2019 Ford Escape

The contact owns a 2019 Ford Escape. The contact stated when the vehicle was started, the check engine warning light illuminated. The contact stated that the failure had occurred while returning home from visiting a nearby town. The vehicle was driven to the residence. The following day, the vehicle was taken to the dealer where it was diagnosed with head gasket failure, coolant intrusion into the engine, and engine failure. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure. The contact was advised to contact the NHTSA Hotline and report the failure. In addition, the contact was informed that the repair was not covered under the Customer Satisfaction Program: 21N12. The failure mileage was approximately 68,000.

Took my 2019 escape in for regular maintenance of changing spark plugs and transmission fluid change. My vehicle was running just fine no issues when I brought it in. They did the service and only after a test drive did it start to misfire. Long story short the mechanic found it was issue with a faulty cracked piston in the cylinder which caused antifreeze to leak into the cylinder. The only repair for this is a new engine! I regularly serviced my vehicle several times a year at ford and never once received any sort of recall alerts in the mail, email or ford app nor did any the of ford service technicians mentioned anything during service appointments. Excuse my wording If I didn’t use the correct terms but this is literally the same issue the f150’s are having so I am curious to why mine has not been recalled yet? I have a 5 year old suv that now needs a new engine and ford knows about the fault and they best replace my engine for free this is shady ford. I’m single mom of 3 kids I can’t afford to replace an engine?! That’s why I bought the 2019 escape brand new to avoid stuff like this happening on a older vehicle but now here I am with a vehicle that is un drivable after 5 years!! Please add this model to your recall ford don’t be so greedy it’s your mistake you pay for it!

Coolant is going into the engine. Ford will not replace since it is a known issue and not a recall. I've had to replace cylinder 3 and spark plug since car started jolting down the road and wouldn't go past 30 mph. Constantly adding coolant. It is available for inspection upon request. Safety is a big issue since I have 2 kids that are with me in that vehicle. If the engine fails while I'm driving it puts everyone on the road at risk. Local Ford dealership confirmed with me this issue was coolant intrusion. This issue has been ongoing since June 2024 until present Nov 2024. Messages for engine failure have popped up. Overheating has came about. Misfiring popped up.

Car started having Misfire code around 40,000 miles (September 2023). Spark plugs and coils were changed out twice within a few months of each other. The last technician to replace the coils said it looked like oil was on the spark plugs. Check Engine light still remains on to this day. Around 55,000 miles, noticed coolant was needing to be replaced every other day. Took to Ford Dealership 10/29/24. Video from Technician, shows coolant leaking into engine and stated this is a common problem TSB and we need a new engine ($9,088). Took to local mechanic for second opinion (11/2/24). He found the same issue. Per Ford Dealership, car is out of warranty as of March 2024 (5 year/50,000). This car was purchased used 1/2023 with 26,800 miles. The car hesitates to start. I have to try multiple times to start the car. Called Ford Motor Company 11/06/24 and they stated to file with NHTSA.

In some of the affected vehicles the 1.5L EcoBoost engine may exhibit a low coolant level, white exhaust smoke and/or may run in a rough condition with or without an illuminated malfunction indicator light (MIL) with only diagnostic trouble codes (DTCs) P0300, P0301-P0304, P0316, P0217, P1285 and/or P1299 stored in powertrain control module (PCM). This may be due to coolant intrusion into a cylinder bore.

The contact owns a 2019 Ford Escape. The contact stated while driving at an undisclosed speed, the check engine warning light illuminated. The vehicle was taken to the dealer, where it was diagnosed and determined that the engine block had failed, causing coolant intrusion into the cylinders. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was made aware of the failure and a case was opened. The contact was advised to file a complaint with the NHTSA Hotline. The failure mileage was approximately 110,000.

The contact owns a 2019 Ford Escape. The contact stated while starting the vehicle, there was white smoke coming from the exhaust, with the check engine warning light illuminated. The contact exited the vehicle and checked under the hood and became aware that the coolant reservoir was low on coolant. The contact refilled the coolant reservoir and drove to a local dealer where the vehicle was diagnosed. The contact was informed that there was a misfire in cylinders #2 and #3 due to coolant intrusion into the engine. The contact was informed that the engine needed to be replaced. The vehicle was not repaired. The manufacturer was notified of the failure. The approximate failure mileage was 93,000.

The contact owns a 2019 Ford Escape. The contact stated that while driving at an undisclosed speed, the vehicle inadvertently lost motive power; however, the engine remained running. The contact pulled over to the shoulder of the roadway to turn the vehicle off. After restarting the vehicle, the vehicle returned to normal functionality. No warning lights were illuminated. The vehicle was taken to the dealer, who was unable to diagnose or duplicate the failure. The vehicle was not repaired. The manufacturer was notified of the failure and referred the contact to the NHTSA Hotline for assistance. The failure mileage was 30,000.

My check engine light first came on in June 2024 (3 months ago), and said there were too many cylinder 4 misfires, and to replace the spark plugs. This was done, check engine light was cleared. My car began showing an "engine fault, service now" error 2.5 weeks ago and it sounded like water was "rushing" in the engine. The check engine light came on 3 days later, got the codes read, took it to a mechanic, then exchanged the ignition coil. When I went to pick it up, the car shuddered whenever trying to accelerate, so much so that my car wouldn't accelerate, and I had to have to towed to the Ford dealer. The mechanic confirmed that with the codes and the symptoms, and he previously worked at Ford, there is a coolant leak into the engine block and I would likely need a new engine. There is a Technical Service Bulletin out for this issue, so they know it exists. The dealer has not confirmed the issue yet, they said it will probably take 2 weeks before they get to that, then it would likely be 1-3 months to get the parts here, then they would start repairing it, but there were 3 vehicles ahead of mine with the exact same issue. My safety was put at risk because the car would not accelerate to the speed limit, increasing likelihood of a wreck, and the engine felt like it was going to die at any moment when I returned the one block back to the mechanic.