Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 4 of 4 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Electrical System. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Fuel System, Diesel. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
4 reports
23,000 miles · May 1, 2015
Fuel/propulsion System
TL* THE CONTACT OWNS A 2005 FORD E-550. WHILE THE VEHICLE WAS AT THE DEALER FOR ROUTINE MAINTENANCE, THE FUEL TANK WAS DISCOVERED TO BE CORRODED CAUSING THE FUEL PUMP TO FAIL. THE DEALER ADVISED THAT THE FUEL TANK AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILUR…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD E-550. WHILE THE VEHICLE WAS AT THE DEALER FOR ROUTINE MAINTENANCE, THE FUEL TANK WAS DISCOVERED TO BE CORRODED CAUSING THE FUEL PUMP TO FAIL. THE DEALER ADVISED THAT THE FUEL TANK AND THE FUEL PUMP NEEDED TO BE REPLACED. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE. THE FAILURE MILEAGE WAS 23,000.
NHTSA ODI #10714002
15,000 miles · Aug 2, 2010
Fuel System, Diesel
FORD 650 TRUCK, YEAR 2005, TOTAL MILES 15,000. PROBLEM; RUSTING FUEL TANK CLOGGING FILTERS AND FUEL INJECTORS. *TR
NHTSA ODI #10346787
1,500 miles · Dec 15, 2006
Electrical System
I PURCHASED MY 2005 FORD ESCAPE JANUARY 15, 2005. IN APRIL THAT SAME YEAR WAS THE FIRST TIME I ATTEMPTED TO START MY BRAND NEW TRUCK AND IT WOULD NOT START. THE VEHICLE WILL CRANK BUT THE ENGINE WILL NOT TURN OVER. THIS HAPPENS ABOUT EVERY 3-4 MONTHS. I HAVE TAKEN IT TO MY LOCAL DEALER REGARDING THIS PROBLEM ABOUT 4 OR 5 TIMES A…
Read full complaint
I PURCHASED MY 2005 FORD ESCAPE JANUARY 15, 2005. IN APRIL THAT SAME YEAR WAS THE FIRST TIME I ATTEMPTED TO START MY BRAND NEW TRUCK AND IT WOULD NOT START. THE VEHICLE WILL CRANK BUT THE ENGINE WILL NOT TURN OVER. THIS HAPPENS ABOUT EVERY 3-4 MONTHS. I HAVE TAKEN IT TO MY LOCAL DEALER REGARDING THIS PROBLEM ABOUT 4 OR 5 TIMES AND EACH TIE THEY TELL ME THEY CAN'T FIND ANY REASON THAT IT WOULD BE DOING THIS. THE LAST TWO TIMES IT HAPPENED I RECALL THAT IT HAD BEEN RAINING IN MY AREA SO I DON'T KNOW IF THAT IS A FACTOR OR NOT BUT THE LAST TIME IT HAPPENED WAS JUST BEFORE THANKSGIVING 2006. *NM
NHTSA ODI #10176201
36,000 miles · Oct 2, 2006
Engine And Engine Cooling
DT*: THE CONTACT STATED THE ENGINE CONTINUED TO STALL. THE DEALER REPLACED 4 FUEL INJECTORS, 2 OIL LINES, AND 2 OIL PUMPS. THE SERVICE DEALER WAS UNSURE HOW TO RECTIFY THE ISSUE. THE VEHICLE STALLED WHILE IN GEAR, WHETHER ACCELERATING OR NOT.
NHTSA ODI #10169799
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2005 Ford E-550 Problems, Complaints & Recalls | Skip That Year
Illustration