THE METAL PORTION OF POWER STEERING FLUID RETURN HOSE AND ONE OF THE METAL LINES TO THE POWER STEERING GEAR BOX/ACTUATOR ARE MOUNTED IN SUCH A MANNER THAT THEY RUB TOGETHER AND OVER TIME RUB AWAY AT THE METAL AND DEVELOP LEAKS THAT CAUSE THE POWER STEERING FLUID TO LEAK OUT CAUSING A CATASTROPHIC FAILURE OF THE POWER STEERING.…
Read full complaint
THE METAL PORTION OF POWER STEERING FLUID RETURN HOSE AND ONE OF THE METAL LINES TO THE POWER STEERING GEAR BOX/ACTUATOR ARE MOUNTED IN SUCH A MANNER THAT THEY RUB TOGETHER AND OVER TIME RUB AWAY AT THE METAL AND DEVELOP LEAKS THAT CAUSE THE POWER STEERING FLUID TO LEAK OUT CAUSING A CATASTROPHIC FAILURE OF THE POWER STEERING. THE ONLY INDICATION OF THIS FAILURE IS WHINING COMING FROM THE ENGINE COMPARTMENT.*AK
NHTSA ODI #740741
Mileage unknown · Aug 24, 1999
Steering
WHILE BACKING VEHICLE OUT OF PARKING LOT, STEERING WHEEL BROKE IN DRIVER'S HANDS & FELL INTO DRIVER'S LAP. HAD NO CONTROL OF VEHICLE. TURNED VEHICLE OFF & TOWED TO DEALER. *AK
NHTSA ODI #845709
Mileage unknown · Jul 16, 1999
Steering
WHILE DRVING VAN AT ANY SPEED A GRINDING NOISE COMES FROM THE RIGHT FRONT WHEEL. WHEN THE VAN WAS CHECKED BY A MECHANIC THE BEARING WAS GONE FROM THE SPINDLE. PLEASE LIST VIN, MILEAGE AND DATES FOR OTHER VANS. *AK
NHTSA ODI #842489
Mileage unknown · Jun 4, 1998
Steering
CONSUMER STATES WHILE TURNING THE HAZARD LIGHT'S ON THE STEERING COLUMN STARTING SMOKING. PLEASE PROVIDE FURTHER DETAILS.
NHTSA ODI #824082
Mileage unknown · Oct 27, 1997
Steering
POWER STEERING LEAKING AT TIME OF DELIVERY.
NHTSA ODI #604440
Mileage unknown · Aug 29, 1997
Steering
THE SPINDLE SNAPPED, CAUSING THE RIGHT FRONT WHEEL TO FLY OFF WHILE DRIVING 65MPH. CHAMPION FORD COULD NOT DUPLICATE OR GIVE A REASON WHY THIS WOULD HAPPEN. *AK
DRIVING ABOUT 35 MPH WHEN FELT A PULL TO THE RIGHT. THE RIGHT SPINDL/ BRAKE CALIPER ANDBRAKE LINE BROKE. LOST CONTROL OF STEERING & THE BRAKES. TOOK TO THE DEALER. LOOKING AT VEHICLE TO DETERMINE CAUSE. *AK
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
THE CERTIFICATION LABELS ON THE INVOLVED VEHICLES HAS INCORRECT REAR TIRE INFLATION PRESSURE DESIGNATIONS. THIS DOES NOT COMPLY WITH FMVSS NO. 120, "TIRE SELECTION AND RIMS FOR MOTOR VEHICLES OTHER THAN PASSENGER CARS."
Consequence & remedy
Consequence: INCORRECT INFLATION PRESSURES COULD CAUSE PREMATURE WEAR OF THE REAR TIRES. .
Remedy: OWNERS WILL BE PROVIDED WITH CORRECT CERTIFICATION LABELS AND INSTRUCTIONS FOR INSTALLING THESE LABELS. DEALERS CAN INSTALL THIS LABEL IF THE OWNER SO DESIRES.
WHEN IN THE SECONDARY LATCHED POSITION, THE DRIVER DOOR LATCHES MAY OPEN WHEN SUBJECTED TO TRANSVERSE LOADS LESS THAN THAT SPECIFIED IN FMVSS NO. 206, "DOOR LOCKS AND DOOR RETENTION COMPONENTS."
Consequence & remedy
Consequence: THE DRIVER'S DOOR, WHEN CLOSED ONLY TO THE SECONDARY LATCHED POSITION, MAY NOT SUSTAIN A 1,000 POUND TRANSVERSE LOAD.
Remedy: DEALERS WILL INSPECT AND, IF NECESSARY, REPLACE THE DRIVER DOOR LATCH.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
1996 Ford Aerostar Problems, Complaints & Recalls | Skip That Year
Illustration