MY TRANSMISSION DEVELOPED A BAD LEAK IN THE FRONT SEAL. I PAID TO HAVE THE TRANSAXLE REMOVED AND THE SEAL REPLACED. THE FLUID WAS CHANGED AS WELL AS THE FILTER AND THEN SHORTLY AFTERWARDS THE CARS OVERDRIVE STOPPED WORKING. IT WILL SHIFT INTO OVERDRIVE BUT IT WILL SHIFT RIGHT BACK OUT WHEN I STEP ON THE GAS EVEN THE LEAST LITTLE…
Read full complaint
MY TRANSMISSION DEVELOPED A BAD LEAK IN THE FRONT SEAL. I PAID TO HAVE THE TRANSAXLE REMOVED AND THE SEAL REPLACED. THE FLUID WAS CHANGED AS WELL AS THE FILTER AND THEN SHORTLY AFTERWARDS THE CARS OVERDRIVE STOPPED WORKING. IT WILL SHIFT INTO OVERDRIVE BUT IT WILL SHIFT RIGHT BACK OUT WHEN I STEP ON THE GAS EVEN THE LEAST LITTLE BIT. I COULD NOT AFFORD TO HAVE IT FIXED SO I PUT IT IN DRIVE AND DROVE IT FOR ABOUT 3 WEEKS AND YESTERDAY I WAS DOING ABOUT 60 AND THE CAR SHIFTED INTO SECOND GEAR FOR NO REASON AND THEN RIGHT BACK INTO THRID. THEN ABOUT A HALF MILE LATER IT BEGAN SHIFTING FROM THIRD TO SECOND AND BACK OVER AND OVER. TALK ABOUT GETTING JERKED AROUND! IT WAS LIKE SOMEONE STEPPING ON THE BRAKES! NOW I AM ON FOOT AND I AM ON FOOT AND DUE TO OUR GREAT ECONOMY I AM OUT OF WORK FOR THE TIME BEING. THEY SHOULD OFFER A MANUAL TRANSMISSION ON ALL THEIR CARS.
NHTSA ODI #10070676
Mileage unknown · Jan 20, 1998
Unknown Or Other
REQUESTING INFORMATION REGARDING RECALL OF EITHER FORD WINDSTAR OR AEROSTAR.
VEHICLE DESCRIPTION: MINIVANS EQUIPPED WITH 3.0L ENGINES. AN ACCELERATOR CABLE WAS KINKED DURING INSTALLATION, CAUSING THE CORE WIRES TO EVENTUALLY FRAY.
Consequence & remedy
Consequence: THIS COULD INCREASE THE FRICTION IN THE CABLE, CAUSING THE THROTTLE TO BE SLOW TO RETURN TO IDLE. THIS CONDITION COULD RESULT IN A STUCK THROTTLE.
Remedy: DEALERS WILL INSTALL A NEW ACCELERATOR CABLE.
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
1997 Ford Aerostar Problems, Complaints & Recalls | Skip That Year
Illustration