NHTSA owner reports · September 18, 2026 snapshot.
Electrical System complaints
75 reportsClear category filter185,876 miles · Jan 5, 2011
Electrical SystemFire
1994 FORD EXPLORER HAD SMOKE COMING OUT OF THE AIR-CONDITIONER VENTS INTO THE PASSENGER COMPARTMENT, SLIGHT AT FIRST, THEN SO HEAVY THAT FORWARD VISIBILITY WAS OBSCURED. AFTER STOPPING THE VEHICLE, A SMALL FIRE WAS SEEN BURNING THE PLASTIC EVAPORATOR COVER WHERE THE BLOWER MOTOR RESISTOR ASSEMBLY IS MOUNTED IN THE EVAPORATOR COV…
Read full complaint
1994 FORD EXPLORER HAD SMOKE COMING OUT OF THE AIR-CONDITIONER VENTS INTO THE PASSENGER COMPARTMENT, SLIGHT AT FIRST, THEN SO HEAVY THAT FORWARD VISIBILITY WAS OBSCURED. AFTER STOPPING THE VEHICLE, A SMALL FIRE WAS SEEN BURNING THE PLASTIC EVAPORATOR COVER WHERE THE BLOWER MOTOR RESISTOR ASSEMBLY IS MOUNTED IN THE EVAPORATOR COVER. SOME SNOW THROWN ON THE FIRE PUT IT OUT. THE BLOWER MOTOR APPEARS TO BE SHORTED OR MAYBE JAMMED FROM ROTATING, CAUSING THE RESISTOR TO GET HOTTER THAN NORMAL, IGNITING THE PLASTIC COVER. MAYBE LEAVES OR OTHER FLAMMABLE DEBRIS CONTACTED THE RESISTOR, BUT I CAN'T TELL AS THE FLAMES BURNED UP ANYTHING IN THE AREA AROUND THE RESISTOR ASSEMBLY. FORTUNATELY, I WAS ABLE TO BRING THE VEHICLE TO A SAFE STOP, IN SPITE OF VERY LIMITED VISIBILITY IN THE HEAVY SMOKE. I WAS ON A SLOW SPEED, LOW TRAFFIC CITY STREET. THE RESULTS WOULD HAVE BEEN MUCH WORSE IF THE FIRE OCCURRED AT HIGHWAY SPEEDS. THE BLOWER MOTOR WILL BE AVAILABLE FOR INSPECTION WHEN I REMOVE AND REPLACE IT TO TRY AND GET THE AIR SYSTEM WORKING FOR HEAT AT LEAST. *TR
NHTSA ODI #10374872
150,000 miles · Feb 11, 2010
Electrical SystemFire
WHILE DRIVING, THE SUV CAUGHT FIRE FROM UNDER THE HOOD. THE VEHICLE WAS CONSUMED BY FLAMES IN LESS THAN 5 MINUTES. ALTHOUGH MANY MAKES AND MODELS OF FORDS HAVE BEEN RECALLED ( FAULTY CRUISE CONTROL - POTENTIAL FIRE HAZARD), THE 1994 FORD EXPLORER HAS NOT BEEN RECALLED. *TR
NHTSA ODI #10308714
150,000 miles · Jun 13, 2008
Electrical SystemFire
TL*THE CONTACT OWNS A 1994 FORD EXPLORER. WHILE DRIVING BETWEEN 25-30 MPH, WHITE SMOKE APPEARED FROM THE AIR CONDITIONING VENTS. THE CONTACT PULLED OVER AND EXITED THE VEHICLE. THE VEHICLE CONTINUED TO SMOKE AND THEN CAUGHT FIRE ON THE FRONT PASSENGER SIDE UNDERNEATH THE VEHICLE. THE VEHICLE WAS DESTROYED. A FIRE REPORT WAS…
Read full complaint
TL*THE CONTACT OWNS A 1994 FORD EXPLORER. WHILE DRIVING BETWEEN 25-30 MPH, WHITE SMOKE APPEARED FROM THE AIR CONDITIONING VENTS. THE CONTACT PULLED OVER AND EXITED THE VEHICLE. THE VEHICLE CONTINUED TO SMOKE AND THEN CAUGHT FIRE ON THE FRONT PASSENGER SIDE UNDERNEATH THE VEHICLE. THE VEHICLE WAS DESTROYED. A FIRE REPORT WAS FILED. THE CURRENT AND FAILURE MILEAGES WERE 150,000.
NHTSA ODI #10230920
145,000 miles · Apr 25, 2007
Electrical SystemFire
TL*THE CONTACT OWNS A 1994 FORD EXPLORER. WHILE DRIVING 2 MPH THE CONTACT ACTIVATED THE HEATER AND NOTICED SMOKE COMING FROM THE VENTS. SHE TURNED OFF THE ENGINE. SHE THEN RESTARTED THE VEHICLE AND ACTIVATED THE AIR CONDITIONER. THE CONTACT NOTICED FIRE ASCENDING FROM THE HOOD NEAR THE PASSENGER SIDE OF THE VEHICLE. THE FIR…
Read full complaint
TL*THE CONTACT OWNS A 1994 FORD EXPLORER. WHILE DRIVING 2 MPH THE CONTACT ACTIVATED THE HEATER AND NOTICED SMOKE COMING FROM THE VENTS. SHE TURNED OFF THE ENGINE. SHE THEN RESTARTED THE VEHICLE AND ACTIVATED THE AIR CONDITIONER. THE CONTACT NOTICED FIRE ASCENDING FROM THE HOOD NEAR THE PASSENGER SIDE OF THE VEHICLE. THE FIRE DEPARTMENT EXTINGUISHED THE FIRE. THE MANUFACTURER STATED THAT THEY WOULD CONDUCT AN INVESTIGATION TO DETERMINE THE CAUSE OF THE FIRE. THE VEHICLE HAS NOT BEEN INSPECTED YET, AND THE INSURANCE COMPANY WAS UNABLE TO DETERMINE THE CAUSE OF THE FIRE. THE CURRENT AND FAILURE MILEAGES WERE 145,000.*AK
NHTSA ODI #10188814
7,300 miles · Feb 17, 2006
Electrical SystemPower TrainSuspension
(1) PURCHASE OF A NEW 2002 FORD EXPLORER; (2) DEFECTIVE VEHICLE FROM THE ONSET. ONGOING PROBLEMS WITH SERIOUS "SAFETY" ISSUES. (3) HAVE REPEATED TAKEN THE VEHICLE INTO THE DEALERSHIP, BUT THE PROBLEMS HAVE NOT BEEN RECTIFIED. *NM
NHTSA ODI #10150527
129,980 miles · Sep 14, 2005
Electrical System
I BOUGHT THIS 1994 FORD EXPLORER EDDIE BAUER SUV FROM A DEALER. THE CAR HAD A PROBLEM WITH ALARM SO THE DEALER REMOVED IT. THE ABS LIGHT COMES ON AND OFF. A WEEK AFTER THE PURCHASE, WHILE DRIVING, THE ENGINE STOPS, CAR COMES TO A HALT IN THE MIDDLE OF THE ROAD, AND THE STEERING LOCKS. I ALMOST GOT HIT BY A TRUCK. IT STARTS BACK …
Read full complaint
I BOUGHT THIS 1994 FORD EXPLORER EDDIE BAUER SUV FROM A DEALER. THE CAR HAD A PROBLEM WITH ALARM SO THE DEALER REMOVED IT. THE ABS LIGHT COMES ON AND OFF. A WEEK AFTER THE PURCHASE, WHILE DRIVING, THE ENGINE STOPS, CAR COMES TO A HALT IN THE MIDDLE OF THE ROAD, AND THE STEERING LOCKS. I ALMOST GOT HIT BY A TRUCK. IT STARTS BACK ON AFTER FEW MINUTES. IT DOES NOT START IF HAZARDS, HEADLIGHTS OR ANY ELECTRICAL COMPONENTS ARE ON. AFTER THAT THE SAME THING HAPPENED 5 TIMES IN 2 WEEKS ONCE AT NIGHT 12''O CLOCK. IT IS HIGHLY UNSAFE TO DRIVE THE CAR NOW. I'M NOT DRIVING IT ANYMORE. THE DEALER DOES NOT KNOW WHAT THE PROBLEM IS AND DOES NOT WANT TO TAKE THE CAR BACK. *JB
NHTSA ODI #10136448
124,000 miles · Jun 1, 2005
Electrical SystemFire
DT: 1994, FORD, EXPLORER LIMITED, CONSUMER WAS DRIVING ON HIGHWAY WHEN THE VEHCILE STARTED SMOKING. CONSUMER STARTED HAVING BREATHING PROBLEMS. THE SMOKE STARTED THICK, AND CONSUMER COULDN'T SEE, AND HE PULLED OVER. WHEN THE CONSUMER GOT OUT OF THE CAR HE EEN SPARKS, THEN THE CAR BLEW UP. OWNER HAD NO PHYSICAL INJURIES. THE F…
Read full complaint
DT: 1994, FORD, EXPLORER LIMITED, CONSUMER WAS DRIVING ON HIGHWAY WHEN THE VEHCILE STARTED SMOKING. CONSUMER STARTED HAVING BREATHING PROBLEMS. THE SMOKE STARTED THICK, AND CONSUMER COULDN'T SEE, AND HE PULLED OVER. WHEN THE CONSUMER GOT OUT OF THE CAR HE EEN SPARKS, THEN THE CAR BLEW UP. OWNER HAD NO PHYSICAL INJURIES. THE FIRE WAS SO HOT THAT TIRES MELTED AND EVEN THE KEYS MELTED. *AK
NHTSA ODI #10123740
120,000 miles · Apr 27, 2005
Electrical SystemFire
VEHICLE WAS ON THE ROAD WHEN ALL OF A SUDDEN ENGINE CAUGHT ON FIRE TOOK VEHICLE TO DEALER FOR CHECKUP, BUT THE CAUSE WAS UNDETERMINED AT THIS TIME.*AK
NHTSA ODI #10119216
70,000 miles · Mar 4, 2005
Electrical SystemFire
CAUGHT FIRE WHILE DRIVING UNDER DASH TOTAL LOSS TO VEHICLE. *AK
NHTSA ODI #10112531
90,000 miles · Feb 28, 2005
Electrical SystemFire
ON JULY 31, 2004, AT 5:00AM, I WAS AWAKEN BY POUNDING ON MY DOORS AND WINDOWS. AS I WAS COMING DOWN THE STAIRS I LOOKED OUT THE WINDOW CAUSE I SAW ALOT OF LIGHT. I OPENED THE DOOR TO FIND THE FIRE DEPARTMENT TELLING ME AND MY KIDS TO GET OUT OF THE HOUSE. HE STATED THAT MY CAR WAS ON FIRE. THIS HAD HAPPEN AFTER MY CAR HAD BEEN P…
Read full complaint
ON JULY 31, 2004, AT 5:00AM, I WAS AWAKEN BY POUNDING ON MY DOORS AND WINDOWS. AS I WAS COMING DOWN THE STAIRS I LOOKED OUT THE WINDOW CAUSE I SAW ALOT OF LIGHT. I OPENED THE DOOR TO FIND THE FIRE DEPARTMENT TELLING ME AND MY KIDS TO GET OUT OF THE HOUSE. HE STATED THAT MY CAR WAS ON FIRE. THIS HAD HAPPEN AFTER MY CAR HAD BEEN PARKED IN THE SAME SPOT SINCE 7:00PM THE PRIOR DAY. MY VEHICLE WAS A 1994 FORD EXPLORER XL, 4 DOOR. THANK GOD THAT SOMEONE HAD SAW IT BECAUSE WHERE MY VEHICLE WAS PARKED WAS RIGHT NEXT TO MY GAS METER ON THE HOUSE. THIS COULD OF KILLED ME AND MY CHILDREN. THE FIRE DEPARTMENT HAD TO PRY OPEN MY HOOD TO PUT THE FIRE OUT. THEY EVEN TRYED BREAKING OUT MY WINDOW TO GET TO IT. BY THEN THE WHOLE ENGINE COMPARTMENT WAS DESTROYED THE DASH BOARD, GLOVE BOX AND EVERYTHING IN THE FRONT END WAS DESTROYED. I ONLY HAD NO-FAULT INSURANCE SO THEY TOLD ME THERE WAS NOTHING TO BE DONE. I DIDN'T RECEIVE ANYTHING TO HELP ME FIX OR REPLACE IT. I HAD TO CALL A TOW TRUCK TO TAKE IT AWAY. I DIDN'T RECEIVE ANYTHING FROM THEM EITHER. I DID TAKE PICTURES OF THE VEHICLE AFTER THIS HAPPENED.
NHTSA ODI #10112308
NHTSA investigations
13EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration