NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
127 reportsClear category filter80,000 miles · Feb 19, 2025
Engine
The contact owns a 2020 Ford F-150. The contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that the vehicle was consuming 2 quarts of oil each 1,300 miles driven. The vehicle was taken to the dealer, where an oil consumption test was performed, and the dealer confirmed that the vehicle…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that the vehicle was experiencing excessive oil consumption. The contact stated that the vehicle was consuming 2 quarts of oil each 1,300 miles driven. The vehicle was taken to the dealer, where an oil consumption test was performed, and the dealer confirmed that the vehicle was consuming an excessive amount of oil. The dealer determined that the engine needed to be replaced; however, the repair was not covered under warranty. The vehicle was not repaired. The manufacturer was notified of the failure, but no assistance was provided. The failure mileage was approximately 80,000.
NHTSA ODI #11643613
Mileage unknown · Feb 11, 2025
Engine
Cam Phasers need to be replaced due to knocking sound. The problem was reproduced by an independent service center. Check engine light is displayed. This issue is under recall for ford f 150 3.5 however we own a 5.0. The same issue is occurring in our vehicle.
NHTSA ODI #11642008
Mileage unknown · Feb 11, 2025
Engine
Cam phasers sensors have failed three times and repaired each time. Caused the engine to stall and accelerate poorly.The third time they failed a part was defected the dealer claimed. All this work was covered under the powertrain warranty. My safety could have been at risk as my vehicle did sputter and wouldn’t accelerate at en…
Read full complaint
Cam phasers sensors have failed three times and repaired each time. Caused the engine to stall and accelerate poorly.The third time they failed a part was defected the dealer claimed. All this work was covered under the powertrain warranty. My safety could have been at risk as my vehicle did sputter and wouldn’t accelerate at enough speed to keep up with traffic. Although I was not in an accident or hurt at this time. Yes, engine light has came on, on each occurrence. My powertrain warranty through ford will expire shortly and I’m afraid I will be left with a large repair bill if this issue occurs again soon.
NHTSA ODI #11641927
Mileage unknown · Feb 10, 2025
Electrical SystemEngine
dash screen went blank while driving engine has a sound like lifters rattling vehicle lost all electrical connectivity and then it finally came back on no other instances
NHTSA ODI #11641682
91,800 miles · Jan 29, 2025
Engine
The contact owns a 2020 Ford F-150. The contact stated while driving at approximately 45 MPH, the vehicle shuddered abnormally. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated while driving at approximately 45 MPH, the vehicle shuddered abnormally. The contact stated that the check engine warning light was illuminated. The vehicle was taken to a dealer where it was diagnosed and determined that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was not notified of the failure. The failure mileage was approximately 91,800.
NHTSA ODI #11639315
Mileage unknown · Jan 22, 2025
Engine
Driving at approximately 20 miles miles per hour going up a slight incline per engine shut-off. I applied the brakes placed the transmisson in neutral and turned the ignition key to start, the engine started. Had some hesitation at first, but the engine continued to run normal after.
NHTSA ODI #11637792
48,000 miles · Dec 18, 2024
Engine
The contact owns a 2020 Ford F-150. The contact stated that the message "Check the engine" was displayed on the mobile App. The contact stated upon starting the vehicle, the check engine warning light was illuminated. The vehicle was taken to the dealer where diagnostic trouble code: P0327 was retrieved. The dealer determined th…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that the message "Check the engine" was displayed on the mobile App. The contact stated upon starting the vehicle, the check engine warning light was illuminated. The vehicle was taken to the dealer where diagnostic trouble code: P0327 was retrieved. The dealer determined that the engine knock sensor A, three unknown gaskets, and unknown parts needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure and informed the contact that the vehicle was not covered under warranty and that the VIN was not included in a recall. The failure mileage was approximately 48,000.
NHTSA ODI #11631377
40,000 miles · Dec 16, 2024
EnginePower Train
The contact owns a 2020 Ford F-150. The contact stated that after coming to a complete stop, the Auto Start-Stop feature was activated. The brake pedal was released, and the vehicle jerked while in first gear. No warning light was illuminated. Additionally, the rear differential was leaking transmission fluid onto the ground, an…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated that after coming to a complete stop, the Auto Start-Stop feature was activated. The brake pedal was released, and the vehicle jerked while in first gear. No warning light was illuminated. Additionally, the rear differential was leaking transmission fluid onto the ground, and the engine was consuming an excessive amount of engine oil. The contact needed to add seven quarts of oil for every 3,000 miles driven. The vehicle was not diagnosed or repaired by an independent mechanic or dealer. The manufacturer was made aware of the failure and advised the contact to file a complaint with the NHTSA Hotline. The failure mileage was approximately 40,000.
NHTSA ODI #11630976
88,000 miles · Nov 14, 2024
EnginePower Train
The contact owns a 2020 Ford F-150. The contact stated while driving approximately 45 MPH for an hour, there was an abnormally loud clunking sound coming from the vehicle. The vehicle lost motive power and was jerking. The contact was able to pullover safely into a parking lot. The contact stated that the message “Anti-collision…
Read full complaint
The contact owns a 2020 Ford F-150. The contact stated while driving approximately 45 MPH for an hour, there was an abnormally loud clunking sound coming from the vehicle. The vehicle lost motive power and was jerking. The contact was able to pullover safely into a parking lot. The contact stated that the message “Anti-collision System Offline” was displayed. There were no warning lights illuminated. The local dealer was contacted and confirmed that there were no recalls for the failure. The vehicle was not diagnosed or repaired. The manufacturer was contacted and confirmed there were no recalls for the failure and referred the contact to the local dealer and the NHTSA Hotline. The failure mileage was approximately 88,000.
NHTSA ODI #11625169
Mileage unknown · Nov 1, 2024
Engine
Cam phaser rattling along with timing chain is slipping. This same year, make and model has a known recall and is a known issue but because my specific VIN isn’t showing it for will not resolve it. I bought the 2020 f150 in 2022 and this is unacceptable.
NHTSA ODI #11623179
Official recalls
11Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 vehicles previously repaired incorrectly under recall number 20V097. When the headlight switch is turned from "Autolamps" to "Headlamps On," the Daytime Running Lamps (DRLs) may remain fully bright instead of dimming to parking lamps as intended. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: Daytime Running Lamps that do not dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: ,Dealers will reprogram the body control module software, free of charge. Owner notification letters were mailed July 17, 2026. Owners may contact customer service at 1-866-436-7332. Ford's number for this recall is 26C28. Vehicle Identification Numbers (VINs) involved in this recall will become searchable on NHTSA.gov on July 6, 2026.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Aug 10, 2020
Ford Motor Company (Ford) is recalling certain 2020 F-150 vehicles. An incorrect attachment nut may have been used to attach the battery positive (B+) power supply cable to the starter motor, possibly affecting the electrical conductivity, resulting in excess heat and electrical arcing.
Consequence & remedy
Consequence: Electrical arcing can increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the starter motor B+ power supply attachment nut, free of charge. The recall began August 25, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S40.
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Feb 21, 2020
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 trucks equipped with high series LED headlamps with Autolamp (On/Off) functionality. The Daytime Running Lamps (DRL) may remain activated instead of dimming to parking lamps when the Master Lighting Switch (MLS) is manually rotated from the "Autolamps" switch position to "Headlamps On." As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 108, "Lamps, Reflective Devices and Associated Equipment."
Consequence & remedy
Consequence: DRL that cannot dim may reduce the visibility of other drivers, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will reprogram the body control module, free of charge. The recall began March 10, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C03.
Dec 18, 2019
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence & remedy
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Additional source detail variants (2)
Tires:temporary/emergency Spare Tire
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Tires:bead
Ford Motor Company (Ford) is recalling certain 2020 F-150 trucks equipped with 17-inch spare tires. The spare tire could have been damaged when it was installed on the rim.
Consequence: The damage can cause the tire to rapidly lose air pressure or detach from the wheel, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the spare tire, free of charge. The recall began January 13, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S55.
Nov 12, 2019
Ford Motor Company (Ford) is recalling certain 2019-2020 F-150 vehicles. The fastener securing the Power Distribution Box (PDB) 12V cable and Battery Monitoring System (BMS) eyelets to the positive battery terminal may loosen and affect the vehicle's systems such as instrument panel displays and braking or steering assist. The engine could also stall.
Consequence & remedy
Consequence: Inoperative vehicle systems or an engine stall can increase the risk of a crash. Reduced braking and steering efforts increases the risk of a crash. This condition could also create a resistive short, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will inspect the positive battery cable/BMS/PDB joint for excess sealant adhesive and remove any excessive adhesive, reassemble the joint, and retorque the fastener, as necessary, free of charge. The recall began November 25, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S40.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration