the service engine light continues to turn on. the timing belt continues to fail and has already been replaced once. the camshaft on both sides have been replaced. the solenoids have also been replaced and the diagnostics codes still pop up (p0022) (p0021) are just some that i can remember. the engine does not have enough power …
Read full complaint
the service engine light continues to turn on. the timing belt continues to fail and has already been replaced once. the camshaft on both sides have been replaced. the solenoids have also been replaced and the diagnostics codes still pop up (p0022) (p0021) are just some that i can remember. the engine does not have enough power on the driver side and throws the timing belt off which causes the loud rattle coming from the engine. when reaching the speed of 40-45 mph the truck begins to shake. recently in november 2023, when fueling up with gas , the truck began to shake and not respond. when accelerating, the truck takes off very slowly and the gears dont kick in on time. when the gas light comes on , the truck begins to function well. but as soon as i put gas again. it feels like the truck is going to fall apart. the driver door gets stuck when trying to open from the inside. the back door on the left does not open from the outside. the gear handle can be moved up and down while the truck is not turned on. please help!!
NHTSA ODI #11564296
66,080 miles · Nov 7, 2018
Fuel/propulsion System
THE CAR WILL SOMETIMES NOT START OR WHEN RUNNING THE ENGINE WILL DIE. IT APPEARS NOT TO GET FUEL
NHTSA ODI #11149843
160,000 miles · Feb 27, 2018
Fuel/propulsion SystemPower Train
TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE "FAIL SAFE MODE" INDICATOR DISPLAYED. HERTRICH FORD IN MILFORD, DELAWARE WAS MADE AWARE OF THE FAILURE AND REPLACED THE THROTTLE BODY AND THE DRIVER'S SIDE FUEL MODULE. THE MANUFACTURER WAS …
Read full complaint
TL* THE CONTACT OWNS A 2006 FORD EXPEDITION. WHILE DRIVING VARIOUS SPEEDS, THE VEHICLE STALLED WITHOUT WARNING. THE CONTACT STATED THAT THE "FAIL SAFE MODE" INDICATOR DISPLAYED. HERTRICH FORD IN MILFORD, DELAWARE WAS MADE AWARE OF THE FAILURE AND REPLACED THE THROTTLE BODY AND THE DRIVER'S SIDE FUEL MODULE. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE AND REFERRED THE CONTACT TO NHTSA. THE FAILURE MILEAGE WAS APPROXIMATELY 160,000.
NHTSA ODI #11075280
Mileage unknown · Sep 11, 2017
Fuel/propulsion System
WHILE DRIVING CARBON BUILDS UP IN VEHICLE
NHTSA ODI #11022588
135,168 miles · May 6, 2016
Fuel/propulsion System
WHILE DRIVING AT 45 MPH ON 2 LANE ROAD THE TRUCK ACTED AS IF IT HAD RUN OUT OF GAS. I SHIFTED INTO NEUTRAL AND COASTED TO A PARKING LOT AT A STORE ON THE OTHER SIDE OF THE ROAD. THANKFULLY THERE WAS NOT OPPOSING TRAFFIC OR I WOULD HAVE STOPPED IN MY LANE AND BLOCKED TRAFFIC.
NHTSA ODI #10863554
Mileage unknown · Oct 5, 2015
Fuel/propulsion System
IT TAKES FOREVER TO DRIBBLE GAS INTO THE TANK AT THE FILLING STATION; THE BACK PRESSURE IN THE FILLER PIPE CUTS OUT THE PUMP SO BAD IT TAKES OVER 20 MINUTES TO FILL THE LARGE TANK; THIS IS UNACCEPTABLE IN BAD WEATHER AND MORE THAN ANNOYING ON A TIGHT SCHEDULE AS IT ENCOURAGES SPEEDING TO MAKE UP FOR LOST TIME!
NHTSA ODI #10779940
90,000 miles · Aug 7, 2014
EngineFuel/propulsion System
ENGINE WENT IN TO FAIL SAFE MODE AND STALLED WHILE COASTING TO PULL OFF. PUT IN NEUTRAL SHUT OFF KEY AND THEN RESTARTED. NO MORE PROBLEM..UNTIL A YEAR LATER. FAIL SAFE THEN STALL. RESTARTED AND CHECK ENGINE LIGHT ON. AFTER 10 MILES FAIL SAFE AND STALL. RESTARTED CHECK ENGINE LIGHT ON TOOK TO DEALER. DIAGNOSED AS THROTTLE BODY $6…
Read full complaint
ENGINE WENT IN TO FAIL SAFE MODE AND STALLED WHILE COASTING TO PULL OFF. PUT IN NEUTRAL SHUT OFF KEY AND THEN RESTARTED. NO MORE PROBLEM..UNTIL A YEAR LATER. FAIL SAFE THEN STALL. RESTARTED AND CHECK ENGINE LIGHT ON. AFTER 10 MILES FAIL SAFE AND STALL. RESTARTED CHECK ENGINE LIGHT ON TOOK TO DEALER. DIAGNOSED AS THROTTLE BODY $650 REPAIR. OBVIOUSLY; I AM NOT THE FIRST VICTIM! SHAME ON YOU FORD FOR NOT STEPPING UP AND TAKING CARE OF YOUR CUSTOMERS AND REPLACING THE THROTTLE BODIES. TO CONSUMERS..FAIL SAFE DOESN'T MEAN SAFE TO KEEP DRIVING, IT IS DESIGNED TO KEEP THE ENGINE RUNNING JUST LONG ENOUGH TO MAINTAIN POWER STEERING AND BRAKES WHILE YOU PULL OVER. GOOD LUCK! *TR
NHTSA ODI #10620711
91,000 miles · Mar 3, 2014
Fuel/propulsion System
CAR JUST DIED ON HIGHWAY JUST SHUT OFF WOULD NOT RESTART. AFTER LOOKING AT IT THE FPDM WAS CORRODED AND BAD. THIS HAS BEEN A INTERRMTINT PROBLEM AND HAS ALMOST CAUSED ACCIDENTS WHEN CAR STALLS WHEN DRIVING AT INTERSECTIONS AND SUCH ALUMINUM AND STEEL DONT WORK WELL UNDER A CAR AND CORRODE VERY BADLY. *TR
NHTSA ODI #10566784
98,000 miles · Jul 19, 2012
Engine And Engine CoolingFuel/propulsion System
3RD TIME PROBLEMS WITH SPARK PLUGS AND FUEL INJECTOR....WAS TOLD BY DEALER THAT THIS YEAR MODEL THE INJECTORS ARE BAD FOR STICKING....LEAVING THE OWNER TO PAY FOR REPAIR COST AND THE EXPENSE OF CHANGING FORDS FAULTY SPARK PLUGS. *TR
ON CERTAIN TRUCKS, PASSENGER CARS AND SPORT UTILITY VEHICLES, THE WINDSHIELD WIPER MOTOR MAY HAVE BEEN PRODUCED WITHOUT GREASE BEING APPLIED TO THE OUTPUT SHAFT GEAR.
Consequence & remedy
Consequence: AFTER A PERIOD OF CONTINUOUS USE ON THE HIGH SPEED SETTING, LACK OF GREASE ON THE OUTPUT SHAFT GEAR MAY CAUSE THE GEAR TO DISTORT OR FRACTURE DURING OPERATION RESULTING IN A LOSS OF WIPER FUNCTION. INOPERATIVE WIPERS UNDER INCLEMENT WEATHER CONDITIONS COULD CAUSE A CRASH DUE TO IMPAIRED VISIBILITY.
Remedy: DEALERS WILL INSPECT THE WIPER MOTOR FOR THE PRESENCE OF GREASE AND GREASE THE WIPER MOTOR GEARS IF NECESSARY. THE RECALL BEGAN ON NOVEMBER 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673 OR LINCOLN/MERCURY AT 1-800-521-4140.
ON CERTAIN SPORT UTILITY VEHICLES, THE FRONT AND REAR TIRES ON THE DRIVER'S SIDE OF AFFECTED VEHICLES MAY HAVE BEEN DAMAGED AT THE CENTER TREAD DURING PRODUCTION.
Consequence & remedy
Consequence: OVER TIME, THE DAMAGE MAY BE SUFFICIENT TO ALLOW BELT CORROSION ULTIMATELY LEADING TO A TREAD SEPARATION, WHICH COULD RESULT IN A CRASH.
Remedy: DEALERS WILL INSPECT ALL FOUR TIRES (TO ENSURE INSPECTION OF THE LEFT HAND SIDE TIRES THAT MAY HAVE BEEN ROTATED TO THE OTHER SIDE OF THE VEHICLE) FOR TIRE TREAD DAMAGE AND, IF NECESSARY, REPLACE THE DAMAGED TIRE. THE RECALL BEGAN ON JULY 13, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08070 · Steel Wheel Fracture
Opened Dec 9, 2008 · Closed Apr 15, 2009
Status: closed (inferred from source dates) · Wheels; Wheels:rim
FORD SPECIAL SERVICE VEHICLE (SSV) EXPEDITIONS USE A STEEL FULL FACE WHEEL DESIGN SIMILAR TO THAT INVESTIGATED IN PE03009, RQ04007, EA04034 (CROWN VICTORIA POLICE INTERCEPTOR) AND PE03026 (GM PICKUPS AND SUVS).A TOTAL OF 8,251 SSVS (2.2% OF TOTAL PRODUCTION) WERE PRODUCED WITHIN MODEL YEARS 2004-2006 AND SOLD PRIMARILY FOR USE BY STATE, FEDERAL, AND MUNICIPAL LAW ENFORCEMENT (LE) AGENCIES.FORD STIPULATES THAT THE SUBJECT VEHICLES ARE NOT SUITABLE FOR HIGH SPEED OR PURSUIT OPERATIONS AND ALSO IDENTIFIED A 2004 NATIONAL INSTITUTE FOR JUSTICE VEHICLE EVALUATION REPORT WHICH ALSO ACKNOWLEDGES THIS LIMITATION. THE FULL FACE WHEEL IS FABRICATED FROM TWO PIECES: A STAMPED OUTER WHEEL DISC AND A FORMED RIM.THE TWO PIECES, WHICH TOGETHER COMPRISE THE OUTER BEAD SEAT, ARE JOINED TOGETHER WITH A CIRCUMFERENTIAL WELD.A CYCLIC BENDING MOMENT OCCURS IN THE OUTER BEAD SEAT AREA AS THE WHEEL ROTATES, RESULTING IN FATIGUE STRESSES IN THE WELD'S HEAT AFFECTED ZONE THAT CAN LEAD TO FRACTURING (CRACKING) OF THE RIM MATERIAL.BECAUSE THE FAILURE OCCURS UNDER THE OUTBOARD TIRE BEAD, AIR LEAKAGE MAY NOT READILY OCCUR WHEN THE RIM CRACKS, DEPENDENT ON HOW WELL THE BEAD SEALS ON THE RIM.IF MULTIPLE CRACKS GROW UNDETECTED AND SUDDENLY JOIN INTO A SINGLE LARGE CRACK, THE WHEEL'S STRUCTURE CAN BECOME COMPROMISED LEADING TO RAPID AIR LOSS.A RAPID AIR LOSS, ESPECIALLY AT HIGHER SPEED, MAY LEAD TO A CRASH. FORD RESPONDED TO ODI'S JANUARY 5, 2009 INFORMATION REQUEST (IR) ON FEBRUARY 24.FORD'S RESPONSE ACKNOWLEDGES A NUMBER OF WHEEL FRACTURES ON THE SSVS.HOWEVER, BASED ON ITS ASSESSMENT OF THE PERTINENT FACTORS, IT CONCLUDES THAT THE CONDITION DOES NOT REPRESENT AN UNREASONABLE RISK TO SAFETY.THE LACK OF REPORTS OF RAPID AIR LOSS, NO ALLEGED CRASHES, AND THEIR ASSESSMENT THAT A CRACKED WHEEL CAN BE DETECTED THROUGH SLOW, REPEATED AIR LOSS OR VIBRATION, WERE THE BASES FOR FORD'S CONCLUSION.FORD DISCUSSES THE RESULTS OF A STUDY IT PERFORMED ON WHEELS RETURNED FROM LE FIELD USE, DESIGN REVISIONS IT MADE TO THE SUBJECT WHEEL, AND THE OUTCOME OF DURABILITY TESTING IT CONDUCTED ON THE OLD AND NEW WHEEL DESIGNS. THE COUNTS SHOWN ABOVE INCLUDE A DUPLICATE ODI AND FORD REPORT; THE FORD COUNTS ARE UNIQUE VEHICLES ALLEGING WHEEL FRACTURE(S).SOME WARRANTY CLAIMS INVOLVED MORE THAN ONE WHEEL REPLACEMENT.ALTHOUGH THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR A LONGER PERIOD OF TIME THAN VEHICLES INVESTIGATED IN THE PREVIOUS INVESTIGATIONS OF TWO-PIECE WHEEL FRACTURE, ODI DID NOT IDENTIFY ANY ALLEGATIONS OF CRASHES, RAPID AIR LOSS EVENTS DUE TO WHEEL FRACTURES OR ALLEGATIONS OF EFFECTS ON VEHICLE CONTROL OR STABILITY, AS WERE THE CASES IN PAST INVESTIGATIONS WHERE SAFETY RECALLS WERE CONDUCTED TO REPLACE AFFECTED WHEELS.THE AGENCY AGREES THAT THE SSV IS NOT SUITABLE FOR PURSUIT OR HIGH SPEED USAGE, REDUCING THE POTENTIAL FOR CRASHES OR LOSS OF CONTROL INCIDENTS TO BE CAUSED BY THE ALLEGED DEFECT. FORD IMPLEMENTED A 'SHOT PEENING' PROCESS IN JUNE 2006 WHICH REDUCED THE WHEEL'S SURFACE STRESS AND SIGNIFICANTLY IMPROVED ITS DURABILITY, AND ODI IS UNAWARE OF ANY FAILURES OF SHOT PEENED WHEELS (SERVICE PART NUMBER 7L1Z-1015-B).FORD'S TESTING SHOWED A SLIGHTLY REDUCED DURABILITY FOR THE NON-SHOT PEENED WHEELS WHEN 'LT' INSTEAD OF FORD APPROVED 'P' METRIC TYPE TIRES ARE USED. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY FURTHER C
Additional source detail variants (2)
Wheels
FORD SPECIAL SERVICE VEHICLE (SSV) EXPEDITIONS USE A STEEL FULL FACE WHEEL DESIGN SIMILAR TO THAT INVESTIGATED IN PE03009, RQ04007, EA04034 (CROWN VICTORIA POLICE INTERCEPTOR) AND PE03026 (GM PICKUPS AND SUVS).A TOTAL OF 8,251 SSVS (2.2% OF TOTAL PRODUCTION) WERE PRODUCED WITHIN MODEL YEARS 2004-2006 AND SOLD PRIMARILY FOR USE BY STATE, FEDERAL, AND MUNICIPAL LAW ENFORCEMENT (LE) AGENCIES.FORD STIPULATES THAT THE SUBJECT VEHICLES ARE NOT SUITABLE FOR HIGH SPEED OR PURSUIT OPERATIONS AND ALSO IDENTIFIED A 2004 NATIONAL INSTITUTE FOR JUSTICE VEHICLE EVALUATION REPORT WHICH ALSO ACKNOWLEDGES THIS LIMITATION. THE FULL FACE WHEEL IS FABRICATED FROM TWO PIECES: A STAMPED OUTER WHEEL DISC AND A FORMED RIM.THE TWO PIECES, WHICH TOGETHER COMPRISE THE OUTER BEAD SEAT, ARE JOINED TOGETHER WITH A CIRCUMFERENTIAL WELD.A CYCLIC BENDING MOMENT OCCURS IN THE OUTER BEAD SEAT AREA AS THE WHEEL ROTATES, RESULTING IN FATIGUE STRESSES IN THE WELD'S HEAT AFFECTED ZONE THAT CAN LEAD TO FRACTURING (CRACKING) OF THE RIM MATERIAL.BECAUSE THE FAILURE OCCURS UNDER THE OUTBOARD TIRE BEAD, AIR LEAKAGE MAY NOT READILY OCCUR WHEN THE RIM CRACKS, DEPENDENT ON HOW WELL THE BEAD SEALS ON THE RIM.IF MULTIPLE CRACKS GROW UNDETECTED AND SUDDENLY JOIN INTO A SINGLE LARGE CRACK, THE WHEEL'S STRUCTURE CAN BECOME COMPROMISED LEADING TO RAPID AIR LOSS.A RAPID AIR LOSS, ESPECIALLY AT HIGHER SPEED, MAY LEAD TO A CRASH. FORD RESPONDED TO ODI'S JANUARY 5, 2009 INFORMATION REQUEST (IR) ON FEBRUARY 24.FORD'S