TL* THE CONTACT OWNS A 2005 FORD E-450. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING AND THE VEHICLE COULD NOT BE RESTARTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, WHO ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE V…
Read full complaint
TL* THE CONTACT OWNS A 2005 FORD E-450. THE CONTACT STATED THAT WHILE DRIVING 45 MPH, THE ENGINE STALLED WITHOUT WARNING AND THE VEHICLE COULD NOT BE RESTARTED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE, WHO ADVISED THE CONTACT THAT THE VEHICLE WAS NOT INCLUDED IN NHTSA CAMPAIGN ID NUMBER: 05V270000 (ELECTRICAL SYSTEM). THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 56, 831.
NHTSA ODI #10503708
Mileage unknown · Apr 12, 2011
Electrical SystemFire
2005 FORD CUTAWAY E450. INSURANCE COMPANY SENT CORRESPONDENCE ON BEHALF OF CONSUMER RELATED TO A FIRE AND TOTAL LOSS OF VEHICLE *TGW THE CONSUMER STATED THE RUNNING LIGHTS AND THE CARGO LIGHTS WERE COMING ON AND GOING OFF FOR NO REASON. HE STATED AT TIMES, THERE WAS AN ODOR COMING FROM THE VEHICLE. THE DAY OF THE FIRE, THE CON…
Read full complaint
2005 FORD CUTAWAY E450. INSURANCE COMPANY SENT CORRESPONDENCE ON BEHALF OF CONSUMER RELATED TO A FIRE AND TOTAL LOSS OF VEHICLE *TGW THE CONSUMER STATED THE RUNNING LIGHTS AND THE CARGO LIGHTS WERE COMING ON AND GOING OFF FOR NO REASON. HE STATED AT TIMES, THERE WAS AN ODOR COMING FROM THE VEHICLE. THE DAY OF THE FIRE, THE CONSUMER HAD DRIVEN THE VEHICLE FOR APPROXIMATELY TWO HOURS AND HAD BEEN SITTING FOR APPROXIMATELY TWO HOURS WHEN THE HORN STARTED BLOWING. THE CONSUMER THEN REALIZED THE VEHICLE WAS ON FIRE. ACCORDING TO THE INVESTIGATION REPORT, THE FIRE ORIGINATED IN THE DASH AREA OF THE PASSENGER COMPARTMENT. IT WAS ALSO THE OPINION OF THE FIRE INVESTIGATOR, THAT ELECTRICALLY GENERATED HEAT FROM A MALFUNCTION COULD NOT BE RULED OUT. *JB
NHTSA ODI #10396316
78,690 miles · May 20, 2009
Electrical System
I HAVE A 2005 FORD E450 CUTAWAY 6.0L DIESEL ENGINE AND IT WILL SHUTDOWN COMPLETELY DURING NORMAL DRIVING CONDITIONS. THIS CONDITION WAS DIAGNOSE BY A CERTIFIED MECHANIC AS A PROBLEM W/ FICM & PCM COMPUTERS BOTH WHERE REPLACED BY US. THE PROBLEM CONTINUES AND AFTER LONG HOURS OF RESEARCH FOUND RECALL CAMPAIGN (05V270000) CALL FO…
Read full complaint
I HAVE A 2005 FORD E450 CUTAWAY 6.0L DIESEL ENGINE AND IT WILL SHUTDOWN COMPLETELY DURING NORMAL DRIVING CONDITIONS. THIS CONDITION WAS DIAGNOSE BY A CERTIFIED MECHANIC AS A PROBLEM W/ FICM & PCM COMPUTERS BOTH WHERE REPLACED BY US. THE PROBLEM CONTINUES AND AFTER LONG HOURS OF RESEARCH FOUND RECALL CAMPAIGN (05V270000) CALL FORD AND THEY INFORMED ME THIS VEHICLE WAS NOT INCLUDED IN THE RECALL. THIS FAILURE OCCURS APROX. 15 MIN AFTER DRIVING AT NORMAL SPEEDS. WE HAVE EMPLOYEES WHO DRIVE THIS VEHICLE AND WERE CLOSE TO HAVE VERY SERIOUS CONSEQUENCES THAT CAN CAUSE MAJOR INJURIES TO THE PUBLIC AND OUR EMPLOYEES. *TR
NHTSA ODI #10269483
75,011 miles · Feb 27, 2008
Electrical SystemFire
FIRE IGNITED AT ENGINE COMPARTMENT WIRING HARNESS TO ALTERNATOR RESULTING IN REPLACEMENT OF ALTERNATOR, ALTERNATOR WIRING HARNESS, RIGHT GLOW PLUG WIRING HARNESS, ENGINE COMPARTMENT WIRING HARNESS AND FIRE DAMAGED HOSES AND BELTS. *TR
NHTSA ODI #10219326
1,997 miles · Dec 30, 2006
Electrical System
I BOUGHT A NEW 2005 WINNEBAGO MOTOR HOME ON A FORD E-SERIES CHASSIS AND THE BATTERY GOES TOTALLY DEAD AFTER SITTING FOR TWO OR THREE WEEKS. THE DEALER AND FORD TELLS ME THIS IS NORMAL, YET I HAVE HAD 5 OTHER MOTOR HOMES ON FORD CHASSIS AND LEFT THEM OUT ALL WINTER AND THE BATTERIES WERE STILL CHARGED IN THE SPRING. THIS PROBLE…
Read full complaint
I BOUGHT A NEW 2005 WINNEBAGO MOTOR HOME ON A FORD E-SERIES CHASSIS AND THE BATTERY GOES TOTALLY DEAD AFTER SITTING FOR TWO OR THREE WEEKS. THE DEALER AND FORD TELLS ME THIS IS NORMAL, YET I HAVE HAD 5 OTHER MOTOR HOMES ON FORD CHASSIS AND LEFT THEM OUT ALL WINTER AND THE BATTERIES WERE STILL CHARGED IN THE SPRING. THIS PROBLEM STILL EXISTS AND NO WHERE IN THE FORD LITERATURE OR WINNEBAGO LITERATURE DOES IT MENTION THIS. A MOTORHOME IS NOT A VEHICLE THAT YOU DRIVE EVERY DAY AND THIS COULD END UP LEAVING YOU STRANDED IN THE MOUNTAINS. THIS HAS HAPPENED NUMEROUS TIMES. *NM
VCI Emergency Vehicle Specialists (VCI) is recalling certain 2017-2018 Ford F-550, 2014 E-350 and E-450, 2015 F-250 and F-450, 2016 E-450, 2017 E-350, F-450 and E-450, 2018 F-350, 2010 E-450, 2005-2006 E-450, 2009 E-450 and Chevrolet C4500-based Type I and Type III ambulances equipped with ASA Electronics Voyager monitors used to display the back-up camera image. The monitors may unexpectedly revert back to the factory default settings which may cause the camera image to be reversed.
Consequence & remedy
Consequence: The driver may inadvertently turn the wrong direction to avoid an object behind the vehicle, increasing the risk of a crash.
Remedy: VCI Emergency Vehicle Specialists will work with ASA to notify the owners, and remedy the displays, free of charge. The recall began May 9, 2019. Owners may contact ASA Electronics at 1-800-384-4400.
NEW YORK BUS SALES IS RECALLING 1 RICON WHEELCHAIR LIFT WHICH IT INSTALLED ON A FORD SCHOOL BUS, MODEL E450. THE VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: NEW YORK BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW YORK BUS SALES AT 1-315-687-3969.
NEW YORK BUS SALES IS RECALLING 1 RICON WHEELCHAIR LIFT WHICH IT INSTALLED ON A FORD SCHOOL BUS, MODEL E450. THE VEHICLE FAILS TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 404, "PLATFORM LIFT INSTALLATIONS IN MOTOR VEHICLES." THE THRESHOLD WARNING SYSTEM MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER IN A CERTAIN SPOT WITHIN THE DEFINED THRESHOLD AREA.
Consequence & remedy
Consequence: THE USER OF THE LIFT COULD BE INJURED SHOULD THE LIFT MOVE UNINTENTIONALLY.
Remedy: NEW YORK BUS SALES IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E095). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR NEW YORK BUS SALES AT 1-315-687-3969.
MOBILITYWORKS IS RECALLING 133 MY 2005-2006 FORD E250, MY 2000, 2004-2006 E350, MY 2000, 2005 E450, MY 2005-2006 GMC 2500, GMC 3500, AND MY 2006 DODGE 2500 VANS EQUIPPED WITH RICON PLATFORM STYLE WHEELCHAIR LIFTS. THESE LIFTS FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 403, "PLATFORM LIFT SYSTEMS FOR MOTOR VEHICLES." THE ANTI-STOW INTERLOCK MAY NOT DETECT THE PRESENCE OF A WHEELCHAIR OR MOBILITY AID USER. THE PRESSURE SENSING SWITCH THAT DETECTS THE PRESENCE OF WEIGHT ON THE PLATFORM WAS NOT ADJUSTED TO THE NECESSARY SENSITIVITY LEVEL. THE LIFT COULD STOW EVEN THOUGH SOMEONE OR SOMETHING IS STILL ON THE LIFT.
Consequence & remedy
Consequence: A LIFT OCCUPANT CAN BE INJURED SHOULD THE LIFT BEGIN TO STOW UNINTENTIONALLY.
Remedy: MOBILITYWORKS IS WORKING WITH RICON TO CORRECT THE WHEELCHAIR LIFTS FREE OF CHARGE (PLEASE SEE 07E097). OWNERS MAY CONTACT RICON AT 1-818-267-3000 OR MOBILITYWORKS AT 1-800-769-8267.
CERTAIN PICKUP TRUCKS, SPORT UTILITY VEHICLES AND VANS EQUIPPED WITH 6.0L DIESEL ENGINES MAY EXPERIENCE STALLING WITHOUT WARNING WHILE DRIVING AND MAY OR MAY NOT RESTART.
Consequence & remedy
Consequence: SHOULD THE ENGINE STALL, A VEHICLE CRASH COULD OCCUR.
Remedy: DEALERS WILL UPGRADE THE FUEL INJECTION CONTROL MODULE (FICM) WIRE HARNESS OR REPLACED, AND/OR HAVE A NEW INJECTION CONTROL PRESSURE (ICP)) SENSOR CONNECTOR INSTALLED FREE OF CHARGE. THE RECALL BEGAN ON JULY 22, 2005. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
CERTAIN CUT-AWAY INCOMPLETE TRUCKS EQUIPPED WITH LT225/75R16E TIRES FAIL TO COMPLY WITH THE REQUIREMENTS OF FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 120, 'TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS.' THE TIRE PRESSURE IS INCORRECTLY LISTED ON THE LABEL FOR THE REAR TIRES.
Consequence & remedy
Consequence: AT THE INCORRECTLY STATED PRESSURE, THE REAR TIRES ARE UNABLE TO SUPPORT THE GROSS AXLE WEIGHT RATING (GAWR) FOR THE REAR AXLE.
Remedy: OWNERS AND DEALERS WILL BE MAILED SUPPLEMENTARY TIRE LABELS CONTAINING THE CORRECT REAR TIRE INFLATION INFORMATION. THE RECALL BEGAN ON JANUARY 11, 2005. OWNERS SHOULD CONTACT FORD AT 1-800-392-3673.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE09055 · Hvac Switch Failures
Opened Dec 7, 2009 · Closed Apr 21, 2010
Status: closed (inferred from source dates) · Electrical System:wiring:interior/under Dash
ODI has received 1 complaint and reports from 4 transportation fleets alleging 182 switch failures.Each fleet operates mini buses built on a Ford E350 or E450 cutaway chassis.The OEM HVAC blower switches have melted, smoked, burned or experienced open flame and become inoperable on vehicles in each fleet.Some drivers have reported a burning smell or smoke coming from the dash.One fleet reported a vehicle fire.No injuries were sustained.However, the bus was carrying special needs children when the driver noticed smoke coming from the dash.The driver was able to evacuate the children prior to the vehicle becoming engulfed in flames.This PE has been upgraded to an Engineering Analysis (EA) to determine if the blower motor switch failures create a situation where a vehicle fire is possible and presents a safety risk to the driver and other passengers.
2005 Ford E-450 Problems, Complaints & Recalls | Skip That Year
Illustration