NHTSA owner reports · September 18, 2026 snapshot.
Unknown Or Other complaints
56 reportsClear category filterMileage unknown · Dec 7, 2022
Unknown Or Other
Driving on freeway and slowed down due to traffic and trucks ahead. Got over into left lane, accelerated and vehicle stalled then jerked forward. Wrench light came on. Got off the freeway, turned vehicle off and waited 5 minutes. Another time was driving up the grapevine to LA, vehicle stalled and again quickly accelerated forwa…
Read full complaint
Driving on freeway and slowed down due to traffic and trucks ahead. Got over into left lane, accelerated and vehicle stalled then jerked forward. Wrench light came on. Got off the freeway, turned vehicle off and waited 5 minutes. Another time was driving up the grapevine to LA, vehicle stalled and again quickly accelerated forward. I got off the freeway to allow the vehicle to rest. Third incident, driving on freeway, wrench light again appeared. When taking long road trips, I must stop every 2 hours in order for vehicle to not stall and to eliminate having transmission issues.
NHTSA ODI #11496425
Mileage unknown · Sep 18, 2022
Forward Collision AvoidanceUnknown Or Other
2020 - Expedition collision avoidance should be investigated. Background: 05-08-21 Traveling south at 6 pm near Oxford Michigan on M-24 (grassy-median 4-lane highway) at the posted 55 MPH limit in clear weather. Ford Co-Pilot360 & 360 Assist active with 360 deg camera. Speed control set to normal mode with “collision avoid…
Read full complaint
2020 - Expedition collision avoidance should be investigated. Background: 05-08-21 Traveling south at 6 pm near Oxford Michigan on M-24 (grassy-median 4-lane highway) at the posted 55 MPH limit in clear weather. Ford Co-Pilot360 & 360 Assist active with 360 deg camera. Speed control set to normal mode with “collision avoidance” set to max and auto braking. I am (1st car) in the right lane with a 2nd car following also in my lane. A 3rd car (waiting to enter the highway) stops ahead (on right- from west) at an intersection where left turns (north) are prohibited. That 3rd car safely turns right (south) in front of us quickly crossing both active southbound lanes and over into the short left turn-around lane north. That 3rd driver had cleared the two active lanes quickly and safely. As our vehicles approached him we had an open traffic lane on our left, a clear shoulder to the right and nothing in front of us, no safety issue yet. Issue: When I drive past that 3rd vehicle my Expedition dashboard shouts “collision warning”. My vehicle applies the brakes while my 360 degree cameras ignore that a car is closing fast behind me. I need to accelerate and do it now! I’m shocked to find that flooring my gas pedal or even pumping it has no effect. Ford has taken my throttle away from me, I can’t help that 2nd car behind me. The 2nd car brakes and swerves hard into the open lane barely missing me. It was just luck that the driver was responsive and the lane was open. No, I did not hit or touch the brake by mistake. The 2nd car now angry at me accelerates hard, passes and swerves back into my lane then hits his brakes! My Expedition “collision warning” doesn’t appear, so my “auto brakes” fail to activate and I’m forced to brake hard in response. After successfully avoiding another Ford induced accident, I backed-off a great distance to encourage a justifiably angry citizen to move away. I didn’t want a third attempt at my life if he pulled a weapon
NHTSA ODI #11485128
Mileage unknown · Aug 28, 2022
Unknown Or Other
I was driving my Expedition and the sunroof exploded out of nowhere. I had the screen closed so no one was injured.
NHTSA ODI #11481613
Mileage unknown · Jun 29, 2022
StructureUnknown Or OtherInjury
While driving down the highway I heard a pop in my vehicle and realized my sunroof had burst. Glass separated and flew into my car and cut myself and my 4 small children. No warning lights were on in my vehicle at this time. When brought to the dealership for repair, the repair shop reported that this will happen with these v…
Read full complaint
While driving down the highway I heard a pop in my vehicle and realized my sunroof had burst. Glass separated and flew into my car and cut myself and my 4 small children. No warning lights were on in my vehicle at this time. When brought to the dealership for repair, the repair shop reported that this will happen with these vehicles and to pursue reimbursement with Ford. Unfortunately, Ford reports that vehicle is not under warranty and the repairs won’t be covered.
NHTSA ODI #11471613
Mileage unknown · Jun 2, 2022
Unknown Or Other
The MOONROOF EXPLODED- PLEASE come look at it before this kills someone!!!!!! Had the curtain been open the glass would have gone all over my children, it also poses danger to those that might be driving behind/around you should the glass fly into their vehicle/passerby's. It appears this has been a issue but a recall has yet …
Read full complaint
The MOONROOF EXPLODED- PLEASE come look at it before this kills someone!!!!!! Had the curtain been open the glass would have gone all over my children, it also poses danger to those that might be driving behind/around you should the glass fly into their vehicle/passerby's. It appears this has been a issue but a recall has yet to be issued which is mind blowing to me- as these vehicles often are hauling large families posing a huge safety risk. There were NO WARNINGS!!!!!!!!!!!! GLASS EVERYWHERE_ ADDRESS this before someone gets killed!!
NHTSA ODI #11467108
Mileage unknown · May 25, 2022
EnginePower TrainUnknown Or Other
At least 5 different times while driving I go to push the accelerator and the gear seems to slip and an awful sound like gears grinding is heard. I always feel like my transmission is going to fall out from under the car. It prohibits the car from moving and I have almost been hit from behind because I cannot accelerate at the t…
Read full complaint
At least 5 different times while driving I go to push the accelerator and the gear seems to slip and an awful sound like gears grinding is heard. I always feel like my transmission is going to fall out from under the car. It prohibits the car from moving and I have almost been hit from behind because I cannot accelerate at the time. It has happened on the freeway, in town driving, and even accelerating up my driveway. I have taken it to a Ford dealership but no answers.
NHTSA ODI #11466029
Mileage unknown · May 1, 2022
Back Over PreventionUnknown Or Other
My car has been skipping between 3 rpm and up. The other day the collision assist pulled up and my car did a crazy jerking and almost cut off while driving. I drove slowly home with it constantly skipping and making it hard to accelerate. After it sat overnight the collision warning went off. It’s still skipping some and the pow…
Read full complaint
My car has been skipping between 3 rpm and up. The other day the collision assist pulled up and my car did a crazy jerking and almost cut off while driving. I drove slowly home with it constantly skipping and making it hard to accelerate. After it sat overnight the collision warning went off. It’s still skipping some and the power is not there like it once was.
NHTSA ODI #11462914
Mileage unknown · Apr 20, 2022
Unknown Or Other
While driving down the highway I heard a noise of something on the roof of my car I looked in the rear view mirror and saw a chrome piece blowing along the road. When I got to my destination I noticed the roof rack front rail cap was missing on the passenger side. The drivers side was secured and not loose. I did see a recall f…
Read full complaint
While driving down the highway I heard a noise of something on the roof of my car I looked in the rear view mirror and saw a chrome piece blowing along the road. When I got to my destination I noticed the roof rack front rail cap was missing on the passenger side. The drivers side was secured and not loose. I did see a recall for a 2017 explorer for the same issue but nothing for my car
NHTSA ODI #11461435
7,000 miles · Mar 25, 2022
Unknown Or Other
The contact owns a 2020 Ford Expedition. The contact stated while driving approximately 35 MPH and going down a hill, the vehicle experienced unintended acceleration. There was no warning light illuminated. The contact stated that the power steering operated as needed however, the brakes failed to operate as needed. The contact …
Read full complaint
The contact owns a 2020 Ford Expedition. The contact stated while driving approximately 35 MPH and going down a hill, the vehicle experienced unintended acceleration. There was no warning light illuminated. The contact stated that the power steering operated as needed however, the brakes failed to operate as needed. The contact steered through an intersection as the vehicle continued to accelerate. Additionally, the Forward Collision Avoidance systems had not activated. The contact attempted to apply the parking brake however, the parking brake failed to engage. The contact stated that the vehicle then decelerated independently and she was able to stop the vehicle. The vehicle was towed to a hotel. The vehicle had not been diagnosed by a dealer or independent mechanic. The vehicle had not been repaired. The manufacturer had been informed of the failure. The failure mileage was approximately 7,000.
NHTSA ODI #11458386
Mileage unknown · Jun 18, 2021
Unknown Or Other
While traveling at highway speed on I-95 North around 10AM, the vehicle brake quickly and abruptly activated which reduced the vehicle speed by 15-20 MPH. Within seconds, the vehicle returned to previously set speed with Adaptive cruise activated. This incident occurred while passing a tractor trailer truck. The truck was in …
Read full complaint
While traveling at highway speed on I-95 North around 10AM, the vehicle brake quickly and abruptly activated which reduced the vehicle speed by 15-20 MPH. Within seconds, the vehicle returned to previously set speed with Adaptive cruise activated. This incident occurred while passing a tractor trailer truck. The truck was in the center lane and I was passing on the far left lane. As I started to pass the truck, the brake activated when within 10-20 feet of the truck for a moment then returned to previously set speed (75 MPH). This happened so quickly and unexpectedly, I did not notice any warning indicators on the dash display. Fortunately there were no vehicles closely behind me so there was little risk of an accident this time! Due to this incident, I have not used adaptive cruise since nor have I taken the vehicle to a dealer.
NHTSA ODI #11421379
Official recalls
18Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Consequence & remedy
Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.
Consequence & remedy
Consequence: Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.
Remedy: Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 10, 2026.
May 27, 2026
Ford Motor Company (Ford) is recalling certain 2018-2022 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 8, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S34. This recall replaces and expands previous NHTSA recalls 24V099 and 25V197. Vehicles previously inspected or repaired under the prior recalls will need the new repair completed.
Sep 19, 2025
Ford Motor Company (Ford) is recalling certain 2020 Expedition and Lincoln Navigator vehicles. A short circuit within the battery junction box can cause an engine fire while driving or parked.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures and other vehicles, until the remedy is performed. Dealers will inspect and replace the battery junction box, as necessary, and remove a ground wire. On models equipped with standard-duty radiator fan motors, dealers will also install an auxiliary electrical box with a wire jumper. Repairs will be performed free of charge. Owner notification letters were mailed October 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's numbers for this recall are 22S36 and 22S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 23, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S31. Some vehicles in this recall that were previously inspected under recall 24V-099 and did not have parts replaced will need to have this new recall remedy completed.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2020 Expedition and Navigator vehicles that were repaired incorrectly under recall 20V262. The Pre-Collision Assist features, such as forward collision warning and automatic emergency braking, are not functional due to a software error.
Consequence & remedy
Consequence: Inoperative pre-collision assist features that fail to perform as expected can increase the risk of a crash or injury.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed June 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S56.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Feb 9, 2024
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently deploy and lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend may fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will replace the seat belt retractors, as necessary. Additionally, dealers will install an HVAC drain tube elbow if it is missing. Repairs will be performed free of charge. Owner notification letters were mailed on July 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S06.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Expedition vehicles. The seat belt tension sensor may incorrectly classify a child occupant as an adult.
Consequence & remedy
Consequence: In the event of a crash, the incorrect classification would enable the passenger air bag to deploy instead of disabling it, increasing the risk of injury to the seat occupant.
Remedy: Ford will notify owners, and dealers will replace the seat belt buckle, free of charge. The recall began October 16, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S54.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Jun 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles. The attachment bracket for the driver's side second-row seat headrest may not have been sufficiently welded to the seat frame. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: An improperly welded headrest bracket may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the seat structure and replace it as needed, free of charge. This recall began July 8, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C12.
May 8, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.
Consequence & remedy
Consequence: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Additional source detail variants (3)
Forward Collision Avoidance: Automatic Emergency Braking
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.
Consequence: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Forward Collision Avoidance
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.
Consequence: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Electrical System: Instrument Cluster/panel
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.
Consequence: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Apr 16, 2020
Ford Motor Company (Ford) is recalling certain 2020 Expedition vehicles. The front passenger seatbelt buckle's Belt Tension Sensor (BTS) may malfunction and may result in the seat occupant being misclassified.
Consequence & remedy
Consequence: In the event of a crash, the restraint system may not provide the intended level of protection, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger seatbelt buckle, free of charge. The recall began May 11, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S17.
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24015 · Seat Belt Retractor Pretensioner Inadvertent Deployment
Opened Nov 15, 2024 · Closed Jul 23, 2025
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On November 22, 2023, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) PE23021 to investigate complaints of front seat belt retractor pretensioner inadvertent deployment in model year (MY) 2019 Ford Expedition vehicles manufactured by Ford Motor Company. Some complaints alleged hearing a loud, explosion-like sound immediately followed by the seat belt tightening around the occupant’s torso area. The complaints did not state that a crash occurred that may have resulted in the deployment of the pretensioner system, suggesting that this deployment was inadvertent or otherwise unwarranted. On February 9, 2024, Ford issued safety recall 24V-099, recalling certain MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and June 30, 2019. Ford described the defect as a seat belt retractor pretensioner assembly that may develop corroded squib pins, resulting in high resistance or an open circuit, which could result in an inadvertent deployment of a pretensioner and an increased risk of injury due to the loss of the pretensioner’s protection and a seat belt that remains in the locked position. This recall includes 77,574 vehicles. On November 15, 2024, ODI opened this Recall Query (RQ24015) after receiving 3 complaints involving vehicles not included in recall 23V-099 but that alleged a similar failure. As a result of this investigation, Ford issued safety recall 25V-197 on March 28, 2025, to expand the scope of 24V-099 to include MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and July 31, 2020. This recall includes 105,322 vehicles, some of which are also included in 24V-099. Additionally, on May 23, 2025, Ford issued 25V-197 Amendment #1, which further expands the recall population’s scope for vehicles with build dates of September 2018. This amendment added 7,627 additional vehicles to the 25V-197 population. In response to ODI’s inquiries in RQ24015, Ford indicated that it cannot conclusively determine the root cause of the relevant failure. Ford was able to determine that certain pretensioners may develop corroded squib pins potentially resulting in inadvertent deployment, but it was unable to specify the cause of corrosion. Without a specific root cause, Ford assessed field performance of pretensioners to determine the scope of the recalls. ODI is aware of three vehicles that experienced pretensioner inadvertent deployment that are not included in either 25V-197 or 24V-099. Two of these vehicles are MY 2018 Lincoln Navigator vehicles built prior to October 1, 2018, and both experienced failures after more than six years of use/exposure while the recalled vehicles experienced higher rate of failures with less exposure. The remaining incident involves a MY 2021 Ford Expedition that was built after July 31, 2020. ODI is not aware of any other relevant failures in vehicles built after July 31, 2020. As such, ODI has not currently identified a safety defect trend for this issue in vehicles outside of the recalled populations. ODI will continue to monitor allegations of pretensioner inadvertent deployment in subject vehicles that are not included in 25V-197. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24015). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration