I BOUGHT A USED 1993 FORD CROWN VIC APPROXIMATELY 4 YEARS AGO, WHILE I EXPECTED I WOULD HAVE TO PUT MONEY INTO REPAIRS THE ONE THING I DIDN'T EXPECT WOULD BE HAVING TO REPAIR A SEAT MOUNTING BRACKET DUE TO POOR WORKMANSHIP & OR MATERIALS. AFTER LOOKING ON THE INTERNET AT VARIOUS SITES I FOUND THAT I'M NOT THE ONLY ONE THIS HAS H…
Read full complaint
I BOUGHT A USED 1993 FORD CROWN VIC APPROXIMATELY 4 YEARS AGO, WHILE I EXPECTED I WOULD HAVE TO PUT MONEY INTO REPAIRS THE ONE THING I DIDN'T EXPECT WOULD BE HAVING TO REPAIR A SEAT MOUNTING BRACKET DUE TO POOR WORKMANSHIP & OR MATERIALS. AFTER LOOKING ON THE INTERNET AT VARIOUS SITES I FOUND THAT I'M NOT THE ONLY ONE THIS HAS HAPPENED TO, MANY PEOPLE HAVE HAD THE SAME PROBLEM WITH THE SEAT FRAME SHEARING AWAY FROM THE BOLTS IN CROWN VICS.I TRIED CONTACTING BOTH THE LOCAL FORD DEALERSHIP & THE CORPORATE CONSUMER AFFAIRS DEPT WITH NO SATISFACTORY RESOLUTION TO THIS MATTER. THIS APPEARS TO BE A SERIOUS DEFECT FLAW IN CROWN VICS THAT NEEDS TO BE ADDRESSED AS IT CAN CAUSE SERIOUS INJURY IN AN ACCIDENT. I BELIEVE MERCURY GRAND MARQUIS ALSO NEED TO BE LOOKED AT ON THIS ISSUE AS I'VE SEEN SOME POSTS ON THE SAME PROBLEM WITH THAT MAKE & MODEL. *TR
NHTSA ODI #10534531
160,000 miles · May 4, 2008
Seats
DRIVERS SEAT LEANS BACK, POSSIBLE BROKEN FLOOR BOLT LIKE MENTIONED IN NHTSA ACTION NUMBER : PE98041 ON A 1993 FORD CROWN VIC, ALSO KNEW OF THE SAME PROBLEM WITH A 1992 CROWN VIC WHICH I NO LONGER OWN. DID THEY CHANGE THE SEAT BETWEEN 1993 AND 1198 MODELS? IF THEY DID NOT THEN THE RECALL SHOULD CERTAINLY INCLUDE OLDER MODEL …
Read full complaint
DRIVERS SEAT LEANS BACK, POSSIBLE BROKEN FLOOR BOLT LIKE MENTIONED IN NHTSA ACTION NUMBER : PE98041 ON A 1993 FORD CROWN VIC, ALSO KNEW OF THE SAME PROBLEM WITH A 1992 CROWN VIC WHICH I NO LONGER OWN. DID THEY CHANGE THE SEAT BETWEEN 1993 AND 1198 MODELS? IF THEY DID NOT THEN THE RECALL SHOULD CERTAINLY INCLUDE OLDER MODEL CROWN VICS. *TR
NHTSA ODI #10226581
Mileage unknown · May 13, 2003
Seats
I HAVE HAD TWO FORD CROWN VICS, A 1992 AND NOW A 1993. IN BOTH VEHICLES THE DRIVER'S SIDE SEAT FRAME, ON THE FRONT LEFT CORNER, SHEARED. THIS LEFT THE BOLT STILL ANCHORED TO THE SLIDER FOR THE SEAT ADJUSTER. THE SEATS ROCK BACK AND FORTH. NOT ONLY IS THIS A SAFETY ISSUE, BUT IT MAKE THE SEAT EXTREMELY UNCOMFORTABLE. I DON'T H…
Read full complaint
I HAVE HAD TWO FORD CROWN VICS, A 1992 AND NOW A 1993. IN BOTH VEHICLES THE DRIVER'S SIDE SEAT FRAME, ON THE FRONT LEFT CORNER, SHEARED. THIS LEFT THE BOLT STILL ANCHORED TO THE SLIDER FOR THE SEAT ADJUSTER. THE SEATS ROCK BACK AND FORTH. NOT ONLY IS THIS A SAFETY ISSUE, BUT IT MAKE THE SEAT EXTREMELY UNCOMFORTABLE. I DON'T HAVE EXACT DATES AS TO WHEN THIS HAPPENED. THE DATE ON THE FORM IS WRONG AND ONLY SHOWS BECAUSE IT WAS A REQUIRED FIELD. *JB
NHTSA ODI #10018601
Mileage unknown · Sep 6, 2000
Seats
THE BOLTS HOLDING DRIVER'S SEAT TO THE FRAME SHEARED OFF, CAUSING SEAT TO BE UNSTABLE. DEALER HAS INSPECTED VEHICLE.*AK
NHTSA ODI #869740
Mileage unknown · Jun 15, 2000
SeatsCrash
WHILE PULLING OUT OF A LOT AT APPROXIMATELY 3-5 MPH VEHICLE STRUCK A POLE, CAUSING LEFT FRONT ANCHOR BOLT TO PULL OUT OF THE SEAT. DEALER/MANUFACTURER WERE NOT CONTACTED AT THIS TIME. FEEL FREE TO PROVIDE FUTHER DETAILS. *AK
BRAKING SYSTEM MALFUNCTIONED, CAUSING EXTENDED STOPPING DISTANCE WHICH MAY RESULT IN A CRASH. DEALER REPLACED BRAKE CALIPERS AND FRONT DISC ROTORS 3 TIMES. ALSO, WIRING HARNESS IN THE STEERING COLUMN BURNED OUT(IGNITION), CAUSING A FIRE. IN ADDITION, BOLT THAT HOLDS DRIVER'S SEAT TO THE FLOOR CAME OUT WHICH COULD CAUSE…
Read full complaint
BRAKING SYSTEM MALFUNCTIONED, CAUSING EXTENDED STOPPING DISTANCE WHICH MAY RESULT IN A CRASH. DEALER REPLACED BRAKE CALIPERS AND FRONT DISC ROTORS 3 TIMES. ALSO, WIRING HARNESS IN THE STEERING COLUMN BURNED OUT(IGNITION), CAUSING A FIRE. IN ADDITION, BOLT THAT HOLDS DRIVER'S SEAT TO THE FLOOR CAME OUT WHICH COULD CAUSE THE DRIVER'S SEAT TO MOVE UNEXPECTEDLY. PLEASE PROVIDE FURTHER INFORMATION. *AK
NHTSA ODI #857322
Mileage unknown · Oct 29, 1999
Electrical SystemSeatsSteering
BOLTS PULL OUT OF THE FRONT PASSENGER SEAT. MJS
NHTSA ODI #549407
Mileage unknown · Oct 25, 1999
Electrical SystemSeatsFire
WIRES IN THE STEERING COLUMN CAUGHT FIRE. NLM
NHTSA ODI #549179
Mileage unknown · Jul 15, 1999
Electrical SystemSeatsService Brakes, Hydraulic
VEHICLE DOES NOT START UP RIGHT AWAY. TOOK VEHICLE TO DEALER. WAS INFORMED THAT THE IGNITION SWITCH WIRES HAD TO BE REPLACED DUE TO BEING BURNED IN & AROUND THE COLUMN. THE HEATER WIRES HAD BURNED ALSO. THE SEAT ANCHOR BOLTS HAD CAME OUT OF THE FRONT SEAT. PLUGS, WIRES, AND BRAKES HAD TO BE REPLACED. *AK *ML
FORD IS RECALLING 225,000 MY 1992-2003 ECONOLINE, MY 1993-1995 TAURUS SHO, MY 1992-1998 CROWN VICTORIA, MY 1993 BRONCO, F-SERIES, MY 1995-1997 F-SERIES SUPER DUTY STRIPPED CHASSIS, MY 1992-1998 MERCURY GRAND MARQUIS, AND MY 1992-1995 LINCOLN TOWN CAR VEHICLES. THE AFFECTED VEHICLES WERE PREVIOUSLY REPAIRED USING A WIRING HARNESS THAT IS NOT COMPATIBLE WITH THE VEHICLE CIRCUIT POLARITY.
Consequence & remedy
Consequence: AS A RESULT, THE FUSE IS LOCATED IN THE OUTPUT CIRCUIT RATHER THAN IN THE INTENDED INPUT POWER FEED CIRCUIT, AND MAY NOT OFFER THE INTENDED PROTECTION IN THE EVENT OF AN ELECTRICAL SHORT TO GROUND.
Remedy: DEALERS WILL INSTALL A NEW WIRING HARNESS, OR REPLACE THE MATING ELECTRICAL COMPONENT. THE RECALL BEGAN ON FEBRUARY 18, 2008. OWNERS MAY CONTACT FORD AT 1-800-392-3673.
ON CERTAIN PICKUP TRUCKS, PASSENGER VEHICLES, SPORT UTILITY VEHICLES, AND MOTOR HOMES CHASSIS, THE SPEED CONTROL DEACTIVATION SWITCH MAY, UNDER CERTAIN CONDITIONS, LEAK INTERNALLY AND THEN OVERHEAT, SMOKE, OR BURN.
Consequence & remedy
Consequence: THIS COULD RESULT IN AN UNDERHOOD FIRE.
Remedy: DEALERS WILL INSTALL A FUSED WIRING HARNESS. OWNERS OF THE PASSENGER CARS INCLUDED IN THIS CAMPAIGN WILL BE INSTRUCTED TO RETURN THEIR VEHICLES TO THEIR DEALERS TO HAVE THE SPEED CONTROL DEACTIVATION SWITCH DISCONNECTED AS AN INTERIM REPAIR. AS SOON AS REPAIR PARTS ARE AVAILABLE (EXPECTED OCTOBER 2007), OWNERS WILL BE INSTRUCTED TO RETURN TO THE DEALERS FOR INSTALLATION OF A FUSED WIRING HARNESS. THE RECALL BEGAN ON AUGUST 13, 2007, AND MAILING COMPLETED BY SEPTEMBER 19, 2007. OWNERS MAY CONTACT FORD AT 1-888-222-2751.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE SPEED CONTROL DEACTIVATION SWITCH CAN DEVELOP A RESISTIVE SHORT IN THE ELECTRICAL CIRCUIT THAT COULD POTENTIALLY RESULT IN AN UNDERHOOD FIRE. A FIRE IS POSSIBLE BOTH WHEN THE VEHICLE IS RUNNING AND WHEN THE VEHICLE ENGINE IS OFF. ALSO, THE SHORT COULD DISABLE THE SPEED CONTROL SYSTEM OR CAUSE THE BRAKE LIGHT FUSE TO OPEN.
Consequence & remedy
Consequence: A FIRE CAN ORIGINATE IN THE LEFT FRONT UNDERHOOD AREA.
Remedy: DEALERS WILL INSTALL A NEW SPEED CONTROL DEACTIVATION SWITCH AND CONNECTOR SHELL. OWNER NOTIFICATION BEGAN MAY 20, 1999.
VEHICLE DESCRIPTION: CERTAIN 1996-1999 FORD CROWN VICTORIA POLICE, FLEET, NATURAL GAS, AND 1996-1999 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT WERE PRODUCED WITH A LOWER CONTROL ARM BALL JOINT CONTAINING A ONE PIECE BEARING; AND 1990-1996 FORD CROWN VICTORIA POLICE, FLEET, AND NGV VEHICLES AND 1990-1996 LINCOLN TOWN CAR LIMOUSINE VEHICLES THAT HAVE BEEN SERVICED WITH EITHER A BALL JOINT CONTAINING THE ONE-PIECE BEARING OR A FRONT LOWER CONTROL ARM CONTAINING A BALL JOINT WITH A ONE-PIECE BEARING. THE ONE-PIECE BEARING WITHIN THE LOWER CONTROL ARM BALL JOINT CAN WEAKEN SLOWLY DURING USE AND EVENTUALLY CRACK. THIS COULD RESULT IN SEPARATION OF THE BALL AND CAP OF THE JOINT, ALLOWING THE CONTROL ARM TO DROP TO THE GROUND.
Consequence & remedy
Consequence: IF THIS OCCURS WHILE THE VEHICLE IS MOVING, REDUCED STEERING CONTROL COULD OCCUR, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE LOWER CONTROL ARM BALL JOINTS (2).
VEHICLE DESCRIPTION: POLICE AND TAXI VEHICLES. THE HOOD LATCH STRIKER CAN WEAR OR BECOME DETACHED FROM THE HOOD.
Consequence & remedy
Consequence: EITHER OF THESE CONDITIONS CAN RESULT IN THE HOOD OPENING WITHOUT WARNING WHILE THE VEHICLE IS BEING OPERATED IMPAIRING THE DRIVER'S VISIBILITY.
Remedy: DEALERS WILL INSTALL AN IMPROVED HOOD LATCH STRIKER (VEHICLES WITH 1992 MODEL HOODS) OR REVISED STRIKER PLATE ATTACHING FASTENERS (VEHICLES WITH 1993-1997 MODEL HOODS).
THE BOLTS THAT ATTACH THE FRONT UPPER CONTROL ARMS TO THE FRAME MOUNTING BRACKETS CAN LOOSEN AND FRACTURE AT ONE OF THE BOLT HOLES CAUSING SUBSTANTIAL NEGATIVE CAMBER AND STEERING PULL TO THE AFFECTED SIDE.
Consequence & remedy
Consequence: IF THE DRIVER'S SIDE BRACKET FRACTURED AT BOTH BOLT HOLES, THE STEERING CONTROL ARM CAN CONTACT THE STEERING COLUMN SHAFT AND RESULT IN A LOSS OF STEERING CONTROL INCREASING THE POTENTIAL FOR AN ACCIDENT.
Remedy: DEALERS WILL INSPECT THE TORQUE LEVELS OF THE FOUR UPPER CONTROL ARM MOUNTING BOLTS, AND IF ANY ARE LOOSE, THE BRACKETS WILL BE INSPECTED FOR DAMAGE. IF DAMAGE IS PRESENT, IT WILL BE REPAIRED.
AN UNUSED POWER SEAT HARNESS CONNECTOR IS POSITIONED ON THE RUBBER FLOOR MAT UNDER THE SEAT. IF THE VEHICLE IS OPERATED IN COLD WEATHER IN AREAS THAT HAVE LARGE AMOUNTS OF SALT USED FOR SNOW AND ICE CONTROL, A PUDDLE OF SALTWATER CAN ACCUMULATE ON THE RUBBER FLOOR MATS, REPEATEDLY WETTING THE CONNECTOR. THIS WILL RESULT IN CORROSION OF THE CONNECTOR, CAUSING A CURRENT TO FLOW BETWEEN THE TERMINALS WITHOUT TRIPPING THE CIRCUIT BREAKER.
Consequence & remedy
Consequence: IF THIS OCCURS, CURRENT FLOW CAN HEAT THE CONNECTOR ANDRELEASE FUMES INTO THE PASSENGER COMPARTMENT, AND CAN RESULT IN A VEHICLE FIRE.
Remedy: DEALERS WILL REMOVE THE UNUSED CONNECTOR AND INSTALL A SEALED HEAT SHRINK CAP OVER THE AFFECTED WIRES.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
10
EA02025 · Speed Control Deactivation Switch Fires
Opened Sep 6, 2002 · Closed Jun 30, 2004
Status: closed (inferred from source dates) · Engine And Engine Cooling
BASED ON THE LOW RATE OF FIRE INCIDENTS (2.5 INCIDENTS PER 100,000 VEHICLES SOLD) WHERE FAILURE OF THE SCDS IS INVOLVED AND THE AGE OF THE VEHICLES ? 7 TO 11 YEARS ? A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.FOR ADDITIONAL INFORMATION, SEE THE ATTACHED CLOSING REPORT.
DP02007 · FUEL-FED Fires
Opened Aug 22, 2002 · Closed Dec 4, 2002
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
THE FARS DATA SHOWS THAT THE RISK OF FIRE FROM IMPACT IN ALL DIRECTIONS IN THE SUBJECT VEHICLES IS THE SAME AS ALL OTHER SEDANS.THE SUBJECT VEHICLES ARE NOT OVER REPRESENTED WITH RESPECT TO THE RISK OF FIRE IN REAL-WORLD HIGH-ENERGY CRASHES.A FURTHER DISCUSSION OF ISSUES RELATED TO POST CRASH FIRES IN THE SUBJECT VEHICLES IS SET OUT IN THE CLOSING REPORT FOR SQ 01-014 AND THAT REPORT IS IN THE DOCKET FOR THIS PETITION.AFTER REVIEWING THE PETITION AND ITS SUPPORTING MATERIALS, AS WELL AS INFORMATION FURNISHED BY FORD AND GM, AND INFORMATION WITHIN THE AGENCY'S POSSESSION FROM PREVIOUS INVESTIGATIONS AND OTHER RELATED ACTIONS,NHTSA HAS CONCLUDED THAT FUTHER INVESTIGATION CONCERNING POST-CRASH FIRES IN THE SUBJECT VEHICLES IS NOT LIKELY TO LEAD TO A DECISION THAT THE VEHICLES CONTAIN A SAFETY DEFECT.
SQ01014 · Post Rear End Collision Fires
Opened Nov 27, 2001 · Closed Oct 3, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:storage
There is no summary currently available
RQ01002 · Engine Compartment Fires
Opened Sep 20, 2001 · Closed Sep 6, 2002
Status: closed (inferred from source dates) · Engine And Engine Cooling
No summary supplied.
PE94073 · Brake Line Punctures
Opened Oct 4, 1994 · Closed Dec 28, 1994
Status: closed (inferred from source dates) · Service Brakes, Hydraulic
There is no summary currently available
EA94022 · Steering Power Assist Fail
Opened Jun 30, 1994 · Closed Mar 2, 1995
Status: closed (inferred from source dates) · Steering
There is no summary currently available
EA94020 · Grounding Strap Routing
Opened Jun 29, 1994 · Closed Nov 21, 1994
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE94032 · Steering Power Assist Failure
Opened Apr 8, 1994 · Closed Jun 30, 1994
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE94015 · Grounding Strap Routing
Opened Feb 14, 1994 · Closed Jun 29, 1994
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
PE93086 · Hood FLY-UP While Driving
Opened Oct 1, 1993 · Closed Feb 28, 1994
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1993 Ford Crown Victoria Problems, Complaints & Recalls | Skip That Year
Illustration