NHTSA owner reports · September 18, 2026 snapshot.
Power Train complaints
258 reportsClear category filterMileage unknown · Apr 2, 2023
Power Train
Cruising on the interstate and the vehicle’s throttle went dead. Vehicle acted as though I let of the accelerator and began to coast. Would not respond to accelerator (rpms went flat and no downshift). This happened approximately 10 times in a row for 5 to 10 seconds each time. I took a quick video of the instrument panel at the…
Read full complaint
Cruising on the interstate and the vehicle’s throttle went dead. Vehicle acted as though I let of the accelerator and began to coast. Would not respond to accelerator (rpms went flat and no downshift). This happened approximately 10 times in a row for 5 to 10 seconds each time. I took a quick video of the instrument panel at the end, prior to me pulling off the interstate. Wrench light appeared at the end. My wife has found multiple reports of similar issues on the web. Our vehicle has been to the dealership 4 times already due to similar drive train issues (hard shifting, going forward when put in reverse, etc.). Ford has failed to fix these issues, which are commonly known to Ford.
NHTSA ODI #11514996
Mileage unknown · Mar 22, 2023
Power Train
Was on a 7hr road trip. Around 2hrs in attempted to accelerate to pass another vehicle using a passing lane which terminated back down to a single lane. Created an unsafe situation while passing other vehicles at 45-55 mph. Only 20-25k miles on our 2020 expedition. Transmission did not shift appropriately. Lost power and began r…
Read full complaint
Was on a 7hr road trip. Around 2hrs in attempted to accelerate to pass another vehicle using a passing lane which terminated back down to a single lane. Created an unsafe situation while passing other vehicles at 45-55 mph. Only 20-25k miles on our 2020 expedition. Transmission did not shift appropriately. Lost power and began roughly shifting between gears especially 6th to 7th gear. Warning lights and wrench appeared during/after this event. No engine or wrench lights on prior to this event. Appeared to get stuck In 10th gear and only accelerating to 45-55mph. Would randomly down shift and have rough shifting back up to 10th gear, especially 6-7th gear. Took the vehicle to the nearest Ford dealership. Stated it was transmission communication errors due to how the computer learns driving patterns. The Ford service center cleared the communication errors and disconnected the battery. Gear wrench disappeared and did not occur again for the rest of the trip. Two days later had similar acceleration issue and rough shifting but no warning, engine or wrench lights.
NHTSA ODI #11513153
20,000 miles · Mar 13, 2023
Power Train
The contact owns a 2020 Ford Expedition. The contact stated while driving 70 MPH, there was an abnormal sound coming from the vehicle, followed by hard shifting from the transmission. The contact stated that the “Service Required” message was displayed. The contact pulled over to the side of the roadway. The vehicle was towed to…
Read full complaint
The contact owns a 2020 Ford Expedition. The contact stated while driving 70 MPH, there was an abnormal sound coming from the vehicle, followed by hard shifting from the transmission. The contact stated that the “Service Required” message was displayed. The contact pulled over to the side of the roadway. The vehicle was towed to the dealer to be diagnosed; however, the mechanic found no failure with the vehicle. The contact stated that the failure persisted. The vehicle was towed to the dealer again and the dealer stated that the transmission needed to be replaced, and that the manufacturer was aware of the failure. The vehicle was not repaired. The manufacturer was contacted but offered no assistance. The failure mileage was 20,000.
NHTSA ODI #11511652
Mileage unknown · Mar 13, 2023
Power Train
I was traveling on the interstate at a rate of 75 mph. I signaled a lane change and pressed the gas pedal. I heard the engine respond and the rpm surged. The drive train went dead. There was no power at all. I checked it was in drive and it was. The car began to slow and I began trying to get off the road. Suddenly with a…
Read full complaint
I was traveling on the interstate at a rate of 75 mph. I signaled a lane change and pressed the gas pedal. I heard the engine respond and the rpm surged. The drive train went dead. There was no power at all. I checked it was in drive and it was. The car began to slow and I began trying to get off the road. Suddenly with a bit of a jerk, it drove normal.
NHTSA ODI #11511481
Mileage unknown · Mar 10, 2023
Power Train
While traveling approximately 65 MPH on State Highway 35 near Austin, TX, my Expedition violently shifted out of gear when I attempted to accelerate to move into the next lane out of the way of a commercial 18 wheeler that was changing lanes. This caused me to lose power and coast until I could recover drive ability. My family …
Read full complaint
While traveling approximately 65 MPH on State Highway 35 near Austin, TX, my Expedition violently shifted out of gear when I attempted to accelerate to move into the next lane out of the way of a commercial 18 wheeler that was changing lanes. This caused me to lose power and coast until I could recover drive ability. My family and I were sitting ducks in the middle lane of a 4-5 lane stretch of highway. I was able to get off the highway and park in the nearest parking lot. I remember seeing a red notification stating something like “No Shift” on the dashboard display when the issue happened. Immediately confirmed no other issues, transmission and cooling system temperatures were in normal range and no other check or warning lights came on. Also, did not see any leaks and all fluids were within normal ranges.
NHTSA ODI #11511284
Mileage unknown · Mar 5, 2023
Power Train
I recently purchased this vehicle and I have had the problem from the beginning. When driving and slowing down. Usually around 5th gear or slower, it will shift hard into the lower gear with an obvious noise(thunk) coming from the rear of the vehicle. You can also slightly feel this. I have tried to duplicate the issue without u…
Read full complaint
I recently purchased this vehicle and I have had the problem from the beginning. When driving and slowing down. Usually around 5th gear or slower, it will shift hard into the lower gear with an obvious noise(thunk) coming from the rear of the vehicle. You can also slightly feel this. I have tried to duplicate the issue without using brakes to rule that out and I have done so. It is definitely not a brake issue but a transmission/power train issue. This happens to me multiple times a day on most every drive. I have looked at multiple forums to see if this is a common issue and it seems that it is. A common issue without a reliable fix. I am hoping that of multiple people claim this issue that Ford will in fact take it seriously and fix the issue
NHTSA ODI #11510206
Mileage unknown · Feb 18, 2023
Lane DeparturePower Train
My transmission shifts very hard while driving. Mainly from 4th to 5th gear while going 50MPH on a decline. The car has been in the shop for it a couple times and have yet to “replicate” the issue or repair it. The blind monitor system keeps saying it’s having an issue responding to the transmission. I get notified on my app …
Read full complaint
My transmission shifts very hard while driving. Mainly from 4th to 5th gear while going 50MPH on a decline. The car has been in the shop for it a couple times and have yet to “replicate” the issue or repair it. The blind monitor system keeps saying it’s having an issue responding to the transmission. I get notified on my app constantly, yet the dealership has told me they can’t replicate it therefore no repairs have been made.
NHTSA ODI #11508002
Mileage unknown · Feb 18, 2023
Power Train
While driving on the interstate and accelerating the vehicle first shifts very hard then goes into complete limp mode, I have had to coast to a stop on the side of the interstate to restart the engine and pray it starts working again. Once it happens once it consistently happens daily till I have it repaired which ford is bookin…
Read full complaint
While driving on the interstate and accelerating the vehicle first shifts very hard then goes into complete limp mode, I have had to coast to a stop on the side of the interstate to restart the engine and pray it starts working again. Once it happens once it consistently happens daily till I have it repaired which ford is booking appointments for transmissions 3 months out. The manufacturer has been able to replicate the failure multiple times. Each time it happens the onboard screen flashes to see owners manual and the check engine light comes on. This has put my entire family at risk because it usually happens at 55+mph and going from that amount of speed to no engine/transmission power is terrifying. I have spoke with other owners and this is a consistent problem these machines re having.
NHTSA ODI #11507941
Mileage unknown · Feb 11, 2023
Power Train
There's two different incidents oke happened at approximately 30,800 transmission made a hard clunk around 30 mph, transmission error on dash appeared but cleared as soon as I came to a stop. Transmission started working but shifting differently as in Harder shifts but not all the time. Last week on. February 4th wife stated s…
Read full complaint
There's two different incidents oke happened at approximately 30,800 transmission made a hard clunk around 30 mph, transmission error on dash appeared but cleared as soon as I came to a stop. Transmission started working but shifting differently as in Harder shifts but not all the time. Last week on. February 4th wife stated she felt a hard shift and thought transmission dropped/broke I know ford will say can not replicate symptoms so I am reporting this incase more issues arise from ford expeditions as this can be a safety issue for family's with children or as in our case we foster and are always taking kids to where they need to be
NHTSA ODI #11506746
Mileage unknown · Feb 3, 2023
Power Train
The transmission in the car is not functioning properly. Shifting is not happening correctly and there is slippage. The shift between gears is significantly impacting the car while in motion. The lurch between gears skips the car ahead. Further, Ford Dealers are so backlogged with transmission issues that they are refusing to di…
Read full complaint
The transmission in the car is not functioning properly. Shifting is not happening correctly and there is slippage. The shift between gears is significantly impacting the car while in motion. The lurch between gears skips the car ahead. Further, Ford Dealers are so backlogged with transmission issues that they are refusing to diagnose and service vehicles due to lack of technicians and parts.
NHTSA ODI #11505382
Official recalls
18Jun 24, 2026
Ford Motor Company (Ford) is recalling certain 2018-2021 Navigator, Expedition, 2020-2021 Explorer, Lincoln Aviator, and 2021 F-150 vehicles. The transmission park pawl may engage while the vehicle is in motion, resulting in park system damage.
Consequence & remedy
Consequence: Park system damage may result in a vehicle rollaway, increasing the risk of a crash.
Remedy: Dealers will update the powertrain control module software, and inspect and replace any damaged transmission components as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed July 10, 2026. Additional letters will be sent once the remedy is available, anticipated in April 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 26, 2026.
Jun 9, 2026
Ford Motor Company (Ford) is recalling certain 2018-2024 Expedition vehicles. The chrome plating on the center console may bubble and peel, resulting in sharp edges.
Consequence & remedy
Consequence: Vehicle occupants may contact the center console's sharp edges, increasing the risk of injury.
Remedy: Dealers will inspect and replace the center consoles as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 16, 2026. Additional letters will be sent once the remedy is available, anticipated in January 2027. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S38. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on June 10, 2026.
May 27, 2026
Ford Motor Company (Ford) is recalling certain 2018-2022 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will inspect and replace the seat belt retractors as necessary, free of charge. Interim letters, notifying owners of the safety risk, were mailed June 8, 2026. Additional letters will be sent once the remedy is available, anticipated in August 2026. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 26S34. This recall replaces and expands previous NHTSA recalls 24V099 and 25V197. Vehicles previously inspected or repaired under the prior recalls will need the new repair completed.
Sep 19, 2025
Ford Motor Company (Ford) is recalling certain 2020 Expedition and Lincoln Navigator vehicles. A short circuit within the battery junction box can cause an engine fire while driving or parked.
Consequence & remedy
Consequence: A vehicle fire increases the risk of injury.
Remedy: Owners are advised to park their vehicles outside and away from structures and other vehicles, until the remedy is performed. Dealers will inspect and replace the battery junction box, as necessary, and remove a ground wire. On models equipped with standard-duty radiator fan motors, dealers will also install an auxiliary electrical box with a wire jumper. Repairs will be performed free of charge. Owner notification letters were mailed October 3, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's numbers for this recall are 22S36 and 22S48. Vehicle Identification Numbers (VINs) involved in this recall became searchable on NHTSA.gov on September 23, 2025.
Jun 27, 2025
Ford Motor Company (Ford) is recalling certain 2018-2022 Transit Connect, 2019-2020 MKZ, MKX, Edge, Continental, F-150, Nautilus, Fusion, 2019-2023 Ranger, Mustang, 2020-2021 EcoSport, Expedition, Navigator, 2020-2022 Escape, F-250 SD, Corsair, 2020-2023 Aviator, Transit, 2020-2024 Explorer, 2021-2024 Bronco Sport, and 2022-2024 Maverick vehicles. A software error may cause the rearview camera to display a blank image, or the image may remain on the display after the backing event has ended.
Consequence & remedy
Consequence: A rearview camera that displays a blank image can reduce the driver's view behind the vehicle. A rearview image that continues to be displayed after the vehicle is shifted out of reverse may distract the driver. Both of these situations can increase the risk of a crash.
Remedy: Dealers will update the rearview camera software, free of charge. Owner notification letters were mailed September 4, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S72.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend can fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will replace the seat belt retractors as necessary, free of charge. Owner notification letters were mailed October 22, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S31. Some vehicles in this recall that were previously inspected under recall 24V-099 and did not have parts replaced will need to have this new recall remedy completed.
May 23, 2025
Ford Motor Company (Ford) is recalling certain 2020 Expedition and Navigator vehicles that were repaired incorrectly under recall 20V262. The Pre-Collision Assist features, such as forward collision warning and automatic emergency braking, are not functional due to a software error.
Consequence & remedy
Consequence: Inoperative pre-collision assist features that fail to perform as expected can increase the risk of a crash or injury.
Remedy: Dealers will update the body control module software, free of charge. Owner notification letters were mailed June 25, 2025. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 25S56.
Nov 8, 2024
Ford Motor Company (Ford) is recalling certain 2020-2025 Explorer, Lincoln Aviator, 2020-2024 Escape, Lincoln Corsair, 2018-2024 F-150, Expedition and Lincoln Navigator vehicles. The air bag warning label may be missing from the dashboard. As such, these vehicles fail to comply with the requirement Federal Motor Vehicle Safety Standard number 208, "Occupant Crash Protection."
Consequence & remedy
Consequence: Without a label that shows the proper restraint usage guidelines, the occupants may have an increased risk of injury in the event of a crash.
Remedy: Ford will mail owners the warning labels, free of charge. Owner notification letters were mailed December 19, 2024. Owners may call Ford customer service at 1-866-436-7332. Ford's number for this recall is 24C39.
Feb 9, 2024
Ford Motor Company (Ford) is recalling certain 2018-2020 Expedition and Lincoln Navigator vehicles. The seat belt pretensioner in the driver and/or front passenger seat may inadvertently deploy and lock the seat belt, which will not allow the belt to retract or extend.
Consequence & remedy
Consequence: Seat belts that do not retract or extend may fail to restrain an occupant as intended, increasing the risk of injury in a crash.
Remedy: Dealers will replace the seat belt retractors, as necessary. Additionally, dealers will install an HVAC drain tube elbow if it is missing. Repairs will be performed free of charge. Owner notification letters were mailed on July 8, 2024. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 24S06.
Jun 9, 2023
Ford Motor Company (Ford) is recalling certain 2018-2023 Expedition and Lincoln Navigator vehicles equipped with third-row seating; and 2019-2023 F-Super Duty F-250, F-350, F-450, and F-550 SuperCab vehicles. The owner's manual does not include instructions for adjusting or removing certain head restraints. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: Without instructions, the head restraints may be improperly adjusted, increasing the risk of injury in the event of a crash.
Remedy: Ford will mail the Owner's Manual addendums that describe how to adjust and remove the head restraints for the center seating positions, free of charge. Owner notification letters were mailed July 21, 2023. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 23C20.
Apr 14, 2022
Ford Motor Company (Ford) is recalling certain 2020-2021 F-150, Expedition, 2020-2022 Super Duty F-250, F-350, F-450, F-550, and 2020-2021 Lincoln Navigator vehicles. The windshield wiper arms may break, causing the windshield wipers to fail.
Consequence & remedy
Consequence: Inoperative windshield wipers can reduce visibility in certain driving conditions, increasing the risk of a crash.
Remedy: Dealers will replace both front windshield wiper arms, free of charge. Interim owner notification letters, informing owners of the safety risk, were mailed on May 24, 2022. Remedy parts are expected to be available 3rd Quarter 2022. Owner notification letters were mailed on October 21, 2022. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 22S26.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Expedition vehicles. The seat belt tension sensor may incorrectly classify a child occupant as an adult.
Consequence & remedy
Consequence: In the event of a crash, the incorrect classification would enable the passenger air bag to deploy instead of disabling it, increasing the risk of injury to the seat occupant.
Remedy: Ford will notify owners, and dealers will replace the seat belt buckle, free of charge. The recall began October 16, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S54.
Sep 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles. Due to a poor electrical connection, the rearview camera may intermittently display a blank or distorted image. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) number 111, "Rear Visibility."
Consequence & remedy
Consequence: Reduced rearward visibility can increase the risk of a crash.
Remedy: Ford will notify owners, and dealers will replace the rearview camera, free of charge. The recall began November 17, 2020. Remedy became available on February 1, 2021. Owner notification letters were mailed on February 1, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C19.
Jun 23, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles. The attachment bracket for the driver's side second-row seat headrest may not have been sufficiently welded to the seat frame. As such, these vehicles fail to comply with Federal Motor Vehicle Safety Standard number 202, "Head Restraints."
Consequence & remedy
Consequence: An improperly welded headrest bracket may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will inspect the seat structure and replace it as needed, free of charge. This recall began July 8, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20C12.
May 8, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.
Consequence & remedy
Consequence: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Additional source detail variants (3)
Forward Collision Avoidance: Automatic Emergency Braking
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.
Consequence: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Forward Collision Avoidance
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.
Consequence: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Electrical System: Instrument Cluster/panel
Ford Motor Company (Ford) is recalling certain 2020 Ford Expedition and Lincoln Navigator vehicles equipped with camera-only Pre-Collision Assist feature. Vehicles built with the optional radar-plus-camera Pre-Collision Assist system are not affected. Due to incorrect coding of interfacing modules, the Pre-Collision Assist feature is not enabled, and the driver cannot access the menu functions necessary to enable the Pre-Collision Assist feature.
Consequence: If the driver is unaware that the Pre-Collision Assist feature is not enabled, they may rely on a system that is not functional, increasing the risk of a crash or injury.
Remedy: Ford will notify owners, and dealers will reprogram software for the Body Control Module, Antilock Braking System, Instrument Panel Cluster and Headlamp Control Modules, and reset the Tire Pressure Monitor System, free of charge. The recall began May 26, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S20.
Apr 16, 2020
Ford Motor Company (Ford) is recalling certain 2020 Expedition vehicles. The front passenger seatbelt buckle's Belt Tension Sensor (BTS) may malfunction and may result in the seat occupant being misclassified.
Consequence & remedy
Consequence: In the event of a crash, the restraint system may not provide the intended level of protection, increasing the risk of injury.
Remedy: Ford will notify owners, and dealers will replace the front passenger seatbelt buckle, free of charge. The recall began May 11, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S17.
Apr 3, 2020
Ford Motor Company (Ford) is recalling certain 2020 Ranger and F-150 vehicles equipped with 10-speed automatic transmissions and certain 2020 Expedition vehicles equipped with a "police" package. The transmission shift cable lock clip may not be fully seated, allowing the transmission to actually be in a different gear than the gear shift position selected by the driver.
Consequence & remedy
Consequence: If the transmission selection does not match the indicated gear selection, and the parking brake is not applied, unintended vehicle movement can occur, increasing the risk of injury or crash.
Remedy: Ford will notify owners, and dealers will inspect and correct the shift cable locking clip installation, as necessary, free of charge. The recall began April 27, 2020. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 20S18.
Aug 28, 2019
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence & remedy
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Additional source detail variants (2)
Seats:mid/rear Assembly
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Seats:front Assembly:recliner
Ford Motor Company (Ford) is recalling certain 2018-2020 F-150 and 2019-2020 F-250, F-350, F-450, and F-550 Super Duty pickup trucks, and 2018-2019 Ford Explorer, 2019-2020 Expedition, and 2020 Escape vehicles equipped with driver and/or passenger's manual front seat back recliner mechanisms. Also included are certain 2020 Ford Explorer and Lincoln Aviator vehicles equipped with rear outboard seats and manual seat back recliner mechanisms. The recliner mechanisms may be missing the third pawl required for seat back strength, resulting in a loose seat back. As such, these vehicles fail to comply with the requirements of Federal Motor Vehicle Safety Standard (FMVSS) numbers 202, "Head Restraints" and 207, "Seating Systems."
Consequence: A seat back with an improperly assembled recliner mechanism may have reduced strength and may not adequately restrain an occupant in a crash, increasing the risk of injury.
Remedy: Ford will notify owners, and Ford and Lincoln dealers will inspect the seat structure and replace them, as necessary, free of charge. The recall began October 21, 2019. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19C07.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2RQ24015 · Seat Belt Retractor Pretensioner Inadvertent Deployment
Opened Nov 15, 2024 · Closed Jul 23, 2025
Status: closed (inferred from source dates) · Seat Belts:pretensioner
On November 22, 2023, the Office of Defects Investigation (ODI) opened Preliminary Evaluation (PE) PE23021 to investigate complaints of front seat belt retractor pretensioner inadvertent deployment in model year (MY) 2019 Ford Expedition vehicles manufactured by Ford Motor Company. Some complaints alleged hearing a loud, explosion-like sound immediately followed by the seat belt tightening around the occupant’s torso area. The complaints did not state that a crash occurred that may have resulted in the deployment of the pretensioner system, suggesting that this deployment was inadvertent or otherwise unwarranted. On February 9, 2024, Ford issued safety recall 24V-099, recalling certain MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and June 30, 2019. Ford described the defect as a seat belt retractor pretensioner assembly that may develop corroded squib pins, resulting in high resistance or an open circuit, which could result in an inadvertent deployment of a pretensioner and an increased risk of injury due to the loss of the pretensioner’s protection and a seat belt that remains in the locked position. This recall includes 77,574 vehicles. On November 15, 2024, ODI opened this Recall Query (RQ24015) after receiving 3 complaints involving vehicles not included in recall 23V-099 but that alleged a similar failure. As a result of this investigation, Ford issued safety recall 25V-197 on March 28, 2025, to expand the scope of 24V-099 to include MY 2018-2020 Ford Expedition and Lincoln Navigator vehicles equipped with driver and front passenger seat belt retractor pretensioners built between October 1, 2018, and July 31, 2020. This recall includes 105,322 vehicles, some of which are also included in 24V-099. Additionally, on May 23, 2025, Ford issued 25V-197 Amendment #1, which further expands the recall population’s scope for vehicles with build dates of September 2018. This amendment added 7,627 additional vehicles to the 25V-197 population. In response to ODI’s inquiries in RQ24015, Ford indicated that it cannot conclusively determine the root cause of the relevant failure. Ford was able to determine that certain pretensioners may develop corroded squib pins potentially resulting in inadvertent deployment, but it was unable to specify the cause of corrosion. Without a specific root cause, Ford assessed field performance of pretensioners to determine the scope of the recalls. ODI is aware of three vehicles that experienced pretensioner inadvertent deployment that are not included in either 25V-197 or 24V-099. Two of these vehicles are MY 2018 Lincoln Navigator vehicles built prior to October 1, 2018, and both experienced failures after more than six years of use/exposure while the recalled vehicles experienced higher rate of failures with less exposure. The remaining incident involves a MY 2021 Ford Expedition that was built after July 31, 2020. ODI is not aware of any other relevant failures in vehicles built after July 31, 2020. As such, ODI has not currently identified a safety defect trend for this issue in vehicles outside of the recalled populations. ODI will continue to monitor allegations of pretensioner inadvertent deployment in subject vehicles that are not included in 25V-197. In view of the safety recall action being taken by Ford, ODI is closing this Recall Query (RQ24015). The agency reserves the right to take additional action if warranted by future circumstances. To review the reports cited in the Closing Resume ODI Report Identification Number document, go to NHTSA.gov.
RQ21002 · Rearview Camera Fmvss 111 Noncompliance
Opened Aug 3, 2021 · No close date supplied
Status: open (inferred from source dates) · Back Over Prevention: Sensing System: Camera
On September 23, 2020, Ford Motor Company (Ford) filed a noncompliance recall report under 49 CFR Part 573 (NHTSA Recall No. 20V-575), recalling 620,246 Model Year (MY) 2020 Ford F-150, F-250, F-350, F-450, F-550, Explorer, Mustang, Transit, Expedition, Escape, Ranger and Edge, and Lincoln Nautilus and Corsair vehicles for a noncompliance with Federal Motor Vehicle Safety Standard (FMVSS) 111, Rear Visibility. Ford's recall described the noncompliance as insufficient electrical conductivity within the printed circuit board (PCB) internal to the camera leading to intermittent rearview camera operation. The supplier of the cameras was Magna Electronics.According to Ford's chronology in the Part 573, during the period February-April 2020, Ford identified and monitored warranty claims pertaining to intermittent or inoperative rearview cameras. Ford reviewed supplier product changes, focusing on changes introduced by the supplier in the October-November 2019 time frame. The Part 573 stated that the issue was brought to Ford's Critical Concerns Review Group (CCRG) for review on May 12, 2020.On July 7, 2020, NHTSA's Vehicle Research and Testing Center (VRTC) informed the Office of Defects Investigation (ODI) of a trend of MY 2020 Escape vehicles with rearview camera malfunctions. ODI contacted Ford the next day, providing five Vehicle Owner Questionnaires (VOQs) alleging inoperative rearview cameras. On July 15, 2020, Ford met with NHTSA to discuss the rearview camera issue. In a subsequent August 24, 2020 meeting, ODI and NHTSA's Office of Vehicle Safety Compliance (OVSC) met with Ford to discuss the recall status and additional VOQs. Ford presented rate and scope data for many of its MY 2020 products during the August 2020 meeting indicating high failure rates for certain models.This RQ is being opened to investigate both the timeliness and scope of Ford's rearview camera recall (20V-575), and Ford's compliance with reporting requirements.The subject reports referenced in the opening resume are identified by the following ODI reference numbers which can be reviewed at NHTSA.gov: 11349813, 11344126, 11342696, 11341486, 11340254, 11337274, 11331444, 11330875, 11329235, 11316960, 11343521, 11341884, 11337226, 11344018, and 11339573.
Illustration