2019 Ford Escape

After the vehicle has been running and stopped at a traffic light or an intersection, whether the auto-start is on or off, as you pull out into traffic the engine shuts off. No error code to the computer that Ford could find, it just stops. This is a life and death situation as oncoming traffic are approaching. In order to get it started again, you have to put the vehicle in park and push the stop/start button.

The engine failed (melted piston) such that I had a sudden lose of power while driving down the expressway. This resulted in my vehicle speed going from 70 MPH to 30 MPH. This resulted in my having to get to the shoulder of the road as quickly as possible to get out of the way of traffic. The vehicle was driven to the dealer (i.e. limp home mode). DTC's P0304 and P0302 were present. The dealer diagnosed the failure of the engine due to a melted piston. This resulted in the vehicle needing a complete engine replacement. I sold the vehicle as is to a scrap yard. The vehicle was running normally and there were no warnings of any kind leading up to the incident.

My car will not drive. Power train light came on out of no where o was less than a mile from home and car keep going from 40 rpm to 5 rpm and would move hardly at all and then speed up. Car makes noise after turn it off like the csp. I have been told the CSP is not valid for me and this is going to be a very expensive repair up to $15,000. Can not believe Ford is not being held accountable for this

I have a 2019 Ford Escape Ecoboost, and the engine had to be replaced at 64,000 miles due to an issue with 2017-2019 Ford Escapes, which Ford did not recall. What happens is the engine sucks all of the antifreeze out of its compartment and dumps it onto the engine block, ruining the engine. It's ridiculous that Ford did not recall this issue, as it is terribly costly to replace an engine on a vehicle. What's even more ridiculous is having to replace an engine with so few miles and paying out of pocket when you're still paying for the vehicle. Some have reported having to have their engine replaced at 15,000 on these same vehicles. Ford needs to be held accountable, if not sued over this issue. And, the dealerships are not nice when they have to fix the problem. Worst and most costly experience with a vehicle ever!

I brought my car into Ford while under warranty because I was having problems. It was told to me that I needed an engine so ford didn’t contact my warranty company & decided to pay out of there pocket for a short block. The new engine & short block was supposedly put in. Months later I experienced the same problem & brought it back to Ford. Ford told me they don’t have to fix it being that my extended warranty doesn’t cover it.

The engine in this vehicle has a known design flaw (see Ford Customer Satisfaction Programs 19B37/21N12) that causes the cylinder head gasket to fail at a location that allows coolant to enter the cylinder. Coolant contains chemicals like ethylene glycol or propylene glycol. While not easily flammable at room temperature, coolant can catch fire if it reaches its autoignition temperature, which can happen when exposed to the extreme heat and pressure inside an engine cylinder during combustion. The gasket failure also exposes the coolant passages within the cylinder head to these extreme temperatures and allows exhaust gases to enter through the failure location. Additionally, the coolant leak will also cause the engine to run at a higher temperature and the increased heat can further elevate the fire risk. Ford admits to this issue and will replace the engine in affected vehicles through Customer Satisfaction Program 21N12, however this program conveniently expired in November 2022, before most owners were made aware of the issue. This extremely dangerous defect does not become less dangerous with the passage of time and there should be no time limit on this repair. Either a class action lawsuit or action by the NHTSA will be required to force Ford to make these repairs. My own vehicle has been parked and not driven for well over a year due to this issue. It was replaced with a Chevrolet Traverse and I refuse to sell the defective Ford Escape to an unsuspecting buyer who would unwittingly be putting their family’s lives in danger.

The 2019 Ford Escape (purchased new in December 2018) was taken to the Nick Mayer Ford (Mayfield Heights, Ohio where it was purchased) service department in August/September 2024 for a computer diagnostic analysis for a previous warranty recall/repair problems regarding short block replacement for coolant intrusion that was not performed/corrected several years prior in 2021 when only the turbocharger was replaced. The problem was excessive smoke being emitted at engine start back in 2021 when the only turbocharger was replaced and the problem reappeared in August 2024. Nick Mayer Ford had the vehicle for two weeks in August/September 2024 and provided neither a computer diagnostic analysis report nor repair of the previous recall/repair issues (2021) including no explanation/resolution of the problem. Currently, due to the previous undiagnosed/unresolved problems, the engine failed at 70,000 miles in December 2024 and the long engine block has to be replaced. The engine warning lamp was on at the time of engine failure. We are still paying on a car loan for the vehicle. References: 1. Ford Help Desk Assistance Claim Case# [XXX] on 12/5/2024 filed with Tanya E. for short block replacement for coolant intrusion. 2. Ohio Attorney General Matter Number [XXX] on 12/6/2024 filed with Ross. 3. Ohio Attorney General Consumer Complaint# [XXX] filed online on 1/3/2025.