Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 0 of 1 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Tires. Review the 1 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
0 crash reports0 fire reports0 injury reports
What owners actually said
1 reports
Mileage unknown · Sep 28, 2005
Tires
CONSUMER RIGHT FRONT TIRE BLEW OUT THE SIDEWALL EXPOSING STEEL BELTS. *TS *** NAR RECEIVED 9-29-05*** THE TIRE WAS REPLACED WITH THE NEW FULL SIZE SPARE. ALMOST A MONTH LATER THE RIGHT FRONT TIRE BLEWOUT AGAIN LEAVING A 2 INCH HOLE IN THE TREAD. THIS WAS THE ORIGINAL SPARE WHICH HAD LESS THAN 2000 MILE ON IT. SIX DAY LATER T…
Read full complaint
CONSUMER RIGHT FRONT TIRE BLEW OUT THE SIDEWALL EXPOSING STEEL BELTS. *TS *** NAR RECEIVED 9-29-05*** THE TIRE WAS REPLACED WITH THE NEW FULL SIZE SPARE. ALMOST A MONTH LATER THE RIGHT FRONT TIRE BLEWOUT AGAIN LEAVING A 2 INCH HOLE IN THE TREAD. THIS WAS THE ORIGINAL SPARE WHICH HAD LESS THAN 2000 MILE ON IT. SIX DAY LATER THE LEFT REAR TIRE BLEWOUT LEAVING A 1 INCH HOLE IN THE TREAD OF THE TIRE. (2004 SPORTSMASTER 194T TRAVEL TRAILER) (5 ORIGINAL CARLISLE ST RADIAL ST250/75R14 LOAD C). *NM
EXTREME RV IS RECALLING 3,294 MY 2004-2007 FIFTH WHEEL AND TRAVEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: IF THIS SOLUTION IS EXPOSED TO AN IGNITION SOURCE UNDER CERTAIN SPECIFIC CIRCUMSTANCES, IT CAN RESULT IN A VEHICLE FIRE.
Remedy: EXTREME RV IS WORKING WITH DOMETIC TO REPAIR THESE REFRIGERATORS (PLEASE SEE 08E032). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR EXTREME RV AT 1-208-453-2500.
EXTREME RV IS RECALLING 12,951 MY 2003-2004 SPORTSMASTER, MONTEREY, EXTREME AND MY 1997-2003 KIT RV CALAY, COMPANION, ESPRE, EXTREME, MILLINIUM, MONTEREY, PATIO HAULER, ROAD RANGER, SPORTSMASTER AND SUNCHASER TRAVEL AND FIFTH WHEEL TRAILERS EQUIPPED WITH A TWO-DOOR REFRIGERATOR MANUFACTURED BY THE DOMETIC CORPORATION. THE REFRIGERATOR MAY HAVE A DEFECT IN THE BOILER TUBE. PRESSURIZED COOLANT SOLUTION COULD BE RELEASED INTO AN AREA WHERE AN IGNITION SOURCE (GAS FLAME) IS PRESENT.
Consequence & remedy
Consequence: RELEASE OF COOLANT UNDER CERTAIN CONDITIONS COULD IGNITE AND RESULT IN A FIRE.
Remedy: EXTREME RV WILL BE WORKING WITH DOMETIC IN ORDER TO REPAIR THESE REFRIGERATORS (PLEASE SEE 06E076). DOMETIC WILL REPAIR THESE REFRIGERATORS BY INSTALLING A SECONDARY BURN HOUSING, A THERMAL FUSE, AND A MELT FUSE FREE OF CHARGE. DOMETIC HAS RETAINED STERICYCLE INC. TO MANAGE THIS CAMPAIGN. STERICYCLE WILL ASSIST THE OWNER IN LOCATING DEALERSHIPS OR SERVICE CENTERS AND WILL PROVIDE ASSISTANCE WITH SCHEDULING OF APPOINTMENTS. OWNERS MAY CONTACT DOMETIC/STERICYCLE AT 1-888-446-5157 OR EXTREME RV AT 1-208-453-2500.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
0
No exact-year investigations in this snapshot.
2004 Extreme RV Sportsmaster Problems, Complaints & Recalls | Skip That Year
Illustration