NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
989 reports95,000 miles · Jan 31, 2017
Power Train
PERSISTENT SMELL WHEN DRIVING AND THEN FOUND DARK "OIL" SPOTS THAT SPREAD THROUGHOUT UNDER SIDE OF THE VEHICLE AND ON MY GARAGE FLOOR AFTER BEING PARKED. BROUGHT TO FORD DEALERSHIP: PTU FAILURE IS WHAT WE ARE BEING TOLD. VERY COSTLY REPAIR/REPLACEMENT CHARGE OF PTU ASSEMBLY, APPROXIMATELY $1500. I'M PUTTING IN THIS COMPLAINT BEC…
Read full complaint
PERSISTENT SMELL WHEN DRIVING AND THEN FOUND DARK "OIL" SPOTS THAT SPREAD THROUGHOUT UNDER SIDE OF THE VEHICLE AND ON MY GARAGE FLOOR AFTER BEING PARKED. BROUGHT TO FORD DEALERSHIP: PTU FAILURE IS WHAT WE ARE BEING TOLD. VERY COSTLY REPAIR/REPLACEMENT CHARGE OF PTU ASSEMBLY, APPROXIMATELY $1500. I'M PUTTING IN THIS COMPLAINT BECAUSE I HAVE SEEN MANY, MANY COMPLAINTS OF OTHER PEOPLE EXPERIENCING SIMILAR ISSUE WITH THIS MAKE, MODEL AND YEAR. PLEASE CONSIDER INVESTIGATING, AND IF THIS HAPPENED TO SOMEONE ELSE PLEASE PUT IN YOUR COMPLAINT SO IT WILL GO TO INVESTIGATION, THANK YOU! *TR
NHTSA ODI #10948636
96,987 miles · Jan 20, 2017
Power Train
I WAS DRIVING DOWN THE INTERSTATE WHEN I SUDDENLY LOST POWER. I MANAGED TO SOMEHOW GET MY CAR OFF THE ROAD AND EXIT THE HIGHWAY (I WAS JUST ABOUT TO THE EXIT WHEN THIS HAPPENED). IT WAS LOOKED AT BY A FORD DEALER WHO SAID THE PCM DIED AND TOOK OUT AT LEAST THREE COIL PACKS. TOLD ME IF I DROVE IT ANY FURTHER IT WOULD LIKELY CATCH…
Read full complaint
I WAS DRIVING DOWN THE INTERSTATE WHEN I SUDDENLY LOST POWER. I MANAGED TO SOMEHOW GET MY CAR OFF THE ROAD AND EXIT THE HIGHWAY (I WAS JUST ABOUT TO THE EXIT WHEN THIS HAPPENED). IT WAS LOOKED AT BY A FORD DEALER WHO SAID THE PCM DIED AND TOOK OUT AT LEAST THREE COIL PACKS. TOLD ME IF I DROVE IT ANY FURTHER IT WOULD LIKELY CATCH FIRE. UP TO THIS POINT I HADN'T HAD ANY PROBLEMS WITH THIS CAR. IT WAS RUNNING FINE. THIS ALL HAPPENED SO QUICKLY AND IN SUCH A DANGEROUS LOCATION THAT IT COULD HAVE CAUSED AN ACCIDENT. UPON RESEARCHING PLACES TO FIX THE ISSUE, I NOTICED A RATHER LARGE AMOUNT OF COMPLAINTS ABOUT THIS SAME ISSUE AND THIS SAME MAKE MODEL AND CAR YEAR. EACH COMPLAINT SAID THIS HAPPENED ON THE FREEWAY. *TR
NHTSA ODI #10946720
Mileage unknown · Jan 17, 2017
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS). THE CONTACT STATED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPE…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT RECEIVED A RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS). THE CONTACT STATED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE. THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10945753
Mileage unknown · Jan 13, 2017
Air Bags
TL* TAKATA RECALL. THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS) WAS RECEIVED IN JUNE. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABL…
Read full complaint
TL* TAKATA RECALL. THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT STATED THAT THE RECALL NOTICE FOR NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS) WAS RECEIVED IN JUNE. AFTER CONTACTING THE DEALER AND THE MANUFACTURER ON MULTIPLE OCCASIONS, THE CONTACT WAS INFORMED THAT THE PARTS NEEDED FOR THE RECALL REMEDY WERE STILL NOT AVAILABLE THERE WAS NO ESTIMATED TIME FOR RECEIVING THE PARTS THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE. UPDATED 03/17/17*LJ *CN
NHTSA ODI #10945116
129,000 miles · Jan 12, 2017
Power Train
WHILE DRIVING ON A FREEWAY SUDDENLY A PUNGENT SMELL FILLED THE CABIN AND THAT WAS UNBEARABLE ALONG WITH A HUGE CRACKING SOUND THAT DIDN'T STOP... TOOK THE NEXT EXIT AND STOPPED AT A PARKING SPOT. TOOK TO THE FORD DEALER THE SAME DAY AND THEY DIAGNOSED IMMEDIATELY THAT THE PTU NEEDS TO BE REPLACED AND THAT'S A KNOW ISSUE WHERE AL…
Read full complaint
WHILE DRIVING ON A FREEWAY SUDDENLY A PUNGENT SMELL FILLED THE CABIN AND THAT WAS UNBEARABLE ALONG WITH A HUGE CRACKING SOUND THAT DIDN'T STOP... TOOK THE NEXT EXIT AND STOPPED AT A PARKING SPOT. TOOK TO THE FORD DEALER THE SAME DAY AND THEY DIAGNOSED IMMEDIATELY THAT THE PTU NEEDS TO BE REPLACED AND THAT'S A KNOW ISSUE WHERE ALMOST ALL THE FORD EDGES OF 2007 AND 08 HAVE THE PTU ISSUE. THE SMELL IS FROM THE OIL THAT LEAKED FROM THE PTU WHICH FELL ON THE EXHAUST. PAID AROUND $1800 TO REPLACE THE PTU. I AM WONDERING WHY THERE IS NO RECALL AS IT SEEM TO HAPPEN FOR MOST OF THE EDGES. CALLED THE FORD CORPORATE CUSTOMER CARE TO REPORT THE ISSUE AND THEY DIDN'T CARE TO LISTEN AND ASKED TO DEAL WITH THE LOCAL DEALERS. DIDN'T EXPECT THIS FROM FORD AND I WOULD REQUEST NHTSA ODI TEAM TO LOOK INTO THIS ISSUE AND FLAG THIS AS RECALL AS THIS COULD CREATE A SERIOUS CRASH WHEN IT HAPPENS ON A FREEWAY AS IT COULD SLOW DOWN THE VEHICLE SUDDENLY AND THINK ABOUT THE CONDITION OF THE INFANTS WHO COULD INHALE THE GASES. I LITERALLY HAD ISSUE INHALING FOR NEXT COUPLE OF DAYS AS THE SMELL WAS THAT BAD WHEN IT LEAKED. *TR
NHTSA ODI #10944686
120,000 miles · Jan 12, 2017
Service BrakesCrash
TL* THE CONTACT OWNS A 2007 FORD EDGE. WHILE DRIVING VARIOUS SPEEDS THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO STOP THE VEHICLE. THERE WAS AN ABNORMAL NOISE WHEN THE FAILURE OCCURRED. THE CONTACT HAD TO PUMP THE BRAKE PEDAL SEVERAL TIMES TO STOP THE VEHICLE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO …
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD EDGE. WHILE DRIVING VARIOUS SPEEDS THE BRAKE PEDAL WAS DEPRESSED, BUT FAILED TO STOP THE VEHICLE. THERE WAS AN ABNORMAL NOISE WHEN THE FAILURE OCCURRED. THE CONTACT HAD TO PUMP THE BRAKE PEDAL SEVERAL TIMES TO STOP THE VEHICLE. THE FAILURE OCCURRED ON NUMEROUS OCCASIONS. THE VEHICLE WAS TAKEN TO AN INDEPENDENT MECHANIC WHERE IT WAS DIAGNOSED THAT THE BRAKE BOOSTER NEEDED REPLACEMENT. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 120,000. UPDATED 04/18/17 LJ THE CONSUMER STATED THE BREAK FAILURE OCCURED FOR THE FIRST TIME AT THE TIME OF THE ACCIDENT. THE DEALER WAS NOTIFIED. THE VEHICLE WAS REPAIRED. UPDATED 09/08/2017 *JS
NHTSA ODI #10944617
Mileage unknown · Jan 10, 2017
Air Bags
TAKATA RECALL MY VEHICLE WAS ONE OF THE MILLIONS IDENTIFIED AS HAVING AN AIRBAG THAT NEEDS TO BE REPLACED. THIS VEHICLE HAS BEEN A FLORIDA VEHICLE SINCE 2008 SO IT HAS DEFINITELY BEEN EXPOSED TO THE TYPES OF CONDITIONS THAT AFFECT THE AIRBAG. WITHOUT RECEIVING ANY WORD ON WHEN A FIX WILL BE AVAILABLE MAKES THE VEHICLE USELESS F…
Read full complaint
TAKATA RECALL MY VEHICLE WAS ONE OF THE MILLIONS IDENTIFIED AS HAVING AN AIRBAG THAT NEEDS TO BE REPLACED. THIS VEHICLE HAS BEEN A FLORIDA VEHICLE SINCE 2008 SO IT HAS DEFINITELY BEEN EXPOSED TO THE TYPES OF CONDITIONS THAT AFFECT THE AIRBAG. WITHOUT RECEIVING ANY WORD ON WHEN A FIX WILL BE AVAILABLE MAKES THE VEHICLE USELESS FOR MY FAMILY. I'M SURE THAT PROVIDING ME WITH THE RECALL ENSURES THAT FORD HAS PASSED ON THE LIABILITY IN THE EVENT THAT SOMETHING SHOULD HAPPEN TO A PASSENGER IN THE FRONT SEAT. *TR
NHTSA ODI #10944107
Mileage unknown · Jan 10, 2017
Air Bags
TL* THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT…
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT RECEIVED NOTIFICATION OF NHTSA CAMPAIGN NUMBER: 16V384000 (AIR BAGS) HOWEVER, THE PART TO DO THE REPAIR WAS UNAVAILABLE. THE CONTACT STATED THAT THE MANUFACTURER EXCEEDED A REASONABLE AMOUNT OF TIME FOR THE RECALL REPAIR. THE MANUFACTURER WAS MADE AWARE OF THE ISSUE. THE CONTACT HAD NOT EXPERIENCED A FAILURE. VIN TOOL CONFIRMS PARTS NOT AVAILABLE.
NHTSA ODI #10944050
Mileage unknown · Jan 7, 2017
Air Bags
JUST BOUGHT A 2007 FORD EDGE THIS JUNE 2016,GOT A RECALL IN THE MAIL TWO WEEKS LATER FOR PASSENGER AIR BAG MIGHT HAVE METAL OR OTHER FRAGMENT THAT CAN INJURE OR DIE. I TAKE MY VEHICLE ON LONG TRIPS SO I DO HAVE A PASSENGER. ALL THE SEATS ARE TAKEN AND THE FRONT SEAT IS NOT USED IF I CAN FIT OTHER PEOPLE IN THE BACK. I RENTED A C…
Read full complaint
JUST BOUGHT A 2007 FORD EDGE THIS JUNE 2016,GOT A RECALL IN THE MAIL TWO WEEKS LATER FOR PASSENGER AIR BAG MIGHT HAVE METAL OR OTHER FRAGMENT THAT CAN INJURE OR DIE. I TAKE MY VEHICLE ON LONG TRIPS SO I DO HAVE A PASSENGER. ALL THE SEATS ARE TAKEN AND THE FRONT SEAT IS NOT USED IF I CAN FIT OTHER PEOPLE IN THE BACK. I RENTED A CAR TO GO TO SOUTH DAKOTA'S BECAUSE WE HAD A HOLE FAMILY AND I DIDN'T WANT TO RISK SOMEONE'S LIKE BECAUSE OF FAULTY AIR BAY. FORD SAID THEY DON'T HAVE THE PARTS BUT MONEY IS THE PROBLEM FORD DOESN'T WANT TO PUT IT OUT. CAN FORD TURN OFF THE PASSENGER AIR BAG SO IT DOESN'T GO OFF. THE RECALL CAME IN JUNE AND THAT'S PLENTY OF TIME TO GET IT TAKEN CARE OF.FORD DISAPPOINTED ME WITH THE EDGE. ALL I WANT TO DO IS MY FAMILY AND I TO BE SAFE IN A VEHICLE.IF THERE ARE ENOUGH COMPLAINTS MAYBE FORD WILL FIX IT. THANKS FOR YOUR TIME [XXX] . INFORMATION REDACTED PURSUANT TO THE FREEDOM OF INFORMATION ACT (FOIA), 5 U.S.C. 552(B)(6). *TR
NHTSA ODI #10940358
133,000 miles · Jan 7, 2017
Structure
DRIVER AND PASSENGER DOORS CLOSE, BUT DO NOT LATCH. THEY ALSO WILL NOT LOCK. DOORS ARE NOT SECURE AND WILL RANDOMLY OPEN. THE DOOR OPEN INDICATION LIGHT IS DISPLAYING ON THE INSTRUMENT PANEL. THIS HAPPENS WHEN CLOSING THE DOORS WHEN THE VEHICLE IS STOPPED. DOORS ARE NOT SAFE OR SECURELY LATCHING. HAPPENING IN COLD WE…
Read full complaint
DRIVER AND PASSENGER DOORS CLOSE, BUT DO NOT LATCH. THEY ALSO WILL NOT LOCK. DOORS ARE NOT SECURE AND WILL RANDOMLY OPEN. THE DOOR OPEN INDICATION LIGHT IS DISPLAYING ON THE INSTRUMENT PANEL. THIS HAPPENS WHEN CLOSING THE DOORS WHEN THE VEHICLE IS STOPPED. DOORS ARE NOT SAFE OR SECURELY LATCHING. HAPPENING IN COLD WEATHER.
NHTSA ODI #10940299
Official recalls
5Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 10, 2017
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
May 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Oct 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2007-2008 Lincoln MKX, and Ford Edge vehicles, manufactured June 15, 2006, to September 22, 2008, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Due to corrosion from salt water exposure such as from road salt use, the affected vehicles may leak fuel from the fuel tank seam weld under the tank mounting reinforcement brackets.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Interim notices were mailed to owners on December 12, 2014. The recall began on October 6, 2015. Dealers will inspect the vehicles and either clean and treat the fuel tank with a corrosion preventative or replace the tank, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S22.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE09031 · Front Suspension Lower Ball Joint
Opened Jul 13, 2009 · Closed Nov 19, 2009
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JULY 13, 2009, THE OFFICE OF DEFECTS INVESTIGATIONS (ODI) OPENED PRELIMINARY EVALUATION PE09-031 TO INVESTIGATE ALLEGATIONS OF FRONT LOWER BALL JOINT SEPARATION IN MODEL YEAR (MY) 2007 AND 2008 FORD EDGE AND LINCOLN MKX VEHICLES.THE INVESTIGATION WAS BASED ON THREE OWNER COMPLAINTS ALLEGING THAT THE FRONT LOWER BALL JOINT SEPARATED AND CAUSED THE FRONT SUSPENSION TO COLLAPSE WHILE DRIVING.ODI ALSO IDENTIFIED INFORMATION RELATED TO THE ALLEGED DEFECT IN EARLY WARNING DATA SUBMITTED BY FORD.PRELIMINARY ANALYSIS INDICATED THAT THE FAILURES WERE RELATED TO THE PINCH BOLT USED TO SECURE THE FRONT LOWER BALL JOINT STUD TO THE STEERING KNUCKLE.ONE COMPLAINT ALLEGED THAT A CRASH OCCURRED WHICH RESULTED IN A MINOR INJURY.HOWEVER, NO ADDITIONAL INFORMATION COULD BE OBTAINED TO SUPPORT THIS CLAIM.INFORMATION PROVIDED BY FORD IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE09-031 INDICATE THAT IN EARLY MY 2007 PRODUCTION THERE WERE SOME ISSUES WITH THE FRONT LOWER CONTROL ARM BALL JOINT ASSEMBLY PROCESS.THE PINCH BOLTS USED WERE HAND STARTED AND HAD THE POTENTIAL TO CROSS THREAD AND NOT ACHIEVE PROPER CLAMP LOAD, POTENTIALLY RESULTING IN A LOOSE JOINT.IN NOVEMBER 2007, CHANGES WERE IMPLEMENTED TO CHASE AND CLEAN THE FIRST SIX THREADS OF THE BOLT TO PROVIDE EASIER HAND STARTING OF THE NUT AND ENSURE GOOD THREAD ENGAGEMENT BEFORE TIGHTENING. FORD ALSO IDENTIFIED ONGOING CONCERNS WITH THE POWER TRANSMISSION UNIT (PTU) SEALS AND FRONT SUSPENSION HYDRO-BUSHINGS ON THE SUBJECT VEHICLES, WHICH BOTH REQUIRE DISASSEMBLY OF THE FRONT LOWER BALL JOINT TO REPAIR.IF THE BALL JOINT IS NOT PROPERLY REASSEMBLED FOLLOWING SUCH SERVICE, THE JOINT MAY SEPARATE IN LATER SERVICE.FORD HAS PROVIDED ADDITIONAL INSTRUCTIONS AND NEW PINCH BOLTS TO THE PTU REPAIR KIT TO IMPROVE THE JOINT REASSEMBLY PROCESS. ODI'S ANALYSIS OF FAILURE DATA IDENTIFIED 31 INCIDENTS OF JOINT SEPARATION (WITH 12 SPECIFICALLY STATING THAT THEY OCCURRED WHILE DRIVING).REPAIR RECORDS FOR THESE 31 VEHICLES SHOWS THAT 28 INVOLVE SEPARATION OF THE JOINT ON THE PASSENGER (RIGHT) SIDE, WHICH IS THE SIDE THAT MUST BE DISASSEMBLED FOR PTU SERVICE.TWENTY-THREE OF THESE WERE FOUND TO HAVE BEEN PREVIOUSLY DISASSEMBLED FOR CONTROL ARM BUSHING SERVICE, PTU SERVICE OR OTHER TRANSMISSION REPAIR. THE EIGHT CLAIMS THAT DID NOT INVOLVE PRIOR SERVICE REPAIRS REQUIRING JOINT DISASSEMBLY ALL OCCURRED VERY EARLY IN VEHICLE LIFE, INDICATING THAT IT IS UNLIKELY THAT ANY JOINTS MANUFACTURED WITH LOOSE PINCH BOLTS ARE STILL IN SERVICE.ALL OF THESE JOINTS FAILED WITHIN 6 MONTHS IN SERVICE AND 10,000 MILES (THE MAXIMUM FAILURE MILEAGE IS 8,097 MILES).THERE HAVEN'T BEEN ANY SUCH FAILURES (I.E., NOT INVOLVING PRIOR SERVICE/DISASSEMBLY) SINCE DECEMBER 2008.THE RATE FOR INCIDENTS THAT DID NOT OCCUR FOLLOWING SERVICE AND, THUS, MAY BE RELATED TO THE MANUFACTURING PROCESS ISSUES IDENTIFIED BY FORD IS VERY LOW (2.5 PER 100,000 VEHICLES) AND THESE INCIDENTS OCCURRED VERY EARLY IN THE LIFE OF THE VEHICLES AND ARE NOT SHOWING A CONTINUING FAILURE TREND.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration