NHTSA owner reports · September 18, 2026 snapshot.
Tires complaints
243 reportsClear category filter68,940 miles · May 23, 2013
Tires
MICHELIN LTX M/S XL P235/75R-15 ON 93 EXPLORER XL. TIRES ARE 5 YRS OLD WITH LESS THAN 5000 MILES. SERIES OF SIDEWALL CRACKS ABOUT 8" LONG APPEARED IN FRONT RIGHT TIRE, APPROX 5/8" FROM RIM, WITH THE LONGEST CRACK ABOUT 4" LONG AND 0.11" DEEP. NO FAILURE YET, AND THE AMERICAS TIRE DEALER SAYS THE CRACKS ARE NOT A PROBLEM, BUT T…
Read full complaint
MICHELIN LTX M/S XL P235/75R-15 ON 93 EXPLORER XL. TIRES ARE 5 YRS OLD WITH LESS THAN 5000 MILES. SERIES OF SIDEWALL CRACKS ABOUT 8" LONG APPEARED IN FRONT RIGHT TIRE, APPROX 5/8" FROM RIM, WITH THE LONGEST CRACK ABOUT 4" LONG AND 0.11" DEEP. NO FAILURE YET, AND THE AMERICAS TIRE DEALER SAYS THE CRACKS ARE NOT A PROBLEM, BUT THE NUMBER OF COMPLAINTS OF SIDEWALL CRACKING AND BLOWOUTS IN MICHELIN TIRES CONCERNS US. *TR
NHTSA ODI #10513334
100,000 miles · Sep 11, 2012
TiresCrashInjury
TL*THE CONTACT OWNS A 1993 FORD EXPLORER EQUIPPED WITH FIRESTONE TIRES, TIRE LINE ATX, AND LINE SIZE P235/75R15. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE TREAD OF THE REAR DRIVER SIDE TIRES SEPARATED. AS A RESULT, SHE LOST CONTROL OF THE VEHICLE AND FLIPPED OVER. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED AND …
Read full complaint
TL*THE CONTACT OWNS A 1993 FORD EXPLORER EQUIPPED WITH FIRESTONE TIRES, TIRE LINE ATX, AND LINE SIZE P235/75R15. THE CONTACT STATED THAT WHILE DRIVING 65 MPH, THE TREAD OF THE REAR DRIVER SIDE TIRES SEPARATED. AS A RESULT, SHE LOST CONTROL OF THE VEHICLE AND FLIPPED OVER. THE VEHICLE WAS DESTROYED. A POLICE REPORT WAS FILED AND FOUR PASSENGERS HAD MINOR INJURIES. THE TIRES WERE NOT THE ORIGINAL TIRES. THE VIN WAS NOT AVAILABLE. THE FAILURE MILEAGE WAS 100,000.
NHTSA ODI #10475064
Mileage unknown · Jan 5, 2005
Tires
WHILE TRAVELING SPARE TIRE SHEARED OFF FROM UNDERNEATH THE VEHICLE. NO INJURIES TO REPORT. THE DRIVER WAS ABLE TO RETRIEVE THE TIRE. GOODYEAR, WRANGLER, LTR 235/75R15. *AK
NHTSA ODI #10106836
Mileage unknown · Nov 30, 2004
Engine And Engine CoolingEquipmentService Brakes, Hydraulic
MULTIPLE FAILURES, CONTINUALLY BRAKE PROBLEMS. THE VEHICLE ALSO OVERHEATED, THERMOSTAT REPLACED SEVERAL TIMES. A/C COMPRESSOR MALFUNCTION, ETC. *BF A BLOWOUT RIPPED THE RUNNING BOARD ASSEMBLY, THE ABS LIGHT WAS INTERMITTENT AND THE MECHANIC COULD NOT FIGURE OUT WHY, THE BRAKES LOCKED UP ON THE VEHICLE AND VIOLENTLY SKIDDED …
Read full complaint
MULTIPLE FAILURES, CONTINUALLY BRAKE PROBLEMS. THE VEHICLE ALSO OVERHEATED, THERMOSTAT REPLACED SEVERAL TIMES. A/C COMPRESSOR MALFUNCTION, ETC. *BF A BLOWOUT RIPPED THE RUNNING BOARD ASSEMBLY, THE ABS LIGHT WAS INTERMITTENT AND THE MECHANIC COULD NOT FIGURE OUT WHY, THE BRAKES LOCKED UP ON THE VEHICLE AND VIOLENTLY SKIDDED TO A STOP, THE EXHAUST WAS REPLACED TWICE, THERE WAS A NOISE THAT LINGERED ON IN THE FRONT END AND A LOUD CREAKING SOUND. *SC
NHTSA ODI #10101884
Mileage unknown · Aug 12, 2004
Tires
GOODYEAR REGATTA 2 TIRES.*MR ONE OF THE TIRES HAS A CONCAVE/CIRCULAR INDENTATION OF APPROXIMATELY 1/2-3/4 INCH BEGINNING AT THE TREAD SURFACE AND RUNNING VERTICALLY UP THE SIDEWALL ARE 2-3 INCHES FROM THE OUTER TREAD. *NM
NHTSA ODI #10089283
91,000 miles · Jul 17, 2004
TiresCrash
DUNLOP LIGHT TRUCK TIRES LT 235-75R15 RADIAL ROVER AT FIRST PROBLEM WAS A TIRE BLISTER THAT CAUSED AN UNEVEN TIRE WEAR PROBLEM. I BROUGHT THE TIRE BACK TO THE TIRE STORE, WHERE I PURCHASED SAID TIRES, AND WAS TOLD THAT IT WAS A ROAD HAZARD THAT CAUSED THE FAILURE. NO WARRANTY COVERAGE ON THE TIRE, EVEN THOUGH I HAD PUT LESS …
Read full complaint
DUNLOP LIGHT TRUCK TIRES LT 235-75R15 RADIAL ROVER AT FIRST PROBLEM WAS A TIRE BLISTER THAT CAUSED AN UNEVEN TIRE WEAR PROBLEM. I BROUGHT THE TIRE BACK TO THE TIRE STORE, WHERE I PURCHASED SAID TIRES, AND WAS TOLD THAT IT WAS A ROAD HAZARD THAT CAUSED THE FAILURE. NO WARRANTY COVERAGE ON THE TIRE, EVEN THOUGH I HAD PUT LESS THAN 50% WEAR ON TIRE. ON JUNE 13, 2004, WHILE RETURNING FRIM A TRIP DOWN TO LONG BEACH, HEADING NORTH BOUND ON INTERSTATE 5 IN CALIFORNIA I EXPERIENCED A COMPLETE TIRE FAILURE OF THE LEFT REAR TIRE. THE TIRE DETREADED OR BLEW ITS TREAD OFF AND THIS CAUSED ME TO LOOSE CONTROL OF MY FORD EXPLORER ( BUBBLES, WAS THE CARS NAME SINCE SHE WAS CHAMPAGNE COLORED ). I SLID BETWEEN THE LANES OF THE HIGHWAY TRYING TO REGAIN CONTROL OF MY CAR. I DIDN'T REGAIN CONTROLL BUT ENDED UP ROLLING IT DOWN THE SHOULDER AND AFTER BOUNCING AROUND LANDED UPRIGHT ON MY TIRES FACING THE WRONG DIRECTION. SOME HOW I DIDN'T GET HURT BUT I DID DESTROY MY 1993 EXPLORER. THE TRUCK I LOVED AND SINCE I DIDN'T GET HURT IN THE ROLL OVER I HAVE ZERO COMPLAINTS ABOUT MY FORD IN FACT I THINK I WILL TELL THEM ABOUT THE ROLL OVER AND THANK THEM FOR BUILDING A CAR THAT I ROLLED AND STILL DIDN'T GET HURT. MY DUNLOPS TIRES ON THE OTHER HAND I HAVE MANY COMPLAINTS, ONE COMPLETE TIRE FAILURE THAT DIRECTLY LEAD TO ME WRECKING MY CAR AND ONE BLISTER THAT MAY OR MAY NOT HAVE BEEN A ROAD HAZARD. I WOULD LIKE TO REPORT THIS TO YOU TO SEE IF ANYONE ELSE HAS HAD SIMILAR PROBLEMS WITH THESE TIRES AND IF YOU NEED TO RESEARCH INTO THIS. I KNOW I AM LUCKY TO NOT HAVE BEEN INJURED BUT FEEL LIKE YOU SHOULD KNOW ABOUT THIS PROBLEM. THANK YOU FOR LISTENING TO ME. *AK, *GEM
NHTSA ODI #10081272
144,000 miles · Feb 26, 2004
Tires
RIGHT REAR TIRE SIDEWALL BLEW OUT AT 45 MPH IN FOUR DIFFERENT PLACES. *AK
NHTSA ODI #10059868
144,000 miles · Feb 26, 2004
Tires
RIGHT REAR TIRE SIDEWALL BLEW OUT AT 45 MPH IN 4 DIFFERENT SECTIONS. AS A RESULT, VEHICLE ALMOST FLIPPED OVER. *AK
NHTSA ODI #10059832
Mileage unknown · Jun 30, 2003
Tires
CONSUMER STATES THAT HIS WIFE WAS DRIVING AT APPROX IMATELY60 MPH, AND DRIVER'S SIDE REAR TIRE SEPARATED FROM THE SIDEWALL , CAUSING HER TO HAVE A BLOWOUT. SHE DID NOT HAVE AN ACCIDENT BECAUSE SHE WAS ABLE TO GET IN A SAFE PLACE TO STOP. CONSUMER STATES THAT HIS WIFE WAS DRIVING A 1993 ,FORD, EXPLORER. CONSUMER STATES THAT THE…
Read full complaint
CONSUMER STATES THAT HIS WIFE WAS DRIVING AT APPROX IMATELY60 MPH, AND DRIVER'S SIDE REAR TIRE SEPARATED FROM THE SIDEWALL , CAUSING HER TO HAVE A BLOWOUT. SHE DID NOT HAVE AN ACCIDENT BECAUSE SHE WAS ABLE TO GET IN A SAFE PLACE TO STOP. CONSUMER STATES THAT HIS WIFE WAS DRIVING A 1993 ,FORD, EXPLORER. CONSUMER STATES THAT THE TIRES WERE PURCHASED APPROXIMATELY ONE AND A HALF YEARS AGO, AND HAD ABOUT 3000 MILES.*AK
NHTSA ODI #10026287
Mileage unknown · Apr 30, 2003
Tires
THE FRONT OF THE VIBRATED EXCESSIVELY, ESPECIALLY WHEN EXCEEDING 65 MPH. THE DEALER STATED THE SHAPE AND DESIGN OF THE TIRES CAUSED THE PROBLEM. *JB
NHTSA ODI #10017885
NHTSA investigations
14EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96074 · Sunroof (air Roof) Shatter
Opened Dec 17, 1996 · Closed May 23, 1997
Status: closed (inferred from source dates) · Structure
THE SUNROOF SHATTERED OR WAS BLOWN OFF.IN ALL BUT ONE CASE THIS OCCURRED WHILE DRIVING.
PE96066 · Driver Door Electrical Fire
Opened Nov 22, 1996 · Closed May 15, 1997
Status: closed (inferred from source dates) · Electrical System
THE CONTACT ASSEMBLY FOR THE REMOTE POWER MIRROR CONTROL SWITCH MAY DEVELOP A SHORT CIRCUIT BETWEEN THE SWITCH POSITIVE PAD AND CHASSIS GROUND PAD AS A RESULT OF WATER INTRUSION.EXCESS CURRENT FLOW RESULTING FROM THE SHORT CIRCUIT CONDITION MAY OVERHEAT THE REMOTE POWER MIRROR CONTROL SWITCH CIRCUIT BOARD AND CAUSE A FIRE IN THE DRIVER'S DOOR.FORD HAS INDICATED THAT CURRENT IN EXCESS OF 15 AMPS CAN OVERHEAT THE CIRCUIT BOARD ENOUGH TO CAUSE A FIRE.CIRCUIT PROTECTION IS PROVIDED BY A 30 AMP FUSE.FORD IS RECALLING ALL 1993-94 4-DOOR EXPLORER VEHICLES EQUIPPED WITH THE SUBJECT ELECTRONIC OPTION COMBINATION TO INSTALL AN IN-LINE 10 AMP FUSE IN THE POSITIVE BATTERY FEED TO THE REMOTE POWER MIRROR CONTROL SWITCH ASSEMBLY.NO 2-DOOR EXPLORER VEHICLES WERE BUILT WITH THE SUBJECT COMPONENTS.ACCORDING TO FORD, VEHICLES BUILT PRIOR TO THE RECALL PRODUCTION RANGE WERE EQUIPPED WITH LOWER CAPACITY CIRCUIT BOARDS FOR THE SUBJECT SWITCH ASSEMBLY THAT WOULD FAIL FROM AN OPEN CIRCUIT IF A SIMILAR SHORT OCCURRED.A NEW SWITCH ASSEMBLY WITH 10 AMP FUSE PROTECTION WAS INTRODUCED BEGINNING WITH THE 1995 MODEL YEAR EXPLORER.MAZDA WILL CONDUCT A PARALLEL COMPAIGN (97V-083.002) TO REMEDY THE SUBJECT CONDITION IN APPROXIMATELY 14,000 NAVAJO VEHICLES.THE NAVAJO VEHICLES WERE AVAILABLE IN ONLY THE 2-DOOR VERSION WHICH, UNLIKE THE EXPLORER VEHICLES, DID USE THE SUBJECT OPTION COMBINATION IN THAT BODY STYLE.
EA96017 · Brake System Malfunction
Opened Jul 24, 1996 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE96016 · Wheel Lockup With Antilock Brake System
Opened Feb 28, 1996 · Closed Jul 24, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic:antilock/traction Control/electronic Limited Slip
ODI HAS RECEIVED OND HUNDRED SEVENTY-THREE (173) CONSUMER COMPLAINTS OF ALLEGED FAILURES OR MALFUNCTIONS IN THE BRAKING SYSTEM ON CERTAIN 1993 AND 1994 FORD EXPLORERS.THESE ALLEGED FAILURES OR MALFUNCTIONS ARE REPORTED TO HAVE CAUSED THIRTY-SIX (36) ACCIDENTS RESULTING FROM VEHICLE LOSS OF DIRECTIONAL CONTROL DURING BRAKING OR FROM THE EXTENDED DISTANCE REQUIRED TO STOP THE VEHICLE DURING BRAKING.THE COMPLAINANTS REPORT THAT THE ALLEGED FAILURES OR MALFUNCTIONS OCCURRED DURING BRAKING MOSTLY ON WET OR SLIPPERY ROADS, BUT ALSO HAVE OCCURRED ON DRY ROADS.SINCE ODI OPENED THIS PE BASED ON WHEEL LOCKUP COMPLAINTS, WE HAVE RECEIVED NUMEROUS ADDITIONAL COMPLAINTS AB OUT THE EXTENDED DISTANCE REQUIRED TO STOP THE SUBJECT VEHICLES WHEN BRAKING UNDER CERTAIN ROAD AND SPEED CONDITIONS.IN RESPONSE TO ODI'S INFORMATION REQUEST (IR) CONCERNING WHEEL LOCKUP COMPLAINTS ONT HE SUBJECT VEHICLES, FORD REPORTED RECEIVING 416 REPORTS (FIELD REPORTS, OWNER COMPLAINTS, AND SUBROGATION CLAIMS) OF WHEEEL LOCKUP ON 1993 AND 1994 FORD EXPLORERS, WITH 24 ALLEGED ACCIDENTS.IN ADDITION, FORD REPORTED RECEIVING 24,916 WARRANTY CLAIMS THAT COULD RELATE TO THE ALLEGED DEFECT OF WHEEL LOCKUP DURING BRAKING ON THE SUBJECT VEHICLES.AN ENGINEERING ANALYSIS IS WARRANTED TO DETERMINE THE SCOPE OF THESE ALLEGED BRAKING SYSTEM FAILURES OR MALFUNCTIONS ON 1993 AND 1994 FORD EXPLORERS.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
Illustration