NHTSA owner reports · September 18, 2026 snapshot.
Vehicle Speed Control complaints
14 reportsClear category filter111,130 miles · Apr 23, 2007
Vehicle Speed ControlFire
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. WHILE AT A STOP SIGN SMOKE ASCENDED FROM UNDERNEATH THE HOOD, AND CONTACT COULD SMELL SOMETHING BURNING. AFTER ALL PASSENGERS EXITED THE VEHICLE FLAMES IGNITED FROM THE HOOD. THERE WERE NO INJURIES. THE FIRE DEPARTMENT PUNCTURED THE HOOD DUE TO THE FLAMES. HOWEVER, THEY OPENED TH…
Read full complaint
TL* THE CONTACT OWNS A 1992 FORD EXPLORER. WHILE AT A STOP SIGN SMOKE ASCENDED FROM UNDERNEATH THE HOOD, AND CONTACT COULD SMELL SOMETHING BURNING. AFTER ALL PASSENGERS EXITED THE VEHICLE FLAMES IGNITED FROM THE HOOD. THERE WERE NO INJURIES. THE FIRE DEPARTMENT PUNCTURED THE HOOD DUE TO THE FLAMES. HOWEVER, THEY OPENED THE HOOD AND EXTINGUISHED THE FIRE. THERE WERE NO WARNING INDICATOR LIGHTS PRESENT PRIOR TO THE FAILURE. ON APRIL 16, 2007 THE OIL WAS CHANGED AND THE FLUIDS WERE AT NORMAL LEVELS. THE FIRE DEPARTMENT DIAGNOSED THE FAILURE AS THE CRUISE CONTROL, AND STATED THAT THIS WAS A KNOWN OCCURRENCE FOR FORD VEHICLES. THE CURRENT AND FAILURE MILEAGES WERE 111,130.*AK
NHTSA ODI #10188572
Mileage unknown · Mar 15, 2005
Vehicle Speed ControlCrashInjury
VEHICLE EXPERIENCED SUDDEN ACCELERATION,VEHICLE FAILED TO STOP, AND RESULTING IN A CRASH. MANUFACTURER WAS NOTIFIED BY CONSUMER.*AK VEHICLE WAS ALREADY AT A STAND STILL WHEN IT SUDDENLY ACCELERATED. *TT
NHTSA ODI #10109533
Mileage unknown · Apr 25, 2000
Vehicle Speed Control
WHILE AT A STOP IN A DRIVEWAY WAITING TO ENTER TRAFFIC THE CAR SUDDENLY LURCHED FORWARD. AT FIRST I THOUGHT THAT THROUGH SOME LACK OF ATTENTION THAT I HAD SOMEHOW STEPPED ON THE GAS. MAKING SURE TO FIRMLY PUT MY FOOR ON THE BRAKE, IT HAPPENED AGAIN 30 SECONDS LATER. AT THAT TIME I NOTICED THAT THE TACHOMETER WENT UP TO 1500 …
Read full complaint
WHILE AT A STOP IN A DRIVEWAY WAITING TO ENTER TRAFFIC THE CAR SUDDENLY LURCHED FORWARD. AT FIRST I THOUGHT THAT THROUGH SOME LACK OF ATTENTION THAT I HAD SOMEHOW STEPPED ON THE GAS. MAKING SURE TO FIRMLY PUT MY FOOR ON THE BRAKE, IT HAPPENED AGAIN 30 SECONDS LATER. AT THAT TIME I NOTICED THAT THE TACHOMETER WENT UP TO 1500 RPM. THIS HAPPENED ONE MORE TIME IN THE NEXT HALF HOUR. I PARKED THE CAR AND LATER WHEN I TRIED TO START THE CAR TO CHECK FOR A PROBLEM THE ENGINE FAILED TO CRANK OVER. I FOUND THAT THE + CONNECTOR ON THE WIRE TO THE BATTERY HAD CRACKED MAKING A LOOSE CONNECTION. I AM AN ENGINEER WHO DESIGNS MICROPROCESSOR CONTROL SYSTEMS AND BELIEVE THIS IS A SOFTWARE PROBLEM. IT IS MY OPINION THAT THIS INTERMITENT CONNECTION BRAKE TO THE BATTERY (SPIKE OR LOSS OF VOLTAGE) CAUSED THE COMPUTER TO RESET AND OPEN THE IDLE ADJUST CONTROL VALVE MOMENTARILY AS IF THE ENGINE WAS FIRST BEING STARTED. I BELIEVE THIS PROBLEM COULD EASILY BE REPEATED IN A TEST AND I WOULD HAVE DONE IT IF THERE WASN'T A GOOD CHANCE THAT I COULD HAVE ZAPPED MY COMPUTER AT MY EXPENSE. I THINK THIS IS SERIOUS BECAUSE IF SOMEONE WOULD HAVE BEEN WALKING ON THE SIDEWALK OR BEEN BEHIND A CAR AT AN INTERSECTION I WOULD HAVE HIT THEM. THERE SHOULD BE A CHECK IN THE PROGRAM THAT PREVENTS THE VALVE FROM OPENING MAX IF THE ENGINE IS RUNNING.*AK
NHTSA ODI #721902
Mileage unknown · Feb 23, 2000
Vehicle Speed Control
ENGINE SPEED INCREASES TO 25OO RPM FROM IDLE WHEN IN PARK AND INADVERTANTLY CHANGES FROM 200 TO 300 RPM WHILE NORMAL DRIVING. *AK
NHTSA ODI #719137
Mileage unknown · Oct 27, 1999
Fuel System, GasolineVehicle Speed Control
ON-GOING / INTERMITTENT PROBLEM WITH VEHICLE SUDDENLY ACCELERATING. WHENEVER RPMS REACHED 3500, THEY CAUSED ACCELERATION. ALSO, VAPOR LOCK FAILURE. CONTACTED.
NHTSA ODI #852041
Mileage unknown · Mar 10, 1999
Vehicle Speed Control
TWICE DURING SAME ROAD TRIP THE THROTTLE FROZE, ONCE IN THE FULL OPEN POSITION AND ONCE IN AN INTERMEDEATE POSITION. ON THE FIRST OCCASION I HAD TO TURN THE ENGINE OFF WITH THE KEY AND ON THE SECOND IT RETURNED TO THE NORMAL POSITION ON ITS OWN. THE FORD GARAGE DETERMINED THAT THE THROTTLE BODY WAS STICKING AND APPLIED A CLEANIN…
Read full complaint
TWICE DURING SAME ROAD TRIP THE THROTTLE FROZE, ONCE IN THE FULL OPEN POSITION AND ONCE IN AN INTERMEDEATE POSITION. ON THE FIRST OCCASION I HAD TO TURN THE ENGINE OFF WITH THE KEY AND ON THE SECOND IT RETURNED TO THE NORMAL POSITION ON ITS OWN. THE FORD GARAGE DETERMINED THAT THE THROTTLE BODY WAS STICKING AND APPLIED A CLEANING AGENT TO THE SYSTEM WHICH APPEARS TO HAVE CORRECTED THE PROBLEM.
NHTSA ODI #704239
Mileage unknown · Mar 9, 1999
Vehicle Speed Control
I STARTED THE VEHICLE AND PLACED THE TRANSMISSION IN REVERSE TO BACK OUT OF A PARKING SPOT. AS SOON AS THE TRANSMISSION WENT INTO REVERSE, THE ENGINE REVVED TO WHAT SEEMED TO BE FULL THROTTLE. I PANICED AND CHANGED THE TRANSMISSION TO NEUTRAL BUT ACCIDENTALLY WENT PAST NEUTRAL AND INTO DRIVE. AT THIS POINT THE TRANSMISSION BL…
Read full complaint
I STARTED THE VEHICLE AND PLACED THE TRANSMISSION IN REVERSE TO BACK OUT OF A PARKING SPOT. AS SOON AS THE TRANSMISSION WENT INTO REVERSE, THE ENGINE REVVED TO WHAT SEEMED TO BE FULL THROTTLE. I PANICED AND CHANGED THE TRANSMISSION TO NEUTRAL BUT ACCIDENTALLY WENT PAST NEUTRAL AND INTO DRIVE. AT THIS POINT THE TRANSMISSION BLEW OUT. I GOT THE TRANSMISSION LEVER BACK TO NEUTRAL BUT THE ENGINE CONTINUED TO RUN FULL THROTTLE. I EVEN REACHED DOWN AND PULLED BACK ON THE GAS PEDAL AND IT MADE NO DIFFERENCE. THE ENGINE STOPPED THE HIGH IDLE ONLY WHEN I TURNED THE KEY OFF. WITH THE CAR STILL IN NEUTRAL, I STARTED THE ENGINE AGAIN AND IT RAN NORMAL. I PUT THE CAR INTO GEAR AND THE FORWARD TRANSMISSION FAILED. REVERSE IS STILL IN TACT. MY CONCERN AND FEAR IS REGARDING THE ENGINE. IF I HAD BEEN ON DRY PAVEMENT (THE PARKING LOT WAS SNOW-COVERED) I COULD HAVE KILLED SOMEONE. I HAVE CONTACED FORD'S CUSTOMER ASSISTANCE AND THEY WERE OF NO HELP. PLEASE TELL ME HOW TO FIND OUT WHAT HAPPENED. I AM GOING TO GET THE TRANSMISSION FIXED, BUT I AM DREADFULLY AFRAID THAT THE ENGINE WILL RUN WILD AGAIN IN DIFFERENT CIRCUMSTANCES WHERE SOMEONE MAY BE SERIOUSLY INJURED.
NHTSA ODI #704195
Mileage unknown · Oct 10, 1997
Vehicle Speed Control
CRUISE CONTROL FAILED AND COULD NOT BE DISENGAGED, CAUSING NEAR ACCIDENT DUE TO LOSS OF CONTROL.
NHTSA ODI #605489
Mileage unknown · Aug 4, 1997
Vehicle Speed ControlInjury
THE ACCELERATOR PEDAL WAS STUCK IN THE DOWN POSITION AT THE TIME OF ACCIDENT.
NHTSA ODI #520481
Mileage unknown · Jan 28, 1997
Service Brakes, HydraulicVehicle Speed Control
PULLING OFF A ROAD TO GET ONTO AN INTERSTATE AND THE VEHICLE SUDDENLY ACCELERATED, APPLIED THE BRAKES AND THE BRAKES DID NOT WORK, HAD TO PUT GEAR IN PARK POSITION IN ORDER TO STOP AND EVERYTHING WAS BURNING. *AK
NHTSA ODI #806776
NHTSA investigations
14EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
EA99004 · Blower Assembly Fires
Opened Jan 15, 1999 · Closed Apr 18, 2000
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
BASED ON THE RELATIVELY LOW FAILURE FREQUENCY MEASURED OVER AN EXTENDED EXPOSURE TIME AND THE FACT THAT THE GREAT MAJOITY OF INCIDENTS ARE CONFINED WITHIN THE BLOWER HOUSING, A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF THE AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHE ACTION IF WARRANTED BY THE CIRCUMSTANCES.
DP98008 · Heater Blower Assembly Fire
Opened Sep 4, 1998 · Closed Sep 11, 1998
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
PE98048 · Blower Assembly Fires
Opened Sep 4, 1998 · Closed Jan 15, 1999
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
There is no summary currently available
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
PE96074 · Sunroof (air Roof) Shatter
Opened Dec 17, 1996 · Closed May 23, 1997
Status: closed (inferred from source dates) · Structure
THE SUNROOF SHATTERED OR WAS BLOWN OFF.IN ALL BUT ONE CASE THIS OCCURRED WHILE DRIVING.
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94044 · Engine Cooling Fan Cracks
Opened Jun 10, 1994 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93004 · Auto Trans Prndl Misalign
Opened Jan 29, 1993 · Closed Jul 29, 1994
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
PE92078 · Auto Trans.prndl Misalign
Opened Sep 9, 1992 · Closed Jan 29, 1993
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
Illustration