FRONT COIL SPRINGS SNAPPED, HAD TO REPLACED WITH READING SPRING WORKS, THEY HAD TO SEND THE SPECKS TO CHICAGO. MY FORD AERO STAR 4 WHEEL DRIVE & 4.0 V6 IS NOT AVAILABLE FROM AFTER MARKET. THE ONLY OPTION IS TO BUY NEW OR USED FORD SPRINGS WHICH ARE MADE IN CHINA. THE LOCAL FORD DEALER ADMITS REPLACING COIL & LEAF SPRINGS ON SEVE…
Read full complaint
FRONT COIL SPRINGS SNAPPED, HAD TO REPLACED WITH READING SPRING WORKS, THEY HAD TO SEND THE SPECKS TO CHICAGO. MY FORD AERO STAR 4 WHEEL DRIVE & 4.0 V6 IS NOT AVAILABLE FROM AFTER MARKET. THE ONLY OPTION IS TO BUY NEW OR USED FORD SPRINGS WHICH ARE MADE IN CHINA. THE LOCAL FORD DEALER ADMITS REPLACING COIL & LEAF SPRINGS ON SEVERAL MODELS. MIDAS WAS SO BUSY REPLACING FORD SPRINGS, THEY COULD NOT SET UP AN APPOINTMENT TO INSTALL SPRINGS EVEN IF I HAD THE SPRINGS. *TR
NHTSA ODI #10217895
Mileage unknown · Feb 20, 2001
Wheels
LEFT REAR ALLOY WHEEL WAS CRACKED WITHIN ONE OF THE SPOKES. DEALER/MANUFACTURER NOTIFIED, AND INFORMED THAT IT WAS OUT OF ITS WARRANTY AND NOTHING WILL DE DONE. *AK THE DEALER INSPECTED THE WHEEL AND CONCLUDED THAT THE WHEEL WAS DEFECTIVE. *YH
NHTSA ODI #880888
Mileage unknown · Mar 24, 1999
Wheels
WHILE DRIVING THE THE RIGHT FRONT WHEEL LOCKED UP, CAUSING THE VEHICLE TO SKID. CAUSE UNKNOWN. PLEASE GIVE ANY FURTHER DETAILS. *AK
NHTSA ODI #836084
Mileage unknown · Mar 8, 1999
Wheels
ON THE DATE LISTED MY PASSENGER SIDE FRONT WHEEL/TIRE FELL OFF. THIS IS MY WIFE'S WORK CAR AND SHE THOUGHT SHE COULD HEAR SOMETHING DIFFERENT. SO I DROVE IT TO WORK THE NEXT DAY. I THOUGHT I COULD FEEL SOME ROUGHNESS SIGHTLY THROUGH MY PEDAL BUT IT WOULD COME AND GO. I THOUGHT IT COULD BE A U-JOINT PROBLEM. ANYWAY AS I WAS …
Read full complaint
ON THE DATE LISTED MY PASSENGER SIDE FRONT WHEEL/TIRE FELL OFF. THIS IS MY WIFE'S WORK CAR AND SHE THOUGHT SHE COULD HEAR SOMETHING DIFFERENT. SO I DROVE IT TO WORK THE NEXT DAY. I THOUGHT I COULD FEEL SOME ROUGHNESS SIGHTLY THROUGH MY PEDAL BUT IT WOULD COME AND GO. I THOUGHT IT COULD BE A U-JOINT PROBLEM. ANYWAY AS I WAS TURNING A SHARP TURN IN THE TOWN OF OF MEROM, IN THE WHEEL FELL OFF WITH THE BRAKE LINE STILL CONNECTED. THE SPINDLE HAD SNAPPED INTO BECAUSE THE BEARING LOCKED UP DUE TO INADEQUATE PACKING GREASE. THIS VAN IS MY FAMILY CAR AND THIS COULD HAVE BEEN A DISASTEROUS ACCIDENT IF THE WHEEL HAD COME OFF ON THE OPEN HIGHWAY. I DO HAVE THE WHEEL BEARING IN MY POSSESSION. THE OUTER COLLAR IS MISSING BUT THE INDIVIDUAL BEARING ROLLARS ARE WELDED TO THE INNER COLLAR AS IS THE PIECE OF SPINDLE SHAFT THAT SHEARED OFF. I JUST THOUGHT THIS SHOULD BE BROUGHT TO SOMEBODIES ATTENTION.
VEHICLE DESCRIPTION: MINI VANS. HEAT GENERATION IN THE WIRING HARNESS TO THE FUEL PUMP/SENDER ASSEMBLY CAN CAUSE AN ELECTRICAL SHORT. THE VEHICLE COULD EXPERIENCE A LOSS OF POWER AND BECOME IMMOBILIZED AND THE FUEL GAUGE MAY BE ERRATIC.
Consequence & remedy
Consequence: HEAT DAMAGE, INCLUDING MELTING OR CHARRING OF THE FUEL PUMP AND SENDER ASSEMBLY WIRE HARNESS AND ASSOCIATED WIRING HARNESSES CAN ALSO RESULT. THE SHORT CIRCUIT COULD ALSO HAVE THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A FUSED JUMPER HARNESS IN THE FUEL PUMP GROUND CIRCUIT THAT WILL BE INSTALLED AT THE FUEL PUMP INERTIA SHUT-OFF SWITCH.
VEHICLE DESCRIPTION: MINI VANS. THESE VEHICLES WERE PRODUCED WITH A HIGHER THAN SPECIFIED ELECTRICAL LOAD THROUGH THE ACCESSORY POWER FEED CIRCUIT. THE POTENTIAL FOR CONTACT BETWEEN THE B2 (BATTERY), A2 (ACCESSORY), AND P1 (PROOF) CIRCUITS CAN OCCUR, CREATING A SHORT CIRCUIT, ALLOWING CURRENT TO FLOW THROUGH THE GROUND WIRE.
Consequence & remedy
Consequence: THIS CAN CAUSE OVER HEATING AND THE POTENTIAL FOR A VEHICLE FIRE.
Remedy: DEALERS WILL INSTALL A JUMPER HARNESS WITH A RELAY WHICH WILL RE-ROUTE AND ACTIVATE ALL A2 ACCESSORIES THROUGH THE RELAY.
VEHICLE DESCRIPTION: ALL WHEEL DRIVE PASSENGER MINIVANS. THESE VEHICLES CAN DEVELOP POWERTRAIN BENDING RESONANCE OR TRANSFER CASE OUTPUT SHAFT BUSHING DISPLACEMENT. THE POWERTRAIN BENDING RESONANCE OR THE OUTPUT SHAFT BUSHING DISPLACEMENT CAN RESULT IN STRUCTURAL FAILURE OF THE TRANSMISSION AND/OR TRANSFER CASE. FLUID EXPLUSION, DRIVESHAFT SEPARATION OR LOSS OF VEHICLE DRIVE CAN RESULT.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, AND, IF THE EXPELLED FLUID CONTACTS THE EXHAUST SYSTEM, A VEHICLE FIRE COULD OCCUR.
Remedy: DEALERS WILL INSTALL A NEW TRANSFER CASE REAR OUTPUT SHAFT BUSHING AND AN ALUMINUM DRIVESHAFT WILL BE INSTALLED.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
5
PE02076 · Luggage Compartment Door Drops Abruptly
Opened Oct 10, 2002 · Closed Mar 10, 2003
Status: closed (inferred from source dates) · Structure:body:hatchback/liftgate:support Device/strut
ODI HAS IDENTIFIED 30 INCIDENTS RESULTING IN MINOR TO MODERATE PERSONAL INJURIES THAT HAVE BEEN CAUSED BY ABRUPT DOOR DROPS OVER THE APPROXIMATELY EIGHT - TWELVE YEAR PERIOD OF PRODUCT USAGE AND EXPOSURE (1991-1995 TO 2003).MOST OF THE INJURY INCIDENTS APPEAR TO HAVE BEEN CAUSED BY A FRACTURE OF THE GAS FILLED LIFT ASSIST CYLINDER MOUNTING STUD.STUD FRACTURES HAVE OCCURRED RANDOMLY OVER TIME AND DO NOT EXHIBIT ANY APPARENT TREND RELATING TO DATE OF VEHICLE PRODUCTION OR TIME-IN-SERVICE (EXPOSURE).THE ODI CLOSING REPORT SUMMARIZES THE DETAILS OF THIS INVESTIGATION.
EA99002 · Transfer Cases And Rear Drive Shaft
Opened Jan 7, 1999 · Closed Nov 14, 2000
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
RQ98012 · Transfer Cases And Rear Driveshaft
Opened Jul 31, 1998 · Closed Jan 7, 1999
Status: closed (inferred from source dates) · Power Train:transfer Case (4-WHEEL Drive)
There is no summary currently available
EA98016 · Fuel Sender Assembly Fires
Opened Jul 14, 1998 · Closed Feb 12, 1999
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
There is no summary currently available
Additional source detail variants (2)
Vehicle Speed Control:linkages
There is no summary currently available
Vehicle Speed Control:linkages
There is no summary currently available
PE98010 · Fuel Sender Assembly Fires
Opened Feb 13, 1998 · Closed Jul 14, 1998
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
OWNERS ALLEGE THAT FAILURE OF THE FUEL PUMP/SENDER CONNECTOR RESULTS IN SHORT CIRCUIT THAT HAS RESULTED IN VEHICLE FIRES.SYMPTOMS INCLUDE ERRATIC FUEL GAUGE OPERATION, , SMOKE FROM THE DASH ON THE DRIVER'S SIDE NEAR THE STEERING COLUMN (FUEL PUMP FUSIBLE LINK) AND PASSENGER SIDE (FUEL PUMP INERTIA CUTOFF SWITCH), INTERMITTENT STALL AND NO START CONCERNS, AND A BURNING ODOR. SEVERAL INCIDENTS HAVE RESULTED IN DAMAGE TO PLASTIC FUEL TUBES AND/OR FUEL SUPPLY/RETURN TUBES.
1994 Ford Aerostar Problems, Complaints & Recalls | Skip That Year
Illustration