IllustrationAs I was crossing the Rockies in July of 2021on I-70, my engine lost power and I was unable to drive it any further. I had it towed to the nearest Ford dealership which was in Silverthorne, Colorado where the engine had to replace at my expense of over $11,000.
2020 Ford F-150
Owner reports · Recalls · Investigations
Similar to other model years
Owner complaints for the 2020 Ford F-150 do not stand out strongly from the model-year median of 676.
About this comparison →How this year compares
Owner complaints by model year
Compare all F-150 years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
910–25K
4625–50K
3150–75K
2575–100K
31100–150K
6150K+
230 reports with mileage · 494 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Power Train. Review the 352 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 127 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Electrical System. Review the 86 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
19 crash reports3 fire reports12 injury reports
Engine complaints
127 reportsCam shaft error codes came up and I took to the dealership. They said the cam shafts needed to be replaced and engine inspected for damage. I have attached an image of the invoice. I have seen that a lot of F150s are having cam shaft failure, so I think it is a large issue with their design.
The contact owns a 2020 Ford F-150. The contact stated that after changing the oil after 5,000 miles, the vehicle had three quarts of oil remaining out of the eight quarts added. The contact mentioned that the vehicle was consuming an excessive amount of oil. There was no warning light illuminated. The local dealer was not conta…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that after changing the oil after 5,000 miles, the vehicle had three quarts of oil remaining out of the eight quarts added. The contact mentioned that the vehicle was consuming an excessive amount of oil. There was no warning light illuminated. The local dealer was not contacted. The vehicle was not diagnosed or repaired. The manufacturer was contacted, and the contact was referred to the NHTSA Hotline for assistance. The failure mileage was approximately 44,681.
Reporting this same incident type again. My truck continues to sporadically shutoff while operating the vehicle. My truck has shutoff while driving twice in the past 2 months. Under normal driving conditions I can be driving and suddenly the engine will shutoff and I lose all power and power steering. The latest episode I was tu…
Read full complaint
Reporting this same incident type again. My truck continues to sporadically shutoff while operating the vehicle. My truck has shutoff while driving twice in the past 2 months. Under normal driving conditions I can be driving and suddenly the engine will shutoff and I lose all power and power steering. The latest episode I was turning right with traffic approaching behind with my kids in the truck as well. The error on the dash is the same every time “Auto StartStop Manual Restart Required”. I have to come to a complete stop and put the truck in park to be able to restart. Having to stop on a very busy road to restart is a major safety issue and I believe this truck will end up hurting myself or others. I have had the truck into ford more than once and they claim there is no problem even though I show pictures and video. I contacted ford directly again and they really don’t seem to care very much, from what I can tell they refuse to acknowledge I have a problem with the truck. Please help me.
Check engine light came on after loud rattle began occurring on acceleration. Took it to dealer who found oil to be 7.9 qts (capacity 8 qt)low since last oil change, less than 5000 miles earlier. Ford has known about this issue on their v8s since 2018 and switched out low oil indicator to conceal problem. Oil loss can cause e…
Read full complaint
Check engine light came on after loud rattle began occurring on acceleration. Took it to dealer who found oil to be 7.9 qts (capacity 8 qt)low since last oil change, less than 5000 miles earlier. Ford has known about this issue on their v8s since 2018 and switched out low oil indicator to conceal problem. Oil loss can cause engine seizure which is dangerous.
The contact owns a 2020 Ford F-150. The contact stated that while the vehicle was being inspected, the contact was informed that the vehicle was consuming an excessive amount of engine oil. The vehicle was taken to the dealer however, the dealer was unable to determine the cause of the failure. The failure persisted. The manufac…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while the vehicle was being inspected, the contact was informed that the vehicle was consuming an excessive amount of engine oil. The vehicle was taken to the dealer however, the dealer was unable to determine the cause of the failure. The failure persisted. The manufacturer was not made aware of the failure. The approximate failure mileage was 63,085.
While driving, the vehicle shut off and displayed a warning on the dash cluster stating that the engine had automatically shut off. It said auto-stop-start was deactivated and that I needed to put the truck in park and then turn the vehicle off and back on to restart. Doing that allowed the vehicle to restart and no malfunction …
Read full complaint
While driving, the vehicle shut off and displayed a warning on the dash cluster stating that the engine had automatically shut off. It said auto-stop-start was deactivated and that I needed to put the truck in park and then turn the vehicle off and back on to restart. Doing that allowed the vehicle to restart and no malfunction indicators were displayed afterward.
The contact owns a 2020 Ford F-150. The contact stated that while driving approximately 50 MPH, the check engine warning light illuminated. The contact stated the vehicle decelerated with an abnormal rattling sound. The vehicle was taken to the local dealer where it was diagnosed that the cam phaser needed to be replaced. The ve…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that while driving approximately 50 MPH, the check engine warning light illuminated. The contact stated the vehicle decelerated with an abnormal rattling sound. The vehicle was taken to the local dealer where it was diagnosed that the cam phaser needed to be replaced. The vehicle was repaired. The manufacturer was notified about the failure. The failure mileage was approximately 70,000.
My check engine light came on. Vehicle would not operate. Checked oil and it was down over 5 quarts of oil but I still had 2,000 miles until oil change was needed. Took to Hiller Ford with excessive oil consumption complaint. New oil dipstick, oil plug, oil change, and reprogrammed PCM. Returned at later date with same iss…
Read full complaint
My check engine light came on. Vehicle would not operate. Checked oil and it was down over 5 quarts of oil but I still had 2,000 miles until oil change was needed. Took to Hiller Ford with excessive oil consumption complaint. New oil dipstick, oil plug, oil change, and reprogrammed PCM. Returned at later date with same issue. Was told to monitor oil levels and sent on my way. Returned to Hiller at a later date with even faster consumption than earlier visits. Was told I had to pay for oil change and come back in 2,000 miles. At 1,000 miles engine sounded rough so I returned to Hiller Ford who agreed the oil was low. They topped off oil abs told me to come back in another 1,000 miles. 500 miles later I checked oil and barely appeared on the dipstick. I returned to Hiller Ford who agreed my truck was consuming oil faster than it should per Ford specs. Hiller kept my vehicle and ran compression test and then scoped my motor to observe damages. Hiller said that I needed a new motor and it falls under warranty and has been approved by Ford. They then followed up with the new motor would not be available for 18 months. I was told that no rental reimbursement allowance and that I'd have to operate my non conformity vehicle for 18 months. Operating this vehicle is unsafe and is prone to cause damage to other components of the vehicle. Engine could over heat causing its to seize or even start on fire. The increased emissions are not only bad for the environment but would decrease fuel efficiency and be very costly having to add a quart of oil every 500 miles.
The contact owns a 2020 Ford F-150. The contact stated that the check engine warning light remained illuminated due to the excessive oil consumption of the vehicle. The contact took the vehicle to the dealer who diagnosed that the PCM module failed and needed to be replaced. Additionally, the dip stick needed to be replaced with…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that the check engine warning light remained illuminated due to the excessive oil consumption of the vehicle. The contact took the vehicle to the dealer who diagnosed that the PCM module failed and needed to be replaced. Additionally, the dip stick needed to be replaced with a longer dip stick. The vehicle was not repaired. The manufacturer was made aware of the failure. The approximate failure mileage was 72,000.
Official recalls
1126V373000 · Exterior Lighting:headlights
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
25V442000 · Back Over Prevention:software
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
24V852000 · Equipment:other:labels
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
22V250000 · Visibility:windshield Wiper/washer:linkages
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
20V575000 · Back Over Prevention: Sensing System: Camera
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
20V467000 · Electrical System:starter Assembly
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.
Consequence & remedy
Consequence: Electrical arcing can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.
20V197000 · Power Train:automatic Transmission:gear Position Indication (prndl)
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
20V097000 · Exterior Lighting:headlights
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
19V903000 · Tires:bead; Tires:temporary/emergency Spare Tire
Dec 18, 2019
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence & remedy
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Additional source detail variants (2)
Tires:temporary/emergency Spare Tire
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Tires:bead
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
19V805000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
19V633000 · Seats:front Assembly:recliner; Seats:mid/rear Assembly
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.