NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
352 reportsClear category filter116,000 miles · Jun 25, 2024
Power Train
The contact owns a 2020 Ford F-150. The contact stated that while operating the vehicle, the transmission malfunctioned, and the shifter display failed to indicate the proper gear while coming to a stop. Additionally, while attempting to accelerate from a stop light, the transmission was in fifth gear and vehicle failed to prope…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while operating the vehicle, the transmission malfunctioned, and the shifter display failed to indicate the proper gear while coming to a stop. Additionally, while attempting to accelerate from a stop light, the transmission was in fifth gear and vehicle failed to properly accelerate. The vehicle was taken to the local dealer who diagnosed that the transmission CDF drum was faulty and informed the contact that the transmission needed to be replaced. The transmission was replaced, and the vehicle was repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was 116,000.
NHTSA ODI #11596491
130,000 miles · Jun 25, 2024
Power Train
The contact owns a 2020 Ford F-150. The contact stated while driving at various speeds, the transmission experienced hard shifting and fluttering while shifting from 3rd to 4th gear. The cause of the failure was not yet determined. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure, but …
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated while driving at various speeds, the transmission experienced hard shifting and fluttering while shifting from 3rd to 4th gear. The cause of the failure was not yet determined. The vehicle was not repaired. The local dealer and manufacturer were notified of the failure, but no assistance was offered. The failure mileage was 130,000.
NHTSA ODI #11596445
147,831 miles · Jun 21, 2024
Power Train
The contact owns a 2020 Ford F-150. The contact stated that while attempting to accelerate, there was a pulling sensation or hesitation at various speeds before accelerating. The contact stated it felt as though the vehicle was going into LIMP Mode. The contact stated that there was a choking and clunking noise emitting from und…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while attempting to accelerate, there was a pulling sensation or hesitation at various speeds before accelerating. The contact stated it felt as though the vehicle was going into LIMP Mode. The contact stated that there was a choking and clunking noise emitting from underneath the vehicle and the vehicle would do a hard shift whenever down shifting especially between 6th and 5th gear. The contact stated that the transmission was stuck in 6th gear intermittently. The DTC code: P061A was displayed on the dashboard. The vehicle was taken to the dealer where the mechanic was unable to diagnose the vehicle. The vehicle was not repaired. The manufacturer was made aware of the failure. The manufacturer referred the contact to the NHTSA Hotline to report the failure. The failure mileage was 147,831.
NHTSA ODI #11595682
134,000 miles · Jun 5, 2024
Power Train
The contact owns a 2020 Ford F-150. The contact stated while driving 25 MPH, there was an abnormal clunking sound coming from the rear of the vehicle. Additionally, the contact stated while reversing, the failure recurred, and the rear end of the vehicle responded forcefully. The contact stated that the failure had been recurrin…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated while driving 25 MPH, there was an abnormal clunking sound coming from the rear of the vehicle. Additionally, the contact stated while reversing, the failure recurred, and the rear end of the vehicle responded forcefully. The contact stated that the failure had been recurring while driving and while reversing. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The contact related the failure to an unknown recall pertaining to the rear axle hub bolt being fractured. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was approximately 134,000.
NHTSA ODI #11592589
Mileage unknown · May 31, 2024
Power Train
10R80 Transmission issues with Ford F150. Many Ford customers in different US states have been experiencing the same transmission issues without Ford fixing them. My Ford truck has been experiencing rough, jerky gear changes and hesitation with acceleration over the past 4 years. The vehicle feels like it is sticking or slipping…
Read full complaint
10R80 Transmission issues with Ford F150. Many Ford customers in different US states have been experiencing the same transmission issues without Ford fixing them. My Ford truck has been experiencing rough, jerky gear changes and hesitation with acceleration over the past 4 years. The vehicle feels like it is sticking or slipping when the the transmission shifts. The truck has been taken into the Ford dealership for multiple inspections with the transmission. The transmission has been completely overhauled and Ford service advisories have been completed. Ford has not been able to resolve the transmission issue involving vehicles with 10R80 10 speed transmissions since 2017. The latest incident was an attempt to accelerate out of the way of an oncoming car from behind on the highway. The vehicle experienced a heavy jerk when accelerating to get out of the way.
NHTSA ODI #11591741
Mileage unknown · May 30, 2024
Forward Collision AvoidancePower Train
The 10 R 80 transmission is unstable and can cause the driver to downshift to make up for a shutter in drive train. Ford calls it normal operation. Secondly, the adaptive cruise control shuts off in traffic. At times unknown to the driver. Very unsafe.
NHTSA ODI #11591520
70,000 miles · May 24, 2024
Power Train
The contact owns a 2020 Ford F-150. The contact stated that the vehicle made a clunking noise when going from 2nd to 3rd and from 7th to 8th gear. The noise also occurred when shifting to reverse or drive. The failure occurred intermittently but had since become more persistent. The contact learned of a faulty main valve control…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that the vehicle made a clunking noise when going from 2nd to 3rd and from 7th to 8th gear. The noise also occurred when shifting to reverse or drive. The failure occurred intermittently but had since become more persistent. The contact learned of a faulty main valve control unit as a possibility while doing research and found that the failure was common; however, had not confirmed the cause for the failure. The vehicle had not been taken to the dealer. The manufacturer was informed of the failure and opened a case. The manufacturer referred the contact to the NHTSA Hotline to file a complaint. The failure mileage was 70,000.
NHTSA ODI #11590526
94,200 miles · May 23, 2024
Power Train
The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission shifted independently, and the check engine warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The contact was …
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the transmission shifted independently, and the check engine warning light illuminated. The vehicle was not diagnosed or repaired by an independent mechanic or the dealer. The dealer was made aware of the failure. The contact was informed of NHTSA Campaign Number: 20V197000 (Power Train) however, the VIN was not included in the recall. The manufacturer was made aware of the failure and a case was filed. The failure mileage was approximately 94,200.
NHTSA ODI #11590464
139,500 miles · May 20, 2024
Power TrainVehicle Speed Control
The contact owns a 2020 Ford F-150. The contact stated while driving 45 MPH, the vehicle started losing motive power and failed to accelerate as needed. The contact stated that after stopping the vehicle, the vehicle inadvertently shifted from first to fourth gear. There was a delay in the vehicle shifting. The power train icon …
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated while driving 45 MPH, the vehicle started losing motive power and failed to accelerate as needed. The contact stated that after stopping the vehicle, the vehicle inadvertently shifted from first to fourth gear. There was a delay in the vehicle shifting. The power train icon was displayed. The vehicle was taken to the local dealer, where it was diagnosed that the failure was due to power train fault code: P07F7. The vehicle was not repaired. The manufacturer was contacted, but no assistance was provided. The failure mileage was approximately 139,500.
NHTSA ODI #11589736
75,000 miles · May 15, 2024
Power Train
The contact owns a 2020 Ford F-150. The contact stated that while driving at undisclosed speeds, the vehicle was decelerating, and the message "See Owner’s Manual" was displayed. The vehicle was restarted; however, the failure recurred. The contact stated that the Owner's Manual stated, "Immediately Stop Driving Vehicle – See De…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while driving at undisclosed speeds, the vehicle was decelerating, and the message "See Owner’s Manual" was displayed. The vehicle was restarted; however, the failure recurred. The contact stated that the Owner's Manual stated, "Immediately Stop Driving Vehicle – See Dealer". The dealer was contacted. The vehicle was not repaired. The manufacturer was made aware of the failure. The failure mileage was approximately 75,000.
NHTSA ODI #11588940
Official recalls
11Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.
Consequence & remedy
Consequence: Electrical arcing can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Dec 18, 2019
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence & remedy
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Additional source detail variants (2)
Tires:temporary/emergency Spare Tire
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Tires:bead
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration