I WAS GIVEN THIS VAN WITH A HANDICAPPED LIFT AS A PRESENT FROM SOME PEOPLE AT OUR CHURCH. EVER SINCE I GOT IT THE ENGINE LIGHT HAS BEEN ON. I'VE HAD IT CHECKED SEVERAL TIMES BUT NO ONE SEEMS TO KNOW HOW TO FIX IT. ANOTHER PROBLEM I'VE BEEN HAVING IS THAT THE LEFT FRONT TIRE WEARS OUT MORE QUICKLY THAN THE OTHER THREE. WE'VE …
Read full complaint
I WAS GIVEN THIS VAN WITH A HANDICAPPED LIFT AS A PRESENT FROM SOME PEOPLE AT OUR CHURCH. EVER SINCE I GOT IT THE ENGINE LIGHT HAS BEEN ON. I'VE HAD IT CHECKED SEVERAL TIMES BUT NO ONE SEEMS TO KNOW HOW TO FIX IT. ANOTHER PROBLEM I'VE BEEN HAVING IS THAT THE LEFT FRONT TIRE WEARS OUT MORE QUICKLY THAN THE OTHER THREE. WE'VE HAD IT BALANCED SEVERAL TIMES BUT WE STILL HAVE THAT PROBLEM EVEN WITH NEW TIRES. SINCE I AM HANDICAPPED AND USE AN ELECTRIC WHEELCHAIR IF A TIRE BLOWS OUT I MAY NOT BE ABLE TO GET OUT USING THE RAMP LIFT THAT WAS INSTALLED AND THE SAME APPLIES TO THE ENGINE. HOW DO I KNOW IF THE ENGINE HAS SOMETHING WRONG WITH IT IF THE LIGHT IS ON ALL THE TIME? *TR
NHTSA ODI #10659389
180,000 miles · Jun 26, 2009
Wheels
OBSERVED FULL CRACK ON ALUMINUM WHEEL RIM SPOKE. THIS IS STANDARD ALUMINUM WHEEL FROM MANUFACTURER. SERIOUS SAFETY ISSUE. THIS PROBLEM SAME AS HTTP://WWW.MOTORBEAT.COM/COMPLAINT/438440/. *TR THIS IS THE SECOND RIM THAT THIS PROBLEM HAS OCCURRED. ANOTHER RIM FAILED IN THE SAME MANNER ONE YEAR AGO. REPLACED.
NHTSA ODI #10275026
Mileage unknown · May 21, 2004
Wheels
CONSUMER'S HUSBAND DISCOVERED THAT ONE OF THE RIMS HAD CRACKED IN THREE PLACES. *LA ANOTHER RIM WAS FOUND WITH CRACKS IN THREE PLACES AS WELL. *SC *JB
NHTSA ODI #10074110
74,000 miles · Mar 23, 2004
Wheels
CONSUMER TOOK VEHICLE TO THE DEALERSHIP FOR INSPECTION, AND MECHANIC DETERMINED THAT TWO FRONT RIMS CRACKED. *AK CONSUMER CALLED FORD MOTOR COMPANY AND SAID THAT THEY WON'T ADDRESS THE PROBLEM BECAUSE IT'S NOT ON WARRANTY OR RECALL. HOWEVER, CONSUMER REPLACED BOTH RIMS. *LA
NHTSA ODI #10059385
136,000 miles · Sep 2, 2003
Wheels
CONSUMER NOTICED THAT REAR DRIVER'S SIDE RIM SPOKES ARE CRACKED. VEHICLE DID NOT HIT ANYTHING. *AK FOUR SPOKES WERE CRACKED COMPLETELY THREW. ANY MORE AND CONSUMER FACED LOSS OF WHEEL FROM THE VEHICLE. CONSUMER HAD THE SPARE PUT ON AND RIM REPLACED. CONSUMER LEARNED A PARTICULAR DEALERSHIP SELLS ONE OR MORE TO OTHER CUSTOME…
Read full complaint
CONSUMER NOTICED THAT REAR DRIVER'S SIDE RIM SPOKES ARE CRACKED. VEHICLE DID NOT HIT ANYTHING. *AK FOUR SPOKES WERE CRACKED COMPLETELY THREW. ANY MORE AND CONSUMER FACED LOSS OF WHEEL FROM THE VEHICLE. CONSUMER HAD THE SPARE PUT ON AND RIM REPLACED. CONSUMER LEARNED A PARTICULAR DEALERSHIP SELLS ONE OR MORE TO OTHER CUSTOMERS WITH THE SAME PROBLEM. ONE PARTICULAR CUSTOMER WENT TO THE DEALERSHIP WITH THREE DEFECTIVE RIMS. *PH
NHTSA ODI #10031918
Mileage unknown · Aug 15, 2000
Wheels
WHILE LOOKING WHEEL OVER NOTICED RIM WITH CRACK. *AK ALL THREE WHEELS HAVE CRACK AT THE SAME PLACE. *YH
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH 3.0L ENGINES. AN ACCELERATOR CABLE WAS KINKED DURING INSTALLATION, CAUSING THE CORE WIRES TO EVENTUALLY FRAY.
Consequence & remedy
Consequence: THIS COULD INCREASE THE FRICTION IN THE CABLE, CAUSING THE THROTTLE TO BE SLOW TO RETURN TO IDLE. THIS CONDITION COULD RESULT IN A STUCK THROTTLE.
Remedy: DEALERS WILL INSTALL A NEW ACCELERATOR CABLE.
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
1997 Ford Aerostar Problems, Complaints & Recalls | Skip That Year
Illustration