Power Train. Review the 7 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Air Bags. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 4 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →

NHTSA owner reports · September 18, 2026 snapshot.

2 crash reports2 fire reports1 injury reports

Wheels complaints

3 reports

Clear category filter

42,000 miles · Mar 21, 2016

Wheels

Read full complaint

I REPLACED THE ORIGINAL OEM PIRELLI TIRES IN DECEMBER 2015 WHEN THE VEHICLE HAD APPROXIMATELY 36,000 MILES ON IT. THEY WERE REPLACED WITH THE SAME BRAND, SIZE AND STYLE OF PIRELLI TIRES. ON MARCH 8, 2016 AT APPROX. 42,000 MILES I RETURNED TO THE TIRE SHOP TO HAVE THE TIRES REBALANCED AFTER NOTICING SOME BUMPINESS. THE TIRE SHOP DISCOVERED THAT IN TWO OF THE TIRES THE STEEL BAND WHICH HELD THE TPMS SENSOR IN PLACE HAD DISINTEGRATED AND WAS FREE FLOATING IN THE TIRE AND HAD RUINED THE INNER LINERS IN THE TIRES MAKING THEM EXTREMELY UNSAFE. I CONTACTED MY LOCAL FORD DEALER AND INQUIRED ABOUT POSSIBLE RECALLS AND/OR BULLETINS INVOLVING THE STEEL BANDS USED ON THE TPMS. FORD DENIED ANY PREVIOUS ISSUES WITH THE BANDS HOWEVER THEY DID NOTE THAT FORD HAD QUIT USING THE STEEL BANDS AFTER ONLY USING THEM A SHORT WHILE. I FEEL FORD MOTOR COMPANY OWES ME THE $542.72 I AM OUT FOR THE REPLACEMENT OF THE TIRES AND SENSORS I HAD TO REPLACE TO REMEDY A VERY UNSAFE SITUTATION. I REPLACE THE BANDS AND SENSORS IN THE OTHER TWO TIRES AS WELL WITH A REPLACEMENT TYPE WHICH DOESN'T INVOLVE STEEL BANDS. FORD SHOULD ISSUE A RECALL NOTICE IMMEDIATELY TO REMEDY AN UNSAFE TPMS BAND SYSTEM IMMEDIATELY WHICH COULD HAVE RESULTED IN A CATASTROPHIC ACCIDENT IF THE SITUTATION HAD NOT BEEN DISCOVERED BY THE TIRE SHOP. I'M ENCLOSING A COPY OF MY EXPENSES AND A PICTURE OF THE BROKEN BANDS WHICH WERE DISCOVERED WITHIN MY TIRES.

NHTSA ODI #10850865

107,000 miles · Aug 10, 2015

SuspensionWheels

DRIVING ON PAVED ROAD, CLEAR WEATHER ENTERING A LEFT BANK, TURNED STEERING WHEEL TOWARDS LEFT AT 30 MPH. TRUCK STARTED TO SHIMMIED AND LOOSE CONTROL. IMMEDIATELY APPLIED BRAKE & STOPPED VEHICLE. BACK RIGHT WHEEL MISSING 2 WHEEL STUDS. HAD TIRES EXCHANGE 400 MILES PRIOR, NO PROBLEM WITH STUDS. MECHANIC IS NOW REPLACING REAR AXEL…

Read full complaint

NHTSA ODI #10747618

30,000 miles · Dec 13, 2011

WheelsCrash

Read full complaint

TL* THE CONTACT OWNS A 2010 FORD EXPLORER SPORT TRAC. THE CONTACT STATED THAT WHILE DRIVING 50 MPH, HE LOST CONTROL OF THE VEHICLE, DROVE THROUGH A FIELD AND CRASHED. UPON EXITING THE VEHICLE, THE CONTACT NOTICED THAT THE FRONT DRIVER SIDE WHEEL WAS DETACHED FROM THE VEHICLE. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE FAILURE AND THE CURRENT MILEAGES WERE 30,000.

NHTSA ODI #10439795

Official recalls

10V161000 · Seats:front Assembly:recliner

Apr 20, 2010

FORD IS RECALLING CERTAIN MODEL YEAR 2010 FUSION, EXPLORER, EXPLORER SPORT TRAC, AND MERCURY MILAN AND MOUNTAINEER VEHICLES MANUFACTURED BETWEEN DECEMBER 15, 2009 THROUGH FEBRUARY 3, 2010 EQUIPPED WITH FRONT SEAT MANUAL RECLINERS. THESE VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 202, "HEAD RESTRAINT." THE RECLINER GEAR PLATE TEETH MAY BE OUT OF DIMENSION SPECIFICATION WHICH COULD RESULT IN LIMITED PAWL TO GEAR PLATE TOOTH ENGAGEMENT.

Consequence & remedy

Consequence: IN THE EVENT OF A CRASH, THE SEATBACK AND HEAD RESTRAINT MAY MOVE REARWARD, INCREASING THE RISK OF INJURY.

Remedy: DEALERS WILL REPLACE THE MANUAL RECLINERS FOR BOTH POWER AND MANUAL SEATS FREE OF CHARGE. THE SAFETY RECALL IS EXPECTED TO BEGIN ON OR BEFORE APRIL 30, 2010. OWNERS MAY CONTACT FORD AT 1-866-436-7332.

Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗

NHTSA investigations

AQ10001 · Fleet Vehicle Recall Completion Audit

Opened Nov 18, 2010 · Closed Dec 28, 2015

Status: closed (inferred from source dates) · Unknown Or Other

On November 18, 2010, NHTSA's Recall Management Division (RMD) opened an audit query (AQ10-001) to investigate recall remedy completion by rental car companies on safety recall campaigns.It was expected to provide the agency an indication of how completely and how quickly rental car fleets perform necessary recall-related remedies on the vehicles owned and then rented/leased for use on the roadways.RMD queried three (3) major motor vehicle manufacturers (Ford, Chrysler, and General Motors) and requested data regarding completion figures for fifteen (15) discreet safety recalls.Analysis of this data demonstrated that rental car recalls completion was neither complete nor consistent.The rental car companies representing the largest market share in the industry were then queried as to their respective policies for the rental, lease, and sale of vehicles with open recalls.The data and responses from the manufacturers and the rental car companies can be found in the document repository by accessing the ?Associated Documents link above.In December 2015, Congress enacted the Fixing America's Surface Transportation (FAST) Act.One section of the Act prohibits rental car companies from renting, leasing, or selling motor vehicles subject to open safety recalls.With the passage of the FAST Act and its prohibition, there is no continuing need for the agency to investigate rental car recall completions.Accordingly, this investigation is closed.The agency reserves the right to open any future investigations, including audits of individual recalls, or groups of recalls, or rental car companies, to examine more closely safety recalls performance and completion issues in this area.