RESPONSE ACKNOWLEDGES A NUMBER OF WHEEL FRACTURES ON THE SSVS.HOWEVER, BASED ON ITS ASSESSMENT OF THE PERTINENT FACTORS, IT CONCLUDES THAT THE CONDITION DOES NOT REPRESENT AN UNREASONABLE RISK TO SAFETY.THE LACK OF REPORTS OF RAPID AIR LOSS, NO ALLEGED CRASHES, AND THEIR ASSESSMENT THAT A CRACKED WHEEL CAN BE DETECTED THROUGH SLOW, REPEATED AIR LOSS OR VIBRATION, WERE THE BASES FOR FORD'S CONCLUSION.FORD DISCUSSES THE RESULTS OF A STUDY IT PERFORMED ON WHEELS RETURNED FROM LE FIELD USE, DESIGN REVISIONS IT MADE TO THE SUBJECT WHEEL, AND THE OUTCOME OF DURABILITY TESTING IT CONDUCTED ON THE OLD AND NEW WHEEL DESIGNS. THE COUNTS SHOWN ABOVE INCLUDE A DUPLICATE ODI AND FORD REPORT; THE FORD COUNTS ARE UNIQUE VEHICLES ALLEGING WHEEL FRACTURE(S).SOME WARRANTY CLAIMS INVOLVED MORE THAN ONE WHEEL REPLACEMENT.ALTHOUGH THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR A LONGER PERIOD OF TIME THAN VEHICLES INVESTIGATED IN THE PREVIOUS INVESTIGATIONS OF TWO-PIECE WHEEL FRACTURE, ODI DID NOT IDENTIFY ANY ALLEGATIONS OF CRASHES, RAPID AIR LOSS EVENTS DUE TO WHEEL FRACTURES OR ALLEGATIONS OF EFFECTS ON VEHICLE CONTROL OR STABILITY, AS WERE THE CASES IN PAST INVESTIGATIONS WHERE SAFETY RECALLS WERE CONDUCTED TO REPLACE AFFECTED WHEELS.THE AGENCY AGREES THAT THE SSV IS NOT SUITABLE FOR PURSUIT OR HIGH SPEED USAGE, REDUCING THE POTENTIAL FOR CRASHES OR LOSS OF CONTROL INCIDENTS TO BE CAUSED BY THE ALLEGED DEFECT. FORD IMPLEMENTED A 'SHOT PEENING' PROCESS IN JUNE 2006 WHICH REDUCED THE WHEEL'S SURFACE STRESS AND SIGNIFICANTLY IMPROVED ITS DURABILITY, AND ODI IS UNAWARE OF ANY FAILURES OF SHOT PEENED WHEELS (SERVICE PART NUMBER 7L1Z-1015-B).FORD'S TESTING SHOWED A SLIGHTLY REDUCED DURABILITY FOR THE NON-SHOT PEENED WHEELS WHEN 'LT' INSTEAD OF FORD APPROVED 'P' METRIC TYPE TIRES ARE USED. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY FURTHER C
Wheels:rim
FORD SPECIAL SERVICE VEHICLE (SSV) EXPEDITIONS USE A STEEL FULL FACE WHEEL DESIGN SIMILAR TO THAT INVESTIGATED IN PE03009, RQ04007, EA04034 (CROWN VICTORIA POLICE INTERCEPTOR) AND PE03026 (GM PICKUPS AND SUVS).A TOTAL OF 8,251 SSVS (2.2% OF TOTAL PRODUCTION) WERE PRODUCED WITHIN MODEL YEARS 2004-2006 AND SOLD PRIMARILY FOR USE BY STATE, FEDERAL, AND MUNICIPAL LAW ENFORCEMENT (LE) AGENCIES.FORD STIPULATES THAT THE SUBJECT VEHICLES ARE NOT SUITABLE FOR HIGH SPEED OR PURSUIT OPERATIONS AND ALSO IDENTIFIED A 2004 NATIONAL INSTITUTE FOR JUSTICE VEHICLE EVALUATION REPORT WHICH ALSO ACKNOWLEDGES THIS LIMITATION. THE FULL FACE WHEEL IS FABRICATED FROM TWO PIECES: A STAMPED OUTER WHEEL DISC AND A FORMED RIM.THE TWO PIECES, WHICH TOGETHER COMPRISE THE OUTER BEAD SEAT, ARE JOINED TOGETHER WITH A CIRCUMFERENTIAL WELD.A CYCLIC BENDING MOMENT OCCURS IN THE OUTER BEAD SEAT AREA AS THE WHEEL ROTATES, RESULTING IN FATIGUE STRESSES IN THE WELD'S HEAT AFFECTED ZONE THAT CAN LEAD TO FRACTURING (CRACKING) OF THE RIM MATERIAL.BECAUSE THE FAILURE OCCURS UNDER THE OUTBOARD TIRE BEAD, AIR LEAKAGE MAY NOT READILY OCCUR WHEN THE RIM CRACKS, DEPENDENT ON HOW WELL THE BEAD SEALS ON THE RIM.IF MULTIPLE CRACKS GROW UNDETECTED AND SUDDENLY JOIN INTO A SINGLE LARGE CRACK, THE WHEEL'S STRUCTURE CAN BECOME COMPROMISED LEADING TO RAPID AIR LOSS.A RAPID AIR LOSS, ESPECIALLY AT HIGHER SPEED, MAY LEAD TO A CRASH. FORD RESPONDED TO ODI'S JANUARY 5, 2009 INFORMATION REQUEST (IR) ON FEBRUARY 24.FORD'S RESPONSE ACKNOWLEDGES A NUMBER OF WHEEL FRACTURES ON THE SSVS.HOWEVER, BASED ON ITS ASSESSMENT OF THE PERTINENT FACTORS, IT CONCLUDES THAT THE CONDITION DOES NOT REPRESENT AN UNREASONABLE RISK TO SAFETY.THE LACK OF REPORTS OF RAPID AIR LOSS, NO ALLEGED CRASHES, AND THEIR ASSESSMENT THAT A CRACKED WHEEL CAN BE DETECTED THROUGH SLOW, REPEATED AIR LOSS OR VIBRATION, WERE THE BASES FOR FORD'S CONCLUSION.FORD DISCUSSES THE RESULTS OF A STUDY IT PERFORMED ON WHEELS RETURNED FROM LE FIELD USE, DESIGN REVISIONS IT MADE TO THE SUBJECT WHEEL, AND THE OUTCOME OF DURABILITY TESTING IT CONDUCTED ON THE OLD AND NEW WHEEL DESIGNS. THE COUNTS SHOWN ABOVE INCLUDE A DUPLICATE ODI AND FORD REPORT; THE FORD COUNTS ARE UNIQUE VEHICLES ALLEGING WHEEL FRACTURE(S).SOME WARRANTY CLAIMS INVOLVED MORE THAN ONE WHEEL REPLACEMENT.ALTHOUGH THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR A LONGER PERIOD OF TIME THAN VEHICLES INVESTIGATED IN THE PREVIOUS INVESTIGATIONS OF TWO-PIECE WHEEL FRACTURE, ODI DID NOT IDENTIFY ANY ALLEGATIONS OF CRASHES, RAPID AIR LOSS EVENTS DUE TO WHEEL FRACTURES OR ALLEGATIONS OF EFFECTS ON VEHICLE CONTROL OR STABILITY, AS WERE THE CASES IN PAST INVESTIGATIONS WHERE SAFETY RECALLS WERE CONDUCTED TO REPLACE AFFECTED WHEELS.THE AGENCY AGREES THAT THE SSV IS NOT SUITABLE FOR PURSUIT OR HIGH SPEED USAGE, REDUCING THE POTENTIAL FOR CRASHES OR LOSS OF CONTROL INCIDENTS TO BE CAUSED BY THE ALLEGED DEFECT. FORD IMPLEMENTED A 'SHOT PEENING' PROCESS IN JUNE 2006 WHICH REDUCED THE WHEEL'S SURFACE STRESS AND SIGNIFICANTLY IMPROVED ITS DURABILITY, AND ODI IS UNAWARE OF ANY FAILURES OF SHOT PEENED WHEELS (SERVICE PART NUMBER 7L1Z-1015-B).FORD'S TESTING SHOWED A SLIGHTLY REDUCED DURABILITY FOR THE NON-SHOT PEENED WHEELS WHEN 'LT' INSTEAD OF FORD APPROVED 'P' METRIC TYPE TIRES ARE USED. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY FURTHER C
2006 Ford Expedition Problems, Complaints & Recalls | Skip That Year
Illustration