NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
724 reportsMileage unknown · Feb 4, 2026
Power Train
While driving my 2020 Ford F-150 on the highway, the transmission suddenly failed, causing loss of normal drivability and creating an immediate safety concern due to reduced vehicle control at highway speeds. The failure involved the transmission system, which I later learned may be related to Ford’s recall notice stating that t…
Read full complaint
While driving my 2020 Ford F-150 on the highway, the transmission suddenly failed, causing loss of normal drivability and creating an immediate safety concern due to reduced vehicle control at highway speeds. The failure involved the transmission system, which I later learned may be related to Ford’s recall notice stating that the installed remanufactured transmission may be missing an internal bearing. Prior to the complete failure, the vehicle exhibited symptoms consistent with the recall, including harsh shifting, shuddering, and vibration. These symptoms escalated until the transmission malfunctioned to the point the vehicle was no longer safely operable, requiring me to tow the truck to Rocklin Transmission. The transmission was replaced out of pocket by that independent service center, and the failed component should be available for inspection upon request through that facility. The malfunction created a serious safety risk because the transmission could become stuck in certain gears, illuminate the check engine light, or potentially fail to properly engage Park, all of which increase the risk of a crash or injury. The issue was confirmed by the independent repair facility when diagnosing and replacing the transmission. The vehicle has not been inspected by Ford or other representatives prior to the repair because the failure required immediate corrective action to restore safe vehicle operation.
NHTSA ODI #11715707
Mileage unknown · Feb 4, 2026
Power Train
Transmission (10r80) down shifts hard and shifts hard between 3-4 and 7-8 gears. And front differential makes a noise.
NHTSA ODI #11715672
Mileage unknown · Feb 3, 2026
Power Train
The transmission exhibits violent, harsh shifting, sudden and unpredictable deceleration, and most alarmingly, abrupt downshifting from 10th gear to 1st gear while driving at highway speeds. This is not a minor drivability issue — it is a severe safety defect that places my life, my passengers, and other drivers at risk.
NHTSA ODI #11715314
Mileage unknown · Feb 2, 2026
Power Train
Truck would downshift so hard it would squeak tires. Took to dealer they replaced transmission saying the drum comes loose inside and oil passages do not line up. This year should be part of your investigation
NHTSA ODI #11715136
Mileage unknown · Feb 1, 2026
EnginePower Train
I am writing to provide supplemental information regarding my existing safety complaints (IDs XXXand XXX). This update concerns a documented failure by Ford’s authorized dealer network to perform mandated Customer Satisfaction Programs (CSPs) that directly correlate to the catastrophic powertrain failures I have experienced. Tim…
Read full complaint
I am writing to provide supplemental information regarding my existing safety complaints (IDs XXXand XXX). This update concerns a documented failure by Ford’s authorized dealer network to perform mandated Customer Satisfaction Programs (CSPs) that directly correlate to the catastrophic powertrain failures I have experienced. Timeline and Documentation of Failure: • August & September 2025: As previously reported, my vehicle suffered sudden "Reduced Power" malfunctions while in motion (P0734/P07F7), leading to a full transmission replacement. Discovery of Non-Disclosure: My records now confirm that on November 11, 2022—just weeks before I purchased this vehicle as a Ford Blue Advantage Gold Certified unit—CrossRoads Ford (Dunn, NC) documented that 21N03 (Cam Phasers), 21N08 (PCM Reprogram), and 21M06 (Tailgate) were outstanding. • Breach of Duty: Despite this knowledge, the dealership sold me the vehicle on December 3, 2022, without completing these safety-related service actions. Furthermore, as the registered owner, I never received the required notification from Ford Motor Company regarding the 21B10 program or its supplements. Safety Implication: The failure to apply the 21B10/21N08 updates directly contributed to the mechanical failure of the cam phasers and transmission. This resulted in the vehicle entering "Limp Mode" during highway operation, creating a severe risk of rear-end collisions due to the sudden loss of motive power. I request that these facts be added to my existing case files. The lack of manufacturer oversight regarding "Certified" vehicle standards has resulted in a vehicle that was represented as safe and fully maintained while actually harboring known, unaddressed mechanical defects.INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11714853
Mileage unknown · Jan 28, 2026
Visibility/wiper
Wiper blades are going very slow/failing like other model years/recalls.
NHTSA ODI #11713815
Mileage unknown · Jan 26, 2026
Power Train
transmission unexpectedly downshifting to first gear at speed. It sounds like shift cable locking clip problem.
NHTSA ODI #11713358
117,000 miles · Jan 22, 2026
Power Train
The contact owns a 2020 Ford F-150. The contact stated that while driving at various speeds and attempting to shift into third gear, the vehicle started shaking abnormally, and the gear shift was difficult to engage, causing the transmission to shift hard. The contact stated that at faster speeds, while attempting to shift into …
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while driving at various speeds and attempting to shift into third gear, the vehicle started shaking abnormally, and the gear shift was difficult to engage, causing the transmission to shift hard. The contact stated that at faster speeds, while attempting to shift into seventh gear, there was a delayed response. The powertrain fault warning light was illuminated. A dealer was contacted. The vehicle was taken to the dealer where it was diagnosed and determined that the transmission needed to be replaced. The vehicle was not repaired. The contact related the failure to Technical Service Bulletin: 23-2123 (Harsh/Delayed Engagement And/or Harsh/Delayed Shift); however, the VIN was not included in the TSB. The manufacturer was not notified of the failure. The failure mileage was 117,000.
NHTSA ODI #11712780
49,244 miles · Jan 21, 2026
Power Train
The contact owns a 2020 Ford F-150. The contact stated while driving from a complete stop, the vehicle went into LIMP Mode and failed to accelerate as intended. After a while, the vehicle accelerated, but the acceleration was delayed. The wrench warning light illuminated, and the contact received a notification from the Ford App…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated while driving from a complete stop, the vehicle went into LIMP Mode and failed to accelerate as intended. After a while, the vehicle accelerated, but the acceleration was delayed. The wrench warning light illuminated, and the contact received a notification from the Ford App with the message “Powertrain Power Reduced”. The contact drove the vehicle to a dealer, where it was diagnosed that the transmission had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The failure mileage was approximately 49,244.
NHTSA ODI #11712496
55,000 miles · Jan 13, 2026
Engine
The contact’s father owns a 2020 Ford F-150. The contact stated that the check engine warning light was illuminated. While driving at various speeds and accelerating or while idling, the vehicle bucked or jerked. The vehicle failed to accelerate intermittently, causing the driver to make several attempts to restart the vehicle, …
Read full complaint
The contact’s father owns a 2020 Ford F-150. The contact stated that the check engine warning light was illuminated. While driving at various speeds and accelerating or while idling, the vehicle bucked or jerked. The vehicle failed to accelerate intermittently, causing the driver to make several attempts to restart the vehicle, depress the accelerator, and allow the engine to cool down for the vehicle to accelerate as needed. There was a loud grinding and knocking sound coming from the engine compartment. The vehicle was taken to the dealer, who diagnosed that the engine had failed and needed to be replaced. The vehicle was not repaired. The manufacturer was informed of the failure, and a case was opened. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was approximately 55,000.
NHTSA ODI #11710628
Official recalls
11Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.
Consequence & remedy
Consequence: Electrical arcing can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Dec 18, 2019
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence & remedy
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Additional source detail variants (2)
Tires:temporary/emergency Spare Tire
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Tires:bead
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration