NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
609 reports79,284 miles · Mar 27, 2005
Vehicle Speed ControlCrashInjury
MY WIFE [XXX] WAS DRIVING MY 1991 FORD EXPLORER TO SEE HER SON ON 2-2-04( AND NEVER USES CRUISE CONTROL)WHEN ON HWY 161 HEADING NORTH THE CRUISE CONTROL TOOK OVER AND MADE THE THROTTLE STICK WIDE OPEN, THE BRAKES WOULD NOT HOLD AND VEHICLE WENT UP TO ABOUT 70 BEFORE SHE FINALLY TURNED OFF KEY, THE BRAKES WERE SMOKING FROM ABOUT …
Read full complaint
MY WIFE [XXX] WAS DRIVING MY 1991 FORD EXPLORER TO SEE HER SON ON 2-2-04( AND NEVER USES CRUISE CONTROL)WHEN ON HWY 161 HEADING NORTH THE CRUISE CONTROL TOOK OVER AND MADE THE THROTTLE STICK WIDE OPEN, THE BRAKES WOULD NOT HOLD AND VEHICLE WENT UP TO ABOUT 70 BEFORE SHE FINALLY TURNED OFF KEY, THE BRAKES WERE SMOKING FROM ABOUT 1 MILE OF FIGHTING TO STOP THE THING, SHE FINALLY STOPPED AFTER HITTING A TRUCK IN FRONT OF BLACKSTONE COLLISION, WHOSE OWNER DEMANDED SHE REMOVE IT DUE TO BLOCKING DRIVEWAY, (2) SALESMEN FROM JET CHEV SAW THE WHOLE THING AND SINCE THE OTHER DRIVERS VEHICLE WAS NOT BADLY DAMAGED HE WANTED TO LEAVE, THE SALESMAN STARTED THE FORD EXPLORER AND IT WAS STILL FLOORED HE WAS ABLE TO MOVE IT AND PARKED IT, HE ALSO UNSTUCK THE THROTTLE THEREBY DESTROYING EVIDENCE,MY INSURANCE CO. WAS GOING TO GO AFTER FORD BUT DIDN'T , SO WE WERE CANCELLED AND NOW I PAY TWICE AS MUCH DUE TO FORD DEFECTS THEY NEED TO OWN UP TO THIS. VEH ID [XXX] MY WIFE HAD TO GO TO HOSPITAL FOR 2 CRACKED ANKLES DUE TO THIS AS X RAYS WERE TAKEN WITHIN 4 HRS OF WRECK (SHE HAD BOTH FEET ON BRAKE PEDAL TRYING TO STOP IT.) I AM GOING TO ALSO REPORT ANOTHER INCIDENT FROM THIS SAME VEHICLE, MFG DEFECT. *JS INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6)
NHTSA ODI #10114817
208,000 miles · Mar 23, 2005
Vehicle Speed ControlFire
ON DEC 23, 2004, MY 1991 FORD EXPLORER CAUGHT FIRE WHILE I WAS DRIVING IT. THE VEHICLE WAS DESTROYED. THE VEHICLE HAD 208,000 MILES ON IT. IT HAD BEEN PROFESSIONALY SERVICED A WEEK PRIOR TO THE FIRE. WHILE I WAS DRIVING, I NOTICED A BURNING SMELL. I LOOKED IN THE REAR-VIEW MIRROR & SAW SOME WHITE SMOKE BEHIND ME. WITHIN SECOND…
Read full complaint
ON DEC 23, 2004, MY 1991 FORD EXPLORER CAUGHT FIRE WHILE I WAS DRIVING IT. THE VEHICLE WAS DESTROYED. THE VEHICLE HAD 208,000 MILES ON IT. IT HAD BEEN PROFESSIONALY SERVICED A WEEK PRIOR TO THE FIRE. WHILE I WAS DRIVING, I NOTICED A BURNING SMELL. I LOOKED IN THE REAR-VIEW MIRROR & SAW SOME WHITE SMOKE BEHIND ME. WITHIN SECONDS THE ENGINE DIED. BY THE TIME I GOT IT PULLED ONTO THE SHOULDER, SMOKE WAS STREAMING OUT FROM UNDER THE HOOD. THE FIRE BURNED THROUGH THE FIREWALL AND CAUGHT THE INTERIOR ON FIRE VERY QUICKLY.*AK
NHTSA ODI #10114537
Mileage unknown · Feb 4, 2005
Exterior LightingCrash
COMPLAINT RECEIVED VIA E-MAIL. THE BRAKE LIGHTS ON MY 1991 FORD EXPLORER CANNOT BE MADE TO WORK CONSISTENTLY. THIS PRESENTS AN OBVIOUS SAFETY HAZARD TO THE DRIVERS FOLLOWING MY VEHICLE. WHEN I HIT MY BRAKES THEY CAN'T TELL. I HAVE BEEN REAR ENDED TWICE ALREADY, AND I AM TIRED OF IT. BUT FORTUNATELY THE REAR BUMPER IS VERY STRO…
Read full complaint
COMPLAINT RECEIVED VIA E-MAIL. THE BRAKE LIGHTS ON MY 1991 FORD EXPLORER CANNOT BE MADE TO WORK CONSISTENTLY. THIS PRESENTS AN OBVIOUS SAFETY HAZARD TO THE DRIVERS FOLLOWING MY VEHICLE. WHEN I HIT MY BRAKES THEY CAN'T TELL. I HAVE BEEN REAR ENDED TWICE ALREADY, AND I AM TIRED OF IT. BUT FORTUNATELY THE REAR BUMPER IS VERY STRONG, AND ONLY IS BENT IN A LITTLE SO FAR, SINCE THE VEHICLE BEHIND HITS THE TOW HITCH, WHICH IS CAPABLE OF TOWING 3,500 POUNDS. RACEWAY FORD IN RIVERSIDE, CALIFORNIA ATTEMPTED TO REPAIR THIS PROBLEM BY REPLACING THE SWITCH AT LEAST TWICE SINCE 1997. I HAVE NOT YET GONE THROUGH THE PAPER WORK BEFORE 1997 TO SEE HOW MANY ATTEMPTS WERE MADE TO CORRECT THE DESIGN DEFECT. I REPLACED THE SWITCH AGAIN, AND STILL CANNOT GET THE BRAKE LIGHTS TO WORK PROPERLY.*AK
NHTSA ODI #10110851
Mileage unknown · Feb 1, 2005
Power TrainFire
I WAS DRIVING AND ALL OF A SUDDEN THE TRASMISSION SLIPPED AND I WOUDNT GO FORWARD TEN SMOKED POURED OUT AND PEOPLE IN THE STREETS STARTED YELLING SAYING "THERE'S FIRE COMING OUT THE HOOD!!" I PULLED OVER AND JUMPED OUT AND THE WHOLE ENGINE WAS ENGULFED IN FLAMES!!! VEHICLE TOTALLED. *AK
NHTSA ODI #10108395
Mileage unknown · Jan 13, 2005
Power TrainService Brakes, AirService Brakes, Hydraulic
TRANSMISSION WENT OUT, THEN THE FRONT MAIN SEAL. IT HASN'T BEEN TWO MONTHS AND THEN MY HEATER CORE WENT OUT AND AT THE SAME TIME MY HEATER FAN. ALSO, BEFORE THE FRONT MAIN SEAL WENT OUT THE ROTORS WENT BAD AND I STILL HAVE PROBLEMS WITH THE BRAKING SYSTEM. THIS HAS ALL HAPPENED WITHIN A YEARS TIME. I AM THOROUGHLY DISGUSTED AND …
Read full complaint
TRANSMISSION WENT OUT, THEN THE FRONT MAIN SEAL. IT HASN'T BEEN TWO MONTHS AND THEN MY HEATER CORE WENT OUT AND AT THE SAME TIME MY HEATER FAN. ALSO, BEFORE THE FRONT MAIN SEAL WENT OUT THE ROTORS WENT BAD AND I STILL HAVE PROBLEMS WITH THE BRAKING SYSTEM. THIS HAS ALL HAPPENED WITHIN A YEARS TIME. I AM THOROUGHLY DISGUSTED AND BROKE. I PRAISED FORD BEFORE THIS, NOW I WOULDN'T RECOMMEND FORD TO ANYONE I KNOW. I AM A SINGLE MOTHER TRYING TO MAKE ENDS MEET AND NOW I HAVE NO TRANSPORTATION BECAUSE I CAN NO LONGER AFFORD TO FIX THIS TRUCK. I HAVE REPLACED THE TRANSMISSION, FRONT MAIN SEAL, WATER PUMP, STARTER, ROTORS, ALTERNATOR, AND THE LOW WHEEL DRIVE ON MY TRUCK BUT NOW ITS THE HEATER CORE AND I HAVE BEEN QUOTED OVER 600-800 TO FIX THIS! THAT IS IF I CAN FIND ANYONE WHO WANTS TO DO IT WHICH BY THE WAY NO ONE DOES. WHAT DO I DO NOW? *NM
NHTSA ODI #10106282
74,096 miles · Dec 8, 2004
Engine And Engine CoolingWheels
THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALER FOR ENGINE REPAIRS. THE CONSUMER WAS TOLD THAT THE VEHICLE WAS READY TO BE DRIVEN. THE CONSUMER WENT TO THE GAS STATION BECAUSE THERE WAS NO FUEL IN IT. WHEN THE CONSUMER WAS LEAVING THE GAS STATION, THE VEHICLE LOST ITS FRONT WHEEL. IT WAS THEN DISCOVERED THAT NO LUGS; BOLTS …
Read full complaint
THE CONSUMER HAD TAKEN THE VEHICLE TO THE DEALER FOR ENGINE REPAIRS. THE CONSUMER WAS TOLD THAT THE VEHICLE WAS READY TO BE DRIVEN. THE CONSUMER WENT TO THE GAS STATION BECAUSE THERE WAS NO FUEL IN IT. WHEN THE CONSUMER WAS LEAVING THE GAS STATION, THE VEHICLE LOST ITS FRONT WHEEL. IT WAS THEN DISCOVERED THAT NO LUGS; BOLTS WERE PUT BACK ON THE FRONT WHEEL. THE CONSUMER WAS HAVING ENGINE WORK DONE TO THE VEHICLE. WHY WOULD THEY TAKE THE WHEELS OFF TO SERVICE THE ENGINE, AND THEN NOT PUT THE BOLTS BACK ON. *AK THE CONSUMER FELT THAT THIS WAS AN ACT OF VANDALISM. *SC *JB
NHTSA ODI #10099632
237,150 miles · Oct 8, 2004
Latches/locks/linkages
TRAVELING 40 MPH IN NORMAL WEATHER IN MODERATE TRAFFIC. HOOD LATCH FAILED CAUSING HOOD TO FLY OPEN AND BLOCK VISIBILITY. WAS ABLE TO COME TO A SAFE STOP AND CLOSE THE HOOD. RESULTED DAMAGE TO THE HOOD, HINGES AND COWLING,(IN ADDITION TO SCARING ME BADLY). PRESENTLY BEING INSPECTED BY A MECHANIC. *NM
NHTSA ODI #10093844
130,000 miles · Jul 26, 2004
Service Brakes, Hydraulic
VEHICLE IS A 1991 FORD EXPLORER XLT EDDIE BAUER EDITION, 4X4 5-SPEED MANUAL TRANSAXLE, 4.0L V6. VEHICLE IS EQUIPPED WITH REAR-WHEEL ANTI-LOCK BRAKES. BOTH REAR WHEELS PERFORM UNCOMMANDED FULL LOCKUP AFTER MEDIUM APPLICATION OF BRAKE PEDAL. CONDITION PERSISTS EVEN WHEN PRESSURE TO THE BRAKE PEDAL IS REMOVED. VEHICLE SKIDS TO A ST…
Read full complaint
VEHICLE IS A 1991 FORD EXPLORER XLT EDDIE BAUER EDITION, 4X4 5-SPEED MANUAL TRANSAXLE, 4.0L V6. VEHICLE IS EQUIPPED WITH REAR-WHEEL ANTI-LOCK BRAKES. BOTH REAR WHEELS PERFORM UNCOMMANDED FULL LOCKUP AFTER MEDIUM APPLICATION OF BRAKE PEDAL. CONDITION PERSISTS EVEN WHEN PRESSURE TO THE BRAKE PEDAL IS REMOVED. VEHICLE SKIDS TO A STOP. FULL APPLICATION OF THE BRAKES FOR SEVERAL SECONDS IS REQUIRED TO RELEASE THE REAR WHEEL BRAKE DRUMS AND RESTORE NORMAL CONTROL TO THE DRIVER. THIS COULD EASILY RESULT IN LOSS OF VEHICLE CONTROL. SYMPTOMS PRESENT REGARDLESS OF WEATHER/ROAD CONDITIONS, VEHICLE SPEED, OR MANEUVER TYPE.*AK
NHTSA ODI #10082713
198,000 miles · May 19, 2004
Structure
IN 2001 THE RIGHT SIDE BRACKET ATTACHMENT OF THE REAR LIFTGATE GAS ASSIST CYLINDER CAME OFF FROM THE INSIDE OF THE LIFTGATE OF MY 1991 FORD EXPLORER. THE REMAINING ASSIST CYLINDER DOES NOT HOLD THE LIFTGATE IN AN OPEN POSITION. AS I UNDERSTAND FROM NHTSA CAMPAIGN ID NO 95I007000 OVER A MILLION VEHICLES HAD THE BRACKETS REINFORC…
Read full complaint
IN 2001 THE RIGHT SIDE BRACKET ATTACHMENT OF THE REAR LIFTGATE GAS ASSIST CYLINDER CAME OFF FROM THE INSIDE OF THE LIFTGATE OF MY 1991 FORD EXPLORER. THE REMAINING ASSIST CYLINDER DOES NOT HOLD THE LIFTGATE IN AN OPEN POSITION. AS I UNDERSTAND FROM NHTSA CAMPAIGN ID NO 95I007000 OVER A MILLION VEHICLES HAD THE BRACKETS REINFORCED, BUT MY EXPLORER WASN'T INCLUDED ALTHOUGH IN MY OPINION IT CLEARLY SHOULD HAVE BEEN. I HAVEN'T PRICED THE REPAIRS.*AK
NHTSA ODI #10072879
Mileage unknown · Apr 2, 2004
Tires
I HAVE A FIRESTONE ATX SPARE TIRE AS ORIGINAL EQUIPMENT ON MY 1991 FORD EXPLORER. BOTH FORD AND FIRESTONE PARTICIPATED IN A RECALL OF THESE TIRES. I WAS NEVER CONTACTED ABOUT THE RECALL. I HAVE CONTACTED BOTH FORD AND FIRESTONE CUSTOMER SERVICE TO GET THIS TIRE REPLACED AND THEY SAY THEY CAN NO LONGER REPLACE MY TIRE. *JB
NHTSA ODI #10064392
Official recalls
8Dec 18, 1997
VEHICLE DESCRIPTION: MULTI-PURPOSE PASSENGER VEHICLES EQUIPPED WITH FACTORY INSTALLED SUNROOF. THE SUNROOF GLASS PANEL ASSEMBLY CAN SEPARATE WHILE THE VEHICLE IS MOVING DUE TO INCORRECT HINGE ENGAGEMENT. THIS WAS CAUSED BY IMPROPER SUNROOF INSTALLATION OF THE GLASS PANEL.
Consequence & remedy
Consequence: UNEXPECTED SEPARATION OF THE SUNROOF GLASS PANEL COULD POSSIBLY DISTRACT THE DRIVER INCREASING THE RISK OF A VEHICLE CRASH OR LOSS OF VEHICLE CONTROL.
Remedy: OWNERS WILL BE PROVIDED WITH AN INSTRUCTION BOOKLET WHICH THOROUGHLY OUTLINES, WITH ILLUSTRATIONS, THE PROPER PROCEDURES FOR THE REMOVAL, STORAGE, AND REINSTALLATION OF THE SUNROOF'S GLASS PANEL. A WARNING LABEL FOR ATTACHMENT TO THE SUNROOF'S LATCH KNOB WILL ALSO BE PROVIDED TO THE OWNERS.
Feb 5, 1996
THE STUDS WHICH ATTACH THE BRAKE MASTER CYLINDER TO THE POWER BRAKE VACUUM BOOSTER ASSEMBLY CAN DEVELOP STRESS CORROSION CRACKING AFTER BEING OPERATED FOR AN EXTENDED PERIOD OF TIME IN THE SOUTHERN CALIFORNIA LOCATION.
Consequence & remedy
Consequence: IF A CRACK OCCURS, IT COULD RESULT IN ONE OR BOTH STUDS FRACTURING. THE MASTER CYLINDER COULD THEN SEPARATE FROM THE VACUUM BOOSTER, WHEN THE BRAKES ARE APPLIED, PREVENTING THE SERVICE BRAKES FROM ACTIVATING INCREASING THE RISK OF A VEHICLE ACCIDENT.
Remedy: DEALERS WILL REPLACE THE POWER BRAKE VACUUM BOOSTER ASSEMBLY.
Aug 17, 1992
THE RIGID MOUNTED SAFETY BELT BUCKLES ARE DEFECTIVE IN THREE WAYS. FIRST, A FASTENED SAFETY BELT BUCKLE WILL NOT UNLATCH WHEN THE RELEASE BUTTON IS DEPRESSED. THIS RESULTS FROM INTERFERENCE BETWEEN THE BUCKLE EJECTOR FINGER AND THE BUCKLE TONGUE WINDOW. THE SECOND DEFECT IS THE SAFETY BELT BUCKLE MAY NOT LATCH. THE THIRD POSSIBLE DEFECT IS THAT THE TONGUE MAY BE RETAINED BY THE BUCKLE, BUT IT MAY NOT BE LATCHED SUFFICIENTLY TO PROVIDE OCCUPANT PROTECTION.
Consequence & remedy
Consequence: AN INSUFFICIENTLY LATCHED OR UNLATCHED SAFETY BELTINCREASES THE RISK OF INJURY TO SEAT OCCUPANTS IN THE EVENT OF A SUDDEN STOP ORACCIDENT. IF THE SAFETY BELT BUCKLE WILL NOT UNLATCH, IT WILL NOT ALLOW THEOCCUPANT TO GET OUT OF THE VEHICLE IN AN EMERGENCY SITUATION.
Remedy: FORD WILL REPLACE THE RIGID MOUNTED SAFETY BELT BUCKLES WITH END RELEASE SAFETY BELT BUCKLES DESIGNED TO PREVENT LATCH PROBLEMS.
Nov 4, 1991
WHEN THE AUTOMATIC TRANSMISSION SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARK PAWL DOES NOT ALWAYS ABUT OR ENGAGE THE PARK GEAR.
Consequence & remedy
Consequence: DRIVER MAY BELIEVE THE VEHICLE IS SAFELY ENGAGED IN PARKWHEN THE GEAR IS NOT TRULY ENGAGED. THIS CAN LEAD TO THE VEHICLE JUMPING OUT OFGEAR UNINTENTIONALLY, VEHICLE ROLLAWAY WHEN PARKED ON A SLOPED SURFACE, ANDINADVERTENT MOTION WHEN THE VEHICLE IS STARTED. ALL OF THESE CONDITIONS CANRESULT IN A VEHICLE ACCIDENT.
Remedy: REPAIR THE TRANSMISSION WITH A NEW PARK PAWL.
Feb 12, 1991
REAR BUMPER REINFORCEMENT MAY BE SUBJECT TO FATIGUE CRACKING UNDER EXTENDED TRAILER TOW SERVICE WHEN USING A BUMPER-MOUNTED TRAILER HITCH BALL.
Consequence & remedy
Consequence: UNDER EXTREME CONDITIONS, BUMPER COULD SEPARATE FROM THEVEHICLE WHEN USING A BUMPER MOUNTED TRAILER HITCH BALL.
Remedy: INSTALL TWO BRACKETS TO REINFORCE THE BUMPER.
Feb 11, 1991
THE FRONT HEAT SHIELD MAY CONTACT THE FRONT OF THE PLASTIC FUEL TANK, CAUSING CUTS OR OTHER DAMAGE TO THE EXTENT OF PENETRATION.
Consequence & remedy
Consequence: THIS PENETRATION OF THE FUEL TANK CAUSES VAPORS TO ESCAPEAND POSSIBLY FUEL TO SPILL, WHICH COULD CATCH FIRE IN THE PRESENCE OF ANIGNITION SOURCE.
Remedy: RELOCATE THE HEAT SHIELD; INSPECT AND REPLACE DAMAGED FUEL FUEL TANKS.
Feb 11, 1991
THE HOT PLATE WELD WHICH ATTACHES THE VAPOR VENT VALVE CARRIER TO THE TOP OF THE PLASTIC FUEL TANK MAY PARTIALLY FRACTURE, ALLOWING VAPOR OF FUEL TO ESCAPE FROM THE TOP OF THE TANK.
Consequence & remedy
Consequence: THE ESCAPED VAPOR OR LEAKED FUEL COULD CAUSE A FIRE INTHE PRESENCE OF A SOURCE OF IGNITION.
Remedy: FUEL TANK WILL BE REMOVED AND INSPECTED FOR WELD INTEGRITY. FUEL TANKS WITH INADEQUATE WELDS WILL BE REPLACED.
May 21, 1990
IF SUNROOF GLASS IS REMOVED AND REINSTALLED BY VEHICLE OPERATOR, HINGE ASSEMBLIES CAN BE ACCIDENTALLY IMPROPERLY MATED.
Consequence & remedy
Consequence: SUNROOF COULD DETACH FROM THE VEHICLE WHILE BEING DRIVEN,CREATING A RISK TO FOLLOWING VEHICLES OR PEOPLE IN THE VICINITY, OR TO VEHICLEOCCUPANTS IF THE GLASS SHOULD FALL INTO THE CABIN.
Remedy: INSTALL REVISED SUNROOF HINGES THAT WILL ADEQUATELY RETAIN SUNROOF ASSEMBLY.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
17EA00012 · Spare Tire Winch Cable
Opened Apr 14, 2000 · Closed Oct 20, 2000
Status: closed (inferred from source dates) · Structure
There is no summary currently available
PE99072 · Spare Tire Winch Cable
Opened Nov 30, 1999 · Closed Apr 14, 2000
Status: closed (inferred from source dates) · Structure
FROM THE BEGINNING OF THE 1991 MODEL YEAR PRODUCTION UNTIL THE MIDDLE OF THE 1994 MODEL YEAR PRODUCTION, FORD USED A GALVANIZED STEEL CABLE TO LIFT AND HOLD IN STORED POSITION, THE EXPLORER SPARE TIRE.ON MAY 19, 1994, BASED ON THE RESULTS OF FORD DURABILITY TESTING , FORD CHANGED TO A 4.00MM STAINLESS STEEL CABLE.THERE HAVE BEEN OVER 100 INCIDENTS IN WHICH THE ORIGINAL GALVANIZED STEEL CABLE FAILED ALLOWING THE SPARE TIRE TO DROP FROM ITS REAR STORAGE WELL.ONE OF THESE INCIDENTS CAUSED A FOLLOWING VEHICLE TO BE INVOLVED IN A COLLISION AND ON SIX OTHER OCCASIONS THE WHEEL MADE CONTACT WITH FOLLOWING VEHICLES, RESULTING IN PROPERTY DAMAGE.
RQ99016 · Liftgate Support Bracket Failure
Opened Jul 29, 1999 · No close date supplied
Status: open (inferred from source dates) · Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Additional source detail variants (2)
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
Structure
SUMMARY:ON AUGUST 22, 1995, FORD CONDUCTED SAFETY RECALL, 95V-164, ON 1992 AND 1993 MODEL YEAR EXPLORER DUE TO LIFTGATE FAILURES.THE REAR LIFTGATE HYDRAULIC CYLINDER BRACKET CAN BECOME UNATTACHED ALLOWING THE LIFTGATE TO SUDDENLY DROP.THE RECALL REMEDY WAS TO INSTALL REINFORCEMENTS ON THE BRACKETS.FORD ALSO INITIATED A SAFETY IMPROVEMENT CAMPAIGN IN OCTOBER 1995, FOR 1991-1995 MODEL YEAR EXPLORER VEHICLES WHICH WERE NOT INCLUDED IN THE RECALL, TO INSTALL REINFORCEMENTS ON THOSE BRACKET THAT WERE FOUND TO BE LOOSE OR DETACHED.THIS CAMPAIGN ENDED IN OCTOBER 1996. SINCE NOVEMBER 1996, ODI HAS RECEIVED 51 CONSUMER COMPLAINTS ALLEGING LIFTGATE FAILURES CAUSED BY THE BRACKET SEPARATION, OF WHICH 19 REPORTED THE LIFTGATE STRUCK THE OCCUPANT CAUSING 12 INJURIES.ONE COMPLAINT WAS ON 1992 MODEL YEAR VEHICLE, THREE COMPLAINTS WERE ON 1993 MODEL YEAR VEHICLES, AND 47 COMPLAINTS WERE ON 1994 MODEL YEAR VEHICLES. THIS RQ IS TO DETERMINE THE EXTENT OF THE PROBLEM EXPERIENCE AND THE SCOPE OF SAFETY RECALL 95V-164.FORD AND MAZDA ARE CONDUCTING A SAFETY RECALL CAMPAIGN UNDER RECALL NUMBER 99V-310.001/.002.
DP98001 · Heavy Lateral Vibration
Opened Jan 6, 1998 · Closed Feb 4, 1998
Status: closed (inferred from source dates) · Structure
NHTSA WAS PETITIONED TO COMMENCE A DEFECT INVESTIGATION OF THE SUBJECT VEHICLES ON JANUARY 6, 1998.THE PETITION ALLEGES THAT EARLY MODEL FORD EXPLORER SPORT UTILITY VEHICLES DEVELOP HEAVY LATERAL VIBRATIONS AT SPEEDS ABOVE 55 MPH AND WHEN ENCOUNTERING BUMPS AT LOW SPEEDS.THE PETITION FURTHER ALLEGES THAT THESE VIBRATIONS COULD POSSIBLY CAUSE LOSS OF VEHICLE CONTROL.THE ANALYSIS OF THE PETITION IS PRESENTED IN THE ATTACHED NOTICE WHICH IS PUBLISHED IN THE FEDERAL REGISTER.
RQ97015 · Parking Pawl
Opened Oct 29, 1997 · Closed Apr 1, 1999
Status: closed (inferred from source dates) · Power Train:automatic Transmission
WHEN THE AUTOMATIC SHIFT LEVER IS PLACED IN THE PARK POSITION, THE PARKING PAWL DOES NOT ALWAYS ENGAGE THE PARK GEAR.THIS CAN LEAD TO THE VEHICLE JUMPING OUT OF GEAR UNINTENTIONALLY AND CAUSE THE VEHICLE TO START ROLLING INADVERTENTLY
EA97011 · Sunroof Shattering And Separation
Opened May 23, 1997 · Closed Jan 20, 1998
Status: closed (inferred from source dates) · Structure
There is no summary currently available
Additional source detail variants (2)
Structure
There is no summary currently available
Structure
There is no summary currently available
EA95018 · Separation Of Master Cylinder
Opened Jun 19, 1995 · Closed Apr 2, 1996
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Additional source detail variants (2)
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
Service Brakes, Hydraulic
FORD CONTINUES TO SUDY THE PROBLEM ATTEMPTING TO DETERMINE WHY STUD FRACTURES ARE NOT FREQUENTLY OCCURRING IN OTHER PARTS OF THE COUNTRY.LIKEWISE, ODI CONTINUES GATHERING INFORMATION TO ASCERTAIN WHETHER THE RECALL SCOPE SHOULD INCLUDE OTHER GEOGRAPHICAL AREAS.IF EVIDENCE INDICATES THE SCOPE SHOULD BE EXPANDED, ODI WILL REOPEN THE INVESTIGATION AS WARRANTED.
PE95001 · Brake Master Cylinder/booster Separation
Opened Jan 3, 1995 · Closed Jun 19, 1995
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE94044 · Engine Cooling Fan Cracks
Opened Jun 10, 1994 · Closed Aug 31, 1994
Status: closed (inferred from source dates) · Engine And Engine Cooling
There is no summary currently available
EA93003 · Throttle Sticking
Opened Jan 15, 1993 · Closed Jan 6, 1994
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE92084 · Front Seat Track Failure
Opened Oct 23, 1992 · Closed Feb 26, 1993
Status: closed (inferred from source dates) · Seats
There is no summary currently available
PE92029 · Whl Separation/torque Loss
Opened Mar 16, 1992 · Closed Aug 31, 1992
Status: closed (inferred from source dates) · Suspension
There is no summary currently available
EA91040 · Vacuum Boostr Valve Fails
Opened Oct 3, 1991 · Closed Aug 17, 1992
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91127 · Park Pawl Bending
Opened Sep 16, 1991 · Closed Nov 8, 1991
Status: closed (inferred from source dates) · Power Train:automatic Transmission
There is no summary currently available
Additional source detail variants (2)
Power Train:automatic Transmission
There is no summary currently available
Power Train:automatic Transmission
There is no summary currently available
EA91034 · Throttle Release Failure
Opened Jul 17, 1991 · Closed Apr 10, 1992
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
PE91084 · Vacuum Boostr Valve Fails
Opened Jun 10, 1991 · Closed Oct 3, 1991
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
PE91058 · Throttle Release Failure
Opened Mar 6, 1991 · Closed Jul 22, 1991
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Illustration