2016 Ford Expedition

TL* THE CONTACT OWNS A 2016 FORD EXPEDITION. THE CONTACT STATED WHILE DRIVING APPROXIMATELY 30 MPH, THE VEHICLE STALLED WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE VEHICLE WAS RESTARTED HOWEVER, THE FAILURE RECURRED SEVERAL TIMES. THE DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 63,000.

TL* THE CONTACT OWNS A 2016 FORD EXPEDITION. THE CONTACT STATED THAT WHILE HER HUSBAND WAS DRIVING APPROXIMATELY 30 MPH, THE BRAKES BECAME SPONGY WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT AFTER DRIVING AN ADDITIONAL FOUR MILES, AND ATTEMPTING TO PULL INTO A PARKING SPACE, THE BRAKE PEDAL WAS DEPRESSED AND WENT TO THE FLOOR. AFTER PUMPING THE BRAKE PEDAL SEVERAL TIMES, THE VEHICLE STOPPED WITH AN UNKNOWN WARNING LIGHT ILLUMINATED. ROADSIDE ASSISTANCE ARRIVED AND THE TOW TRUCK DRIVER STATED THAT THERE WAS NO BRAKE FLUID INSIDE THE BRAKE MASTER CYLINDER. THE VEHICLE WAS TOWED TO GALPIN FORD (15505 ROSCOE BLVD, VAN NUYS, CA 91343, (818) 787-3800) AND THE CONTACT WAS INFORMED THAT THE BRAKE MASTER CYLINDER AND THE BRAKE BOOSTER NEEDED TO BE REPLACED. THE VEHICLE WAS REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND FILED A CASE. THE APPROXIMATE FAILURE MILEAGE WAS 37,222.

WHILE DRIVING THE VEHICLE AT APPROX 35 MPH ON A CITY STREET. THE BRAKES WERE LIGHTLY APPLIED UPON APPROACHING A TRAFFIC LIGHT. THE PEDAL, WITHOUT ANY WARNING, WENT STRAIGHT TO THE FLOOR WITH NO RESISTANCE AND THEN THE BRAKE WARNING LIGHT CAME ON. PUMPING THE BRAKES ALLOWED THE VEHICLE TO SLOWLY DECELERATE BUT, PEDAL TRAVEL CONSISTENTLY WENT FULL THROW. A VISUAL INSPECTION SHOWED AN EMPTY FLUID RESERVOIR AND NO INDICATION OF AN EXTERNAL LEAK. THE BREAK DOWN SHOWS THE MASTER CYLINDER FAILED AND WAS DIVERTING THE BRAKE FLUID INTO THE BOOST ASSEMBLY. THE VEHICLE HAS 56,511 MILES ON IT.

WHILE DRIVING ON A CITY STREET, MY BRAKE PEDAL LOST RESISTANCE AND WENT TO THE FLOOR. I DISCOVERED THAT THE BRAKE FLUID RESERVOIR WAS EMPTY. I WAS ABLE TO GET THE VEHICLE TO A LOCAL DEALERSHIP BECAUSE THE BACK BRAKES WERE FUNCTIONING. I DISCOVERED THAT THIS WAS A COMMON OCCURRENCE FOR THE 2016 FORD F150 (THAT HAS BEEN RECALLED BECAUSE OF THE MASTER BRAKE CYLINDER) AND WAS BECOMING A COMMON OCCURRENCE THE 2016 FORD EXPEDITION. IT SEEMS THAT BOTH MODEL SHARE THE SAME PART. THE LOCAL FORD DEALER DIAGNOSED THE PROBLEM AND REPLACED THE MASTER BRAKE CYLINDER AND BOOSTER ASSEMBLIES. THE REPAIR WAS DELAYED ABOUT A WEEK BECAUSE THE "RECALLED" MASTER BRAKE CYLINDER MODEL WAS ORDERED IN ERROR AND THE NEW MODEL WOULD TAKE A FEW DAYS TO GET IN. I FOUND THAT TO BE A STRANGE COMMENT WHEN THERE IS NOT INFORMATION RELATED TO A RECALL FOR THE 2016 FORD EXPEDITION.

WHILE DRIVING ON THE INTERSTATE AT 70 MPH THE VEHICLE SUDDENLY LOST ALL POWER AND A "WRENCH" INDICATOR APPEARED. WAS ABLE TO NAVIGATE TO THE SIDE OF THE ROAD. WRENCH LIGHT INDICATES A POWER TRAIN ISSUE. THE VEHICLE WAS TURNED OFF WHILE CONTACTING HELP. TURNED THE VEHICLE BACK ON AND WRENCH INDICATOR GONE. WAS ABLE TO DRIVE WITHOUT FURTHER INCIDENT. UPON SEARCHING THE PROBLEM APPARENTLY THIS HAS OCCURRED TO NUMEROUS FORD EXPEDITION OWNERS. VERY DANGEROUS AS THERE IS NO WARNING AND CAN HAPPEN AT ANYTIME.

WE DETECTED A BURNT RUBBER SMELL WHILE DRIVING ON A SURFACE STREET (WITH A/C ON). THE A/C SUDDENLY QUIT. WE PULLED OVER TO TURN SUV OFF AND BACK ON AGAIN HOPING A/C WOULD RETURN. A/C DID NOT RETURN, SMOKE BEGAN BILLOWING OUT OF A/C VENTS. STOPPED AT A GAS STATION AND TURNED OFF SUV. THE SMOKE FROM THE VENTS GOT THICKER AND LARGE FLAMES BEGAN COMING OUT UNDERNEATH THE DASH. HUSBAND RAN IN TO GAS STATION AND GOT A FIRE EXTINGUISHER AND PUT OUT THE FIRE. FIRE KEPT RESTARTING (THE PARKING LIGHTS WERE ON THOUGH THE CAR WAS OFF). HUSBAND FINALLY HAD TO DISCONNECT THE BATTERY TO KEEP FIRE FROM RESTARTING. THE A/C/HEATER BLOWER THEN FELL OUT ONTO THE FRONT PASSENGER FLOOR-MAT BURNED TO A CRISP.

2016 FORD EXPEDITION EL LIMITED - MANUFACTURED IN DEARBORN MICHIGAN "YELLOW WRENCH" WARNING LIGHT CAME ON THE FREEWAY AND CUT 100% OF POWER TO THE MOTOR, ALMOST CAUSING AN ACCIDENT. I HAD TO TRAVERSE TRAFFIC TO GET TO A SAFE AREA. CALLED A DEALERSHIP AND THEY SAID IT WAS LIKELY THE THROTTLE BODY. FORD IMPLEMENTED A VOLUNTARY RECALL FOR ALL OTHER 2015 & 2016 MODELS EXCEPT THE EXPEDITION WHICH IS BUILT ON THE EXACT SAME ASSEMBLY LINE AS THE F150 AND WITH THE SAME DEFECTIVE PART. FORD RECALL NUMBER WAS 16B32. I AM PAYING $500 OUT OF POCKET SINCE THIS ITEM IS NOT COVERED UNDER WARRANTY AND MY VEHICLE WAS NOT INCLUDED IN THE RECALL. THIS ISSUE IS DANGEROUS AND COULD SERIOUSLY HURT OR KILL SOMEONE. FORD HAS HAD A HISTORY OF BAD THROTTLE BODIES AND THE NHSTA NEEDS TO HAVE THIS ISSUE FORMALLY RECALLED.

TL* THE CONTACT OWNS A 2016 FORD EXPEDITION. THE CONTACT STATED THAT WHILE STOPPED AT A STOP SIGN, THE LOW BRAKE FLUID LEVEL WARNING LIGHT ILLUMINATED. THE CONTACT STATED THAT WHILE DRIVING AT 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND WENT TO THE FLOORBOARD FAILING TO EFFECTIVELY SLOW THE VEHICLE TO A STOP. THE CONTACT SHIFTED THE VEHICLE INTO NEUTRAL TO SLOW THE VEHICLE. THE CONTACT STOPPED THE VEHICLE AND SHIFTED INTO REVERSE AND THE VEHICLE INDEPENDENTLY ACCELERATED. THE CONTACT DEPRESSED THE BRAKE PEDAL AND SHIFTED THE VEHICLE INTO PARK. THE CONTACT STATED THAT HER HUSBAND ADDED TWO BOTTLES OF BRAKE FLUID TO THE RESERVOIR AND STATED THAT THERE WERE NO LEAK WAS VISIBLE. THE CONTACT STATED THE FAILURE PERSISTED. THE VEHICLE WAS TOWED TO AN INDEPENDENT MECHANIC TO BE DIAGNOSED. THE CONTACT WAS INFORMED THAT THE BRAKE MASTER CYLINDER AND BRAKE BOOSTER NEEDED TO BE REPLACED. A DEALER WAS NOT CONTACTED. THE VEHICLE WAS NOT REPAIRED. THE CONTACT ASSOCIATED THE FAILURE WITH NHTSA CAMPAIGN NUMBER: 20V332000 (SERVICE BRAKES, HYDRAULIC) HOWEVER, THE VIN WAS NOT INCLUDED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS UNKNOWN.

BRAKE MASTER CYLINDER LEAKING INTO BRAKE BOOSTER RENDERING THE VEHICLE BRAKES USELESS. NOTE THAT THIS IS HAPPENING ON THE 2016 F-150 TRUCKS AS WELL AND THE 2 VEHICLES SHARE THE SAME PARTS FOR THE BRAKE SYSTEM. THE INCIDENT OCCURRED WHILE DRIVING BACK TO THE OFFICE AND NOTICED THAT IT WAS TAKING A LONG STROKE OF THE PEDAL TO APPLY THE BRAKES. UPON ARRIVAL BACK AT THE OFFICE THE RESERVOIR WAS INSPECTED AND THERE WAS LITTLE TO NO FLUID LEFT, AND NO VISIBLE LEAKS.