NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
724 reportsMileage unknown · Mar 26, 2025
Power Train
DURING MAINTENANCE PRIOR TO THE MAIN ISSUE STATED TO FORD, CUSTOMER NOTICED SOMETHING WAS WRONG WITH TRANS AND MECHANIC REPORTED IT WAS FINE AND DIDNT SEE ANYTHING ON THEIR COMPUTER AND THAT THE CUSTOMER COULD WAIT UNTIL 90K MILE UPCOMING MAINTENANCE. CUSTOMER STATES CHECK ENGINE LIGHT CAME ON WHILE DRIVING AND THE TRUCK WAS SHI…
Read full complaint
DURING MAINTENANCE PRIOR TO THE MAIN ISSUE STATED TO FORD, CUSTOMER NOTICED SOMETHING WAS WRONG WITH TRANS AND MECHANIC REPORTED IT WAS FINE AND DIDNT SEE ANYTHING ON THEIR COMPUTER AND THAT THE CUSTOMER COULD WAIT UNTIL 90K MILE UPCOMING MAINTENANCE. CUSTOMER STATES CHECK ENGINE LIGHT CAME ON WHILE DRIVING AND THE TRUCK WAS SHIFTING ROUGH / WHEN PULLING AWAY FROM A STOP THE TRUCK WOULD REV UP AND NOT GO FORWARD THEN DELAYED ENGAGEMENT / ALSO WHEN DRIVING AT HIGHWAY SPEED THE TRUCK HAS DIFFICULTY ACCELERATING SMOOTHLY IN PASSING GEARS VERIFIED THE CONCERN. PERFORMED SELF TEST AN FOUND P07F7 INCORRECT 10 GEAR RATIO. PERFORMED TEST DRIVE AND FOUND THE SHIFT FLARE EXCEEDING 290RPMS AN SPEC IS 0-10RPMS. ALSO FOUND THE TORQUE CONVERTER SLIPPING OVER 270RPMS DURING LOCK UP. MONITORED LINE PRESSURE TEST AN FOUND IT IS WITHIN SPEC. INSPECTED FLUID CONDITION AN AN FOUND EXCESSIVE SIGNS OF METAL DEBRIS PRESENT. DUE TO INTERNAL TRANSMISSION FAILURE RECOMMEND REPLACING UNIT AN RETEST.
NHTSA ODI #11650677
Mileage unknown · Mar 25, 2025
Power Train
While traveling 65 mph on highway, truck shifted from 10th gear to 5th causing truck to jerk to a slower mph and raising rpms
NHTSA ODI #11650632
Mileage unknown · Mar 25, 2025
Power Train
This truck when shifting from 4th to 5th will snap your neck! sometimes it just slips in gear., when I back up ity will stop like its in neutral and then bang into gear. sometimes you pull out on the road and it will not go just sit in neutral then bank in gear and take off. This is totally unsafe with this 10 speed trans.
NHTSA ODI #11650411
Mileage unknown · Mar 25, 2025
Power Train
While driving on a high traffic street in stop and go traffic truck shifted down from 3 to 2 with a lurch and a verry loud clunk. Truck shifted so hard there was rapid deacceleration and lurching and a loud clunking while shifting.
NHTSA ODI #11650392
Mileage unknown · Mar 24, 2025
Power Train
On [XXX] I [XXX] started my truck and left my job at Publix Supermarket in Lake City, Fl. As I turned out of the shopping plaza, My 2020 Ford F-150 felt like it was about to lose power. As I turned into [XXX]. The truck shifted from the first gear, to the second smoothly, as the truck shifted from 2-3 , the truck revved and did…
Read full complaint
On [XXX] I [XXX] started my truck and left my job at Publix Supermarket in Lake City, Fl. As I turned out of the shopping plaza, My 2020 Ford F-150 felt like it was about to lose power. As I turned into [XXX]. The truck shifted from the first gear, to the second smoothly, as the truck shifted from 2-3 , the truck revved and did not engage into 3rd gear. I let off the gas thinking it was going to catch the next gear and continue to increase speed. but it did not, again it revved and did not engage into 3rd gear. now the traffic was flying past me, i pushed the accelerator to the floor in attempt to avoid an accident. and not get rear ended. After several seconds , the transmission engaged and the truck began to move forward at a slow pace. This is when i received a notification for Ford Pass app, saying the power train malfunction/ reduced power. I was able to get the truck to the closest gas station. where I shut it off. After several minutes, I restarted the truck and drove back to work with no issues. The next day I took it to a local shop, where they indicated that I needed a new transmission. Since then, this vehicle has been in the shop multiple times for the same issue. This will be the 3rd Valve body replaced. Its unsafe to be on the road. Its a safety hazard. INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11650359
Mileage unknown · Mar 24, 2025
Power Train
Erratic down shifts stalls at lights
NHTSA ODI #11650319
35,000 miles · Mar 24, 2025
Power Train
The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission hesitated and made an abnormal clunking sound. In addition, the rear of the vehicle was shaking ab…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed; however, the vehicle failed to accelerate as intended. The contact stated that the transmission hesitated and made an abnormal clunking sound. In addition, the rear of the vehicle was shaking abnormally. The vehicle was taken to the dealer; however, the failure was not duplicated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The contact stated that the vehicle was taken to the dealer several times due to the failure. The contact stated that the transmission was rebuilt in 2023. In addition, the contact stated that the PCM was reprogrammed in 2022. The manufacturer was made aware of the failure, and a case was filed. The failure mileage was approximately 35,000.
NHTSA ODI #11650189
Mileage unknown · Mar 24, 2025
Power Train
Vehicle is equipped with the 10r80 ( ten speed ) transmission. Vehicle hard shifts and hard down shifts. It also searches for gears so if I am in cruise control or driving approx 55 the vehicle will drop out of gear, search for a gear then slam back into the correct gear; at random
NHTSA ODI #11650162
Mileage unknown · Mar 24, 2025
Power Train
In these vechicals it has a 10 speed transmission. from what I was told ford knows about a problem with it shiften hard and down shiften even harder. ford says all they can do is reset the computer in it, but isn't going to help with the problem. something needs to be done.
NHTSA ODI #11650134
40,000 miles · Mar 21, 2025
Electrical System
The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the instrument cluster failed to function as intended. The contact stated that the instrument cluster displayed a black screen. The vehicle was taken to the dealer where it was diagnosed with a failed instrument cluster. The conta…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the instrument cluster failed to function as intended. The contact stated that the instrument cluster displayed a black screen. The vehicle was taken to the dealer where it was diagnosed with a failed instrument cluster. The contact was informed that the instrument cluster needed to be replaced. The vehicle was not repaired. The contact stated that the dealer had replaced the original instrument cluster two years prior to the failure. The contact stated that the repair was covered under warranty. The manufacturer was not made aware of the failure. The failure mileage was approximately 40,000.
NHTSA ODI #11649815
Official recalls
11Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.
Consequence & remedy
Consequence: Electrical arcing can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Dec 18, 2019
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence & remedy
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Additional source detail variants (2)
Tires:temporary/emergency Spare Tire
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Tires:bead
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration