THIS VEHICLE IS A MOTORHOME, BUILD ON THE 2005 E450 CAB/CHASSIS WITH A GAS V10 ENGINE. WHILE DRIVING IN A SINGLE LANE CONSTRUCTION ZONE ON THE INTERSTATE THE ELECTRONIC THROTTLE BODY SYSTEM FAILED, AND THE ENGINE SUDDENLY STOPPED RESPONDING TO THE ACCELERATOR PEDAL. AS A RESULT THE VEHICLE SUDDENLY LOST POWER AND SLOWED TO A …
Read full complaint
THIS VEHICLE IS A MOTORHOME, BUILD ON THE 2005 E450 CAB/CHASSIS WITH A GAS V10 ENGINE. WHILE DRIVING IN A SINGLE LANE CONSTRUCTION ZONE ON THE INTERSTATE THE ELECTRONIC THROTTLE BODY SYSTEM FAILED, AND THE ENGINE SUDDENLY STOPPED RESPONDING TO THE ACCELERATOR PEDAL. AS A RESULT THE VEHICLE SUDDENLY LOST POWER AND SLOWED TO A VERY VERY LOW SPEED (A FEW INCHES PER SECOND). AS TRAFFIC APPROACHED AND BUILT UP BEHIND I INCHED THE VEHICLE ONTO THE SHOULDER. THE VEHICLE WAS UNABLE TO MOVE UNDER IT'S OWN POWER ANY FURTHER AND REQUIRED A TOW. IT WAS AN EXTREMELY DANGEROUS SITUATION ON A CROWDED HIGHWAY, IN A CONSTRUCTION ZONE, WITH MY FAMILY.
NHTSA ODI #11109624
Mileage unknown · Aug 4, 2014
EngineVehicle Speed Control
2005 FORD E-450. CONSUMER WRITES IN REGARDS TO THROTTLE BODY FAILURE. *SMD THE CONSUMER STATED THE THROTTLE BODY FAILED, WITHOUT WARNING AND THERE WAS NO ACCELERATION. ALSO, THE CHECK ENGINE LIGHT ILLUMINATED. THE THROTTLE BODY WAS REPLACED AT A COST OF $ 682.
NHTSA ODI #10618557
115,000 miles · Jan 23, 2013
Engine
TL* THE CONTACT OWNS A 2005 FORD E-450 VAN. THE CONTACT STATED THAT ANTI-FREEZE WAS LEAKING ONTO THE ENGINE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHERE HE WAS ADVISED THAT THE COOLANT HOSE WAS FRACTURED AT THE CONNECTION TO THE ENGINE AND CYLINDER HEADS. THE MECHANIC COULD NOT REPLACE THE HOSE DUE TO THE PART BEING …
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD E-450 VAN. THE CONTACT STATED THAT ANTI-FREEZE WAS LEAKING ONTO THE ENGINE. THE CONTACT TOOK THE VEHICLE TO A LOCAL MECHANIC WHERE HE WAS ADVISED THAT THE COOLANT HOSE WAS FRACTURED AT THE CONNECTION TO THE ENGINE AND CYLINDER HEADS. THE MECHANIC COULD NOT REPLACE THE HOSE DUE TO THE PART BEING ON BACK ORDER. THE MECHANIC HAD TO WELD THE HOSE TO STOP THE LEAK BUT THE REPAIR DID NOT REMEDY THE ISSUE. THE MANUFACTURER HAD NOT PRODUCED THE PART IN OVER A YEAR. THE FAILURE MILEAGE WAS 115,000.
VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
Consequence & remedy
Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Remedy: VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.
NEW YORK BUS SALES IS RECALLING 1 RICON WHEELCHAIR LIFT WHICH IT INSTALLED ON A FORD SCHOOL BUS, MODEL E450. THE VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: NEW YORK BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW YORK BUS SALES AT 1-315-687-3969.
NEW YORK BUS SALES IS RECALLING 1 RICON WHEELCHAIR LIFT WHICH IT INSTALLED ON A FORD SCHOOL BUS, MODEL E450. THE VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: NEW YORK BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW YORK BUS SALES AT 1-315-687-3969.
MOBILITYWORKS IS RECALLING 133 MY 2005-2006 FORD E250, MY 2000, 2004-2006 E350, MY 2000, 2005 E450, MY 2005-2006 GMC 2500, GMC 3500, AND MY 2006 DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy: MOBILITYWORKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITYWORKS AT 1-800-769-8267.
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN CUT-AWAY INCOMPLETE TRUCKS EQUIPPED WITH LT225/75R16E TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES.
Consequence & remedy
Consequence: AT THE INCORRECTLY STATED PRESSURE, THE REAR TIRES ARE UNABLE TO SUPPORT THE GROSS AXLE WEIGHT RATING (GAWR) FOR THE REAR AXLE.
Remedy: OWNERS AND DEALERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT REAR TIRE INFLATION INFORMATION. THE RECALL BEGAN ON JANUARY 11, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE09055 · Hvac Switch Failures
Opened Dec 7, 2009 · Closed Apr 21, 2010
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
ODI has received 1 complaint and reports from 4 transportation fleets alleging 182 switch failures.Each fleet operates mini buses built on a Ford E350 or E450 cutaway chassis.The OEM HVAC blower switches have melted, smoked, burned or experienced open flame and become inoperable on vehicles in each fleet.Some drivers have reported a burning smell or smoke coming from the dash.One fleet reported a vehicle fire.No injuries were sustained.However, the bus was carrying special needs children when the driver noticed smoke coming from the dash.The driver was able to evacuate the children prior to the vehicle becoming engulfed in flames.This PE has been upgraded to an Engineering Analysis (EA) to determine if the blower motor switch failures create a situation where a vehicle fire is possible and presents a safety risk to the driver and other passengers.
2005 Ford E-450 Problems, Complaints & Recalls | Skip That Year
Illustration