NHTSA owner reports · September 18, 2026 snapshot.
Engine complaints
88 reportsClear category filter102,000 miles · Jul 23, 2014
Engine
WAS DRIVING AT 45 MPH WHEN THE CAR SUDDENLY OVERHEATED AND IN A MATTER OF SECONDS IT CRACKED THE BLOCK. THE DEALERSHIP IT WAS TOWED TO COULDN'T EVEN TELL ME HOW SOMETHING LIKE THAT COULD HAVE HAPPENED. THIS CAR HAS BEEN WELL TAKEN CARE OF. NEEDLESS TO SAY...I HAD TO BUY A WHOLE NEW ENGINE FOR IT. I DON'T THINK THIS WAS ANYTH…
Read full complaint
WAS DRIVING AT 45 MPH WHEN THE CAR SUDDENLY OVERHEATED AND IN A MATTER OF SECONDS IT CRACKED THE BLOCK. THE DEALERSHIP IT WAS TOWED TO COULDN'T EVEN TELL ME HOW SOMETHING LIKE THAT COULD HAVE HAPPENED. THIS CAR HAS BEEN WELL TAKEN CARE OF. NEEDLESS TO SAY...I HAD TO BUY A WHOLE NEW ENGINE FOR IT. I DON'T THINK THIS WAS ANYTHING THAT I DID THAT MADE THIS HAPPEN. HONESTLY I THINK IT IS SOMETHING FORD SHOULD REALLY LOOK AT IF THE SERVICE MECHANICS AT A FORD DEALERSHIP CAN'T EVEN TELL ME HOW IT HAPPENED. *TR
NHTSA ODI #10615745
95,000 miles · Jul 18, 2014
Electrical SystemEnginePower Train
I WAS DRIVING MY 2007 FORD EDGE WITH 3 CHILDREN IN IT WHEN ALL OF A SUDDEN I LOST THE ABILITY TO NOT ONLY ACCELERATE BUT MY SPEED SUDDENLY FELL FROM 45 MILES AN HOUR TO 15 MILES AN HOUR WITHOUT ANY ABILITY TO ACCELERATE. MY CAR WAS IN A CONSTANT STATE OF SHAKING AND SPUTTERING AND INCREASED WHEN APPLYING THE BRAKES. THERE WAS SO…
Read full complaint
I WAS DRIVING MY 2007 FORD EDGE WITH 3 CHILDREN IN IT WHEN ALL OF A SUDDEN I LOST THE ABILITY TO NOT ONLY ACCELERATE BUT MY SPEED SUDDENLY FELL FROM 45 MILES AN HOUR TO 15 MILES AN HOUR WITHOUT ANY ABILITY TO ACCELERATE. MY CAR WAS IN A CONSTANT STATE OF SHAKING AND SPUTTERING AND INCREASED WHEN APPLYING THE BRAKES. THERE WAS SOMETHING SIGNIFICANTLY WRONG AND IT WAS PRETTY SCARY TO EXPERIENCE PARTICULARLY WITH 3 SMALL CHILDREN. I HAD THE CAR TOWED TO MY AUTOMOTIVE SERVICE COMPANY WHERE THE CAR'S SOFTWARE SYSTEM DISPLAYED CODES INDICATING TWO IGNITION CODES FAILED. SUBSEQUENTLY, THE SERVICE PROVIDER REPLACED ALL THE SPARK PLUGS AND TWO COILS. THE CAR WAS NOT FIXED AND IT WAS FURTHER DETERMINED THAT THE PCM BOARD IS SENDING EXTREMELY HIGH CURRENT TO THE IGNITION COILS AND COULD HAVE CAUSED AN ENGINE FIRE. THIS IS VERY DISTRESSING. FORD HAS ISSUED AN INTERNAL TSB ACKNOWLEDGING THIS ISSUE BUT HAS NOT ENACTED A RECALL. THE ESTIMATED COST TO REPLACE THE PCM, SPARK PLUGS AND COILS (6) IS APPROXIMATELY $3,000. ADDITIONALLY IN MY RESEARCH THERE IS A CLASS ACTION LAWSUIT THAT HAS BEEN FILED BY A GROUP OF FORD OWNERS. *TR
NHTSA ODI #10614661
83,770 miles · Jun 25, 2014
EnginePower Train
MY VEHICLE ALL OF A SUDDEN STARTED TO SLOW DOWN SUDDENLY LIKE I HAD TAKEN MY FOOT OFF THE GAS. IT STARTED SHUDDERING AND MY TRANSMISSION LIGHT CAME ON. I THOUGHT IT WAS THE TRANSMISSION SO I HAD IT TOWED TO THE SHOP. AFTER DIAGNOSIS, IT SHOWED MY CYLINDERS WERE MISFIRING. IT WAS DUE TO A BAD COIL WHICH WAS CAUSING THE SPARK PLUG…
Read full complaint
MY VEHICLE ALL OF A SUDDEN STARTED TO SLOW DOWN SUDDENLY LIKE I HAD TAKEN MY FOOT OFF THE GAS. IT STARTED SHUDDERING AND MY TRANSMISSION LIGHT CAME ON. I THOUGHT IT WAS THE TRANSMISSION SO I HAD IT TOWED TO THE SHOP. AFTER DIAGNOSIS, IT SHOWED MY CYLINDERS WERE MISFIRING. IT WAS DUE TO A BAD COIL WHICH WAS CAUSING THE SPARK PLUGS TO READ AT AN EXTREMELY HIGH VOLTAGE. THEY NEEDED TO REPLACE ALL COILS AND ALL SPARK PLUGS. THEN FOUND OUT THAT IT FRIED MY PCM(COMPUTER) WHICH ALSO HAD TO BE REPLACED. COME TO FIND OUT, THIS IS A KNOW ISSUE WITH THE 2007 FORD EDGE AND THERE IS A TSB ON IT FOR THIS EXACT SITUATION. THE DEALERSHIP TOLD ME THAT THE PCM HAD A MALFUNCTION WHICH CAUSED THE COILS/SPARK PLUGS TO GO BAD. THEY ALSO SAID THE PCM HAS A MANUFACTURER 8 YEAR/80,000 MILE WARRANTY. WELL I WAS AT 7 YEARS/83000 MILES AND WHEN THEY SUBMITTED THE WARRANTY CLAIM, FORD DENIED IT FORCING ME TO PAY $2400 FOR THE REPAIRS. I THINK THIS IS RIDICULOUS TO DENY A KNOWN MALFUNCTION FOR ONLY 3000 MILES OVER. WHAT IF I HAD BEEN ON THE HIGHWAY WHEN MY VEHICLE SUDDENLY CAME TO A STOP? I HAD MY SON WITH ME THAT DAY AND THIS COULD HAVE CAUSED A MAJOR ACCIDENT, POSSIBLY INVOLVING OTHER DRIVERS, AND WE MAY HAVE EVEN BEEN INJURED. AND FORD DOESN'T FEEL RESPONSIBLE TO HELP WITH THE COST OF THIS REPAIR?? *TR
NHTSA ODI #10606068
98,800 miles · Jun 3, 2014
Engine
SINCE FEB 2014, MY 2007 FORD EDGE SEEMED TO BE WANTING TO STALL WHEN I WAS DRIVING AND/OR TRYING TO ACCELERATE. I DIDN'T THINK ANYTHING OF IT AS IT WASN'T A 24/7 ISSUE BUT IT DID HAPPEN REGULARLY. YESTERDAY EVERYTHING CHANGED. I WENT TO TURN MY CAR ON YESTERDAY AND IT DIDN'T TURN ON RIGHT AWAY. IT WAS "TRYING" TO START AND THEN …
Read full complaint
SINCE FEB 2014, MY 2007 FORD EDGE SEEMED TO BE WANTING TO STALL WHEN I WAS DRIVING AND/OR TRYING TO ACCELERATE. I DIDN'T THINK ANYTHING OF IT AS IT WASN'T A 24/7 ISSUE BUT IT DID HAPPEN REGULARLY. YESTERDAY EVERYTHING CHANGED. I WENT TO TURN MY CAR ON YESTERDAY AND IT DIDN'T TURN ON RIGHT AWAY. IT WAS "TRYING" TO START AND THEN IT WOULD SHUT DOWN. I WOULD TRY TO START IT AGAIN AND ONCE AGAIN, IT WAS "TRYING" TO START AND EVENTUALLY DID. I WAS DRIVING HOME ON THE HIGHWAY WHEN I BEGAN TO NOTICE THAT I WASN'T ABLE TO ACCELERATE AND I WAS GOING SLOWER AND SLOWER SO I MANAGED TO PULL OVER TO THE BREAK DOWN LANE AND THEN THE CAR JUST SHUT OFF. ONCE AGAIN, IT DIDN'T TURN ON THE FIRST TIME I TRIED BUT THEN IT DID THE SECOND TIME BUT RELUCTANTLY. THE LIGHTS WERE DIM ON MY DASHBOARD WHICH HADN'T HAPPENED BEFORE. I MANAGED TO GET HOME VERY SLOWLY. I SHUT MY CAR OFF AT HOME AND TRIED TO TURN IT ON AND AGAIN IT WAS STRUGGLING TO TURN ON. I TOOK THE CAR TO THE DEALER TODAY AND I WAS TOLD THAT THE THROTTLE BODY HAD TO BE REPLACED. THE SERVICE TECH WENT ON TO EXPLAIN THAT HE HAS SEEN THIS ISSUE ESPECIALLY IN THE YEAR AND MODEL THAT I HAVE. I HAVE GOOGLED THIS ISSUE ONLINE AND SEE THAT THE NHTSA HAD BEEN LOOKING INTO THIS SAME ISSUE/COMPLAINTS BUT WITH A LATER YEAR AS WELL AS WELL AS OTHER MODELS. I DON'T UNDERSTAND WHY THIS WASN'T A RECALL AS THIS COULD HAVE BEEN A DANGEROUS SCENARIO. I WAS ON THE HIGHWAY WHEN THIS OCCURRED AND THANKFULLY NOT WITH MY CHILDREN. I SEE SEVERAL COMPLAINTS ONLINE FOR THE SAME ISSUE. I NEED TO PAY TO GET THIS FIXED BUT I FEEL THIS SHOULD BE COMING OUT OF FORD'S POCKET AS IT SEEMS LIKE IT WAS A DEFECTIVE PART. THIS COMPLAINT SHOULD BE OPENED AGAIN AND A FORMAL RECALL SHOULD BE ESTABLISHED. THIS COULD BE POTENTIALLY VERY DANGEROUS AND EVEN FATAL. *TR
NHTSA ODI #10595769
65,000 miles · Apr 10, 2014
EnginePower Train
DRIVING AT LOW SPEEDS THE VEHICLE WILL SHIFT VERY HARD, FEELS LIKE SOMEONE REAR ENDING ME. THE TRANSMISSION FEELS LIKE IT HAS A HARD TIME GETTING INTO GEAR. AT HIGH SPEEDS THE SAME THING HAPPENS BUT USUALLY ON HOT DAYS. THE TRANSMISSION FINALLY GAVE OUT AT 75000 DUE TO THE HARD SLAMMING AND HAD TO BE REBUILT. I WAS LEAVING A DRI…
Read full complaint
DRIVING AT LOW SPEEDS THE VEHICLE WILL SHIFT VERY HARD, FEELS LIKE SOMEONE REAR ENDING ME. THE TRANSMISSION FEELS LIKE IT HAS A HARD TIME GETTING INTO GEAR. AT HIGH SPEEDS THE SAME THING HAPPENS BUT USUALLY ON HOT DAYS. THE TRANSMISSION FINALLY GAVE OUT AT 75000 DUE TO THE HARD SLAMMING AND HAD TO BE REBUILT. I WAS LEAVING A DRIVEWAY AND WAS UNABLE TO ACCELERATE, PUTTING ME AT RISK OF BEING HIT FROM BEHIND. THIS COULD HAVE BEEN DISASTROUS AT HIGH SPEEDS. AT 78000 MILES I AM STILL HAVING THE SAME PROBLEM, I TURN THE VEHICLE ON THE TRANSMISSION SLAMS INTO R AND THEN I CANNOT ACCELERATE PAST 10 MPH. I TURN THE VEHICLE OFF AND RESTART IT, AND IT SEEMS LIKE NOTHING EVERY HAPPENED. THIS HAPPENS INTERMITTENTLY AND THE CHECK ENGINE LIGHTS COME ONE ONLY EVERY ONCE IN A WHILE IT IS HAPPENING. WORRIED ABOUT ME AND MY BABIES SAFETY WHILE DRIVING. *TR
NHTSA ODI #10578832
98,000 miles · Dec 26, 2013
Engine
TL* THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT STATED THAT THE VEHICLE MISFIRED INTERMITTENTLY, SHOOK VIOLENTLY AND THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE PCM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE …
Read full complaint
TL* THE CONTACT OWNS A 2007 FORD EDGE. THE CONTACT STATED THAT THE VEHICLE MISFIRED INTERMITTENTLY, SHOOK VIOLENTLY AND THE CHECK ENGINE LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO A PRIVATE MECHANIC WHERE IT WAS FOUND THAT THE PCM NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS CONTACTED ABOUT THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 98,000.
NHTSA ODI #10557344
97,360 miles · Dec 7, 2013
EnginePower Train
WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SHUTTERED AND THERE WAS A LOSS OF ACCELERATION POWER. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTOMOTIVE REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE 6 IGNITION COILS, SPARK PLUGS AND THE PCM SYSTEM NEEDED TO BE REPLACED. THE CURRENT MILEAGE IS 97…
Read full complaint
WHILE DRIVING APPROXIMATELY 60 MPH, THE VEHICLE SHUTTERED AND THERE WAS A LOSS OF ACCELERATION POWER. THE CHECK ENGINE WARNING LIGHT WAS ILLUMINATED. THE VEHICLE WAS TAKEN TO AN AUTOMOTIVE REPAIR SHOP WHERE IT WAS DIAGNOSED THAT THE 6 IGNITION COILS, SPARK PLUGS AND THE PCM SYSTEM NEEDED TO BE REPLACED. THE CURRENT MILEAGE IS 97395. *TR
NHTSA ODI #10555164
89,000 miles · Nov 5, 2013
Electrical SystemEngine
SECOND TIME A YEAR OR SO LATER ELECTRICAL COOLING RADIATOR FAN GOES OUT. REPLACING AGAIN. *TR
NHTSA ODI #10550989
71,111 miles · Nov 5, 2013
Electrical SystemEngine
ELECTRIC RADIATOR COOLING FAN QUIT. CAR OVERHEATED. HAD TO BE REPLACED. *TR
NHTSA ODI #10550987
87,000 miles · Oct 22, 2013
Engine
I WAS DRIVING ON THE HIGHWAY WHEN MY CHECK ENGINE LIGHT CAME ON AND I NOTICED MY THERMOSTAT CLIMBING ABOUT TO OVER HEAT. I PULL OF AT THE NEAREST EXIT AND STOP AT AN OIL CHANGE SERVICE STATION. THE MECHANIC SAY I HAD NO ANTIFREEZE IN THE CAR. HE REFILLS THE ANTIFREEZE AND I WAS ON MY WAY. 20 MINS INTO MY DRIVE, THE CHECK ENGIN…
Read full complaint
I WAS DRIVING ON THE HIGHWAY WHEN MY CHECK ENGINE LIGHT CAME ON AND I NOTICED MY THERMOSTAT CLIMBING ABOUT TO OVER HEAT. I PULL OF AT THE NEAREST EXIT AND STOP AT AN OIL CHANGE SERVICE STATION. THE MECHANIC SAY I HAD NO ANTIFREEZE IN THE CAR. HE REFILLS THE ANTIFREEZE AND I WAS ON MY WAY. 20 MINS INTO MY DRIVE, THE CHECK ENGINE LIGHT ON AND THE THERMOSTAT LOOKS FINE, BUT THE CAR STARTED SPUTTERING AND STOPPED IN THE MIDDLE OF A BUSY AREA OF NYC. I HAD THE CAR TOWED TO A MECHANIC AND AFTER THEIR DIAGNOSTIC TEST THEY SAID THE ENGINE HEAD IS CRACKED OR WARPED AND THEY FOUND ANTIFREEZE MIXED IN OIL AND RADIATOR AND WILL COST $2500 TO FIX! WTF!! IS THIS ALLOWED TO HAPPEN?? I TOOK GREAT CARE OF THIS VEHICLE AND I FEEL LIKE A SUCKER! NOW I CAN'T GET TO WORK, CAN'T GET MY KIDS TO OR FROM SCHOOL AND I'M NOT SURE WHAT TO DO AT THIS POINT! *TR
NHTSA ODI #10549014
Official recalls
5Mar 10, 2021
Ford Motor Company (Ford) is recalling certain 2007-2011 Ranger, 2006-2012 Fusion, Lincoln Zephyr, Lincoln MKZ, 2006-2011 Mercury Milan, 2007-2010 Ford Edge, and Lincoln MKX vehicles. The driver's side air bag inflator may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, high temperatures, and high temperature cycling.
Consequence & remedy
Consequence: An inflator explosion may result in sharp metal fragments striking the driver or other occupants, resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will replace the driver-side airbag inflator or module with an alternate one, free of charge. Owner notification letters were mailed on April 9, 2021 for the passenger side, and November 14, 2022 for the driver side. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S12.
Feb 16, 2021
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence & remedy
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Additional source detail variants (3)
Air Bags:frontal:passenger Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal:driver Side:inflator Module
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Air Bags:frontal
Ford Motor Company (Ford) is recalling certain 2005-2014 Mustang, 2004-2011 Ranger, 2009-2011 Mercury Milan, 2006 Ford GT, 2008-2012 Fusion, 2007-2010 Edge and Lincoln MKX, and 2009-2010 Lincoln MKZ vehicles. These vehicles may be equipped with a driver or passenger frontal air bag inflator used as a replacement service part, that may explode due to propellant degradation occurring after long-term exposure to high absolute humidity, temperature and temperature cycling.
Consequence: In the event of a crash necessitating deployment of the frontal air bag, an inflator explosion may result in sharp metal fragments striking the driver or other occupants resulting in serious injury or death.
Remedy: Ford will notify owners, and dealers will inspect the driver and passenger air bag module, and replace either the module or the inflator, if necessary, free of charge. The recall began March 17, 2021. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 21S05.
Jan 10, 2017
Ford Motor Company (Ford) is recalling certain 2012 Ford Fusion and Mustang and Lincoln Zephyr and MKZ vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain 2009 Ford Ranger, Edge, Fusion and Mustang, Lincoln MKX, MKZ and Zephyr and Mercury Milan vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia and West Virginia, or "Zone B." Additionally, unless included in "Zone A" or "Zone B" above, Ford is recalling certain 2007-2008 Ford Ranger, Edge and Lincoln MKX, 2006-2008 Ford Fusion, Mercury Milan, Lincoln Zephyr and MKZ, 2005-2008 Ford Mustang and 2005-2006 Ford GT vehicles originally sold, or ever registered, in the states of Alaska, Colorado, Connecticut, Idaho, Iowa, Maine, Massachusetts, Michigan, Minnesota, Montana, New Hampshire, New York, North Dakota, Oregon, Rhode Island, South Dakota, Utah, Vermont, Washington, Wisconsin and Wyoming. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the passenger frontal air bag, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Interim letters informing owners of the recall and that parts are not yet available began mailing March 1, 2017. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
May 31, 2016
Ford Motor Company (Ford) is recalling certain model year 2007-2011 Ford Ranger vehicles, 2006-2011 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2007-2010 Ford Edge, Lincoln MKX vehicles, 2005-2006 Ford GT vehicles, and 2005-2011 Ford Mustang vehicles originally sold, or ever registered, in Alabama, California, Florida, Georgia, Hawaii, Louisiana, Mississippi, South Carolina, Texas, Puerto Rico, American Samoa, Guam, the Northern Mariana Islands (Saipan), and the U.S. Virgin Islands, or "Zone A." Additionally, unless included in "Zone A" above, Ford is recalling certain model year 2007-2008 Ford Ranger, Edge and Lincoln MKX vehicles, 2006-2008 Ford Fusion, Mercury Milan and Lincoln Zephyr/MKZ vehicles, 2005-2006 Ford GT vehicles and 2005-2008 Ford Mustang vehicles originally sold, or ever registered, in Arizona, Arkansas, Delaware, District of Columbia, Illinois, Indiana, Kansas, Kentucky, Maryland, Missouri, Nebraska, Nevada, New Jersey, New Mexico, North Carolina, Ohio, Oklahoma, Pennsylvania, Tennessee, Virginia, and West Virginia, or "Zone B." Any vehicle not included in "Zone A", or "Zone B" is not included in the safety recall. These vehicles are equipped with certain air bag inflators assembled as part of the passenger frontal air bag modules, and used as original equipment or replacement equipment. In the event of a crash necessitating deployment of the front air bags, these inflators may rupture due to propellant degradation occurring after long-term exposure to absolute humidity and temperature cycling.
Consequence & remedy
Consequence: An inflator rupture may result in metal fragments striking the vehicle occupants resulting in serious injury or death.
Remedy: Owners are advised not to drive their vehicles until the repair has been performed. Ford will notify owners, and dealers will replace the passenger frontal air bag inflator, free of charge. Ford mailed interim letters informing owners that parts are not yet available on July 15, 2016. Owners will receive a second notice when remedy parts become available. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 19S01.
Oct 29, 2014
Ford Motor Company (Ford) is recalling certain model year 2007-2008 Lincoln MKX, and Ford Edge vehicles, manufactured June 15, 2006, to September 22, 2008, and originally sold, or currently registered in, Connecticut, Delaware, Illinois, Indiana, Iowa, Kentucky, Maine, Maryland, Massachusetts, Michigan, Minnesota, Missouri, New Hampshire, New Jersey, New York, Ohio, Pennsylvania, Rhode Island, Vermont, West Virginia, Wisconsin and the District of Columbia. Due to corrosion from salt water exposure such as from road salt use, the affected vehicles may leak fuel from the fuel tank seam weld under the tank mounting reinforcement brackets.
Consequence & remedy
Consequence: A fuel leak in the presence of an ignition source increases the risk of a fire.
Remedy: Interim notices were mailed to owners on December 12, 2014. The recall began on October 6, 2015. Dealers will inspect the vehicles and either clean and treat the fuel tank with a corrosion preventative or replace the tank, free of charge. Owners may contact Ford customer service at 1-866-436-7332. Ford's number for this recall is 14S22.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2PE09031 · Front Suspension Lower Ball Joint
Opened Jul 13, 2009 · Closed Nov 19, 2009
Status: closed (inferred from source dates) · Suspension:front:control Arm:lower Ball Joint
ON JULY 13, 2009, THE OFFICE OF DEFECTS INVESTIGATIONS (ODI) OPENED PRELIMINARY EVALUATION PE09-031 TO INVESTIGATE ALLEGATIONS OF FRONT LOWER BALL JOINT SEPARATION IN MODEL YEAR (MY) 2007 AND 2008 FORD EDGE AND LINCOLN MKX VEHICLES.THE INVESTIGATION WAS BASED ON THREE OWNER COMPLAINTS ALLEGING THAT THE FRONT LOWER BALL JOINT SEPARATED AND CAUSED THE FRONT SUSPENSION TO COLLAPSE WHILE DRIVING.ODI ALSO IDENTIFIED INFORMATION RELATED TO THE ALLEGED DEFECT IN EARLY WARNING DATA SUBMITTED BY FORD.PRELIMINARY ANALYSIS INDICATED THAT THE FAILURES WERE RELATED TO THE PINCH BOLT USED TO SECURE THE FRONT LOWER BALL JOINT STUD TO THE STEERING KNUCKLE.ONE COMPLAINT ALLEGED THAT A CRASH OCCURRED WHICH RESULTED IN A MINOR INJURY.HOWEVER, NO ADDITIONAL INFORMATION COULD BE OBTAINED TO SUPPORT THIS CLAIM.INFORMATION PROVIDED BY FORD IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER FOR PE09-031 INDICATE THAT IN EARLY MY 2007 PRODUCTION THERE WERE SOME ISSUES WITH THE FRONT LOWER CONTROL ARM BALL JOINT ASSEMBLY PROCESS.THE PINCH BOLTS USED WERE HAND STARTED AND HAD THE POTENTIAL TO CROSS THREAD AND NOT ACHIEVE PROPER CLAMP LOAD, POTENTIALLY RESULTING IN A LOOSE JOINT.IN NOVEMBER 2007, CHANGES WERE IMPLEMENTED TO CHASE AND CLEAN THE FIRST SIX THREADS OF THE BOLT TO PROVIDE EASIER HAND STARTING OF THE NUT AND ENSURE GOOD THREAD ENGAGEMENT BEFORE TIGHTENING. FORD ALSO IDENTIFIED ONGOING CONCERNS WITH THE POWER TRANSMISSION UNIT (PTU) SEALS AND FRONT SUSPENSION HYDRO-BUSHINGS ON THE SUBJECT VEHICLES, WHICH BOTH REQUIRE DISASSEMBLY OF THE FRONT LOWER BALL JOINT TO REPAIR.IF THE BALL JOINT IS NOT PROPERLY REASSEMBLED FOLLOWING SUCH SERVICE, THE JOINT MAY SEPARATE IN LATER SERVICE.FORD HAS PROVIDED ADDITIONAL INSTRUCTIONS AND NEW PINCH BOLTS TO THE PTU REPAIR KIT TO IMPROVE THE JOINT REASSEMBLY PROCESS. ODI'S ANALYSIS OF FAILURE DATA IDENTIFIED 31 INCIDENTS OF JOINT SEPARATION (WITH 12 SPECIFICALLY STATING THAT THEY OCCURRED WHILE DRIVING).REPAIR RECORDS FOR THESE 31 VEHICLES SHOWS THAT 28 INVOLVE SEPARATION OF THE JOINT ON THE PASSENGER (RIGHT) SIDE, WHICH IS THE SIDE THAT MUST BE DISASSEMBLED FOR PTU SERVICE.TWENTY-THREE OF THESE WERE FOUND TO HAVE BEEN PREVIOUSLY DISASSEMBLED FOR CONTROL ARM BUSHING SERVICE, PTU SERVICE OR OTHER TRANSMISSION REPAIR. THE EIGHT CLAIMS THAT DID NOT INVOLVE PRIOR SERVICE REPAIRS REQUIRING JOINT DISASSEMBLY ALL OCCURRED VERY EARLY IN VEHICLE LIFE, INDICATING THAT IT IS UNLIKELY THAT ANY JOINTS MANUFACTURED WITH LOOSE PINCH BOLTS ARE STILL IN SERVICE.ALL OF THESE JOINTS FAILED WITHIN 6 MONTHS IN SERVICE AND 10,000 MILES (THE MAXIMUM FAILURE MILEAGE IS 8,097 MILES).THERE HAVEN'T BEEN ANY SUCH FAILURES (I.E., NOT INVOLVING PRIOR SERVICE/DISASSEMBLY) SINCE DECEMBER 2008.THE RATE FOR INCIDENTS THAT DID NOT OCCUR FOLLOWING SERVICE AND, THUS, MAY BE RELATED TO THE MANUFACTURING PROCESS ISSUES IDENTIFIED BY FORD IS VERY LOW (2.5 PER 100,000 VEHICLES) AND THESE INCIDENTS OCCURRED VERY EARLY IN THE LIFE OF THE VEHICLES AND ARE NOT SHOWING A CONTINUING FAILURE TREND.ACCORDINGLY, THIS INVESTIGATION HAS BEEN CLOSED. THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST. THE AGENCY WILL CONTINUE TO MONITOR COMPLAINTS AND OTHER INFORMATION RELATING TO THE ALLEGED DEFECT IN THE SUBJECT VEHICLES AND TAKE FURTHER ACTION IN THE FUTURE IF WARRANTED.
PE08060 · Tire Valve Cracking
Opened Oct 14, 2008 · Closed Apr 9, 2009
Status: closed (inferred from source dates) · Tires:valve
ON OCTOBER 14, 2008, ODI OPENED PE08-060 TO INVESTIGATE ALLEGATIONS OF CRACKED AND LEAKING SNAP-IN TIRE VALVES IN MODEL YEAR (MY) 2007 VEHICLES MANUFACTURED BY FORD MOTOR COMPANY.THE VALVES WERE SUPPLIED TO FORD BY TOPSEAL AUTO-PARTS, A SUBSIDIARY OF THE SHANGHAI BAOLONG AUTOMOTIVE CORPORATION IN CHINA.VALVES MADE BY TOPSEAL FOR AFTERMARKET SALE WERE THE SUBJECT OF TWO RECENT SAFETY RECALLS BY TECH INTERNATIONAL (08T-018) AND DILL AIR CONTROLS (08T-028), THE LATTER OF WHICH WAS INVESTIGATED BY ODI IN PE08-036 AND EA08-022.THE DEFECT CONDITIONS ADDRESSED BY THE AFTERMARKET TIRE VALVE RECALLS BOTH INVOLVED INADEQUATE RESISTANCE TO OZONE CRACKING DUE TO ISSUES WITH THE SUPPLY OF ANTI-OZONANT CHEMICALS TO TOPSEAL FOR A PERIOD FROM JULY TO MID-NOVEMBER 2006.THE AFTERMARKET VALVES WERE COMPOUNDED WITH A BLEND OF EPDM AND NATURAL RUBBER, USING A RELATIVELY LOW PERCENTAGE OF EPDM (EPDM PROVIDES INHERENT RESISTANCE TO OZONE CRACKING).HENCE, THE NEED FOR ANTI-OZONANT CHEMICALS AND THE PROBLEMS WITH CRACKING WHEN THOSE CHEMICALS WERE MISSING OR OUT OF SPECIFICATION IN SOME LOTS OF VALVES.BOTH RECALL CAMPAIGNS INVOLVED INSPECTION PROGRAMS TO IDENTIFY AND REPLACE VALVES WITH VISIBLE SURFACE CRACKING.ALTHOUGH THE TOPSEAL VALVES SUPPLIED TO FORD ALSO APPEAR TO HAVE BEEN AFFECTED BY THE ANTI-OZONANT SUPPLY ISSUES IN MID TO LATE-2006, FORD INDICATED THAT ITS VALVES WERE MADE AT A DIFFERENT TOPSEAL PRODUCTION LINE AND WERE COMPOUNDED WITH A HIGHER PERCENTAGE OF EPDM RUBBER TO MEET MORE STRINGENT SPECIFICATIONS FROM FORD.ODI'S ANALYSIS OF COMPLAINT AND WARRANTY DATA PROVIDED BY FORD SHOWED THAT PROBLEMS WITH CRACKED TIRE VALVES WERE SIGNIFICANTLY HIGHER FOR MY 2007 VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007.FORD RESPONDED BY IMPLEMENTING CHANGES IN ITS MATERIAL SPECIFICATIONS FOR SNAP-IN RUBBER TIRE VALVES AND ALSO INCREASING THE QUALITY AND ACCEPTANCE STANDARDS FOR VALVES IMPORTED FOR USE IN ITS VEHICLES.WHILE THE COMPLAINT AND WARRANTY CLAIM RATES ARE ELEVATED FOR SUBJECT VEHICLES PRODUCED FROM DECEMBER 2006 THROUGH MARCH 2007, THE RATES OF LEAKING VALVES ARE WELL BELOW ONE PERCENT OF PRODUCTION FOR EACH OF THE PEAK MONTHS FOR ALL OF THE AFFECTED MODELS.A SUBSTANTIAL MAJORITY OF THE SUBJECT VEHICLES ARE EQUIPPED WITH TIRE PRESSURE MONITORING SYSTEMS (TPMS) WHICH WARN THE DRIVER WHEN ANY TIRE PRESSURES DROPS BELOW 25 PERCENT OF RECOMMENDED INFLATION PRESSURE. AS OUTLINED IN A LETTER TO ODI DATED APRIL 6, 2009, FORD HAS AGREED TO SEND LETTERS TO OWNERS OF CERTAIN MY 2007 AND 2008 FORD, LINCOLN AND MERCURY VEHICLES TO PROVIDE INFORMATION ABOUT THE CRACKING CONCERN. LETTERS WILL BE SENT TO OWNERS OF VEHICLES BUILT FROM NOVEMBER 2006 THROUGH MAY 2007.OWNERS CAN OPT FOR A FREE DEALER INSPECTION.VALVES EXHIBITING SURFACE CRACKS OR AIR LEAKAGE RELATED TO OZONE ATTACK WILL BE REPLACED BY FORD UNDER ITS NORMAL WARRANTY TERMS.FORD EXPECTS TO SEND THE LETTER BY APPROXIMATELY MID-MAY 2009. BASED ON THE USE OF TPMS IN THE MAJORITY OF SUBJECT VEHICLES AND THE RELATIVELY LOW RATES OF REPAIRS ASSOCIATED WITH LEAKING VALVES AND RESULTANT TIRE DAMAGE, ODI BELIEVES THAT THE ACTIONS FORD HAS AGREED TO TAKE WILL PROVIDE EFFECTIVE AND EXPEDITIOUS RESOLUTION FOR VEHICLES THAT WERE BUILT DURING THE PERIOD WHEN VALVES WITH INADEQUATE RESISTANCE TO OZONE CRACKING WERE MOST LIKELY TO HAVE BEEN USED IN VEHICLE PRODUCTION.FURTHER INVESTIGATION OF THIS MATTER WOULD NOT BE AN EFFICIENT ALLOCATION OF AGENCY RESOURCES.ACCORDINGLY, THIS INVESTIGATION IS CLOSED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL CONTINUE TO
Illustration