Structure. Review the 584 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Steering. Review the 530 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine. Review the 381 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

39 crash reports14 fire reports43 injury reports

Structure complaints

584 reports

Clear category filter

Mileage unknown · Jun 17, 2021

Structure

The trim to the lining of my window on the right side flew off on the highway

NHTSA ODI #11421226

Mileage unknown · May 17, 2021

Structure

The recall has been put out and the dealership is claiming that the fix of gluing the roof rack covers back on is not sufficient and that a new fix needs to be made. The fix is not available to me and I cannot use the vehicle for work with an open recall. I understand that recalls happen, but the fix should be available immediat…

Read full complaint

NHTSA ODI #11417428

54,000 miles · May 13, 2021

Structure

Read full complaint

THE VEHICLE WAS PURCHASED IN 2020 AND SO FAR I HAVE HAD TO REPLACE THE A PILLAR TRIM 3 TIMES.ONCE ON THE PASSENGER SIDE AND TWICE ON THE DRIVERS SIDE. COSTING OVER $100 EACH TIME JUST FOR THE PARTS.THE TRIM HAS COME OFF TWICE WHILE AT HIGHWAY SPEED, 60 MPH, CAUSING A LOUD NOISE AND FLYING DEBRIS. THE THIRD TIME THE TRIM CAME OFF AT A SLOW SPEED OFF 35 MPH AND ACTUALLY BROKE IN HALF. I ATTACHED A PHOTO OF THE TRIM PIECE. I BELIEVE THE CAUSE MAY BE THE PLASTIC CLIPS THAT HOLD THE TRIM IN PLACE.

NHTSA ODI #11416460

55,000 miles · Apr 27, 2021

Structure

WHILE DRIVING DOWN THE HIGHWAY AT APPROXIMATELY 75 MPH, THE DRIVER'S WINDSHIELD SIDE TRIM MOLDING DETACHED FROM THE VEHICLE. THIS MOLDING IMPACTED THE SIDE OF THE VEHICLE, AND BECAME FOD ON THE HIGHWAY. IN REVIEW, ONLY HALF OF THE MOLDING DETACHED FROM THE VEHICLE, WITH HALF REMAINING IN PLACE.

NHTSA ODI #11414142

Mileage unknown · Apr 17, 2021

Electrical SystemStructure

RADIO SPARKING AND SMOKING PLUS PEELING AND BUBBLES INSIDE THE HOOD PAINT

NHTSA ODI #11408573

5 miles · Apr 9, 2021

Structure

DRIVING ON HIGHWAY, WINDSHIELD TRIM ON DRIVERS SIDE BROKE OFF. ONCE STATIONARY, INSPECTED WHERE THE TRIM WAS AND IT'S COMPLETELY GONE & APPEARS THAT THE CLIPS HOLDING IT THERE ARE BROKEN AND SOME GONE. PASSENGERS SIDE TRIM IS WARPED AND APPEARS LOOSE. ALSO, DRIVERS DOORS TRIM IS NOW PARTLY DETACHED FROM DOOR

NHTSA ODI #11407271

45,000 miles · Feb 22, 2021

Structure

WHILE TRAVELING AT APPROXIMATELY 70 MPH THE PASSENGER SIDE WINDSHIELD PILLAR MOLDING DEPARTED THE VEHICLE. WHILE RESEARCHING PART NUMBERS AND REPAIRS ONLINE I HAVE NOTICED THIS APPEARS TO BE A COMMON PROBLEM FOR EXPLORERS FROM 2011- 2018. ALSO SEEMS SOMEWHAT RELATED TO THE CURRENT RECALL FOR EXPLORER ROOF RACKS THAT USE SOME O…

Read full complaint

NHTSA ODI #11397294

44,000 miles · Feb 22, 2021

Structure

THE HOOD OF THE VEHICLE IS RUSTING ALONG THE FRONT EDGE. IT STARTED WITH A SMALL AREA AT FIRST A YEAR AGO BY BUBBLING UP FROM UNDERNEATH. NOW THERE ARE SEVERAL VISIBLE AREAS ALONG THE FRONT EDGE OF THE HOOD DOING THE SAME. IT'S A MATTER OF TIME TIL THE RUST BREAKS THRU THE PAINT. 5 YEARS OLD AND I LIVE IN MD. MILD WINTERS. SHOU…

Read full complaint

NHTSA ODI #11397268

34,000 miles · Feb 2, 2021

Structure

PAINT BUBBLING AND PEELING AROUND FRONT EDGE OF HOOD SHOWING RUST UNDERNEATH. VEHICLE IS GARAGE KEPT AND CLEANED REGULARLY.

NHTSA ODI #11391154

Mileage unknown · Sep 19, 2020

SeatsStructureUnknown Or Other

Read full complaint

POWER LOCKS GET STUCK ON EITHER LOCK OR UNLOCKED NOT ALLOWING ME TO EITHER LOCK OR UNLOCK THE CAR DOOR ON DRIVER AND BACK PASSENGER DOOR. PLASTIC STRIPPING PANELS ON FRONT DRIVER AND PASSENGER DOORS ARE COMING OFF AND THE PANELS CONNECTED TO THE WINDSHIELD ON BOTH SIDES. POWER SEATS DO NOT HOLD THE MEMORY OF WHERE IT WAS LEFT. THE SEAT GOES ALL THE WAY UP TO THE STEERING WHEEL WHEN MEMORY BUTTONS ARE PRESSED OR IF THE KEYLESS CODE ON THE DOOR IS USED TO UNLOCKED THE CAR. KEYLESS ENTRY WILL UNLOCK WITHOUT TO CODE BEING TYPED IN CORRECTLY. USING THE FIRST THREE NUMBERS CAN UNLOCK THE DOOR. ALL OF THESE THINGS HAPPEN WILL THE CAR IS STATIONARY.

NHTSA ODI #11359957

Official recalls

26V448000 · Structure:body

Jul 14, 2026

Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The roof rail covers may come loose and detach from the vehicle.

Consequence & remedy

Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.

Remedy: Dealers will inspect the roof rail covers and as necessary, repair or replace the push-pins, rail clips, or roof rail covers, free of charge. Interim letters, notifying owners of the safety risk, were mailed August 28, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S54. This recall expands previous NHTSA recall number 21V316. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on July 16, 2026.

25V685000 · Equipment:electrical:engine Block Heater

Oct 10, 2025

Ford Motor Company (Ford) is recalling certain 2016-2019 Lincoln MKC, 2016-2023 Explorer, 2019-2020 Fusion, 2019-2024 Ranger, 2020-2022 Lincoln Corsair, Escape, 2021-2024 Bronco, Bronco Sport, and 2022-2024 Maverick vehicles. The engine block heater may crack and develop a coolant leak, causing it to short circuit when the block heater is plugged in.

Consequence & remedy

Consequence: An electrical short circuit can increase the risk of a fire.

Remedy: Owners are advised not to plug in their block heater until the vehicle is remedied. Dealers will replace the block heater, free of charge. Owners will also have a alternative option to replace engine block heater element with a threaded blanking plug, and remove the block heater electrical cord. Interim letters, notifying owners of the safety risk, were mailed December 3, 2025. Additional letters will be sent once the final remedy is available, anticipated September 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25SA4. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on October 15, 2025.

25V347000 · Structure:body

May 23, 2025

Ford Motor Company (Ford) is recalling certain 2016-2017 Explorer vehicles. The driver and front passenger B-Pillar door trim may detach while driving.

Consequence & remedy

Consequence: Door trim that detaches while driving can create a road hazard, increasing the risk of a crash.

Remedy: Dealers will repair the B-pillar trim, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 5, 2025. A second notice will be sent once the final remedy is available, anticipated November 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S53.

24V031000 · Structure:body:roof And Pillars

Jan 19, 2024

Ford Motor Company (Ford) is recalling certain 2011-2019 Explorer vehicles. The A-pillar trim retention clips may not be properly engaged, allowing the trim to detach.

Consequence & remedy

Consequence: A detached trim piece can fall off the vehicle, becoming a road hazard and increasing the risk of a crash.

Remedy: Dealers will inspect and replace the A-pillar trim as necessary, free of charge. This will be a phased campaign, with the remedy becoming available in different phases based on model years. Owner notification letters were mailed between July 18, 2024 and December 16, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S02.

21V537000 · Suspension:rear

Jul 15, 2021

Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or ever registered, in Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, Wisconsin, and the District of Columbia. Exposure to road salt can cause the cross-axis ball joint to corrode and seize, resulting in a fracture of the outboard section of the rear suspension toe link.

Consequence & remedy

Consequence: A rear toe-link fracture can result in a loss of steering control, increasing the risk of a crash.

Remedy: Dealers will inspect and replace as necessary, the cross-axis ball joint (CABJ) knuckle, and replace the rear suspension toe links, free of charge. This recall is an expansion of previous NHTSA recall numbers 16V-245, 19V-435, and 20V-675. Certain vehicles previously repaired will need to return for the new remedy. An interim notification letter notifying owners of the safety risk were mailed on September 10, 2021. Owner notification letters were mailed on March 16, 2022. Owners may contact Ford's customer service at 1-866-436-7332. Ford's number for this recall is 21S32.

21V316000 · Structure:body

May 5, 2021

Ford Motor Company (Ford) is recalling certain 2016-2019 Explorer vehicles. The retention pins could loosen and allow the roof rail covers to detach from the vehicle.

Consequence & remedy

Consequence: A detached roof rail cover can create a road hazard, increasing the risk of a crash.

Remedy: Dealers will install push-pins and replace any damaged rail clips and roof rail covers, as necessary, free of charge. The interim owner notification letter was mailed on June 22, 2021. Owner notification letters (remedy available) were mailed on October 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S22.

20V675000 · Suspension:rear

Mar 12, 2021

Ford Motor Company (Ford) is recalling certain 2013-2017 Explorer vehicles originally sold, or currently registered in Connecticut, Delaware, the District of Columbia, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, Virginia, West Virginia, and Wisconsin that were previously repaired under a prior recall numbers 16V-245 or 19V-435. The outboard section of a rear suspension toe link may fracture.

Consequence & remedy

Consequence: A rear toe link fracture can result in a loss of steering control, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will inspect the cross-axis ball joint (CABJ) knuckle attached to the rear suspension toe link and replace it as necessary, free of charge. The recall began November 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S62.

20V692000 · Power Train:axle Assembly:axle Shaft

Nov 10, 2020

Ford Motor Company (Ford) is recalling certain 2014-2016 Explorer, 2014-2015 Taurus and 2014 Edge vehicles equipped with 2.0L or 2.3L engines and front wheel drive. The support bracket for the front drive axle halfshaft may fail.

Consequence & remedy

Consequence: The failed bracket could result in a loss of park function which can cause unintended vehicle movement, and loss of motive power while driving which increases the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the link shaft bracket, free of charge. Parts are not currently available. Owners received an interim notification detailing safety risk December 8, 2020. A second letter will be mailed when parts become available in January 2021. The recall began February 2, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S63.

19V435000 · Suspension:rear

Jun 10, 2019

Ford Motor Company (Ford) is recalling certain 2011-2017 Explorer vehicles. The rear suspension toe links may fracture due to stress on the rear suspension.

Consequence & remedy

Consequence: A fractured rear toe link will cause a sudden change in vehicle handling and increase the risk of a crash.

Remedy: Ford will notify owners, and dealers will replace the rear suspension toe links, and inspect both rear toe link ball joints, replacing the rear wheel knuckle(s), if necessary, free of charge. The recall began June 26, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S17.

17V767000 · Seats

Nov 29, 2017

Ford Motor Company (Ford) is recalling certain 2016 F-150 and Explorer vehicles. Loose power seat adjuster pivot bolts may cause the front seat cushions to detach and not properly restrain the seat occupant in the event of a crash.

Consequence & remedy

Consequence: In the event of a crash, a seat occupant that is not properly restrained has an increased risk of injury.

Remedy: Ford will notify owners, and dealers will inspect the tightness of the power seat track upper pivot link bolt, either applying threadlocker or replacing the lift link and hardware, free of charge. Interim letters are expected to go out January 15, 2018. Owners will receive a second notice when the remedy becomes available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 17S40.

16V475000 · Seats:front Assembly:recliner

Jun 28, 2016

Ford Motor Company (Ford) is recalling certain model year 2016 Ford Explorer and F-150 vehicles equipped with a manual recline driver's seat. The seat back frame may have insufficient welds which may not meet the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."

Consequence & remedy

Consequence: The seat back may not adequately restrain the occupant during a crash, increasing the risk of injury.

Remedy: Ford will notify owners, and dealers will inspect and, if necessary, replace the seat back frame, free of charge. The recall begin on August 18, 2016. Owners may contact Ford at 1-800-392-3673. Ford's number for this recall is 16C11.

16V183000 · Engine And Engine Cooling:engine

Mar 31, 2016

Ford Motor Company (Ford) is recalling certain model year 2015-2016 Lincoln MKC vehicles manufactured November 25, 2013, to January 25, 2016, and 2016 Ford Explorer vehicles manufactured October 20, 2014, to January 28, 2016. The affected vehicles are equipped with 2.3L GTDI engines and engine block heaters. These engine block heaters have elements that may overheat while plugged in.

Consequence & remedy

Consequence: Overheating of the engine block increase the risk of a fire.

Remedy: Ford will notify owners, and dealers will replace the engine block heater, free of charge. Dealers will also inspect and replace the electrical cord, as necessary. The recall began on May 18, 2016. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 16S14. Note: Owners should not use the engine block heater until the vehicle has been remedied.

15V605000 · Fuel System, Gasoline:storage:tank Assembly:mounting

Sep 28, 2015

Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Lincoln MKS, and 2016 Ford Explorer vehicles manufactured on July 24, 2015. During vehicle production, the fuel tank attachment bolts may not have been properly tightened. As a result, the fuel tank straps may fracture and the fuel tank could separate from the vehicle.

Consequence & remedy

Consequence: If the fuel tank separates from the vehicle, a fuel leak may occur, increasing the risk of a fire.

Remedy: Ford will notify owners, and dealers will tighten the fuel tank attachment bolts, as necessary, free of charge. The recall began on October 19, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15S26.

15V464000 · Parking Brake

Jul 24, 2015

Ford Motor Company (Ford) is recalling certain model year 2015 Ford Taurus, Ford Flex, and Lincoln MKS vehicles manufactured May 4, 2015, to May 23, 2015, Lincoln MKT vehicles manufactured May 4, 2015, to May 21, 2015, and 2015-2016 Ford Explorer vehicles manufactured May 4, 2015, to May 23, 2015. The affected vehicles have a parking brake that may not fully engage when applied. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 135, "Light Vehicle Brake Systems."

Consequence & remedy

Consequence: If the parking brake does not fully engage and the transmission is left in a gear other than 'Park' while on a slope, the vehicle may roll away, increasing the risk of a crash.

Remedy: Ford will notify owners, and dealers will test the operation of the parking brake system, and if necessary, replace the parking brake control assembly, free of charge. The recall began on September 4, 2015. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 15C07.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

PE23001 · Windshield Trim Molding Item Detachment

Opened Jan 27, 2023 · Closed Feb 8, 2024

Status: closed (inferred from source dates) · Structure:body:roof And Pillars

On January 27, 2023, the Office of Defects Investigation (ODI) opened PE23-001 to investigate allegations of A-pillar trim panel detachment on model year (MY) 2011-2019 Ford Explorer vehicles. At the time of opening, the office had received 164 Vehicle Owner Questionnaires (VOQs) reporting this failure. ODI has received 671 VOQs regarding this failure, including 1 alleged crash and 2 alleged injuries. Some consumers have reported that the failure occurred while they were driving at highway speeds, with the detached trim panel entering the path of travel of the vehicle behind them, requiring the driver of the following vehicle to take evasive action. It is noteworthy that motorists who experience this type of road hazard are less likely to accurately identify the subject vehicle the item detached from and report the event to the NHTSA. In its April 17, 2023 response to ODI’s information request, Ford provided 175 consumer complaints (including field reports) and 14,162 warranty claims related to A-pillar trim panel detachment. Ford relayed that the subject vehicles utilize a plastic A-pillar bracket, which is bolted to the vehicle structure during assembly. The A-pillar trim panel is attached to the bracket utilizing 7 plastic clips. Contributory factors which have been identified by Ford as leading to the subject defect include incomplete installation at the assembly plant, inadequate part stack up, damage to fasteners during installation, and failure to follow proper repair procedure during windshield replacements or other services. On January 19, 2024, Ford filed safety recall 24V-031 for MY 2011-2019 Ford Explorer vehicles to address the subject defect. In the Part 573 Safety Recall Report, Ford identified that a detached A-pillar trim panel can create a road hazard for other road users, increasing the risk of a crash. The recall remedy includes an inspection of the existing A-pillar trim panel and, if necessary, the replacement of the component. The remedy A-pillar trim panels will be installed with an additional adhesive for robustness and utilize an inspection procedure to ensure full engagement of all the retention clips during installation. In view of the recall action being taken by Ford, ODI is closing this Preliminary Evaluation. The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.

EA17002 · Exhaust Odor In Passenger Cab

Opened Jul 27, 2017 · Closed Jan 17, 2023

Status: closed (inferred from source dates) · Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe; Structure:body

During the EA17-002 investigation, the agency reviewed and analyzed reports of exhaust odors in the passenger cabins of Model Year 2011 to 2017 Ford Explorers. This investigation required an approach that incorporated knowledge and expertise from the automotive, medical, environmental health, and occupational safety fields. The agency conducted an in-depth investigation that encompassed the review of over 6,500 consumer complaints, conducting field inspections, and testing the relevant vehicles, both independently and in coordination with Ford and other entities. During the investigation, the evolution of Ford service bulletins intended to reduce the level of exhaust odors and carbon monoxide (CO) entering the occupant compartment was examined and independent tests to evaluate the effectiveness of the final Field Service Actions (FSA) for both consumer and police vehicles were conducted. As part of the investigation, the agency also examined the effects of cracked exhaust mani-cats on the measured CO levels in the vehicles and tested the FSA repairs to ensure they did not adversely impact occupant compartment CO levels due to cracked mani-cats.The investigation identified upfitting issues for Police Interceptor vehicles. Upfitting (sirens, lights, cages, auxiliary power, etc.) is typically performed by governmental fleet operations, independent repair facilities, or local Ford dealers after the sale of the new vehicle. Sealing issues caused by upfitting were responsible for the highest measured carbon monoxide levels in tested vehicles. The police FSA instructs how to inspect the quality of the vehicle upfits and how to properly seal any leaks caused by these upfits, at no cost to the police agency. Similarly, the highest CO levels measured in consumer vehicles were usually traced to sealing issues caused by rear crash damage where the repairs did not ensure sealing integrity. The most recent Ford FSA procedure for both the police (17B25) and consumer vehicles (17N03) includes an HVAC reprogramming operation. Tests by Ford and NHTSA have demonstrated a substantial reduction of CO levels due solely to the HVAC reprogramming. Other FSA repairs also demonstrated measurable contributions to CO level reductions during controlled tests.Throughout the investigation, vehicles accurately measured with higher levels of carbon monoxide were almost always affected by upfitter alterations, damage, or other causes compromising rear passenger cabin seals.NHTSA received thousands of reports alleging odors which triggered a variety of physiological responses, predominately nausea, headaches, and lightheadedness. NHTSA focused the investigation on accurately measuring vehicle CO levels, and accurately measuring carboxyhemoglobin (COHB) levels from properly administered blood tests. Using rigorous test methods to produce exhaust gas intrusion in vehicles with a properly performed FSA, occupant compartment CO levels remained below current environmental limits for CO in any environment (EPA ambient air quality standards). Furthermore, even without FSA repairs, no vehicles unaffected by upfitter issues or prior crash damage were identified with CO levels that exceed accepted occupational CO exposure levels. This investigation finds that the 2011-2017 Ford Explorer vehicles when accurately measured produce occupant compartment CO levels which fall below current accepted health standards, and could not identify COHB levels for vehicle drivers or other occupants, which exceeded thresholds for acute physiological effects. Therefore, the agency has not identified a defect that represents an unreasonable risk to motor vehicle safety.This inve

Additional source detail variants (2)

Engine And Engine Cooling:exhaust System:manifold/header/muffler/tail Pipe

Structure:body

Go deeper into Ford Explorer problems

Ford Explorer electrical problems →Ford Explorer transmission problems →