NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
76 reportsClear category filter10,000 miles · Jul 19, 2016
Vehicle Speed Control
I WAS DRIVING MY VEHICLE ON A STREET AND THE GAS PETAL STOPPED WORKING. THE CAR STARTED SHAKING AND I COULDN'T MAKE IT TO THE SIDE OF THE ROAD. THE CAR WOULD DRIVE AGAIN AFTER RESTARTING THE ENGINE, BUT, ONLY FOR 5-10 MINUTES BEFORE THE GAS PETAL STOPPED WORKING AGAIN. I TOOK IT TO THE FORD DEALERSHIP AND WAS TOLD IT WAS THE …
Read full complaint
I WAS DRIVING MY VEHICLE ON A STREET AND THE GAS PETAL STOPPED WORKING. THE CAR STARTED SHAKING AND I COULDN'T MAKE IT TO THE SIDE OF THE ROAD. THE CAR WOULD DRIVE AGAIN AFTER RESTARTING THE ENGINE, BUT, ONLY FOR 5-10 MINUTES BEFORE THE GAS PETAL STOPPED WORKING AGAIN. I TOOK IT TO THE FORD DEALERSHIP AND WAS TOLD IT WAS THE THROTTLE BODY AND THEY HAVE BEEN HAVING ELECTRICAL ISSUES AND THIS HAPPENS A LOT. THEY INSTALLED A NEW THROTTLE BODY AND TOLD ME THEY WEREN'T SURE IF IT WOULD HAPPEN AGAIN. I HAD MY FAMILY IN THE CAR WITH ME AND IT WAS AN EXTREMELY DANGEROUS SITUATION.
NHTSA ODI #10885835
Mileage unknown · Jul 17, 2016
EnginePower TrainService Brakes
HUSBAND WAS DRIVING THE VEHICLE WAS ABOUT TO ACCELERATE TO GET UP A HILL ON A CITY STREET AND ENGINE SOUNDED LIKE TRANSMISSION OR OTHER MAJOR PART JUST "DROPPED". STEERING WHEEL FROZE, CAR IDLED VIOLENTLY, COULD NOT MOVE VEHICLE, STARTED TO ROLL BACKWARDS UNTIL EMERGENCY BRAKE WAS APPLIED.ACCELERATION WENT TO LITERALLY ZERO,SUV …
Read full complaint
HUSBAND WAS DRIVING THE VEHICLE WAS ABOUT TO ACCELERATE TO GET UP A HILL ON A CITY STREET AND ENGINE SOUNDED LIKE TRANSMISSION OR OTHER MAJOR PART JUST "DROPPED". STEERING WHEEL FROZE, CAR IDLED VIOLENTLY, COULD NOT MOVE VEHICLE, STARTED TO ROLL BACKWARDS UNTIL EMERGENCY BRAKE WAS APPLIED.ACCELERATION WENT TO LITERALLY ZERO,SUV WOULD NOT MOVE. ORANGE WRENCH LIGHT CAME ON, STATED TO SEE MANUAL.PLACED CAR IN PARK SHUT OFF ENGINE AND WAITED AND STARTED AT BACK UP AGAIN. SCARRY STUFF, 2 CHILDREN 2 AND YOUNGER IN VEHICLE. WON'T LET ME INPUT ON NEXT PAGE, APPROXIMATELY 25-30 MILES AN HOUR, SUV HAS 5,500 MILES ON IT
NHTSA ODI #10885312
9,000 miles · Jul 15, 2016
EnginePower TrainVehicle Speed Control
DRIVING ON I-10 ABOUT 1 MILE BEFORE DAPHNE, AL, ENGINE SPUTTERED AND VEHICLE BEGAN LOOSING SPEED. PRESSING THE GAS PEDAL DID NOTHING, CHECK ENGINE LIGHT CAME ON, SERVICE MANUAL LIGHT CAME ON, AND AIRBAG LIGHT CAME ON. COASTED TO THE SIDE OF THE INTERSTATE, STUCK BETWEEN THE WHITE LINE OF THE LANE EDGE AND A GUARDRAIL WITH ONLY…
Read full complaint
DRIVING ON I-10 ABOUT 1 MILE BEFORE DAPHNE, AL, ENGINE SPUTTERED AND VEHICLE BEGAN LOOSING SPEED. PRESSING THE GAS PEDAL DID NOTHING, CHECK ENGINE LIGHT CAME ON, SERVICE MANUAL LIGHT CAME ON, AND AIRBAG LIGHT CAME ON. COASTED TO THE SIDE OF THE INTERSTATE, STUCK BETWEEN THE WHITE LINE OF THE LANE EDGE AND A GUARDRAIL WITH ONLY INCHES TO SPARE FROM TRAFFIC PASSING AT 70 MPH. ALL THIS WITH MY WIFE IN THE FRONT SEAT AND OUR 2 DAUGHTERS IN THE BACKSEAT WHO ARE 2 YEARS OLD AND 5 MONTHS OLD. ENGINE WAS RUNNING ROUGH AND WOULD NOT INCREASE RPMS EVEN WHEN PRESSING THE ACCELERATOR PEDAL. SHUT ENGINE OFF AND ON 6 TIMES BEFORE IT FINALLY RESPONDED TO ACCELERATOR PEDAL INPUT. WAS FINALLY ABLE TO MERGE BACK ON TO THE INTERSTATE AND GET TO THE DAPHNE EXIT. WE HAD TO STAY THE NIGHT IN A HOTEL IN DAPHNE WHILE WE WAITED FOR ANOTHER VEHICLE TO GET US HOME TO LOUISIANA. THIS WAS A RENTAL VEHICLE AND HAD TO BE TOWED TO THE MOBILE AIRPORT SO THAT WE COULD GET ANOTHER VEHICLE FROM ENTERPRISE. A QUICK INTERNET SEARCH REVEALED NUMEROUS COMPLAINTS OF THE EXACT SAME ISSUE BUT NO EVIDENCE OF ANY RECALL. APPARENTLY THE THROTTLE BODY IS FAULTY AND MOST PEOPLE REPORT THAT THE PART IS ON BACK ORDER. FORD KNOWS ABOUT THIS PROBLEM AND NHTSA SHOULD TOO BUT SOMEHOW NOTHING IS BEING DONE. THIS INCIDENT LEFT US ON THE SIDE OF THE ROAD, INCHES FROM BEING KILLED BY PASSING MOTORISTS. HOW THIS IS NOT UNDER A RECALL OR STOP SALE ORDER IS BEYOND ME. PLEASE INITIATE A RECALL AND/OR STOP SALE ORDER ON THESE VEHICLES BEFORE SOMEONE IS KILLED OR SERIOUSLY INJURED.
NHTSA ODI #10884957
6,000 miles · Jul 11, 2016
EngineSteeringVehicle Speed Control
I WAS DRIVING MY 2016 FORD EXPLORER ON A BUSY STREET WHEN THE ENGINE LIGHT AND THE ORANGE WRENCH LIGHT CAME ON. THE CAR STALLED AND WOULD NOT ACCELERATE.IT LOST ALL POWER. I AM TERRIFIED OF DRIVING IT NOW. IT WOULD NOT MOVE FASTER THAN 5 MILES PER HOUR. THE CAR HAS 6,000 MILES ON IT.
NHTSA ODI #10884138
18,000 miles · Jul 8, 2016
EngineVehicle Speed Control
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED AT 50 MPH, THE VEHICLE FAILED TO RESPOND AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE SERVICE VEHICLE SOON AND AIR BAG WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THRO…
Read full complaint
TL* THE CONTACT OWNS A 2016 FORD EXPLORER. WHEN THE ACCELERATOR PEDAL WAS DEPRESSED AT 50 MPH, THE VEHICLE FAILED TO RESPOND AND STALLED WITHOUT WARNING. THE VEHICLE WAS ABLE TO BE RESTARTED. THE SERVICE VEHICLE SOON AND AIR BAG WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS TOWED TO THE DEALER WHERE IT WAS DIAGNOSED THAT THE THROTTLE BODY FAILED. THE VEHICLE WAS REPAIRED TWICE FOR THE SAME FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 18,000.
NHTSA ODI #10883523
9,000 miles · Jul 7, 2016
EngineFuel/propulsion SystemVehicle Speed Control
THIS PARTICULAR PROBLEM OCCURRED THREE TIMES OVER TWO DAYS. THE FIRST TIME I WAS DRIVING APPROXIMATELY 45MPH ON A CITY STREET WHEN A WRENCH LIGHT AND AIRBAG LIGHT CAME ON AND THE VEHICLE'S THROTTLE STOPPED RESPONDING. IF I LET OFF THE BREAK THE VEHICLE WOULD CONTINUE TO MOVE AT APPROXIMATELY 5MPH SO I WAS ABLE TO GET IT OFF THE …
Read full complaint
THIS PARTICULAR PROBLEM OCCURRED THREE TIMES OVER TWO DAYS. THE FIRST TIME I WAS DRIVING APPROXIMATELY 45MPH ON A CITY STREET WHEN A WRENCH LIGHT AND AIRBAG LIGHT CAME ON AND THE VEHICLE'S THROTTLE STOPPED RESPONDING. IF I LET OFF THE BREAK THE VEHICLE WOULD CONTINUE TO MOVE AT APPROXIMATELY 5MPH SO I WAS ABLE TO GET IT OFF THE ROADWAY. I TURNED THE VEHICLE OFF AND BACK ON AND IT SEEMED TO BE FUNCTIONING NORMALLY WITH THE CHECK ENGINE LIGHT ILLUMINATED. I WAS ABLE TO MAKE IT TO MY OFFICE WHERE I LEFT IT PARKED UNTIL AFTER LUNCH. WHEN I CRANKED UP THE VEHICLE AFTER LUNCH THE CHECK ENGINE LIGHT WAS NO LONGER ON. AFTER DRIVING APPROXIMATELY TEN MORE MILES I ATTEMPTED TO MAKE A LEFT TURN INTO A PARKING LOT WHEN THE SAME THING HAPPENED AND I WAS ALMOST HIT BY AN ONCOMING TRUCK. AFTER TURNING THE VEHICLE OFF FOR A WHILE I CRANKED IT AGAIN AND THE CHECK ENGINE LIGHT WAS NOT ILLUMINATED. I MADE IT HOME WITH NO ISSUE AND THE NEXT MORNING I LEFT HOME HEADING TO THE DEALERSHIP TO DROP THE VEHICLE OFF. AS I WAS TURNING LEFT ON TO A SIDE STREET THE VEHICLE AGAIN STALLED AND AGAIN I WAS ALMOST STRUCK BY ONCOMING TRAFFIC. I TURNED THE VEHICLE OFF AND BACK ON AND AFTER THAT WAS ABLE TO MAKE IT TO THE DEALERSHIP WITHOUT AN ISSUE. THE DIAGNOSTIC TEST INDICATED THAT THE ELECTRONIC THROTTLE BODY WAS THE ISSUE. THE DEALERSHIP INFORMED ME THAT THIS WAS A WIDESPREAD PROBLEM. THE VEHICLE I WAS OPERATING IS AN UNDERCOVER POLICE VEHICLE AND ONLY HAS 9,000 MILES ON IT. HAD I BEEN RESPONDING TO AN EMERGENCY AT A HIGH SPEED I FEAR THAT EITHER I OR ANOTHER MOTORIST COULD HAVE BEEN SERIOUSLY HURT OR KILLED.
NHTSA ODI #10883462
10 miles · Jul 5, 2016
Power TrainVehicle Speed Control
I WAS DRIVING 45MPH ON A BUSY STREET WHEN SUDDENLY THE CAR JUST STALLED. I HAD KIDS IN THE BACK SEAT AND FRANTICALLY PRESSED THE GAS PEDAL WHICH PRESSED DOWN BUT NOTHING HAPPENED. THE WRENCH AND CHECK ENGINE LIGHT ILLUMINATED. LUCKILY, I WAS ABLE TO PUT MY HAZARDS ON AND PULL OVER. WE ARE SO FORTUNATE WE DIDN'T REACH THE HIGH…
Read full complaint
I WAS DRIVING 45MPH ON A BUSY STREET WHEN SUDDENLY THE CAR JUST STALLED. I HAD KIDS IN THE BACK SEAT AND FRANTICALLY PRESSED THE GAS PEDAL WHICH PRESSED DOWN BUT NOTHING HAPPENED. THE WRENCH AND CHECK ENGINE LIGHT ILLUMINATED. LUCKILY, I WAS ABLE TO PUT MY HAZARDS ON AND PULL OVER. WE ARE SO FORTUNATE WE DIDN'T REACH THE HIGHWAY YET ON THIS BUSY HOLIDAY WEEKEND. I AM SURE IT WOULD HAVE ENDED DIFFERENTLY. THIS IS A VERY DANGEROUS SITUATION AND NEEDS TO BE ADDRESSED. WHAT GOOD IS A NEW CAR IF YOU CAN'T TRUST IT? HOPING THE THROTTLE BODY IS A RECONFIGURED PART WHEN THEY FIX IT. NEEDS A RECALL!!
NHTSA ODI #10882561
3,750 miles · Jun 28, 2016
EngineFuel/propulsion SystemVehicle Speed Control
I WAS DRIVING HOME AT 10:00 AM AFTER VISITING A DOCTOR'S OFFICE ON A BUSY HIGHWAY AT 57 MPH WHEN ALL OF A SUDDEN THE CAR GAS PEDDLE IS NOT WORKING. THE CAR IS IN COMPLETE SHUT DOWN MODE. I ROLLED THROUGH AN INTERSECTION TO GET TO SAFE PLACE OUT OF TRAFFIC. THE CAR DASH BOARD SHOWED A WRENCH AND ENGINE LIGHT AND ON THE DASHBOA…
Read full complaint
I WAS DRIVING HOME AT 10:00 AM AFTER VISITING A DOCTOR'S OFFICE ON A BUSY HIGHWAY AT 57 MPH WHEN ALL OF A SUDDEN THE CAR GAS PEDDLE IS NOT WORKING. THE CAR IS IN COMPLETE SHUT DOWN MODE. I ROLLED THROUGH AN INTERSECTION TO GET TO SAFE PLACE OUT OF TRAFFIC. THE CAR DASH BOARD SHOWED A WRENCH AND ENGINE LIGHT AND ON THE DASHBOARD A MESSAGE STATED "SEE MANUAL". THE CAR HAD COMPLETELY SHUT DOWN. SCARED TO DEATH AT WHAT JUST HAPPENED, I CALLED FORD WARRANTY NUMBER FOR A TOW TRUCK AND WAITED FOR 2 1/2 HOURS TILL FINALLY THE TOW TRUCK SHOWED UP. WHEN I GOT TO THE DEALERSHIP WHERE I PURCHASED THE CAR, I WAS SERIOUSLY DEVASTATED. TWO MANAGERS TOLD ME THEY DIDN'T KNOW WHAT WAS WRONG WITH THE CAR, BUT THEY WOULD WORK TO FIND OUT. THEY KNEW WHAT THE PROBLEM WAS AND HOW SERIOUS THIS SITUATION WAS AND NEVER TOLD ME AT THE TIME. I SEARCHED THE INTERNET AND FOUND THAT THE PROBLEM IS THE THROTTLE BODY. IT HAS BEEN HAPPENING A QUITE A FEW OF FORD'S CARS. I STILL CAN'T BELIEVE THE VERY SERIOUS SITUATION I HAD BEEN IN. I SEARCHED TO SEE IF THERE WERE ANY RECALLS FOR MY VEHICLE AND THERE WASN'T ANY. THIS NEEDS TO STOP AND FORD NEEDS TO RECALL ALL THESE VEHICLES BEFORE SOMEBODY GETS KILLED. I DO NOT CARE TO OWN THIS VEHICLE ANY LONGER OR ANY OTHER FORD VEHICLE FOR THAT MATTER.. WHOSE TO SAY THIS PROBLEM DOESN'T EXIST IN ANY OTHER MODELS. I WAS CALLED YESTERDAY BUT JUSTIN IN SERVICE AND WAS TOLD THAT IT IS THE THROTTLE BODY AND IT WAS GOING TO TAKE ALONG TIME TO GET THE PART AND THAT HE WOULD STAY IN TOUCH TO LET ME KNOW ANYTHING. HE STATED THAT SAM GALLAWAY FORD WOULD PAY FOR THE 1ST 9 DAYS OF MY RENTAL AND THEN MY INSURANCE WOULD HAVE TO PAY THE REST.
NHTSA ODI #10877111
6,000 miles · Jun 25, 2016
EngineVehicle Speed Control
THE VEHICLE WAS IN MOVEMENT, GOING 50 MPH, WHEN IT CAME TO A SUDDEN STALL. THE VEHICLE WOULD NOT GO OVER 5 MPH EVEN WHILE PRESSING THE ACCELERATOR. THE WRENCE LIGHT WOULD COME ON AND IT WOULD IT WOULD NOT GO OVER 5 MPH.
NHTSA ODI #10876539
7,419 miles · Jun 24, 2016
Vehicle Speed Control
THE VEHICLE WAS PAUSED AT GAS STATION EXIT READY TO ENTER THE TRAFFIC. WHEN I STEPPED ON THE GAS PEDAL THE VEHICLE STARTED TO MOVE FORWARD THEN IMMEDIATELY THREE LIGHTS (AIR BAG, WRENCH, AND MOTOR) CAME ON AND THE VEHICLE WOULD NOT ACCELERATE LEAVING ME TO SIMPLY "ROLL" ON AND MANEUVER TO A SIDE AREA OFF THE MAIN ROAD. THANKFULL…
Read full complaint
THE VEHICLE WAS PAUSED AT GAS STATION EXIT READY TO ENTER THE TRAFFIC. WHEN I STEPPED ON THE GAS PEDAL THE VEHICLE STARTED TO MOVE FORWARD THEN IMMEDIATELY THREE LIGHTS (AIR BAG, WRENCH, AND MOTOR) CAME ON AND THE VEHICLE WOULD NOT ACCELERATE LEAVING ME TO SIMPLY "ROLL" ON AND MANEUVER TO A SIDE AREA OFF THE MAIN ROAD. THANKFULLY THE BRAKES WERE FUNCTIONING OR THE OUTCOME COULD HAVE BEEN POTENTIALLY WORSE.
NHTSA ODI #10876396
Official recalls
14Jul 14, 2026
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.
Oct 10, 2025
Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.
Consequence & remedy
Consequence: An electrical short circuit can increase the risk of a fire.
Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.
Consequence & remedy
Consequence: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.
Jan 19, 2024
Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.
Consequence & remedy
Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.
Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.
Jul 15, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.
Consequence & remedy
Consequence: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.
May 5, 2021
Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.
Consequence & remedy
Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.
Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.
Mar 12, 2021
Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.
Consequence & remedy
Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.
Nov 10, 2020
Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.
Consequence & remedy
Consequence: The failed bracket could result in a loss of park function which can cause unintended vehicle movement, and loss of motive power while driving which increases the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the link shaft bracket, free of charge. Parts are not currently available. Owners received an interim notification detailing safety risk December 8, 2020. A second letter will be mailed when parts become available in January 2021. The recall began February 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S63.
Jun 10, 2019
Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.
Consequence & remedy
Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.
Nov 29, 2017
Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.
Consequence & remedy
Consequence: In the event of a crash, a seat occupant that is not properly restrained has an increased risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the tightness of the power seat track upper pivot link bolt, either applying threadlocker or replacing the lift link and hardware, free of charge. Interim letters are expected to go out January 15, 2018. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S40.
Jun 28, 2016
Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: The seat back may not adequately restrain the occupant during a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.
Mar 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.
Consequence & remedy
Consequence: Overheating of the engine block increase the risk of a fire.
Remedy: Ford will notify owners, and dealers will replace the engine block heater, free of charge. Dealers will also inspect and replace the electrical cord, as necessary. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S14. Note: Owners should not use the engine block heater until the vehicle has been remedied.
Sep 28, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.
Consequence & remedy
Consequence: If the fuel tank separates from the vehicle, a fuel leak may occur, increasing the risk of a fire.
Remedy: Ford will notify owners, and dealers will tighten the fuel tank attachment bolts, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S26.
Jul 24, 2015
Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."
Consequence & remedy
Consequence: If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.
Remedy: Ford will notify owners, and dealers will test the operation of the parking brake system, and if necessary, replace the parking brake control assembly, free of charge. The recall began on September 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE23001 · Windshield Trim Molding Item Detachment
Opened Jan 27, 2023 · Closed Feb 8, 2024
Status: closed (inferred from source dates) · Structure:body:roof And Pillars
On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
EA17002 · Exhaust Odor In Passenger Cab
Opened Jul 27, 2017 · Closed Jan 17, 2023
Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Additional source detail variants (2)
Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Structure:body
During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve
Illustration