IllustrationWE HAVE EXHAUST FUMES IN THE BACK OF THE RV. GET A FILM ON OUR MIRRORS FROM THE EXHAUST. *TR
2008 Fleetwood Expedition
Owner reports · Recalls · Investigations
Limited comparison data
There is not enough comparable history to draw a useful model-year comparison.
About this comparison →How this year compares
Owner complaints by model year
Compare all Expedition years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 1 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Engine And Engine Cooling. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reportsOfficial recalls
609V175000 · Electrical SYSTEM:12V/24V/48V Battery:cables
May 21, 2009
FLEETWOOD IS RECALLING 311 MY 2008-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOUNDER DIESEL MOTOR HOME. THE BATTERY CABLE MAY BECOME DISLODGED AND COME IN CONTACT WITH THE DRIVER SHAFT CAUSING ENTANGLEMENT OR ABRASION TO THE BATTERY CABLE.
Consequence & remedy
Consequence: THIS COULD LEAD TO AN ELECTRICAL SHORT WHICH MAY RESULT IN A FIRE OR UN-COMMANDED VEHICLE SHUTDOWN WHICH MAY RESULT IN A LOSS OF VEHICLE CONTROL.
Remedy: DEALERS WILL INSPECT AND REPLACE DAMAGE BATTERY CABLES AND SECURE THE BATTERY CABLE HARNESS ABOVE THE DRIVE SHAFT FREE OF CHARGE. THE RECALL IS EXPECTED TO BEGIN DURING JUNE 2009. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
09V056000 · Electrical SYSTEM:12V/24V/48V Battery:cables
Feb 18, 2009
FLEETWOOD IS RECALLING 3,782 MY 2006-2009 PROVIDENCE, EXCURSION, EXPEDITION, DISCOVERY AND BOULDER DIESEL MOTOR HOMES. THE BATTERY CABLE IS ROUTED TOO CLOSE TO A SHARP EDGE LOCATED ON TOP OF A SHELF INSTALLED OVER THE DRIVESHAFT.
Consequence & remedy
Consequence: THIS CAN CAUSE ABRASION TO THE BATTERY CABLE INSULATION, LEADING TO AN ELECTRICAL SHORT AND POSSIBLY A FIRE.
Remedy: DEALERS WILL RE-ROUTE THE CABLE AWAY FROM THE SHARP EDGE LOCATION. THIS SERVICE WILL BE PERFORMED FOR YOU FREE OF CHARGE. THE RECALL BEGAN ON MAY, 26 2009. OWNERS MAY CONTACT FLEETWOOD AT 800-509-3418.
08V292000 · Equipment:other:labels
Jul 1, 2008
FLEETWOOD IS RECALLING 226 MY 2008-2009 AMERICAN ALLEGIANCE, AMERICAN EAGLE, AMERICAN HERITAGE, AMERICAN TRADITION, BOUNDER, BOUNDER DIESEL, DISCOVERY, EXCURSION, EXPEDITION, FIESTA LX, PACE ARROW, PROVIDENCE, REVOLUTION LE, SOUTHWIND, CLASS A MOTOR HOMES, AND ICON, JAMBOREE, JAMBOREE GT, JAMBOREE SPORT, PULSE, TIOGA, AND TIOGA RANGER CLASS C MOTOR HOMES. THESE MOTOR HOMES FAIL TO COMPLY WITH THE REQUIREMENTS OF THE CODE OF FEDERAL REGULATIONS, PART 567, 'CERTIFICATION.' THE OCCUPANT AND CARGO CARRYING CAPACITY WERE CALCULATED INCORRECTLY ALLOWING ADDITIONAL LOAD CARRYING CAPACITY.
Consequence & remedy
Consequence: OVERLOADING MAY HAVE AN ADVERSE AFFECT ON MOTOR HOME HANDLING, INCREASING THE RISK OF A CRASH.
Remedy: FLEETWOOD WILL MAIL A CORRECTED FEDERAL CERTIFICATION LABEL ALONG WITH INSTALLATION INSTRUCTIONS TO THE AFFECTED MOTOR HOME OWNERS. OWNERS WHO DO NOT FEEL COMFORTABLE INSTALLING THIS LABEL CAN TAKE THEIR MOTOR HOME TO ANY FLEETWOOD DEALER AND THE DEALER WILL INSTALL THE LABEL FOR THEM. THE RECALL BEGAN ON JULY 28, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
08V269000 · Suspension
Jun 17, 2008
DAIMLER TRUCKS IS RECALLING 2,506 MY 2008 XC MOTOR HOME CHASSIS AND THOMAS BUILT HDX SCHOOL AND TRANSIT BUSES EQUIPPED WITH SAF-HOLLAND ADL SERIES REAR SUSPENSIONS. IN SOME INSTANCES THE TRANSVERSE BEAM WAS NOT PROPERLY WELDED WHICH COULD RESULT IN A FAILURE OF THE WELD.
Consequence & remedy
Consequence: IF THE WELD FAILS, VEHICLE STABILITY WHILE CORNERING COULD BE AFFECTED RESULTING IN LOSS OF VEHICLE CONTROL, POSSIBLY RESULTING IN A CRASH. IN ADDITION, THE TRANSVERSE BEAM COULD DROP TO THE GROUND CAUSING SPARKS THAT COULD CAUSE A FIRE HAZARD.
Remedy: DAIMLER TRUCKS IS WORKING WITH SAF-HOLLAND TO HAVE A VISUAL INSPECTION OF THE ADL TRANSVERSE BEAM PERFORMED. IF A WELD DEFECT IS IDENTIFIED, SAF-HOLLAND WILL PROVIDE A SERVICE REPLACEMENT KIT THAT CONTAINS A NEW TRANSVERSE BEAM, ALL NECESSARY INSTALLATION HARDWARE, BEAM REPLACEMENT, AND INSTRUCTIONS FREE OF CHARGE (PLEASE SEE 08E031). THE RECALL RECALL BEGAN ON SEPTEMBER 12, 2008 (THOMAS BUILT BUSES) AND OCTOBER 8, 2008. OWNERS MAY CONTACT SAF-HOLLAND AT 1-231-773-3271 OR DAIMLER TRUCKS AT 1-800-547-0712.
08V013000 · Electrical System:wiring
Jan 10, 2008
ON CERTAIN MOTOR HOMES EQUIPPED WITH A FIELD EFFECT TRANSISTOR (FET) BOARD BUILT BY MAGNUM ENERGY, INC., THE CIRCUITRY INSIDE CERTAIN INVERTERS CAN CAUSE AN INOPERATIVE CONDITION RESULTING IN OVERHEATING OF THE INVERTER.
Consequence & remedy
Consequence: OVERHEATING OF THE INVERTER MAY RESULT IN A POTENTIAL FIRE.
Remedy: DEALERS WILL INSPECT AND REPLACE THE INVERTER FREE OF CHARGE. THE RECALL BEGAN ON JANUARY 19, 2008. OWNERS MAY CONTACT FLEETWOOD AT 1-800-509-3418.
07V306000 · Steering
Jul 18, 2007
FREIGHTLINER IS RECALLING CERTAIN SCHOOL BUS CHASSIS, HEAVY TRUCKS, VAN CHASSIS, RV MOTORHOME CHASSIS MANUFACTURED FROM JANUARY 5 TO MAY 17, 2007, EQUIPPED WITH AXLE ALLIANCE COMPANY (AAC) FRONT AXLES. DURING THE FRONT AXLE ASSEMBLY, THE FASTENERS THAT ATTACH THE STEERING ARM OR TIE ROD ARMS TO THE SPINDLE MAY BE OVER OR UNDER TIGHTENED.
Consequence & remedy
Consequence: INCORRECTLY TIGHTENED STEERING ARM FASTENERS MAY FATIGUE AND FRACTURE WHICH COULD CAUSE A CRASH WITHOUT WARNING.
Remedy: THOMAS BUILT WILL NOTIFY OWNERS, INSPECT THE FASTENERS, AND REPLACE THE STEERING ARM IF NECESSARY. THE RECALL BEGAN ON DECEMBER 21, 2007. OWNERS CAN CONTACT FREIGHTLINER AT 1-800-547-0712.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0No exact-year investigations in this snapshot.