ACTUALLY THE COMPLAINT IS IN REGARD TO A NEAR MISS CONDITION WHILE DRIVIING MY 1994 DAMON ULTRASPORT (FORD E350) MOTOR HOME. WHILE REURNING FROM VACATION I NOTICED THAT THE STEERING ON THE FRONT OF MY MOTORHOME WAS LOOSE AND AS I WAS PASSED BY A TRACTOR TRAILER RIG IN IOWA ON INTERSTATE 80 THE WIND TURBULANCE CAUSED MY VEHICLE S…
Read full complaint
ACTUALLY THE COMPLAINT IS IN REGARD TO A NEAR MISS CONDITION WHILE DRIVIING MY 1994 DAMON ULTRASPORT (FORD E350) MOTOR HOME. WHILE REURNING FROM VACATION I NOTICED THAT THE STEERING ON THE FRONT OF MY MOTORHOME WAS LOOSE AND AS I WAS PASSED BY A TRACTOR TRAILER RIG IN IOWA ON INTERSTATE 80 THE WIND TURBULANCE CAUSED MY VEHICLE STEERING TO BE VERY ERRATIC. I TOOK THE VEHICLE IN FOR A SERVICE CALL AND EXPLAINED THE PROBLEM TO THE SERVICE MECHANIC AT MONTICELLO FORD. THEY INSPECTED THE VEHICHLE AND SAID THE TOP BALL JOINTS WERE WORN APPROXIMATELY AN 1/8". FORD SAID THE TOLERANCE IS 1/4' AND MY WARRANTY WILL NOT FIX THE PROBLEM. THE PROBLEM HAS BEEN DESCRIBED AS MEMORY STEERING BY THE MECHANIC. IN THE ABSENCE OF WARRANTY COVERAGE FOR AN $800 REPAIR, HE RECOMMENDED REPLACING THE THE STEERING DAMPENER TO SEE IF IT HELPS MITIGATE THE PROBLEM. IT SEEMED TO REDUCE THE PROBLEM BUT HAS NOT ELIMINATED IT. HE DOES NOT RECOMMEND A FRONT END ALIGNMENT WITH THE BALL JOINTS BEING SO LOOSE. HE ALSO MENTIONED HE DOES NOT UNDERSTAND WHY FORD SPECIFIES A 1/4" WHEN CHRYSLER SPECIFIES 1/16" WERE LIMITS ON THE BALL JOINTS. MY COMPLAINT IS THAT FORD HAS A SPECIFICATION THAT IS NOT REALISTIC AND PUTS THE LIVES OF THEIR VAN AND MOTORHOMES DRIVERS AND PASSENGERS AT RISK EPSPECIALLY ON FREEWAYS WHERE DRIVERS GO 70-75MPH IN SEMI RIGS CAUSING VEHICLES NEAR THEM TO BE IN JEPARDY IS THEIR STEERING IS AS LOOSE AS FORD ALLOWS.
NHTSA ODI #10000908
Mileage unknown · Jun 23, 1997
Suspension
WHEN THE VEHICLE IS IN MOTION THERE IS A LOUD NOISE COMING FROM THE REAR END OF THE VEHICLE; ALSO, THERE IS SOME VIBRATION IN THE REAR OF THE VEHICLE. VEHICLE IS AWAITING SERVICE. NEEDS TO REPLACE THE REAR END. *AK
NHTSA ODI #813366
Mileage unknown · Jul 26, 1996
SuspensionCrash
STEERING PULLED LEFT, CAUSING ACCIDENT. (NEW JERSEY STATE POLICE REPORT) *DH
NHTSA ODI #506678
Mileage unknown · May 17, 1996
SuspensionCrashInjury
VEHICLE SKID, BECAME UNCONTROLLABLE, CAUSING VEHICLE TO ROLL OVER IN ACCIDENT, CAUSING INJURIES. *DH
Cummings Mobility Conversion & Supply, Inc. (Cummings) is recalling various model year 1994-2011 Ford and Chevrolet vans equipped with Braun NCL-2, and NVL-2 wheel chair lifts manufactured November 20, 2006, through September 10, 2010. Over time, and with frequent use, the roll stop latches on the outer barrier of the lifts in these vans may become bent or misaligned.
Consequence & remedy
Consequence: A wheelchair occupant may defeat or ride over the insufficiently latched roll stop. If this occurs when the lift platform is in an elevated position, the wheelchair's occupant could fall and sustain injury.
Remedy: Braun Corporation notified all the vehicle owners, and Cummings Mobility replaced the recalled parts with new parts, free of charge. The recall was completed as of April 10, 2014. Owners may contact Cummings customer service at 1-800-639-5438.
FORD IS RECALLING MODEL YEARS 1995-2003 WINDSTAR, 2000-2003 EXCURSION DIESEL, 1993-1997 AND 1999-2003 F-250 SD THROUGH F-550 SD DIESEL, 1992-2003 E-150 THROUGH E-550, 1995-2002 EXPLORER, 1997 AND 2002 MERCURY MOUNTAINEER, 1995-1997 AND 2001-2003 RANGER, AND 1994 F53 VEHICLES EQUIPPED WITH THE TEXAS INSTRUMENTS SPEED CONTROL DEACTIVATION SWITCH (SCDS). THE SCDS MAY LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: A VEHICLE FIRE COULD OCCUR WITH OR WITHOUT THE ENGINE RUNNING.
Remedy: FORD WILL NOTIFY OWNERS THAT DEALERS WILL INSTALL A FUSED WIRING HARNESS IN LINE WITH THE SCDS. ON 1999-2003 WINDSTAR VEHICLES WITH A LEAKING SCDS, DEALERS WILL ALSO INSPECT THE ABS CONTROL MODULE CONNECTOR AND REPAIR AS NECESSARY. REPAIRS WILL BE COMPLETED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 27, 2009. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN TRUCKS EQUIPPED WITH SPEED CONTROL, GASOLINE OR NATURAL GAS ENGINES, THE SPEED CONTROL DEACTIVATION SWITCH MAY OVERHEAT.
Consequence & remedy
Consequence: OVERHEATING COULD RESULT IN SMOKE OR BURN AND AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS INTO THE SPEED CONTROL SYSTEM FREE OF CHARGE. THE RECALL BEGAN ON AUGUST 7, 2006. OWNERS MAY CONTACT FORD AT 1-866-436-7332. (NOTE: ALSO SEE RECALLS 05V017 AND 05V388)
THESE VEHICLES DO NOT COMPLY WITH FMVSS 105, "HYDRAULIC BRAKE SYSTEMS." THE PARKING BRAKE APPLICATION FORCE FOR A FOOT OPERATED CONTROL SYSTEM SHOULD NOT EXCEED 125 POUNDS TO HOLD THE VEHICLE ON A 30% GRADE. INTERFERENCE BETWEEN THE PARKING BRAKE PEDAL AND A WIRE HARNESS MAY INCREASE THE NEEDED PEDAL FORCE TO GREATER THAN 125 POUNDS TO SET THE PARKING BRAKE TO HOLD THE VEHICLE ON THE 30% GRADE.
Consequence & remedy
Consequence: THE INTERFERENCE BETWEEN THE FOOT PEDAL AND THE WIREHARNESS MAY NOT ALLOW THE PARKING BRAKE TO FULLY SET. IF THIS OCCURS WHEN THEVEHICLE IS PARKED ON AN INCLINE, IT MAY ROLL, CAUSING A CRASH.
Remedy: FINAL STAGE MANUFACTURERS WILL BE INFORMED OF THIS CONDITION AND PROVIDED WITH PARTS AND INSTRUCTIONS NECESSARY TO CORRECT THIS SITUATION.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
EA95012 · Failure Of Serpentine Belt
Opened Mar 31, 1995 · Closed May 28, 1996
Status: closed (inferred from source dates) · Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Additional source detail variants (2)
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
Power Train
AN ENGINEERING ANALYSIS CLOSING REPORT IS INCLUDED.
1994 Ford E-350 Problems, Complaints & Recalls | Skip That Year
Illustration