NHTSA owner reports · September 18, 2026 snapshot.
Engine And Engine Cooling complaints
74 reportsClear category filterMileage unknown · Feb 13, 2012
Engine And Engine CoolingVehicle Speed ControlFire
MY TENANT'S VEHICLE - A 1994 FORD EXPLORER - SPONTANEOUSLY CAUGHT FIRE WHILE PARKED IN MY PROPERTY'S GARAGE IN THE MIDDLE OF THE NIGHT. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FLAMES AND DETERMINED THAT THE CAUSE OF THE FIRE WAS THE CAR ITSELF - LIKELY A FAULTY CRUISE CONTROL VALVE ACCORDING TO THEM. THE INSURANCE COMPA…
Read full complaint
MY TENANT'S VEHICLE - A 1994 FORD EXPLORER - SPONTANEOUSLY CAUGHT FIRE WHILE PARKED IN MY PROPERTY'S GARAGE IN THE MIDDLE OF THE NIGHT. THE FIRE DEPARTMENT WAS ABLE TO EXTINGUISH THE FLAMES AND DETERMINED THAT THE CAUSE OF THE FIRE WAS THE CAR ITSELF - LIKELY A FAULTY CRUISE CONTROL VALVE ACCORDING TO THEM. THE INSURANCE COMPANY WILL CONDUCT ITS OWN INVESTIGATION. *TR
NHTSA ODI #10447825
171,000 miles · Nov 16, 2011
Engine And Engine CoolingVehicle Speed Control
I WAS SITTING AT A STOP LIGHT ALL OF A SUDDEN THE TRUCK ACCELERATED FORWARD. THE NEXT EVENT I WAS TRAVELING ABOUT 40 MILES AN HOUR AND THE TRUCK ACCELERATED OUT OF CONTROL AND I WAS UNABLE TO STOP IT, THE BRAKES WOULDN'T STOP IT, FINALLY I TURNED THE KEY OFF AND IT SHUT DOWN. IT'S BEEN HAPPENING ON AND OFF SINCE THEN. IT DOESN'T…
Read full complaint
I WAS SITTING AT A STOP LIGHT ALL OF A SUDDEN THE TRUCK ACCELERATED FORWARD. THE NEXT EVENT I WAS TRAVELING ABOUT 40 MILES AN HOUR AND THE TRUCK ACCELERATED OUT OF CONTROL AND I WAS UNABLE TO STOP IT, THE BRAKES WOULDN'T STOP IT, FINALLY I TURNED THE KEY OFF AND IT SHUT DOWN. IT'S BEEN HAPPENING ON AND OFF SINCE THEN. IT DOESN'T HAPPEN ALL THE TIME, BUT, I NEVER KNOW WHEN IT WILL HAPPEN AGAIN. I CONTACTED FORD SEVERAL TIMES ABOUT THIS PROBLEM AND THEY TOLD ME IT COULD BE ALOT OF DIFFERENT REASONS, THEY NAMED OFF SOME PARTS AND I REPLACED ALOT OF THEM AND AM STILL HAVING THE SAME PROBLEM. THEY DID SAY THEY HAVE HEARD OF OTHER PEOPLE HAVING THE SAME PROBLEMS, BUT THEY WERE NOT ALL FOR THE SAME REASONS. *TR
NHTSA ODI #10436124
200,000 miles · Apr 1, 2010
Engine And Engine CoolingFire
TL*THE CONTACT OWNS A 1994 FORD EXPLORER. WHEN THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH, DARK SMOKE BEGAN EMITTING FROM THE INSTRUMENT PANEL. THE CONTACT TURNED THE VEHICLE OFF WHICH IMMEDIATELY BECAME ENGULFED IN FLAMES. THE POLICE AND FIRE DEPARTMENT WERE NOTIFIED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE C…
Read full complaint
TL*THE CONTACT OWNS A 1994 FORD EXPLORER. WHEN THE CONTACT WAS DRIVING APPROXIMATELY 10 MPH, DARK SMOKE BEGAN EMITTING FROM THE INSTRUMENT PANEL. THE CONTACT TURNED THE VEHICLE OFF WHICH IMMEDIATELY BECAME ENGULFED IN FLAMES. THE POLICE AND FIRE DEPARTMENT WERE NOTIFIED AND EXTINGUISHED THE FIRE. THE VEHICLE WAS DESTROYED. THE CURRENT AND FAILURE MILEAGES WERE APPROXIMATELY 200,000.
NHTSA ODI #10323374
175,000 miles · Oct 15, 2009
Engine And Engine CoolingFire
TL* THE CONTACT OWNS A 1994 FORD EXPLORER. WHILE PARKED, THE VEHICLE CAUGHT ON FIRE. THE FIRE DEPARTMENT EXTINGUISHED THE FLAMES. THE FIRE INSPECTOR WAS UNABLE TO DETERMINE THE CAUSE OF FIRE. THE VEHICLE WAS SEVERELY DAMAGED. THE MANUFACTURER HAS NOT BEEN NOTIFIED. THE CURRENT AND FAILURE MILEAGES WERE 175,000.
NHTSA ODI #10288536
Mileage unknown · Jun 15, 2009
Engine And Engine CoolingSuspension
MY VEHICLE WAS PURCHASED AS IS AND I HAVE HAD SOME PROBLEMS WITH IT . I NEED ROCKER PANELS , 3 BALL JOINTS AND A NEW MUFFLER. *TR
NHTSA ODI #10273856
90,000 miles · May 21, 2008
Engine And Engine CoolingVehicle Speed Control
TL*THE CONTACT OWNS A 1994 FORD EXPLORER. AFTER MAKING A RIGHT TURN AT 5 MPH, THE VEHICLE SLOWLY GAINED SPEED AND THEN UNEXPECTEDLY ACCELERATED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE SLOWED DOWN MOMENTARILY, BUT DID NOT STOP COMPLETELY. THE SPEEDOMETER DISPLAYED 80 MPH AND THE REAR WHEELS BEGAN TO SMOKE, DUE T…
Read full complaint
TL*THE CONTACT OWNS A 1994 FORD EXPLORER. AFTER MAKING A RIGHT TURN AT 5 MPH, THE VEHICLE SLOWLY GAINED SPEED AND THEN UNEXPECTEDLY ACCELERATED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND THE VEHICLE SLOWED DOWN MOMENTARILY, BUT DID NOT STOP COMPLETELY. THE SPEEDOMETER DISPLAYED 80 MPH AND THE REAR WHEELS BEGAN TO SMOKE, DUE TO THE FACT THAT THE BRAKE PEDAL WAS DEPRESSED WHILE THE VEHICLE WAS STILL ACCELERATING. HE MANAGED TO TURN THE KEY AND SHUT OFF THE ENGINE. THE CONTACT ATTEMPTED TO RESTART THE ENGINE, BUT THE RPM DIAL WAS IN THE RED ZONE. HE WAS ABLE TO DRIVE THE VEHICLE BACK TO HIS RESIDENCE AND DISCOVERED THAT THE THROTTLE PLATE WAS STUCK IN THE OPEN POSITION. HE REPAIRED THE FAILURE ON HIS OWN, WITHOUT THE DEALER'S ASSISTANCE. HE BELIEVES THAT HAD HE NOT BEEN KNOWLEDGEABLE OF THE FAILURE, IT COULD HAVE BEEN A LOT MORE SEVERE. THE CURRENT AND FAILURE MILEAGES WERE 90,000. UPDATED 07/15/08
NHTSA ODI #10228545
114,000 miles · Oct 26, 2004
Electrical SystemEngine And Engine CoolingEquipment
1994 EXPLORER 4.0 V6 AUTOMATIC TRANSMISSION REBIULT 3 TIMES IN PAST YEAR .COUNTLESS TIMES VEHICLE HAS STALLED ACTING AS IF THE FUEL PUMP QUIT, FUEL PUMP REPLACED, COIL PACKS REPLACED, RELAYS REPLACED. ONCE ON THE HIGHWAY AT 70 MPH, ANOTHER TIME WHILE PULLING INTO TRAFFIC. USUALLY UPON START UP. AIR CONDITIONER SWITCH SHORTED OU…
Read full complaint
1994 EXPLORER 4.0 V6 AUTOMATIC TRANSMISSION REBIULT 3 TIMES IN PAST YEAR .COUNTLESS TIMES VEHICLE HAS STALLED ACTING AS IF THE FUEL PUMP QUIT, FUEL PUMP REPLACED, COIL PACKS REPLACED, RELAYS REPLACED. ONCE ON THE HIGHWAY AT 70 MPH, ANOTHER TIME WHILE PULLING INTO TRAFFIC. USUALLY UPON START UP. AIR CONDITIONER SWITCH SHORTED OUT, SAW BURNED WIRES ON SWITCH UPON REPLACEMENT. ANTIFREEZE SPEWED OUT FROM SIDE OF MOTOR, ASSUMED TO BE AROUND HEADS BUT HAS NOT BEEN TO SHOP YET.*AK
NHTSA ODI #10096436
88,500 miles · Aug 9, 2004
Electrical SystemEngine And Engine CoolingService Brakes, Hydraulic
I BOUGHT MY 1994 FORD EXPLORER (4WD) IN MAY OF 1999 AND HAVE HAD NUMEROUS PROBLEMS SINCE. THE VEHICLE HAD APPROXIMATELY 50900 MILES WHEN I BOUGHT IT. IT NOW HAS 89000 MILES. I HAVE REPLACED THE BRAKE ROTORS TWICE AND REPLACED THE BRAKE PADS THREE TIMES. THE LAST TIME I COMPLETED BRAKE WORK WAS BECAUSE THE LEFT FRONT CALIPER OVER…
Read full complaint
I BOUGHT MY 1994 FORD EXPLORER (4WD) IN MAY OF 1999 AND HAVE HAD NUMEROUS PROBLEMS SINCE. THE VEHICLE HAD APPROXIMATELY 50900 MILES WHEN I BOUGHT IT. IT NOW HAS 89000 MILES. I HAVE REPLACED THE BRAKE ROTORS TWICE AND REPLACED THE BRAKE PADS THREE TIMES. THE LAST TIME I COMPLETED BRAKE WORK WAS BECAUSE THE LEFT FRONT CALIPER OVERHEATED AND FAILED. I THEN REPLACED BOTH FRONT CALIPERS. THERE IS A BAD VIBRATION PROBLEM AT SPEEDS OF 55-67 MPH. I RECENTLY PURCHASED FOUR NEW TIRES, HAD THEM BALANCED, HAD THE FRONT END ALIGNED, AND REPLACED THE SHOCKS TO FIX THIS PROBLEM. IT STILL VIBRATES AT THE ABOVE MENTIONED SPEEDS. ALSO, THE VEHICLE HAD NUMEROUS PROBLEMS WITH THE PCM (CHECK ENGINE LIGHT). I REPLACED THE PCM AS A LAST RESORT BECAUSE I HAD ALREADY REPLACED ALL THE SENSORS THAT COULD HAVE BEEN CAUSING THE PROBLEM. REPLACING THE PCM CORRECTED THE PROBLEM FOR ABOUT A YEAR, BUT NOW THE CHECK ENGINE LIGHT COMES ON AGAIN DURING INITIAL STARTING AND THEN GOES OUT AFTER DRIVING ABOUT 2-3 MILES. I ALSO HAVE A SOUND COMING FROM MY AIR VENTS WHEN THE A/C IS TURNED ON. NOW FOR MY MOST RECENT PROBLEM. THE TEMPERATURE GAUGE WAS READING HOTTER THAN NORMAL SO I OVERHAULED THE COOLING SYSTEM INCLUDING: NEW THERMOSTAT, NEW COOLING FAN (OLD ONE WAS CRACKED ALL AROUND THE HUB), NEW FAN CLUTCH, NEW RADIATOR, NEW ENGINE COOLANT TEMPERATURE SENSOR, AND NEW FLUID FLUSH AND REFILL. THE TEMPERATURE GAUGE STILL READS THE SAME. I HAVE NO IDEA WHAT TO DO NOW. ANY RECALL INFORMATION YOU COULD PROVIDE WOULD HELP. I HAVE ALL RECEIPTS FOR PARTS PURCHASED AND WORK PERFORMED.*AK
NHTSA ODI #10086453
Mileage unknown · Apr 12, 2004
Engine And Engine CoolingEquipment
I HAD THE FUEL SYSTEM ON MY 1994 FORD EXPLORER REPLACED BY PEP BOYS IN CRESTWOOD, ILLINOIS. TODAY I LEARNED THAT THEY HAD BOTCHED THE JOB TO THE POINT THAT GASOLINE WAS BEING SPRAYED ONTO THE MANIFOLD OF THE VEHICLE WHICH COULD HAVE RESULTED IN A FIRE OR AND EXPLOSION. WHY IT DIDN'T HAPPEN IS SERENDIPITY FOR ME. WHEN I CALLED…
Read full complaint
I HAD THE FUEL SYSTEM ON MY 1994 FORD EXPLORER REPLACED BY PEP BOYS IN CRESTWOOD, ILLINOIS. TODAY I LEARNED THAT THEY HAD BOTCHED THE JOB TO THE POINT THAT GASOLINE WAS BEING SPRAYED ONTO THE MANIFOLD OF THE VEHICLE WHICH COULD HAVE RESULTED IN A FIRE OR AND EXPLOSION. WHY IT DIDN'T HAPPEN IS SERENDIPITY FOR ME. WHEN I CALLED PEP BOYS THEY INFORMED ME THAT THEY DON'T INSPECT THEIR WORK. NEITHER THE TECHNICIAN, THE SUPERVISOR, OR ANY KIND OF QUALITY CONTROL MECHANISM CHECKS FOR DEFECTIVE WORK. SUCH A LACK OF CONTROL, PARTICULARLY WHEN DEALING WITH THE FUEL SYSTEM, REPRESENTS A SUBSTANTIAL THREAT TO ANYONE WHO HAS WORK DONE AT PEP BOYS.*AK
NHTSA ODI #10065971
Mileage unknown · Dec 24, 2003
Engine And Engine CoolingFire
WHILE DRIVING ON HIGHWAY VEHICLE CAUGHT ON FIRE.*MR WHILE DRIVING THE CONSUMER NOTICED SMOKE IN HIS REAR VIEW MIRROR. THE CONSUMER PULLED OVER, EXITED THE VEHICLE, LOOKED UNDER THE CAR AND NOTICED FLAMES COMING FROM UNDER THE ENGINE. A PASSER BY AND A SAFETY CREW ATTEMPTED TO EXTINGUISH THE FIRE BUT WERE UNSUCCESSFUL. …
Read full complaint
WHILE DRIVING ON HIGHWAY VEHICLE CAUGHT ON FIRE.*MR WHILE DRIVING THE CONSUMER NOTICED SMOKE IN HIS REAR VIEW MIRROR. THE CONSUMER PULLED OVER, EXITED THE VEHICLE, LOOKED UNDER THE CAR AND NOTICED FLAMES COMING FROM UNDER THE ENGINE. A PASSER BY AND A SAFETY CREW ATTEMPTED TO EXTINGUISH THE FIRE BUT WERE UNSUCCESSFUL. THE CONSUMER REMOVED PERSONAL BELONGINGS FROM THE VEHICLE BEFORE IT BECAME TOTALLY ENGULFED IN FLAMES. *PH *NM
NHTSA ODI #10053304
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration