NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
16 reports160,000 miles · Aug 21, 2023
Power Train
The contact owns a 2012 Ford E-350. The contact stated while driving approximately 10 MPH, after a traffic stop, the transmission was slipping out of gear and would shift to a higher gear very rough. The contact stated no warning light was illuminated. The vehicle was driven back to the residence and turned off and restarted and…
Read full complaint
The contact owns a 2012 Ford E-350. The contact stated while driving approximately 10 MPH, after a traffic stop, the transmission was slipping out of gear and would shift to a higher gear very rough. The contact stated no warning light was illuminated. The vehicle was driven back to the residence and turned off and restarted and shifted into reverse(R) however, the vehicle failed to respond. The vehicle was shifted into (D) and operated as needed. The contact had not taken the vehicle to a local dealer or independent mechanic. The vehicle had not been diagnosed and had not been repaired. The contact researched online and related the failure to Customer Satisfaction Program: 19S20 - Transmission Coast Clutch Cylinder and One-Way Clutch Replacement (Power Train). The manufacturer had been informed of the failure. The failure mileage was approximately 160,000.
NHTSA ODI #11539911
113,940 miles · Feb 13, 2020
Engine
TL* THE CONTACT CALLED ON BEHALF OF HER BROTHER WHO OWNS A 2012 FORD E-350. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN FOR A ROUTINE CHECK AT (SAYVILLE FORD 5686 SUNRISE HWY, SAYVILLE, NY 11782 (855) 561-1191), IT WAS DISCOVERED AND THE VALVE COVER GASKET WAS DEFECTIVE AND NEEDED TO BE REPLACED. THERE WAS HOWEVER NO LEAKS …
Read full complaint
TL* THE CONTACT CALLED ON BEHALF OF HER BROTHER WHO OWNS A 2012 FORD E-350. THE CONTACT STATED THAT WHILE THE VEHICLE WAS IN FOR A ROUTINE CHECK AT (SAYVILLE FORD 5686 SUNRISE HWY, SAYVILLE, NY 11782 (855) 561-1191), IT WAS DISCOVERED AND THE VALVE COVER GASKET WAS DEFECTIVE AND NEEDED TO BE REPLACED. THERE WAS HOWEVER NO LEAKS EVIDENT WHILE PERFORMING THE INSPECTION. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 113,940.
NHTSA ODI #11308992
111,000 miles · Aug 9, 2019
Power Train
TL* THE CONTACT OWNS A 2012 FORD E-350. WHILE DRIVING 60 MPH, THE CONTACT EXPERIENCED A SUDDEN LOSS OF POWER AND THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER TO THE HIGHWAY SHOULDER AND WAITED A FEW MINUTES TO RESTART THE VEHICLE. UPON RESTARTING THE VEHICLE, THE FAILURE RECURRED. THE CONTACT WAS ABL…
Read full complaint
TL* THE CONTACT OWNS A 2012 FORD E-350. WHILE DRIVING 60 MPH, THE CONTACT EXPERIENCED A SUDDEN LOSS OF POWER AND THE VEHICLE SHUT OFF WITHOUT WARNING. THE CONTACT PULLED THE VEHICLE OVER TO THE HIGHWAY SHOULDER AND WAITED A FEW MINUTES TO RESTART THE VEHICLE. UPON RESTARTING THE VEHICLE, THE FAILURE RECURRED. THE CONTACT WAS ABLE TO DRIVE THE VEHICLE TO AN INDEPENDENT MECHANIC WHO DIAGNOSED THAT THE TRANSMISSION FAILED. THE CONTACT STATED THAT NHTSA CAMPAIGN NUMBER: 19V432000 (POWER TRAIN) WAS ISSUED FOR THE VEHICLE YEAR, MAKE, AND MODEL; HOWEVER, THE CONTACT'S VIN WAS NOT INCLUDED. THE CONTACT CALLED GALPIN FORD (15505 ROSCOE BLVD, NORTH HILLS, CA 91343, 818-787-3800) AND WAS INFORMED TO CALL THE MANUFACTURER. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND STATED THAT THE VEHICLE WAS NOT INCLUDED IN THE RECALL. THE VEHICLE WAS NOT REPAIRED. THE FAILURE MILEAGE WAS 111,000.
NHTSA ODI #11242788
285,000 miles · Sep 15, 2018
Unknown Or OtherFire
DRIVING DOWN THE ROAD, STARTED SMELLING GAS, SO I PULLED OVER THE CHECK WHY I SMELLED GAS AND AS SOON ASI OPENS THE HOOD, THE VAN BURST INTO FLAMES FROM UNDER THE HOOD. IT FULLY ENGULFED THE VAN IN ABOUT 3 TO 4 MINUTES AND IS A TOTAL LOSS. THIS HAPPENED ON THE HIGHWAY AND HAD ONLY BEEN DRIVING FOR 15 MINUTES. UNKNOWN WHAT ACTUAL…
Read full complaint
DRIVING DOWN THE ROAD, STARTED SMELLING GAS, SO I PULLED OVER THE CHECK WHY I SMELLED GAS AND AS SOON ASI OPENS THE HOOD, THE VAN BURST INTO FLAMES FROM UNDER THE HOOD. IT FULLY ENGULFED THE VAN IN ABOUT 3 TO 4 MINUTES AND IS A TOTAL LOSS. THIS HAPPENED ON THE HIGHWAY AND HAD ONLY BEEN DRIVING FOR 15 MINUTES. UNKNOWN WHAT ACTUALLY CAUSED THE FIRE.
NHTSA ODI #11129699
15,000 miles · Sep 6, 2018
Wheels
THREE OUT OF THE FOUR ORIGINAL TIRES HAVE SEPARATED. THE VEHICLE HAS LESS THAN 20,000 MILES. ALL TIRES HAVE BEEN MAINTAINED AND INFLATED ACCORDING TO MANUFACTURER SPECS.
NHTSA ODI #11127975
102,000 miles · Sep 20, 2017
Power Train
THE PLANETARY GEARS IN OUR TRANSMISSION HAVE FAILED. I DISCOVERED THAT THERE WAS A FORD RECALL SPECIFICALLY FOR VANS THAT WERE MANUFACTURED IN OHIO PLANT DURING 2011 AND 2012 BECAUSE OF DEFECTS IN THE PLANETARY GEARS WHICH CAUSE HAZARDOUS CONDITIONS. OUR VIN NUMBER IS NOT INCLUDED IN THE CASE, BUT IT CLEARLY SHOULD HAVE BEEN. W…
Read full complaint
THE PLANETARY GEARS IN OUR TRANSMISSION HAVE FAILED. I DISCOVERED THAT THERE WAS A FORD RECALL SPECIFICALLY FOR VANS THAT WERE MANUFACTURED IN OHIO PLANT DURING 2011 AND 2012 BECAUSE OF DEFECTS IN THE PLANETARY GEARS WHICH CAUSE HAZARDOUS CONDITIONS. OUR VIN NUMBER IS NOT INCLUDED IN THE CASE, BUT IT CLEARLY SHOULD HAVE BEEN. WE ARE SEEKING HELP TO GET FORD TO EXTEND THE RECALL TO INCLUDE OUR VAN.
NHTSA ODI #11024577
136,000 miles · Feb 22, 2017
Exterior Lighting
SUDDEN LOSS OF HIGH BEAM HEADLIGHTS WITHOUT ANY WARNINGS ..FIRST OCCURRED WHILE MOVING ,,,HIGH BEAMS HAVE PERMANENTLY STOPPED WORKING SINCE THE INCIDENT.
NHTSA ODI #10956287
63,586 miles · Mar 23, 2016
Vehicle Speed Control
TL* THE CONTACT RENTED A 2012 FORD E-350 UHAL TRUCK. THE CONTACT STATED THAT THE VEHICLE WOULD NOT ACCELERATE OVER 40 MPH. THE CONTACT WAS TRAVELING ON THE INTERSTATE DURING HIGH WINDS WHEN THE FAILURE OCCURRED. THE VEHICLE WAS NOT DIAGNOSED NOR REPAIRED. THE FAILURE MILEAGE WAS 63,586.
NHTSA ODI #10851279
97,500 miles · May 15, 2015
EngineService BrakesSteering
WHILE MAKING A 40MPH TURN AT NIGHT THE ENGINE DIED. LOST STEERING AND BRAKE BOOST. ALMOST LOST THE VEHICLE BEFORE COMPLETING A STOP. TRIED FOR FIVE MINUTES TO RESTART. DIAGNOSED AS A BAD FUEL PUMP AND REPLACED. SITUATION RE-OCCURED AND THE VEHICLE REMAINS AT THE FORD DEALER.
NHTSA ODI #10716624
46,000 miles · Feb 13, 2015
EngineFuel/propulsion System
TL* THE CONTACT OWNS A 2012 FORD E-350. WHILE DRIVING 35 MPH, THE VEHICLE BEGAN TO MAKE AN ABNORMAL NOISE COMING FROM THE ENGINE. THE FAILURE RECURRED SEVERAL TIMES. THE DEALER STATED THAT THE FUEL WAS BAD. THE VEHICLE WAS NOT REPAIRED AND THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS 46,000.
NHTSA ODI #10683347
Official recalls
11May 24, 2016
New England Wheels (New England) is recalling certain model year 2006-2014 Ford E-250, E-350, and 2015 Ford Transit vans equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts by Ricon. The platform side plate of the affected wheelchair lifts may crack. Additionally, the lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the platform side plates crack or the platform mounting fails from out-of-position bearings, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the vehicle's doors are opened, the platform may fall onto the lift operator, increasing their risk of injury.
Remedy: New England will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on June 29, 2016. Owners may contact New England customer service at 1-800-886-9247. New England's number for this recall is 16E-020.
Nov 20, 2015
New England Wheels is recalling certain model year 2006-2014 Ford E-250, and E-350 cargo vans modified to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts built by the Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy: New England Wheels will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on January 5, 2016. Owners may contact New England Wheels customer service at 1-800-866-9247, or Ricon Customer Service at 1-800-322-2884. New England Wheels' number for this recall is 15E-068. Note: These vans and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
Nov 17, 2015
Mobility Specialists, Inc. (Mobility Specialists) is recalling certain model year 2006-2014 Ford E-250, and E-350 vehicles modified to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack. Additionally, the affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator. Additionally, if the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy: Mobility Specialists will notify owners to take their vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 13, 2015. Owners may contact Mobility Specialists customer service at 1-877-777-5438, or Ricon customer service at 1-800-322-2884.
Nov 4, 2015
MobilityWorks (WMK Inc.) is recalling certain model year 2006-2014 Ford E-150, E-250, and E-350 vans modified by MobilityWorks to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The affected lifts are equipped with folding link arms that may have pivot holes that are too big, allowing the bearings to move out of position.
Consequence & remedy
Consequence: If the bearings move out of position, the stowed platform may have excessive movement resulting in failure of the platform mounting. This failure could cause the wheel chair lift platform to fall out of the vehicle when the doors are opened, increasing the risk of injury for the lift operator.
Remedy: MobilityWorks will notify owners, and Ricon dealers will inspect the link arms for damage or for displaced bearings. The platform will be inspected for cracks. Any damaged parts will be replaced, free of charge. The recall began on December 15, 2015. Owners may contact MobilityWorks customer service at 1-800-769-8267, or Ricon Customer Service at 1-800-322-2884. Note: These vehicles and wheelchair lifts were subject to a similar recall in 2014. All vehicles that received that recall remedy are still affected by this recall as well.
Nov 5, 2014
Cummings Mobility Conversion & Supply (Cummings) is recalling certain model year 2006-2014 Ford E-150, E-250, E-350, Chevrolet Express, 2006-2008 Dodge Sprinter, and 2009-2014 Mercedes-Benz Sprinter, and 2013 Ford Transit Connect vehicles manufactured January 1, 2006, to October 8, 2014, equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation after January 1, 2006. The platform side plate of the affected wheelchair lifts may crack.
Consequence & remedy
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Cummings will notify owners to take buses to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began January 13, 2015. Owners may contact Cumming's customer service at 1-800-639-5438 or Ricon customer service at 1-800-322-2884. Cumming's number for this recall is 14E-041.
Oct 3, 2014
New England Wheels (New England) is recalling certain model year 2006-2014 E-250, and E-350 vehicles modified by New England to be equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence & remedy
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: New England will notify owners to take vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on November 17, 2014. Owners may contact New England customer service at 1-800-886-9247 or Ricon customer service at 1-800-322-2884. New England's number for this recall is 14E-041.
Sep 24, 2014
Elkhart Coach (Elkhart) is recalling certain model year 2006-2014 Ford E-350 and Ford E-450 vehicles manufactured January 1, 2006, to May 1, 2014 and equipped with certain model S2005, S2010, S5005, S5010, S5505, and S5510 wheelchair lifts manufactured by Ricon Corporation. The platform side plate of the affected wheelchair lifts may crack.
Consequence & remedy
Consequence: If the platform side plates crack, the lift platform can separate from the lift and come to rest against the vehicle's lift door. When the doors are opened, the platform may fall out, increasing the risk of injury to the lift operator.
Remedy: Elkhart will notify owners to take the vehicles to a Ricon dealer or service center who will install supplemental platform support bumpers. Any platform that has already started cracking will be replaced, free of charge. The recall began on October 1, 2014. Owners may contact Ricon customer service at 1-800-322-2884. Owners may also contact Elkhart customer service at 1-574-264-5179. This recall has been superseded by campaign 15V-768.
Aug 6, 2014
Adrian Steel Company (Adrian) is recalling certain model year 2012 Ford E-150, E-250 and E-350 Commercial Cargo Vans modified by Adrian between September 21, 2012, to September 24, 2012. The affected vehicles are equipped with certain propane fuel system conversion kits with an aluminum fuel line fitting manufactured by Roush CleanTech. Due to a reaction between the different metals, the affected kits may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.
Consequence & remedy
Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.
Remedy: Adrian will notify owners, and dealers will replace the aluminum fuel line fittings with stainless steel fittings, free of charge. The recall began during July 2014. Owners may contact Adrian customer service at 1-800-677-2726.
Jul 10, 2014
Roush Performance Products, Inc. (Roush) is recalling certain model year 2010-2012 Ford E-150 Wagons and Cargo Vans, E-250 Cargo Vans and Extended Cargo Vans, E-350 Wagons, Extended Wagons, Cargo Vans, and Extended Vans, and E-450 Cutaway models. These models were modified by Roush to be equipped with certain propane fuel system conversion kits manufactured January 2011 to August 2012 with an aluminum fuel line fitting. Due to a reaction between the different metals, the affected kits may develop a propane leak where the aluminum fuel line fitting contacts the brass supply valve housing.
Consequence & remedy
Consequence: A propane leak in the presence of an ignition source increases the risk of a fire.
Remedy: Roush will notify owners and will replace the aluminum fuel line fittings with new stainless steel fittings, free of charge. The recall began on September 1, 2014. Owners may contact Roush customer service at 1-800-597-6874.
Mar 4, 2014
Landi Renzo USA is recalling certain model year 2011-2014 Ford E-150, E-250, and E-350 vehicles modified January 2, 2011, through February 24, 2014 to operate on compressed natural gas (CNG). In the affected vehicles, the left and right rear brackets that support the rear CNG cylinder may fail, allowing the cylinder to dislodge from the vehicle.
Consequence & remedy
Consequence: If the cylinder dislodges, a CNG leak may result, increasing the risk of a fire.
Remedy: Landi Renzo USA will notify owners, and dealers will inspect and replace the side arm brackets, as necessary, free of charge. The recall began on March 27, 2014. Owners may contact Landi Renzo USA at 1-855-526-3400.
Jun 21, 2013
Mobility Works is recalling certain model year 2006-2012 Ford E-150, E-250 and E-350 vehicles manufactured August 2006 through August 2012. The vehicles are equipped with certain Ricon S series and K Series wheelchair lifts with an optional armored pendant cable. The armored cable may be positioned such that it does not clear the wheelchair lift.
Consequence & remedy
Consequence: If the cable does not clear the wheel chair lift it may contact the power lug and, if it does not have a nonconductive cover, or it has an improperly installed non-conductive cover, a short circuit may occur that could result in a fire.
Remedy: Mobility Works will notify owners and Ricon will provide a supplemental cover kit and instructions, free of charge. This recall campaign is expected to begin July 15, 2013. Owners may contact Mobility Works at 1-877-275-4912 and Ricon at 1-818-267-3000.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration