IllustrationTHE TRANSMISSION WOULD STALL AND NOT GO FORWARD IN THE DRIVE GEAR. STALLED IN THE MIDDLE OF AN INTERSECTION WITH THE FAMILY IN THE EXPEDITION. HAD TO DRIVE HOME IN SECOND AND FIRST GEAR. VEHICLE IS 27 DAYS OLD WITH 952 MILES PURCHASED AT BILLINGLSEY FORD IN LAWTON, OK 73501. *JB
2005 Ford Expedition
Owner reports · Recalls · Investigations
More warning signs than most Expedition years
Owner complaints for the 2005 Ford Expedition are substantially higher than the model-year median of 155.
About this comparison →How this year compares
Owner complaints by model year
Compare all Expedition years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
250–25K
4025–50K
7950–75K
6275–100K
60100–150K
23150K+
289 reports with mileage · 26 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 76 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Vehicle Speed Control. Review the 66 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Engine. Review the 57 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
20 crash reports6 fire reports10 injury reports
What owners actually said
315 reportsI WAS TRAVELING AT 50MPH IN MY 2005 FORD EXPEDITION (3,700 MILES) WHEN A CHEVY CAVALIER RAN A STOP SIGN. I IMPACTED THE VEHICLE WITHOUT HAVING AN OPPORTUNITY TO HIT MY BRAKES. I WAS THE SOLE PERSON IN THE VEHICLE. IMPACT DESTROYED THE FRONT END OF MY VEHIVLE, AND PUSHED THE PASSENGER SIDE OF THE CAVALIER TO THE DRIVERS SEAT. MY …
Read full complaint
I WAS TRAVELING AT 50MPH IN MY 2005 FORD EXPEDITION (3,700 MILES) WHEN A CHEVY CAVALIER RAN A STOP SIGN. I IMPACTED THE VEHICLE WITHOUT HAVING AN OPPORTUNITY TO HIT MY BRAKES. I WAS THE SOLE PERSON IN THE VEHICLE. IMPACT DESTROYED THE FRONT END OF MY VEHIVLE, AND PUSHED THE PASSENGER SIDE OF THE CAVALIER TO THE DRIVERS SEAT. MY VEHICLE THEN EXITED THE ROAD THROUGH A STAND OF TREES, DOWN AN EMBANKMENT AND CAME TO REST ON THE FAR SIDE OF THE EMBANKMENT. FAILURE: PASSNGER AIRBAG DEPLOYED, BUT DRIVER'S AIRBAG DID NOT, RESULTING IN NECK INJURIES. MAJORITY OF DAMAGE WAS TO DRIVER'S SIDE OF FRONT END. FORD HAS EXPRESSED NO INTEREST AS TO THE CAUSE OF THE AIRBAG FAILURE.
DT: THE CAR WAS SITTING AND RUNNING FOR MORE THAN 10 MINUTES NEAR A BUILDING. THE CAR WAS IN PARK. THE OWNER WAS UNLOADING THE VEHICLE, AND THEN WALKED BACK INTO THE BUILDING. THE OWNER HEARD A BOOM, AND CAME OUTSIDE AND SAW THAT THE CAR HIT A FAN, AND ALMOST HIT THE BARN. THE CAR WAS IN REVERSE WHEN THE OWNER GOT BACK INTO …
Read full complaint
DT: THE CAR WAS SITTING AND RUNNING FOR MORE THAN 10 MINUTES NEAR A BUILDING. THE CAR WAS IN PARK. THE OWNER WAS UNLOADING THE VEHICLE, AND THEN WALKED BACK INTO THE BUILDING. THE OWNER HEARD A BOOM, AND CAME OUTSIDE AND SAW THAT THE CAR HIT A FAN, AND ALMOST HIT THE BARN. THE CAR WAS IN REVERSE WHEN THE OWNER GOT BACK INTO THE CAR. THE OWNER PUT IT BACK IN PARK AND SHUT VEHICLE OFF. THE CAR WAS INSPECTED, AND WAS DETERMINED THAT THEY COULDN'T DUPLICATE THE INCIDENT. THE OWNER HAS NOT CALLED THE MANUFACTURER. THE VEHICLE HAD MINIMAL DAMAGE. THERE WAS PROPERTY DAMAGE TO THE FAN.THE OWNER NOTED THERE WAS NO ONE AROUND THE VEHICLE. *AK
DT HAS A GLARE PROBLEM WITH THE WINDSHIELD, ALMOST LIKING LOOKING IN A MIRROR BECAUSE DASHBOARD LIGHTS INTERFERE WITH THE VISIBILITY OF DRIVING DOWN THE ROAD. HAD A DARK TOWEL ON THE DASHBOARD TO HELP WITH THE GLARE. NOTICED THIS ALMOST IMMEDIATELY. BEEN TO THE DEALER, THEY HAD CONSUMER CALL FORD BECAUSE OTHER CUSTOMERS HAD…
Read full complaint
DT HAS A GLARE PROBLEM WITH THE WINDSHIELD, ALMOST LIKING LOOKING IN A MIRROR BECAUSE DASHBOARD LIGHTS INTERFERE WITH THE VISIBILITY OF DRIVING DOWN THE ROAD. HAD A DARK TOWEL ON THE DASHBOARD TO HELP WITH THE GLARE. NOTICED THIS ALMOST IMMEDIATELY. BEEN TO THE DEALER, THEY HAD CONSUMER CALL FORD BECAUSE OTHER CUSTOMERS HAD THE SAME PROBLEM. *AK
(1) VEHICLE STARTED AND SHIFTED INTO DRIVE (2) IMMEDIATELY AFTER SHIFTING WITH FOOT ON BRAKE, EXPERIENCED FULL ENGINE THROTTLE CAUSING UNWANTED ACCELERATION FORWARD AND ALMOST CAUSING ACCIDENTS (3) VEHICLE TAKEN TO FORD DEALERSHIP FOR SERVICE AND PROBLEM REOCCURED 2 DAYS LATER
Official recalls
0No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1PE08070 · Steel Wheel Fracture
Opened Dec 9, 2008 · Closed Apr 15, 2009
Status: closed (inferred from source dates) · Wheels; Wheels:rim
FORD SPECIAL SERVICE VEHICLE (SSV) EXPEDITIONS USE A STEEL FULL FACE WHEEL DESIGN SIMILAR TO THAT INVESTIGATED IN PE03009, RQ04007, EA04034 (CROWN VICTORIA POLICE INTERCEPTOR) AND PE03026 (GM PICKUPS AND SUVS).A TOTAL OF 8,251 SSVS (2.2% OF TOTAL PRODUCTION) WERE PRODUCED WITHIN MODEL YEARS 2004-2006 AND SOLD PRIMARILY FOR USE BY STATE, FEDERAL, AND MUNICIPAL LAW ENFORCEMENT (LE) AGENCIES.FORD STIPULATES THAT THE SUBJECT VEHICLES ARE NOT SUITABLE FOR HIGH SPEED OR PURSUIT OPERATIONS AND ALSO IDENTIFIED A 2004 NATIONAL INSTITUTE FOR JUSTICE VEHICLE EVALUATION REPORT WHICH ALSO ACKNOWLEDGES THIS LIMITATION. THE FULL FACE WHEEL IS FABRICATED FROM TWO PIECES: A STAMPED OUTER WHEEL DISC AND A FORMED RIM.THE TWO PIECES, WHICH TOGETHER COMPRISE THE OUTER BEAD SEAT, ARE JOINED TOGETHER WITH A CIRCUMFERENTIAL WELD.A CYCLIC BENDING MOMENT OCCURS IN THE OUTER BEAD SEAT AREA AS THE WHEEL ROTATES, RESULTING IN FATIGUE STRESSES IN THE WELD'S HEAT AFFECTED ZONE THAT CAN LEAD TO FRACTURING (CRACKING) OF THE RIM MATERIAL.BECAUSE THE FAILURE OCCURS UNDER THE OUTBOARD TIRE BEAD, AIR LEAKAGE MAY NOT READILY OCCUR WHEN THE RIM CRACKS, DEPENDENT ON HOW WELL THE BEAD SEALS ON THE RIM.IF MULTIPLE CRACKS GROW UNDETECTED AND SUDDENLY JOIN INTO A SINGLE LARGE CRACK, THE WHEEL'S STRUCTURE CAN BECOME COMPROMISED LEADING TO RAPID AIR LOSS.A RAPID AIR LOSS, ESPECIALLY AT HIGHER SPEED, MAY LEAD TO A CRASH. FORD RESPONDED TO ODI'S JANUARY 5, 2009 INFORMATION REQUEST (IR) ON FEBRUARY 24.FORD'S RESPONSE ACKNOWLEDGES A NUMBER OF WHEEL FRACTURES ON THE SSVS.HOWEVER, BASED ON ITS ASSESSMENT OF THE PERTINENT FACTORS, IT CONCLUDES THAT THE CONDITION DOES NOT REPRESENT AN UNREASONABLE RISK TO SAFETY.THE LACK OF REPORTS OF RAPID AIR LOSS, NO ALLEGED CRASHES, AND THEIR ASSESSMENT THAT A CRACKED WHEEL CAN BE DETECTED THROUGH SLOW, REPEATED AIR LOSS OR VIBRATION, WERE THE BASES FOR FORD'S CONCLUSION.FORD DISCUSSES THE RESULTS OF A STUDY IT PERFORMED ON WHEELS RETURNED FROM LE FIELD USE, DESIGN REVISIONS IT MADE TO THE SUBJECT WHEEL, AND THE OUTCOME OF DURABILITY TESTING IT CONDUCTED ON THE OLD AND NEW WHEEL DESIGNS. THE COUNTS SHOWN ABOVE INCLUDE A DUPLICATE ODI AND FORD REPORT; THE FORD COUNTS ARE UNIQUE VEHICLES ALLEGING WHEEL FRACTURE(S).SOME WARRANTY CLAIMS INVOLVED MORE THAN ONE WHEEL REPLACEMENT.ALTHOUGH THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR A LONGER PERIOD OF TIME THAN VEHICLES INVESTIGATED IN THE PREVIOUS INVESTIGATIONS OF TWO-PIECE WHEEL FRACTURE, ODI DID NOT IDENTIFY ANY ALLEGATIONS OF CRASHES, RAPID AIR LOSS EVENTS DUE TO WHEEL FRACTURES OR ALLEGATIONS OF EFFECTS ON VEHICLE CONTROL OR STABILITY, AS WERE THE CASES IN PAST INVESTIGATIONS WHERE SAFETY RECALLS WERE CONDUCTED TO REPLACE AFFECTED WHEELS.THE AGENCY AGREES THAT THE SSV IS NOT SUITABLE FOR PURSUIT OR HIGH SPEED USAGE, REDUCING THE POTENTIAL FOR CRASHES OR LOSS OF CONTROL INCIDENTS TO BE CAUSED BY THE ALLEGED DEFECT. FORD IMPLEMENTED A 'SHOT PEENING' PROCESS IN JUNE 2006 WHICH REDUCED THE WHEEL'S SURFACE STRESS AND SIGNIFICANTLY IMPROVED ITS DURABILITY, AND ODI IS UNAWARE OF ANY FAILURES OF SHOT PEENED WHEELS (SERVICE PART NUMBER 7L1Z-1015-B).FORD'S TESTING SHOWED A SLIGHTLY REDUCED DURABILITY FOR THE NON-SHOT PEENED WHEELS WHEN 'LT' INSTEAD OF FORD APPROVED 'P' METRIC TYPE TIRES ARE USED. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY FURTHER C
Additional source detail variants (2)
Wheels
FORD SPECIAL SERVICE VEHICLE (SSV) EXPEDITIONS USE A STEEL FULL FACE WHEEL DESIGN SIMILAR TO THAT INVESTIGATED IN PE03009, RQ04007, EA04034 (CROWN VICTORIA POLICE INTERCEPTOR) AND PE03026 (GM PICKUPS AND SUVS).A TOTAL OF 8,251 SSVS (2.2% OF TOTAL PRODUCTION) WERE PRODUCED WITHIN MODEL YEARS 2004-2006 AND SOLD PRIMARILY FOR USE BY STATE, FEDERAL, AND MUNICIPAL LAW ENFORCEMENT (LE) AGENCIES.FORD STIPULATES THAT THE SUBJECT VEHICLES ARE NOT SUITABLE FOR HIGH SPEED OR PURSUIT OPERATIONS AND ALSO IDENTIFIED A 2004 NATIONAL INSTITUTE FOR JUSTICE VEHICLE EVALUATION REPORT WHICH ALSO ACKNOWLEDGES THIS LIMITATION. THE FULL FACE WHEEL IS FABRICATED FROM TWO PIECES: A STAMPED OUTER WHEEL DISC AND A FORMED RIM.THE TWO PIECES, WHICH TOGETHER COMPRISE THE OUTER BEAD SEAT, ARE JOINED TOGETHER WITH A CIRCUMFERENTIAL WELD.A CYCLIC BENDING MOMENT OCCURS IN THE OUTER BEAD SEAT AREA AS THE WHEEL ROTATES, RESULTING IN FATIGUE STRESSES IN THE WELD'S HEAT AFFECTED ZONE THAT CAN LEAD TO FRACTURING (CRACKING) OF THE RIM MATERIAL.BECAUSE THE FAILURE OCCURS UNDER THE OUTBOARD TIRE BEAD, AIR LEAKAGE MAY NOT READILY OCCUR WHEN THE RIM CRACKS, DEPENDENT ON HOW WELL THE BEAD SEALS ON THE RIM.IF MULTIPLE CRACKS GROW UNDETECTED AND SUDDENLY JOIN INTO A SINGLE LARGE CRACK, THE WHEEL'S STRUCTURE CAN BECOME COMPROMISED LEADING TO RAPID AIR LOSS.A RAPID AIR LOSS, ESPECIALLY AT HIGHER SPEED, MAY LEAD TO A CRASH. FORD RESPONDED TO ODI'S JANUARY 5, 2009 INFORMATION REQUEST (IR) ON FEBRUARY 24.FORD'S RESPONSE ACKNOWLEDGES A NUMBER OF WHEEL FRACTURES ON THE SSVS.HOWEVER, BASED ON ITS ASSESSMENT OF THE PERTINENT FACTORS, IT CONCLUDES THAT THE CONDITION DOES NOT REPRESENT AN UNREASONABLE RISK TO SAFETY.THE LACK OF REPORTS OF RAPID AIR LOSS, NO ALLEGED CRASHES, AND THEIR ASSESSMENT THAT A CRACKED WHEEL CAN BE DETECTED THROUGH SLOW, REPEATED AIR LOSS OR VIBRATION, WERE THE BASES FOR FORD'S CONCLUSION.FORD DISCUSSES THE RESULTS OF A STUDY IT PERFORMED ON WHEELS RETURNED FROM LE FIELD USE, DESIGN REVISIONS IT MADE TO THE SUBJECT WHEEL, AND THE OUTCOME OF DURABILITY TESTING IT CONDUCTED ON THE OLD AND NEW WHEEL DESIGNS. THE COUNTS SHOWN ABOVE INCLUDE A DUPLICATE ODI AND FORD REPORT; THE FORD COUNTS ARE UNIQUE VEHICLES ALLEGING WHEEL FRACTURE(S).SOME WARRANTY CLAIMS INVOLVED MORE THAN ONE WHEEL REPLACEMENT.ALTHOUGH THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR A LONGER PERIOD OF TIME THAN VEHICLES INVESTIGATED IN THE PREVIOUS INVESTIGATIONS OF TWO-PIECE WHEEL FRACTURE, ODI DID NOT IDENTIFY ANY ALLEGATIONS OF CRASHES, RAPID AIR LOSS EVENTS DUE TO WHEEL FRACTURES OR ALLEGATIONS OF EFFECTS ON VEHICLE CONTROL OR STABILITY, AS WERE THE CASES IN PAST INVESTIGATIONS WHERE SAFETY RECALLS WERE CONDUCTED TO REPLACE AFFECTED WHEELS.THE AGENCY AGREES THAT THE SSV IS NOT SUITABLE FOR PURSUIT OR HIGH SPEED USAGE, REDUCING THE POTENTIAL FOR CRASHES OR LOSS OF CONTROL INCIDENTS TO BE CAUSED BY THE ALLEGED DEFECT. FORD IMPLEMENTED A 'SHOT PEENING' PROCESS IN JUNE 2006 WHICH REDUCED THE WHEEL'S SURFACE STRESS AND SIGNIFICANTLY IMPROVED ITS DURABILITY, AND ODI IS UNAWARE OF ANY FAILURES OF SHOT PEENED WHEELS (SERVICE PART NUMBER 7L1Z-1015-B).FORD'S TESTING SHOWED A SLIGHTLY REDUCED DURABILITY FOR THE NON-SHOT PEENED WHEELS WHEN 'LT' INSTEAD OF FORD APPROVED 'P' METRIC TYPE TIRES ARE USED. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY FURTHER C
Wheels:rim
FORD SPECIAL SERVICE VEHICLE (SSV) EXPEDITIONS USE A STEEL FULL FACE WHEEL DESIGN SIMILAR TO THAT INVESTIGATED IN PE03009, RQ04007, EA04034 (CROWN VICTORIA POLICE INTERCEPTOR) AND PE03026 (GM PICKUPS AND SUVS).A TOTAL OF 8,251 SSVS (2.2% OF TOTAL PRODUCTION) WERE PRODUCED WITHIN MODEL YEARS 2004-2006 AND SOLD PRIMARILY FOR USE BY STATE, FEDERAL, AND MUNICIPAL LAW ENFORCEMENT (LE) AGENCIES.FORD STIPULATES THAT THE SUBJECT VEHICLES ARE NOT SUITABLE FOR HIGH SPEED OR PURSUIT OPERATIONS AND ALSO IDENTIFIED A 2004 NATIONAL INSTITUTE FOR JUSTICE VEHICLE EVALUATION REPORT WHICH ALSO ACKNOWLEDGES THIS LIMITATION. THE FULL FACE WHEEL IS FABRICATED FROM TWO PIECES: A STAMPED OUTER WHEEL DISC AND A FORMED RIM.THE TWO PIECES, WHICH TOGETHER COMPRISE THE OUTER BEAD SEAT, ARE JOINED TOGETHER WITH A CIRCUMFERENTIAL WELD.A CYCLIC BENDING MOMENT OCCURS IN THE OUTER BEAD SEAT AREA AS THE WHEEL ROTATES, RESULTING IN FATIGUE STRESSES IN THE WELD'S HEAT AFFECTED ZONE THAT CAN LEAD TO FRACTURING (CRACKING) OF THE RIM MATERIAL.BECAUSE THE FAILURE OCCURS UNDER THE OUTBOARD TIRE BEAD, AIR LEAKAGE MAY NOT READILY OCCUR WHEN THE RIM CRACKS, DEPENDENT ON HOW WELL THE BEAD SEALS ON THE RIM.IF MULTIPLE CRACKS GROW UNDETECTED AND SUDDENLY JOIN INTO A SINGLE LARGE CRACK, THE WHEEL'S STRUCTURE CAN BECOME COMPROMISED LEADING TO RAPID AIR LOSS.A RAPID AIR LOSS, ESPECIALLY AT HIGHER SPEED, MAY LEAD TO A CRASH. FORD RESPONDED TO ODI'S JANUARY 5, 2009 INFORMATION REQUEST (IR) ON FEBRUARY 24.FORD'S RESPONSE ACKNOWLEDGES A NUMBER OF WHEEL FRACTURES ON THE SSVS.HOWEVER, BASED ON ITS ASSESSMENT OF THE PERTINENT FACTORS, IT CONCLUDES THAT THE CONDITION DOES NOT REPRESENT AN UNREASONABLE RISK TO SAFETY.THE LACK OF REPORTS OF RAPID AIR LOSS, NO ALLEGED CRASHES, AND THEIR ASSESSMENT THAT A CRACKED WHEEL CAN BE DETECTED THROUGH SLOW, REPEATED AIR LOSS OR VIBRATION, WERE THE BASES FOR FORD'S CONCLUSION.FORD DISCUSSES THE RESULTS OF A STUDY IT PERFORMED ON WHEELS RETURNED FROM LE FIELD USE, DESIGN REVISIONS IT MADE TO THE SUBJECT WHEEL, AND THE OUTCOME OF DURABILITY TESTING IT CONDUCTED ON THE OLD AND NEW WHEEL DESIGNS. THE COUNTS SHOWN ABOVE INCLUDE A DUPLICATE ODI AND FORD REPORT; THE FORD COUNTS ARE UNIQUE VEHICLES ALLEGING WHEEL FRACTURE(S).SOME WARRANTY CLAIMS INVOLVED MORE THAN ONE WHEEL REPLACEMENT.ALTHOUGH THE SUBJECT VEHICLES HAVE BEEN IN SERVICE FOR A LONGER PERIOD OF TIME THAN VEHICLES INVESTIGATED IN THE PREVIOUS INVESTIGATIONS OF TWO-PIECE WHEEL FRACTURE, ODI DID NOT IDENTIFY ANY ALLEGATIONS OF CRASHES, RAPID AIR LOSS EVENTS DUE TO WHEEL FRACTURES OR ALLEGATIONS OF EFFECTS ON VEHICLE CONTROL OR STABILITY, AS WERE THE CASES IN PAST INVESTIGATIONS WHERE SAFETY RECALLS WERE CONDUCTED TO REPLACE AFFECTED WHEELS.THE AGENCY AGREES THAT THE SSV IS NOT SUITABLE FOR PURSUIT OR HIGH SPEED USAGE, REDUCING THE POTENTIAL FOR CRASHES OR LOSS OF CONTROL INCIDENTS TO BE CAUSED BY THE ALLEGED DEFECT. FORD IMPLEMENTED A 'SHOT PEENING' PROCESS IN JUNE 2006 WHICH REDUCED THE WHEEL'S SURFACE STRESS AND SIGNIFICANTLY IMPROVED ITS DURABILITY, AND ODI IS UNAWARE OF ANY FAILURES OF SHOT PEENED WHEELS (SERVICE PART NUMBER 7L1Z-1015-B).FORD'S TESTING SHOWED A SLIGHTLY REDUCED DURABILITY FOR THE NON-SHOT PEENED WHEELS WHEN 'LT' INSTEAD OF FORD APPROVED 'P' METRIC TYPE TIRES ARE USED. A SAFETY-RELATED DEFECT HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY FURTHER C