NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
97 reportsMileage unknown · Feb 11, 2026
Electrical SystemEngineService Brakes
I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support Line after the first incident, the technical response was insufficient, leading…
Read full complaint
I am writing to formally report a series of catastrophic and life-threatening mechanical and electronic failures in my 2025 Ford Explorer Active (VIN: [XXX] ]), purchased in Bogotá, Colombia. Despite immediately notifying the Ford Post-Sales Support Line after the first incident, the technical response was insufficient, leading to a second, more severe event that nearly resulted in a fatal high-speed collision on February 9, 2026. Incidents Summary: 1. Total Power Loss: Engine and all electrical systems shut down while in motion (40 km/h), losing steering and braking assistance. 2. Brake System Failure: At 70 km/h, The vehicle presented a multi-system failure of sensors, audible alarm and illumination of warning lights (ABS, Traction Control, Pre-collision Assistant, hill start assist not available, check brake system, BRAKE, ESC check, driving modes not available). the vehicle experienced a total loss of brake pedal response followed by a sudden, uncontrolled autonomous "hard braking" event. This happened on a high-traffic highway (Autopista Norte). Global Safety Concern: I am formally requesting a Global Technical Investigation into this unit and the 2025 Explorer Active series. The failure of the electronic brake booster and the total system shutdown represent a "Product Liability" risk that could lead to mass-casualty events. I demand: • Direct intervention from Ford Global to Ford Colombia. • A formal safety alert or recall investigation for similar units. Sincerely, [XXX] MAIL [XXX] bogota colombia phone [XXX] INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #11717439
Mileage unknown · Feb 9, 2026
Back Over PreventionForward Collision AvoidanceUnknown Or Other
The vehicle failed the inspection related to Recall 25C42. Since owning the vehicle, I have experienced repeated intermittent failures of multiple safety and driver-assistance systems, which raise serious safety concerns. The Pre-Collision Assist system has activated without any apparent reason on four separate occasions, inclu…
Read full complaint
The vehicle failed the inspection related to Recall 25C42. Since owning the vehicle, I have experienced repeated intermittent failures of multiple safety and driver-assistance systems, which raise serious safety concerns. The Pre-Collision Assist system has activated without any apparent reason on four separate occasions, including situations where there were no vehicles, pedestrians, or obstacles present. These unexpected activations are alarming and could increase the risk of a collision. I fear for my safety when driving the vehicle due to these unpredictable safety system activations. Additionally, the Rear Cross Traffic Alert system functions intermittently and does not activate consistently when vehicles are present, further reducing confidence in the vehicle’s safety systems. While driving, the vehicle’s phone connectivity system has disconnected unexpectedly, and during these events the GPS/navigation system became unavailable, preventing the use of turn-by-turn directions. These failures occur while the vehicle is in motion and contribute to driver distraction and safety concerns. The vehicle was inspected for Recall 25C42, and I was informed that the required repair cannot be completed because the replacement part is on backorder until June. As a result, the vehicle continues to be operated with known and unresolved safety-related defects for an extended period of time. These issues occur intermittently and without warning, making them difficult to reproduce or diagnose. Due to the ongoing malfunction of critical safety systems and the delay in recall repairs, I fear for my safety while driving this vehicle.
NHTSA ODI #11716635
Mileage unknown · Feb 6, 2026
Forward Collision AvoidanceLane DepartureCrash
While using Ford Blue Cruise, the Blue Cruise system failed to maintain lane control and fought the driver's steering wheel input, resulting in the vehicle colliding with a traffic cone. I have had 3 other instances where Blue Cruise has randomly jerked me toward the shoulder or an exit ramp, this is the first time colliding wit…
Read full complaint
While using Ford Blue Cruise, the Blue Cruise system failed to maintain lane control and fought the driver's steering wheel input, resulting in the vehicle colliding with a traffic cone. I have had 3 other instances where Blue Cruise has randomly jerked me toward the shoulder or an exit ramp, this is the first time colliding with anything. Only damage to the vehicle from this incident is a ripped fender well liner, there are some markings on tire sidewall but no damage. Certainly could have been worse. The cone collision happened on Interstate 79 Northbound at MM101 in West Virginia. I have had lane jerking happen with Blue Cruise twice Northbound at MM105, and once Southbound at MM118. The system is on by default, I am trying to figure out how to turn it off to prevent future safety issues.
NHTSA ODI #11716094
Mileage unknown · Feb 3, 2026
Electrical SystemForward Collision AvoidanceService Brakes
Ever since I bought that vehicle, it's had system malfunctions. I received three letters directly from Ford explaining the problems this vehicle had or could have. But he and the dealerships, where I took my vehicle for repairs, never did them. They always denied that it had any problems and said that my vehicle was new and had …
Read full complaint
Ever since I bought that vehicle, it's had system malfunctions. I received three letters directly from Ford explaining the problems this vehicle had or could have. But he and the dealerships, where I took my vehicle for repairs, never did them. They always denied that it had any problems and said that my vehicle was new and had nothing wrong with it.
NHTSA ODI #11715207
Mileage unknown · Feb 1, 2026
Fuel/propulsion System
Car was parked on a driveway, decent grade, with 50 miles left to empty (no low fuel light on). Facing downward. Car did not turn over. Had to use manual override to put vehicle into neutral and coast to a more level area and start it up. Seen this issue posted on the Explorer ST Facebook group multiple times, so I was lucky…
Read full complaint
Car was parked on a driveway, decent grade, with 50 miles left to empty (no low fuel light on). Facing downward. Car did not turn over. Had to use manual override to put vehicle into neutral and coast to a more level area and start it up. Seen this issue posted on the Explorer ST Facebook group multiple times, so I was lucky I knew what the issue is. Most other people would be stranded. There is a flaw in the Explorer's fuel tank system that will not allow the car to start if fuel level gets below a certain threshold when parked facing down a steep street or driveway.
NHTSA ODI #11714872
11 miles · Jan 20, 2026
Forward Collision Avoidance
The contact owns a 2025 Ford Explorer. The contact stated that on the first day after the vehicle was purchased, the pre-collision camera failed to function as intended. The contact stated that the alarm failed to beep as intended when a person or an object was in front of or passing by the vehicle. There was no warning light il…
Read full complaint
The contact owns a 2025 Ford Explorer. The contact stated that on the first day after the vehicle was purchased, the pre-collision camera failed to function as intended. The contact stated that the alarm failed to beep as intended when a person or an object was in front of or passing by the vehicle. There was no warning light illuminated. The vehicle was taken to the dealer; however, no cause for the failure was found. A diagnostic test was performed, and it was determined that the pre-collision camera worked as designed. The contact stated that the manager at the dealer took the vehicle home and confirmed that the pre-collision camera sensor had failed to function as intended; however, the vehicle was not repaired. The vehicle was taken to Biener Ford; however, no cause for the failure was found. The contact stated that on a separate occasion, while driving at an undisclosed speed in the snow, the message "Pre-collision Camera Blocked" was displayed. The vehicle was not taken to the dealer or an independent mechanic. The vehicle was not repaired. The manufacturer was made aware of the issue. The failure mileage was approximately 11.
NHTSA ODI #11712187
Mileage unknown · Jan 14, 2026
Visibility/wiper
Since new. Thousands of dots or specs are visible in the window upon sun up of sun down. This is not the snow flake safety campain that Ford has. Others have the same complaint on social media.
NHTSA ODI #11710897
Mileage unknown · Jan 9, 2026
Electrical SystemExterior Lighting
First, we took this vehicle to a dealer because the rear window buttons were not working. They wouldn't roll down. Second, the dome lamps inside only work part of the time, when we take the vehicle to the dealer or another Ford dealer that we decided to try, they say they can't do anything because they see no issue as the ligh…
Read full complaint
First, we took this vehicle to a dealer because the rear window buttons were not working. They wouldn't roll down. Second, the dome lamps inside only work part of the time, when we take the vehicle to the dealer or another Ford dealer that we decided to try, they say they can't do anything because they see no issue as the lights are working AT THAT TIME. Third, while connected to a trailer, an error message appears several times stating that the trailer has been disconnected. It just flashes and pings, and then disappears. This is a safety issue, as it has caused me to make sudden stops as I am made to believe that the trailer has became disconnected. All these things are stated in the recall we received on this vehicle, and we just want the body control module replaced as it says they should do, but both dealers(Bruce Walters Ford - Pikeville KY) and the dealer we switched to to try and remedy the issue (Freedom Ford of Wise VA) say that there is no issue, and refuse to do the control module replacement. This vehicle has been inspected at the least 6 different times for these issues, and still nothing has been fixed.
NHTSA ODI #11709936
Mileage unknown · Jan 2, 2026
Power Train
Parked vehicle on snowy driveway, went to back to unload personal items from liftgate, and vehicle began sliding backwards towards me. Ran to the driver‘s door, got in, put on brakes, started vehicle and pulled it forward. Put it in park, and as I was exiting the vehicle, it began sliding backwards again. Rear wheels were locked…
Read full complaint
Parked vehicle on snowy driveway, went to back to unload personal items from liftgate, and vehicle began sliding backwards towards me. Ran to the driver‘s door, got in, put on brakes, started vehicle and pulled it forward. Put it in park, and as I was exiting the vehicle, it began sliding backwards again. Rear wheels were locked. However, the front wheels were rolling. Apparently the transmission park pawl did not engage. I took pictures of the tires after the last roll. Front tracks show clear tread in the snow (rolling); rear show lines and pushed show (sliding)
NHTSA ODI #11708298
Mileage unknown · Dec 29, 2025
Structure
I brought my 2025 Explorer in on 12/19/2025 for a recall check. I mentioned to the Service Advisor that the left rear inner wheel well skirt was detached from the quarter panel. After the car was looked at, he came to me and said that they can be replaced at a cost of $600...XXX. He said it is from the snow and ice tearing them …
Read full complaint
I brought my 2025 Explorer in on 12/19/2025 for a recall check. I mentioned to the Service Advisor that the left rear inner wheel well skirt was detached from the quarter panel. After the car was looked at, he came to me and said that they can be replaced at a cost of $600...XXX. He said it is from the snow and ice tearing them because of the larger tires on the vehicles now....NO XXX..we live in WNY. This is a brand new-ish vehicle with 15,000 miles. How is this something that is my cost, there is obviously a problem with parts or engineering. Basically I will have to replace these after every winter season for the reason that was given....AGAIN...why is this not covered. I regress, he did say Ford MAY help the first time...REALLY?? What happens the next winter and the one after that?? $40K+ for the vehicle and this
NHTSA ODI #11707558
Official recalls
20Jul 21, 2026
Ford Motor Company (Ford) is recalling certain 2025-2027 Explorer and Lincoln Aviator vehicles. An unoccupied driver's seat may recline unintentionally during certain scenarios, such as remote unlock or remote start.
Consequence & remedy
Consequence: Unexpected movement of the driver’s seat back may trap a second-row occupant, increasing the risk of injury.
Remedy: Dealers will disable the driver seat module (DSM) feature until parts are available. Once available, the motor will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed September 3, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S53.
Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2020-2027 Aviator and 2020-2026 Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, tipping, or sliding unexpectedly.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect and replace the bezel around the switch as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model and model years. Interim letters explaining the safety risk were mailed August 19, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Lincoln Aviator owner notification letters were mailed August 21, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S52. This recall expands Recall 25V393. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
May 27, 2026
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer, Ranger, and Bronco vehicles. The engine may fail, which can result in a loss of drive power.
Consequence & remedy
Consequence: A sudden loss of drive power can increase the risk of a crash.
Remedy: Dealers will replace the engine long block, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2026. Additional letters will be sent once the remedy is available, anticipated in November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S35. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on May 28, 2026.
Mar 18, 2026
Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
Consequence & remedy
Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.
Additional source detail variants (2)
Back Over Prevention:software
Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.
Electrical System:adas
Ford Motor Company (Ford) is recalling certain 2022-2025 Lincoln Navigator, 2024-2025 Lincoln Nautilus, 2025 Lincoln Aviator and Explorer vehicles. The Image Processing Module A (IPMA) may experience multiple unexpected resets, resulting in loss of the rearview camera image and advanced driver assistance (ADAS) features, including pre-collision assist, lane-keeping assist, and blind-spot monitoring.
Consequence: Loss of the rearview camera image and certain driver assistance features, can reduce the driver’s ability to detect hazards, increasing the risk of a crash.
Remedy: The Image Processing Module A software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. This is a Phased campaign. Phase 1 will include 2025 Aviator, 2025 Explorer, 2025 Nautilus notified owners on 4/13/2026. Phase 2 will include 2025 Navigator will notify owners on or about 4/20/2026. Phase 3 will include 2022-2024 Navigator will notify owners on or about 6/8/2026. Phase 4 will include 2024 Nautilus will notify owners on or about 6/22/2026. Owner notification letters were mailed April 13, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S21. Vehicle Identification Numbers (VINs) involved in this recall will be searchable on NHTSA.gov beginning March 25, 2026.
Mar 17, 2026
Ford Motor Company (Ford) is recalling certain 2020-2026 Explorer and Lincoln Aviator vehicles. The seat belt anchor bolts at the second-row outer seating positions may be improperly secured.
Consequence & remedy
Consequence: A loose seat belt buckle may not properly restrain an occupant during a crash, increasing the risk of injury.
Remedy: Dealers will inspect the second-row outer seat belt lower anchor bolts and replace or repair them as necessary, free of charge. Owner notification letters were mailed March 30, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C18. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 19, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2025-2026 Explorer vehicles. The Dynamic Bending Light (DBL) system software may cause the passenger-side headlight to turn in the wrong direction when driving through curves in the road. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: A headlight that turns incorrectly can result in increased glare to other road users, increasing the risk of a crash.
Remedy: The headlight control module software will be updated by a dealer, or through an over-the-air (OTA) update, free of charge. Owner notification letters were mailed March 23, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26C12. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 5, 2026.
Mar 3, 2026
Ford Motor Company (Ford) is recalling certain 2025 Ranger, Lincoln Nautilus, Mustang, Maverick, Explorer, Escape, Lincoln Corsair, Bronco Sport, and Bronco vehicles. The exhaust gas recirculation (EGR) valve may fail, resulting in an unexpected loss of drive power.
Consequence & remedy
Consequence: An unexpected loss of drive power increases the risk of a crash.
Remedy: Dealers will replace the EGR valves, free of charge. Owner notification letters were mailed July 31, 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S10. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on March 4, 2026.
Oct 24, 2025
Ford Motor Company (Ford) is recalling certain 2025-2026 Lincoln Corsair, Lincoln Aviator, and Explorer vehicles. The windshield glass may have visible air bubbles, which can obscure the driver's visibility. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 205, "Glazing Materials."
Consequence & remedy
Consequence: Reduced visibility while driving can increase the risk of a crash.
Remedy: Dealers will inspect and replace the windshield as necessary, free of charge. Owner notification letters were mailed November 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C60. Vehicle Identification Numbers (VINs) involved in this recall become searchable on NHTSA.gov beginning October 27, 2025.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2024-2026 Explorer and 2024-2026 Lincoln Aviator vehicles. The trailer hitch assembly bolts may be loose.
Consequence & remedy
Consequence: While towing a trailer, loose trailer hitch bolts can cause a loss of vehicle handling and control, or cause the trailer to detach. Either of these conditions can increase the risk of a crash.
Remedy: Dealers will inspect and tighten the trailer hitch bolts, or replace them as necessary, free of charge. Owner notification letters were mailed October 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA3. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
Aug 22, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. When towing a trailer, the tail lights on the trailer may fail to illuminate due to an improperly manufactured body control module. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 108, " Lamps, Reflective Devices, and Associated Equipment."
Consequence & remedy
Consequence: Trailer tail lights that do not illuminate as intended can reduce visibility to other drivers, increasing the risk of a crash.
Remedy: Dealers will replace the body control module C on vehicles with less than 9,000 miles. For vehicles over 9,000 miles, dealers will perform a functional check on the body control module C and replace it as necessary. Repairs will be performed free of charge. Aviator 2025 owner notification letters were mailed October 13, 2025. Explorer 2025 owner letters were mailed November 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25C42.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2025 Transit, F-150, and Explorer vehicles. The connecting rod and rod bearing components may have manufacturing defects that can lead to engine damage and engine failure.
Consequence & remedy
Consequence: A damaged engine can result in engine failure and a stall, increasing the risk of a crash.
Remedy: Dealers will inspect the connecting rods and replace the engine long block assembly as necessary, free of charge. Owner notification letters were mailed August 15, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S55.
Jun 13, 2025
Ford Motor Company (Ford) is recalling certain 2020-2025 Aviator, and Explorer vehicles. The switch for the easy-entry second-row outer seats may bind or stick, resulting in the seats unlatching, folding, or sliding unexpectedly while driving.
Consequence & remedy
Consequence: A seat that moves unexpectedly may not properly restrain an occupant during a crash, increasing their risk of injury.
Remedy: Dealers will inspect the second-row seat switch, and replace the bezel around the switch as necessary, free of charge. Owner notification letters were mailed August 7, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S67.
Jun 3, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The bolts securing the front brake caliper may not be tightened properly, which can result in a loss of front brake function and possible wheel damage.
Consequence & remedy
Consequence: Loss of brake function and wheel damage can increase the risk of a crash.
Remedy: Dealers will inspect and tighten the bolts as necessary. If bolts are missing, the brake caliper and pads will be replaced. Repairs will be performed free of charge. Owner notification letters were mailed June 19, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S60.
May 9, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Aviator vehicles. A mounting bolt for the front subframe may have been tightened improperly.
Consequence & remedy
Consequence: A loose subframe bolt may reduce the vehicle's performance in a crash, increasing the risk of injury.
Remedy: Dealers will inspect and tighten the subframe bolts as necessary, free of charge. Owners may contact Ford Customer Service at 1-866-436-7332. Owner notification letters were mailed May 21, 2025. Ford's number for this recall is 25S43.
Apr 11, 2025
Ford Motor Company (Ford) is recalling certain 2025 Explorer vehicles. The powertrain control module (PCM) may reset while driving, which can damage the park system or cause an engine stall.
Consequence & remedy
Consequence: A damaged park system can result in a vehicle rollaway when the vehicle is placed in park without the parking brake applied. An engine stall while driving can result in a sudden loss of drive power. Either of these scenarios can increase the risk of a crash.
Remedy: Dealers will update the powertrain control module software, free of charge. Owner notification letters were mailed June 6, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S35.
Mar 14, 2025
Ford Motor Company (Ford) is recalling certain 2024-2025 F-150, Bronco, 2024 Ranger, 2025 Mustang, Explorer, and Aviator vehicles. The transmission valve body may have been machined incorrectly, which can cause reverse gear failure, or unexpected forward movement in reverse or neutral gear.
Consequence & remedy
Consequence: Unexpected vehicle movement increases the risk of a crash.
Remedy: Dealers will replace the transmission main control valve body, free of charge. Owner notification letters were mailed April 11, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S19.
Jan 17, 2025
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Consequence & remedy
Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Additional source detail variants (2)
Structure:frame And Members
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Power Train:automatic Transmission
Ford Motor Company (Ford) is recalling certain 2025 Ford Explorer and Lincoln Aviator vehicles. The transmission may be improperly secured due to loose cross member bolts.
Consequence: An improperly secured transmission can result in a loss of drive power, increasing the risk of a crash.
Remedy: Dealers will inspect and replace the transmission cross member bolts as necessary, free of charge. If the cross member bolts are missing, dealers will replace the cross member and install new bolts, free of charge. Owner notification letters were mailed January 29, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S03.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Oct 25, 2024
Ford Motor Company (Ford) is recalling certain 2025 Explorer and Lincoln Aviator vehicles. The rearview camera image may fail when the vehicle speed reaches 10 MPH or greater. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 111, "Rear Visibility."
Consequence & remedy
Consequence: The loss of the rearview camera image while in reverse can reduce the driver's rear visibility, increasing the risk of a crash.
Remedy: The accessory protocol interface module (APIM) software will be updated through an over-the-air (OTA) update or by a dealer, free of charge. Owner notification letters were mailed on March 28, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C34.
Aug 23, 2024
Ford Motor Company (Ford) is recalling certain 2023 Lincoln Corsair, 2023-2024 Escape, 2024 Mustang, and 2025 Explorer vehicles. The fuel injectors may have been assembled without O-ring support discs, which can result in a fuel leak.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Dealers will install new fuel injector O-rings and O-ring support discs, free of charge. Owner notification letters were mailed on October 7, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S54.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration