NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
352 reportsClear category filter46,000 miles · Nov 17, 2025
Power Train
The contact owns a 2020 Ford F-150. The contact stated that while driving 70 MPH on the interstate, while depressing the accelerator pedal, the vehicle decelerated to 2 MPH. The messages to “Schedule Maintenance” and “Powertrain - Reduced Power” were displayed on the instrument panel and the Mobile App on the cellphone, and the …
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while driving 70 MPH on the interstate, while depressing the accelerator pedal, the vehicle decelerated to 2 MPH. The messages to “Schedule Maintenance” and “Powertrain - Reduced Power” were displayed on the instrument panel and the Mobile App on the cellphone, and the vehicle went into LIMP Mode. The contact pulled over to the right side of the road and researched the failure. A dealer was contacted. The vehicle was taken to a dealer to be diagnosed. The vehicle was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and stated that the dealer would be contacted, and then the contact would receive a callback. The approximate failure mileage was 46,000.
NHTSA ODI #11699919
Mileage unknown · Nov 15, 2025
Power Train
Once the vehicle is in Drive and starts shifting through the gears, the truck losses all acceleration for 3-5 seconds and then experiences a harsh shift into gear. This causes the vehicle to "stall" in intersections and other hazardous locations if it does not shift properly. The 2020 F150 3.5 ecoBoost has been serviced at loc…
Read full complaint
Once the vehicle is in Drive and starts shifting through the gears, the truck losses all acceleration for 3-5 seconds and then experiences a harsh shift into gear. This causes the vehicle to "stall" in intersections and other hazardous locations if it does not shift properly. The 2020 F150 3.5 ecoBoost has been serviced at local Ford dealerships since bought. Most recently, it was taken into a Ford dealership for routine oil change, transmission fluid change, spark plugs and coils, and 100K inspection due to the vehicle being at 94K miles. I advised the service technician of the concern for the shifting issue that started between the last oil change, which got significantly worse during day-to-day operation.
NHTSA ODI #11699587
Mileage unknown · Nov 6, 2025
Power Train
10rd80 Transmission CDF drum failure. A known design defect on 2020 F150 that Ford should issue a recall on. Ford finally fixed the design issue in August 2022. My truck is out of warranty so I will be out over $6000 that I do not have to fix. Extreme financial problem as I do not have the money to fix and this is my only vehicl…
Read full complaint
10rd80 Transmission CDF drum failure. A known design defect on 2020 F150 that Ford should issue a recall on. Ford finally fixed the design issue in August 2022. My truck is out of warranty so I will be out over $6000 that I do not have to fix. Extreme financial problem as I do not have the money to fix and this is my only vehicle
NHTSA ODI #11698034
Mileage unknown · Nov 3, 2025
Power Train
Transmission will not shift into gear. No recall on this and dealers option is for service and repair. Transmission was serviced and problem shifting still continues. I have received alerts from Ford Pass App indicating Powertrain Malfunction/ Reduced Power — What Is Happening? The transmission control module has detected a conc…
Read full complaint
Transmission will not shift into gear. No recall on this and dealers option is for service and repair. Transmission was serviced and problem shifting still continues. I have received alerts from Ford Pass App indicating Powertrain Malfunction/ Reduced Power — What Is Happening? The transmission control module has detected a concern when trying to shift to 7th gear. A failsafe logic disables 7th gear for the remainder of this key cycle. What Should I Do? Have your vehicle checked by an authorized dealer as soon as possible. This loss of power is a huge safety issue as when I accelerate into traffic the lag in shifting causes the truck to not get up to speed and you’re basically a sitting duck. Transmission was serviced and this did not resolve the issues. Replacement is now scheduled and will cost a minimum of $9000.00. This is a KNOWN issue with the 10-speed transmissions and should be recalled for repair &/or replacement by FORD. This truck has only 116,000 miles!!
NHTSA ODI #11697149
Mileage unknown · Oct 23, 2025
Power Train
The transmission progressively became worse--skipping gears, lurching, clanking, hesitating and losing power. It became unsafe to drive. A complete rebuild of the transmission we required. There is a defect int he transmission that allows bushing/rings to move around.
NHTSA ODI #11695225
Mileage unknown · Oct 15, 2025
EnginePower TrainUnknown Or Other
Truck was traveling at 30 mph and slowing down for stop sign and shifted from 4 th gear to 3rd gear so hard the trucks engine turned off and had to come to a stop and shift into park to turn truck off and back on again. Truck was traveling at 30 mph and slowing down for stop sign
NHTSA ODI #11693621
Mileage unknown · Oct 10, 2025
Power Train
At around 61,000 miles my transmission started having a shuttering noise and had a harsh jerky shift from 3rd to 5th when vehicle was recently started up for the first time of the day. multiple TSB's on Ford's website for this issue including the latest TSB 25-2301. It appears that the interior drum has failed which has been a…
Read full complaint
At around 61,000 miles my transmission started having a shuttering noise and had a harsh jerky shift from 3rd to 5th when vehicle was recently started up for the first time of the day. multiple TSB's on Ford's website for this issue including the latest TSB 25-2301. It appears that the interior drum has failed which has been a known issue. Dealer states $6219.87 to repair the transmission. CDF TSB, replace the valve body, and reprogram the PCM.
NHTSA ODI #11692574
Mileage unknown · Oct 9, 2025
Power Train
While driving on the interstate doing around 70 MPH I I Stanton drive up a fairly steep hill on the road . About half way up the truck down shifted from 10th gear too what it said was 7th. The gear did not engage and the truck revved up like it was in neutral. I pulled over immediately. Checked under the truck and no leaks. Got …
Read full complaint
While driving on the interstate doing around 70 MPH I I Stanton drive up a fairly steep hill on the road . About half way up the truck down shifted from 10th gear too what it said was 7th. The gear did not engage and the truck revved up like it was in neutral. I pulled over immediately. Checked under the truck and no leaks. Got back in and truck ran like normal. Went to the dealer and was told that is a common issue with this particular transmission. I also have noticed when driving and coasting too a stop when the truck downshifts there is sometimes a loud clunking sound. Ford needs to be help responsible for putting trash transmissions in these vehicles. Please advise them to issue a recall and repair or replace them.
NHTSA ODI #11692430
65,000 miles · Oct 9, 2025
Power Train
The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended and jolted. The contact stated that the failure occurred while driving between the second and the third gears. Additionally, the contact noticed …
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while driving at an undisclosed speed, the accelerator pedal was depressed, but the vehicle failed to accelerate as intended and jolted. The contact stated that the failure occurred while driving between the second and the third gears. Additionally, the contact noticed that the vehicle made unusual sounds while shifting into gears. No warning lights were illuminated. The vehicle was taken to the dealer, where it was diagnosed with transmission failure. The contact was informed that the transmission needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline to report the safety failure. The failure mileage was approximately 65,000.
NHTSA ODI #11692399
Mileage unknown · Sep 29, 2025
Power Train
Component/System Failure: The 10-speed automatic transmission failed prematurely at only 75,000 miles. The transmission is still in the vehicle and available for inspection upon request. The symptoms include harsh shifting between gears, particularly into lower gears, followed by significant lag and then abrupt jumping/engagemen…
Read full complaint
Component/System Failure: The 10-speed automatic transmission failed prematurely at only 75,000 miles. The transmission is still in the vehicle and available for inspection upon request. The symptoms include harsh shifting between gears, particularly into lower gears, followed by significant lag and then abrupt jumping/engagement. This is consistent with numerous other complaints filed regarding the 10-speed transmission in this model year. Safety Risk: The unpredictable transmission behavior created dangerous driving conditions. The harsh shifting and lag followed by sudden acceleration made it impossible to safely merge into traffic, navigate intersections, or maintain consistent speed on highways. The erratic gear engagement put myself, my passengers, and other drivers at risk as the vehicle's response became completely unreliable. The truck is currently unsafe to drive. Professional Confirmation: Yes, the problem has been confirmed by Aamco Transmission on Sept 17, 2025. They diagnosed it as transmission failure requiring complete replacement. Manufacturer/Other Inspection: No inspection by Ford has occurred to date. Warning Indicators: No warning lights, check engine lights, or dashboard messages appeared prior to or during the failure. The only symptoms were the physical driving symptoms described above—harsh shifting, significant lag, and abrupt gear engagement—which began approximately gradually over the past month and progressively worsened until the vehicle became unsafe to operate.
NHTSA ODI #11690358
Official recalls
11Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.
Consequence & remedy
Consequence: Electrical arcing can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Dec 18, 2019
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence & remedy
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Additional source detail variants (2)
Tires:temporary/emergency Spare Tire
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Tires:bead
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration