-ins
NHTSA ODI #11653731
Mileage unknown · Apr 1, 2025
Unknown Or OtherWheels
Ford stated a solution to this would be available Q1 2025, but has not provided one. They had already pushed this back once before. THE WHEEL END HUB BOLT IN THE REAR AXLE MAY BECOME LOOSE OR BREAK. CONTINUED DRIVING WITH A BROKEN BOLT MAY LEAD TO WEAR WITHIN THE AXLE AND DAMAGE THE AXLE HUB SPLINES. THIS MAY INITIALLY RESULT…
Read full complaint
Ford stated a solution to this would be available Q1 2025, but has not provided one. They had already pushed this back once before. THE WHEEL END HUB BOLT IN THE REAR AXLE MAY BECOME LOOSE OR BREAK. CONTINUED DRIVING WITH A BROKEN BOLT MAY LEAD TO WEAR WITHIN THE AXLE AND DAMAGE THE AXLE HUB SPLINES. THIS MAY INITIALLY RESULT IN A CLICKING NOISE AS THE BOLT BECOMES LOOSE AND A RATTLE NOISE FROM THE WHEEL CAP IF THE BOLT BREAKS. VEHICLES WITH DAMAGED AXLE HUB SPLINES MAY ROLL IN PARK WITHOUT THE PARKING BRAKE APPLIED, OR, ALTERNATIVELY, LOSE DRIVE POWER, BOTH OF WHICH MAY INCREASE THE RISK OF INJURY OR A CRASH.
NHTSA ODI #11651997
Mileage unknown · Apr 1, 2025
Unknown Or OtherVisibility/wiper
I was driving to in the morning and my entire rear window randomly shattered and glass flew everywhere in my truck and on me in the drivers seat.
NHTSA ODI #11651974
Mileage unknown · Mar 31, 2025
Unknown Or Other
The factory-installed panoramic sunroof mesh air deflector is causing a water drainage issue. Water accumulates in the main channels, saturating the mesh and allowing it to retain moisture for an extended period. This prolonged dampness leads to mold growth, creating a health concern due to the mold odor inside the cabin after a…
Read full complaint
The factory-installed panoramic sunroof mesh air deflector is causing a water drainage issue. Water accumulates in the main channels, saturating the mesh and allowing it to retain moisture for an extended period. This prolonged dampness leads to mold growth, creating a health concern due to the mold odor inside the cabin after any rainstorm.
NHTSA ODI #11651680
Official recalls
29Jul 28, 2026
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Additional source detail variants (2)
Back Over Prevention:display Function
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 and 2023-2026 F-250 SD vehicles equipped with 8-inch SYNC infotainment screens. A software error may cause the rearview camera image to be obstructed by the infotainment home screen menu when the vehicle is placed in reverse. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence: An obstructed rearview camera image can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air (OTA) update, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 7, 2026. Additional letters will be sent once the remedy is available, anticipated in September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C37. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 31, 2026.
Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Consequence & remedy
Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
Feb 20, 2026
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Additional source detail variants (2)
Exterior Lighting:tail Lights
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Electrical System: Integrated Trailer Brake Control
Ford Motor Company (Ford) is recalling certain 2021-2026 F-150, 2022-2026 F-250 SD, F-350 SD, F-450 SD, F-550 SD, Maverick, 2024-2026 Ranger, 2023-2026 F-600 SD, 2022-2027 Lincoln Navigator, Expedition, and 2026 E-Transit vehicles. When towing a trailer, the integrated trailer module (ITRM) may lose communication with the vehicle, possibly causing a loss of brake and turn signal lights, or a loss of brake function. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence: Trailer lights or brakes that do not function can reduce the driver’s ability to control the trailer and decrease the trailers visibility to other road users, increasing the risk of a crash.
Remedy: The integrated trailer module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 25, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C10. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 17, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 Expedition, Lincoln Navigator, 2021-2023 F-150, 2022 F-250 SD, F-350 SD, and F-450 SD vehicles. The moonroof wind deflector clips may be inadequately attached to the moonroof frame, which can result in the wind deflector detaching from the vehicle.
Consequence & remedy
Consequence: A detached wind deflector can become a road hazard and increase the risk of a crash.
Remedy: Dealers will inspect and repair the moonroof wind deflector as necessary, free of charge. Owner notification letters were mailed November 10, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SB7. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning October 30, 2025.
Jul 7, 2025
Ford Motor Company (Ford) is recalling certain 2021-2023 Bronco, Explorer, Lincoln Aviator, F-250 SD, F-350 SD, F-450 SD, F-550 SD, 2021-2022 Lincoln Navigator, Mustang, F-150, and 2022 Expedition vehicles. The low-pressure fuel pump may fail, which can result in an engine stall while driving.
Consequence & remedy
Consequence: An engine stall increases the risk of a crash.
Remedy: Dealers will replace the low pressure fuel pump on super duty vehicles and update the powertrain control module (PCM) software on all other affected vehicles, free of charge. Owner notification letters were mailed July 27, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S75.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature that were repaired incorrectly under recall 24V443. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.
Consequence & remedy
Consequence: Inoperative reverse lights may fail to alert others that the vehicle is reversing, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed on June 27, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S57.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2021-2024 Bronco, F-150, 2021-2024 Edge, 2022-2025 Escape, F-250, F-350, F-450, F-550, F-600, 2022-2024 Expedition, 2022-2025 Transit, 2021-2023 Mach-E, 2024 Ranger, Mustang, 2021-2023 Lincoln Nautilus, 2022-2024 Navigator, and 2023-2024 Corsair vehicles. A software error may cause the rearview camera image to delay, freeze, or not display when the vehicle is in reverse.
Consequence & remedy
Consequence: A frozen or missing rearview camera image can reduce the driver's view behind the vehicle, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated by a dealer or through an over-the-air update, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters notifying owners of the safety risk were mailed on June 26, 2025. Additional letters will be mailed once the final remedy is available on each phase. Owner notification letters were sent on October 8, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S49.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles previously repaired incorrectly under recall number 22V-188. The Diagnostic Trouble Code (DTC) for low transmission fluid pressure may falsely activate and cause the transmission to unexpectedly shift into neutral.
Consequence & remedy
Consequence: An unexpected shift into neutral will cause a loss of drive power and increase the risk of a crash.
Remedy: Dealers will update the Powertrain Control Module (PCM) software, free of charge. Owner notification letters were mailed April 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S24.
Feb 28, 2025
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles previously repaired incorrectly under recall number 22V-193. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality can extend the distance required to stop, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S18.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Aug 23, 2024
Ford Motor Company (Ford) is recalling certain 2021-2022 Bronco, F-150, Edge, Explorer, Lincoln Nautilus, and Lincoln Aviator vehicles equipped with either a 2.7L or 3.0L Nano EcoBoost engine. The engine intake valves may break while driving, which can result in engine failure and a loss of drive power.
Consequence & remedy
Consequence: A loss of drive power increases the risk of a crash.
Remedy: Dealers will perform an engine cycle test and replace the engine as necessary, free of charge. Owner notification letters were mailed July 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S55.
Jun 14, 2024
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.
Consequence & remedy
Consequence: Disabled reverse lights cannot alert others that the vehicle is reversing, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters are were mailed June 26, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S38.
Additional source detail variants (2)
Electrical System:body Control Module:software
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.
Consequence: Disabled reverse lights cannot alert others that the vehicle is reversing, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters are were mailed June 26, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S38.
Exterior Lighting:back Up Lights
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles equipped with the Onboard Scales feature. An over-the-air software update to the body control module (BCM) may have disabled both reverse lights.
Consequence: Disabled reverse lights cannot alert others that the vehicle is reversing, increasing the risk of a crash.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters are were mailed June 26, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S38.
Dec 22, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with the Trailer Tow Max Duty package and a 9.75-inch heavy duty axle with a 3/4 float axle design. The rear axle hub bolt may fatigue and break, which can result in damage to the axle hub splines.
Consequence & remedy
Consequence: Damaged axle hub splines can result in a vehicle rollaway when the vehicle is in park without the parking brake applied or cause a loss of drive power. Both of these conditions can increase the risk of a crash.
Remedy: Dealers will replace the left and right rear axle shaft assemblies, free of charge. Owner notification letters were mailed on May 9, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S65.
Jul 21, 2023
Ford Motor Company (Ford) is recalling certain 2021-2023 F-150 vehicles equipped with a single exhaust system. Contact with the rear axle housing may damage the wiring harness, causing the electric parking brake to activate unexpectedly.
Consequence & remedy
Consequence: Unexpected activation of the electric parking brake while driving increases the risk of a crash.
Remedy: Dealers will install a protective tie strap, tape wrap, and replace the harness as necessary, free of charge. Owner notification letters were mailed February 12, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S35.
Mar 10, 2023
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the wiper arms, as necessary, free of charge. Owner notification letters were mailed December 13, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23S10. This recall expands previous recall number 22V-250.
Nov 15, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will replace the front windshield wiper motor, free of charge. Owner notification letters were mailed June 30, 2023. Remedy parts are expected in the 3rd Quarter of 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S71. This recall expands previous recall number 22V-142.
Aug 12, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios increases the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft, as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed September 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S53.
Jun 10, 2022
Ford Motor Company (Ford) is recalling one 2021 F-150 vehicle. A single vehicle may have been assembled without a fuel tank front attachment resulting in an unsecured fuel tank attachment strap.
Consequence & remedy
Consequence: An improperly attached fuel tank increases the risk of a fuel leak and potential for fire.
Remedy: Dealers will inspect and repair (if necessary) the fuel tank strap bracket, free of charge. Owner notification letters were mailed July 1, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S42.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The Diagnostic Trouble Code (DTC) for low transmission fluid pressure may falsely activate and cause the transmission to unexpectedly shift into neutral.
Consequence & remedy
Consequence: An unexpected shift into neutral will cause a loss of drive power and increase the risk of a crash.
Remedy: Dealers will update the Powertrain Control Module (PCM) software, free of charge. Owner notification letters were mailed on April 12, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S15.
Mar 25, 2022
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150, 2022 Maverick, Expedition, Lincoln Navigator, F-250, F-350, F-450, and F-550 vehicles. Due to a software error, a towed trailer equipped with an electric or electric-over hydraulic brake system may not brake.
Consequence & remedy
Consequence: Loss of trailer brake functionality could result in extended stopping distance, increasing the risk of a crash.
Remedy: Dealers will update the integrated trailer brake control module software, free of charge. Owner notification letters were mailed April 22, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S17.
Mar 11, 2022
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The front windshield wiper motor may become inoperative, causing the wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain conditions, increasing the risk of a crash.
Remedy: Dealers will replace the front windshield wiper motor, free of charge. Owner notification letters were mailed June 22, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S12.
Dec 16, 2021
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence & remedy
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.
Additional source detail variants (2)
Structure:frame And Members:underbody Shields
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.
Power Train:driveline:driveshaft
Ford Motor Company (Ford) is recalling certain 2021-2022 F-150 vehicles. Underbody heat and noise insulators may loosen and contact the aluminum driveshaft, which could damage the driveshaft and cause it to fracture.
Consequence: A fractured driveshaft can cause a loss of drive power, or a loss of vehicle control if the driveshaft contacts the ground. Additionally, unintended movement could occur while parked if the parking brake is not engaged. Any of these scenarios can increase the risk of a crash.
Remedy: Dealers will inspect and repair the driveshaft as necessary, and properly attach the underbody insulators, free of charge. Owner notification letters were mailed February 4, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S56.
Oct 15, 2021
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence & remedy
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Additional source detail variants (2)
Air Bags:sensor:side Impact
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Air Bags:side/window
Ford Motor Company (Ford) is recalling certain 2022 Super Duty F-250, F-350, 2021 F-150, Expedition, and Lincoln Navigator vehicles. The front-door side impact pressure sensor modules may have been damaged during supplier assembly, which can cause the side impact air bags to not deploy properly in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 214, "Side Impact Protection."
Consequence: An air bag that does not deploy properly during a crash increases the risk of injury.
Remedy: Dealers will replace the driver and passenger front door side impact sensors, free of charge. Owner notification letters were mailed November 3, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C26.
Aug 23, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 Super Cab vehicles. The front seatbelt webbing may be incorrectly routed.
Consequence & remedy
Consequence: A misrouted seatbelt may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Owners are advised to perform a preliminary self-inspection of the front seatbelts. If the passenger-side seatbelt fails inspection, owners should not use the passenger seat until the repair is performed. If the driver-side seatbelt fails inspection, owners should not drive their vehicle until the repair is performed. Dealers will inspect the front seatbelts and, if the webbing is misrouted, will replace the seatbelt retractor and pretensioner, free of charge. Owner notification letters were mailed on October 14, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C20.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The electronic brake booster may leak brake fluid into the electronic control unit, which could result in reduced braking performance.
Consequence & remedy
Consequence: Reduced braking performance can increase the risk of a crash.
Remedy: Dealers will replace the electronic brake booster assembly, free of charge. Owner notification letters were mailed on July 28, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S33.
May 29, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The steering gear may have internal damage, which could result in difficulty steering, or the inability to rotate the steering wheel while driving.
Consequence & remedy
Consequence: Loss of steering control can increase the risk of a crash.
Remedy: Owners are advised to not drive their vehicles until the repair is complete. Vehicles will be towed in for service, and dealers will remove and replace the steering gear, free of charge. Owner notification letters were mailed on June 4, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S28.
Additional source detail variants (3)
Steering:rack And Pinion
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The steering gear may have internal damage, which could result in difficulty steering, or the inability to rotate the steering wheel while driving.
Consequence: Loss of steering control can increase the risk of a crash.
Remedy: Owners are advised to not drive their vehicles until the repair is complete. Vehicles will be towed in for service, and dealers will remove and replace the steering gear, free of charge. Owner notification letters were mailed on June 4, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S28.
Steering:gear Box (other Than Rack And Pinion)
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The steering gear may have internal damage, which could result in difficulty steering, or the inability to rotate the steering wheel while driving.
Consequence: Loss of steering control can increase the risk of a crash.
Remedy: Owners are advised to not drive their vehicles until the repair is complete. Vehicles will be towed in for service, and dealers will remove and replace the steering gear, free of charge. Owner notification letters were mailed on June 4, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S28.
Steering
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The steering gear may have internal damage, which could result in difficulty steering, or the inability to rotate the steering wheel while driving.
Consequence: Loss of steering control can increase the risk of a crash.
Remedy: Owners are advised to not drive their vehicles until the repair is complete. Vehicles will be towed in for service, and dealers will remove and replace the steering gear, free of charge. Owner notification letters were mailed on June 4, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S28.
May 24, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 vehicles. The two-piece driveshafts may have been improperly assembled, which could result in driveshaft separation.
Consequence & remedy
Consequence: Driveshaft separation may result in a sudden loss of drive power, or unintended vehicle movement if the vehicle is in park without the parking brake applied, increasing the risk of a crash.
Remedy: Dealers will inspect the driveshaft, and replace it if necessary, free of charge. Owner notification letters were mailed on June 15, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S25.
Feb 18, 2021
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence & remedy
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Additional source detail variants (2)
Visibility:windshield:critical Fasteners
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Visibility:windshield
Ford Motor Company (Ford) is recalling certain 2021 F-150 and 2020-2021 F-250, F-350, F-450, and F-550 Super Duty vehicles. During manufacturing, the windshield may not have been properly bonded to the vehicle, allowing it to detach in a crash. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 212, "Windshield Mounting."
Consequence: In the event of a crash, if the windshield separates from the vehicle, it can increase the risk of injury.
Remedy: Ford will notify owners, and dealers will remove and reinstall the windshield, free of charge. The recall began April 16, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21C06.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1EA23002 · Loss Of Motive Power
Opened Sep 29, 2023 · Closed Oct 31, 2024
Status: closed (inferred from source dates) · Engine
On July 22, 2022, the Office of Defects Investigation (ODI) granted a Defect Petition (DP22001) and opened a Preliminary Evaluation (PE22007) to investigate allegations of loss of motive power in model year (MY) 2021 Ford Bronco vehicles equipped with 2.7L EcoBoost engines. Complainants were reporting sudden engine failure while driving resulting in a loss of motive power, often without the ability to restart. During PE22007, the cause of engine failure and loss of motive power in the subject vehicles was determined to be intake valve fracture, and the full scope of vehicles affected by the subject defect was identified as all MY 2021-2022 Ford and Lincoln models equipped with either the 2.7L or 3.0L EcoBoost engines, referred to as the “Nano” engine family. If an intake valve fractures in the subject engines, it may drop into the cylinder and contact the piston, often resulting in catastrophic engine damage. On September 29, 2023, PE22007 was upgraded to an Engineering Analysis (EA23002) to further investigate the subject defect across the full scope of affected vehicles. During EA23002, ODI visited Ford facilities to review technical information related to intake valve fracture in “Nano” engines, coordinated with NHTSA’s Vehicle Research and Testing Center (VRTC), and analyzed updated field data relating the subject defect. Forensic analysis of fractured intake valves demonstrated that the defective components exhibited “grinding burn” or out of specification hardness in the area of the keeper grooves. The presence of grinding burn is evidence that during the groove grinding phase of production, the temperature of the valve became sufficiently high to alter the microstructure of the material and is indicative that the valve supplier’s manufacturing processes were not within control specifications. Grinding burn results in a hard, brittle microstructure and high residual stresses toward the surface of the valve. Through normal engine loading, a valve with grinding burn will likely fracture at the area of highest vulnerability, which is the third keeper groove. In its response to the EA23002 Information Request (IR) letter, Ford provided evidence of 396 customer complaints (including field reports), 825 warranty claims, and 936 engine exchanges. When considering both ODI and manufacturer failure report data, there have been reports representing 1066 unique vehicles within the subject vehicle population. Analysis of the failure report data demonstrates that vehicles equipped with potentially defective intake valves were built within a production “spike period” of May 2021 – October 2021. The beginning of the spike period corresponds to a ramp up in production at the valve supplier manufacturing facility, and the end of the spike period aligns with the implementation of several mid-production process improvements and the decision to change the metal alloy used to produce intake valves from “Silchrome Lite” to “Silchrome 1”. Ford began investigating the subject defect in July 2021, determined the root cause, and took corrective measures for the new production vehicles. Analysis of the failure report data demonstrates that these corrective actions were successful in eliminating the risk of intake valve fracture for subject vehicles produced after October 2021. However, Ford did not take any field action to address vehicles produced during the spike period, and in the several months following the implementation of the production changes, a significant number of field failures continued to occur. It is Ford’s assessment that not all valves produced during the spike period are defective, and that failures associated with the subject defect occur at low time in service. Analysis of the failure report data demonstrates that the vast majority of failures have occurred before 20,000 miles with over half of all reported failures occurring before 5,000 miles. The rate of reported failures related to the subject defect has steadily decreased since November 2021. ODI coordinated with NHTSA’s National Center for Statistics and Analysis (NCSA) to conduct statistical analysis and predict the number of future failures associated with the subject defect. The results of this analysis, and the trends identified through the failure report data are generally consistent with Ford’s assessment that defective intake valves will likely fail at a low time in service and indicate that the majority of subject vehicles equipped with defective valves have already experienced a failure. On August 23, 2024, Ford submitted recall 24V635 for subject vehicles equipped with “Nano” engines and built within the production spike period identified above (total population 90,736 vehicles). The remedy includes an inspection at a Ford/Lincoln dealership where the lifetime engine cycles of the vehicle will be determined. If a vehicle does not meet a threshold for lifetime engine cycles, the dealership will conduct a high RPM engine cycle accumulation procedure, which aims to identify if the vehicle is equipped with defective intake valves. Any vehicle that fails the accumulation procedure will receive an engine replacement under the recall. In addition to recall 24V635, Ford has stated that it will launch customer satisfaction campaign 24N12, which will provide extended warranty coverage to the subject vehicles through the earlier of 10 years or 150,000 miles. In view of the recall action being taken by Ford, ODI is closing this Engineering Analysis. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
Illustration