THIS CAR HAS LESS THAN 70000 MILES ON IT. WE HAD TROUBLE WITH THE FUEL DOOR, FRONT WHEEL BEARINGS, BRAKES, DOOR HANDLES, TRANSMISSION, ELECTRIC WINDOWS, AND NOW AS A SPECIAL TREAT THE ENGINE FAILED. THIS CAR HAS BEEN THE WORST INVESTMENT THAT MY WIFE AND I HAVE EVER MADE. I HAVE HAVE OWNED SEVERAL CARS AND TRUCKS WITH 200000 PLU…
Read full complaint
THIS CAR HAS LESS THAN 70000 MILES ON IT. WE HAD TROUBLE WITH THE FUEL DOOR, FRONT WHEEL BEARINGS, BRAKES, DOOR HANDLES, TRANSMISSION, ELECTRIC WINDOWS, AND NOW AS A SPECIAL TREAT THE ENGINE FAILED. THIS CAR HAS BEEN THE WORST INVESTMENT THAT MY WIFE AND I HAVE EVER MADE. I HAVE HAVE OWNED SEVERAL CARS AND TRUCKS WITH 200000 PLUS MILES ON THEM AND NONE OF THEM HAVE EVER BEEN AS PROBLEMATIC AS THIS AUTOMOBILE.
NHTSA ODI #10069333
Mileage unknown · Jan 15, 2004
Engine And Engine CoolingEquipment
MY NEWEST PROBLEM THAT I HAVE WITH THE CAR NOW IS IT STALLS AT RED LIGHTS AND DOESNT START FOR 45 MINUTE TO AN HOUR. I TOOK IT TO 3 GARAGES ALREADY AND THEY CAN'T FIND THE PROBLEM.
NHTSA ODI #10068969
103,000 miles · Aug 7, 2003
Engine And Engine Cooling
THE CONSUMER STATED THAT WHILE DRIVING THE COOLING FAN SEIZED. THIS CAUSED THE ELECTRICAL COMPONENTS TO MELT AND RESULT IN A FIRE. *AK THE CONSUMER SAW THE RECALL ON THE INTERNET BUT LATER FOUND OUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE CONSUMER FELLS THE SCOPE OF THE RECALL SHOULD BE EXPANDED.…
Read full complaint
THE CONSUMER STATED THAT WHILE DRIVING THE COOLING FAN SEIZED. THIS CAUSED THE ELECTRICAL COMPONENTS TO MELT AND RESULT IN A FIRE. *AK THE CONSUMER SAW THE RECALL ON THE INTERNET BUT LATER FOUND OUT THE VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO THE VIN. THE CONSUMER FELLS THE SCOPE OF THE RECALL SHOULD BE EXPANDED. *PH *NLM
NHTSA ODI #10026795
Mileage unknown · Jun 7, 2003
Electrical SystemEngine And Engine CoolingFire
THE WIRING HARNESS OF MY 1996 FORD CONTOUR CAUGHT FIRE. I HAD PRIOR PROBLEMS WITH THE VEHICLE IN THE PAST SUCH AS TAIL LIGHT GOING OUT CONSTANTLY AND ALSO HEADLIGHTS, AS WELL AS PROBLEMS WITH THE O2 SENSOR. I HAVE PUT MORE THAT$2000 DOLLARS ALONE ON THIS CAR JUST GETTING IT REPAIRED. *JB
NHTSA ODI #10021232
Mileage unknown · May 13, 2003
Engine And Engine Cooling
THE CONSUMERS VEHICLE EXPERIENCED SYMPTOMS OF NHTSA RECALL # 01-V-230-000 WHICH WAS RELATED TO THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES. THE CONSUMERS VEHICLE WAS NOT INCLUDED IN THE RECALL DUE TO VIN. *NLM
NHTSA ODI #10019775
Mileage unknown · Mar 4, 2003
Engine And Engine Cooling
THE ENGINE HEAD GASKET FAILED CAUSING THE ENGINE TO STOP WORKING. *NLM
NHTSA ODI #10009768
Mileage unknown · Nov 4, 2002
Engine And Engine Cooling
WHILE DRIVING THE VEHICLE AT 50 MPH ENGINE STALL. DEALER HAS BEEN NOTIFIED. PLEASE PROVIDE FURTHER INFORMATION AS PER CONVERSATION. MR
NHTSA ODI #8022146
Mileage unknown · Oct 27, 2002
Engine And Engine Cooling
PROBLEM APPEARS TO BE ELECTRICAL, CHANGE ALTERNATOR-AND THIS IS NOT PROBLEM. DT
NHTSA ODI #768948
Mileage unknown · Oct 14, 2002
Electrical SystemEngine And Engine CoolingEquipment
MR
NHTSA ODI #768458
Mileage unknown · Sep 11, 2002
Engine And Engine Cooling
WIRING TO COOLING SYSTEM MELTED. ALSO, EACH TIME CONSUMER TAKES VEHICLE TO DEALER SHE IS TOLD THAT NOTHING IS WRONG WITH VEHICLE. *AK
ON CERTAIN MY 1996-1998 PASSENGER VEHICLES BUILT AT THE KANSAS CITY, CUAUTITLAN ASSEMBLY PLANTS OR ON MY 1999 PASSENGER VEHCLES BUILT AT THE AUTOMOTIVE ALLIANCE INTERNATIONAL ASSEMBLY PLANTS, THE ROUGH SURFACE OF THE HEATER BLOWER RESISTOR'S STAINLESS STEEL BLADES CAN DAMAGE THE COPPER SURFACE OF THE WIRING HARNESS CONNECTOR. THE DAMAGE COULD, OVER TIME, CAUSE INCREASED RESISTANCE IN THE CONNECTOR AND, DUE TO SUBSEQUENT TERMINAL RELAXATION, RESULT IN AN OPEN CIRCUIT CONDITION.
Consequence & remedy
Consequence: THE OPEN CIRCUIT COULD LEAD TO ELECTRICAL ARCING THAT COULD MELT THE CONNECTOR HOUSING MATERIAL CREASING THE POTENTIAL FOR A FIRE.
Remedy: DEALERS WILL INSTALL A NEW HEATER BLOWER RESISTOR AND A NEW WIRE JUMPER HARNESS. OWNER NOTIFICATION BEGAN AUGUST 29, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT FORD AT 1-800-392-3673.
VEHICLE DESCRIPTION: 1995 PASSENGER VEHICLES EQUIPPED WITH THE 2.0L AND 2.5L ENGINES, AND 1996 VEHICLES EQUIPPED WITH 2.5L ENGINES. TIGHTENING OF THE ENGINE COOLING FAN MOTOR BEARINGS, UP TO AND INCLUDING MOTOR STALL, CAN RESULT IN INCREASED MOTOR TORQUE AND HIGHER THAN NORMAL MOTOR CURRENT AND ACCOMPANYING HIGH MOTOR TEMPERATURES.
Consequence & remedy
Consequence: OVERHEATING OF THE COOLING FAN MOTOR DUE TO EXCESSIVE CURRENT CAN RESULT IN SMOKE AND ODORS FROM BEARING GREASE, INSULATION AND OTHER INTERNAL MOTOR COMPONENTS. IF ELECTRICAL CURRENT CONTINUES TO BE APPLIED TO THE MOTOR, INTERNAL MOTOR COMPONENTS COULD IGNITE POSSIBLY IGNITING OTHER ENGINE COMPARTMENT COMPONENTS.
Remedy: DEALERS WILL INSTALL A POSITIVE TEMPERATURE COEFFICIENT DEVICE IN-LINE WITH EACH FAN MOTOR. FORD WILL ALSO EXTEND THE WARRANTY ON THE ENGINE COOLING FAN ASSEMBLY TO A TOTAL OF 8 YEARS OF SERVICE OR 100,000 MILES FROM THE WARRANTY START DATE, WHICHEVER OCCURS FIRST. IF THE VEHICLE ALREADY HAS MORE THAN 100,000 MILES, THIS COVERAGE WILL LAST UNTIL JULY 31, 2001.
VEHICLE DESCRIPTION: PASSENGER VEHICLES NOT EQUIPPED WITH THE ANTI-LOCK BRAKING SYSTEM (ABS). A PRESSURE CONSCIOUS REDUCING VALVE (PCRV) IN THE REAR BRAKES MAY BE SUBJECT TO CORROSION AND RESULT IN MALFUNCTION, WHEN OPERATED IN AREAS THAT USE SALT COMPOUNDS ON THE ROADWAY FOR DE-ICING OR DUST CONTROL.
Consequence & remedy
Consequence: IF BOTH PCRV'S MALFUNCTION, VEHICLE HANDLING COULD BE ADVERSELY AFFECTED DURING BRAKING AS A RESULT OF THE REAR WHEELS LOCKING, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSTALL IMPROVED PCRV'S IN THE REAR BRAKE SYSTEM. THIS RECALL WAS EXPANDED IN SEPTEMBER 2000 TO INCLUDE 1999 AND 2000 FORD CONTOUR, MERCURY MYSTIQUE AND COUGAR VEHICLES.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FUEL FILLER PIPE VENT HOSE MAY HAVE LESS THAN THE INTENDED LEVEL OF OZONE RESISTANCE, WHICH COULD RESULT IN THE HOSE BECOMING BRITTLE AND CRACKING.
Consequence & remedy
Consequence: A CRACKED HOSE COULD RESULT IN FUEL LEAKAGE WHEN THE VEHICLE IS BEING FUELED.
Remedy: DEALERS WILL INSTALL A FUEL FILLER VENT HOSE CONTACTING THE APPROPRIATE BLEND OF PVC AND NITRILE RUBBER.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE TERMINALS AT THE HEADLIGHT SWITCH AND WIRING HARNESS CONNECTOR CAN EXPERIENCE HEAT DAMAGE AS A RESULT OF OVERHEATING.
Consequence & remedy
Consequence: THE DAMAGE COULD RESULT IN DISTORTION OF THE TERMINAL CAUSING AN OPEN CIRCUIT IN THE INSTRUMENT PANEL ILLUMINATION, PARKING LAMP, AND TAIL LAMP CIRCUITS.
Remedy: DEALERS WILL INSTALL A HEADLAMP SWITCH WIRING CONNECTOR CONTAINING BRONZE TERMINALS AND AN INSPECTION, AND REPLACEMENT IF NECESSARY, OF THE HEADLAMP SWITCH.
VEHICLE DESCRIPTION: PASSENGER VEHICLES. THE FLOOR SHIFT AUTOMATIC TRANSMISSION CONTROL CAN BE DAMAGED IF SUBJECTED TO CERTAIN INTERIOR CLEANING PRODUCTS. THE GEAR POSITION INDICATOR CAN DETERIORATE AND NOT CORRECTLY INDICATE THE ACTUAL GEAR POSITION.
Consequence & remedy
Consequence: THIS CONDITION CAN RESULT IN INCORRECT GEAR SELECTION.
Remedy: DEALERS WILL REPLACE THE AUTOMATIC TRANSMISSION FLOOR SHIFT CONTROL.
VEHICLE DESCRIPTION: PASSENGER VEHICLES EQUIPPED WITH THE TRACTION CONTROL OPTION. THE THROTTLE CABLES WERE DAMAGED DURING VEHICLE ASSEMBLY LEADING TO FRAYING OR SEPARATION OF THE THROTTLE CABLE.
Consequence & remedy
Consequence: THIS CONDITION COULD PREVENT THE ENGINE FROM RETURNING TO IDLE.
Remedy: DEALERS WILL REPLACE THE THROTTLE CABLE WITH A REVISED DESIGN THAT IS LESS SUSCEPTIBLE TO BENDING OR KINKING DURING INSTALLATION.
VEHICLE DESCRIPTION: BI-FUEL VEHICLES MODIFIED TO RUN ON EITHER GASOLINE OR COMPRESSED NATURAL GAS (CNG). THE NATURAL GAS FUEL TANKS HAVE A SOLENOID SHUT-OFF VALVE THAT STOPS FUEL FLOW FROM THE FUEL TANK IN THE EVENT OF CERTAIN MODERATE TO SEVERE COLLISIONS. IF THE VEHICLE IS IN A COLLISION AND THE NATURAL GAS FUEL LINE IS DAMAGED, THE SYSTEM COULD LEAK NATURAL GAS.
Consequence & remedy
Consequence: FUEL LEAKAGE IN THE PRESENCE OF AN IGNITION SOURCE COULD RESULT IN A FIRE.
Remedy: FORD HAS REQUESTED OWNERS OF THESE VEHICLES TO HAVE THE CNG FUEL SYSTEM DISABLED UNDER A PREVIOUS RECALL CAMPAIGN AND TO ONLY USE GASOLINE FUEL UNTIL A PERMANENT CORRECTIVE ACTION IS DEVELOPED. OWNERS ARE BEING ALERTED TO THIS SOLENOID VALVE CONCERN AT THIS TIME. THE TIMING OF CORRECTIVE ACTIONS IS BEING DELAYED TO ALLOW BOTH CONDITIONS TO BE REMEDIED AT ONE TIME. IN THE MEANTIME, THERE IS NOT RISK AS LONG AS THE NATURAL GAS SYSTEM HAS BEEN DISABLED AND THE VHEICLE IS ONLY OPERATED ON GASOLINE.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
RQ02006 · Incorrect Gear Indication
Opened Feb 26, 2002 · Closed Sep 12, 2002
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
EA01001 · Blower Switch/resistor Or Wiring Harness
Opened Jan 5, 2001 · Closed Jul 31, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
Additional source detail variants (2)
Electrical System
There is no summary currently available
Electrical System
There is no summary currently available
PE00023 · Blower Switch/resistor Or Wiring Harness
Opened Jun 14, 2000 · Closed Jan 5, 2001
Status: closed (inferred from source dates) · Electrical System
There is no summary currently available
RQ99019 · Various Intermittent Electrical Issues
Opened Sep 15, 1999 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Unknown Or Other
There is no summary currently available
PE98063 · Headlight Switch
Opened Dec 3, 1998 · Closed May 10, 1999
Status: closed (inferred from source dates) · Exterior Lighting
ODI OPENED THE PRELIMINARY EVALUATION ON DECEMBER 3, 1989 BASED ON FIVE CONSUMER COMPLAINTS, ALL OF WHICH MENTIONED CONCERNS CENTERED ON THE DASHBOARD-MOUNTED HEADLIGHT SWITCH.THESE CONCERNS INCLUDED AN ALLEGATION OF THE SWITCH CATCHING FIRE, AN ALLEGATION OF HEADLIGHT LOSS, AND THREE ALLEGATIONS OF INSTRUMENT PANEL AND TAIL LIGHT OUTAGES.THREE OF THE REPORTS SPECIFICALLY IDENTIFIED THE HEADLIGHT SWITCH AND ITS ASSOCIATED WIRING AS HAVING BEEN HEAT DAMAGED.FORD INVESTIGATIONS HAVE FOUND THAT OVERHEATING OF AN ELECTRICAL TERMINAL AT THE HEADLIGHT SWITCH CONNECTOR CAUSES LOSS OF THE INSTRUMENT PANEL AND TAIL LIGHTS.FORD WILL REMEDY THIS CONDITION IN 1996-1998 MODEL CONTOUR AND MYSTIQUE VEHICLES BUILT AT THE KANSAS CITY ASSEMBLY PLANT FROM APRIL 20, 1995 THROUGH AUGUST 12, 1998 AND AT THE CAUTITLAN, MEXICO ASSEMBLY PLANT FROM JUNE 13, 1995 THROUGH AUGUST 24, 1998 UNDER RECALL 99V-103.THE REMEDY INVOLVES REPLACEMENT OF THE HEADLIGHT SWITCH CONNECTOR AND IF NECESSARY, THE SWITCH ITSELF.THIS PRELIMINARY EVALUATION IS CLOSED.
1996 Ford Contour Problems, Complaints & Recalls | Skip That Year
Illustration