Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
Limited mileage data: 2 of 104 reports include usable mileage. There isn’t enough coverage to show a useful chart.
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
Power Train. Review the 55 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Engine And Engine Cooling. Review the 22 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
Seat Belts. Review the 14 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
5 crash reports3 fire reports4 injury reports
What owners actually said
104 reports
81,374 miles · Aug 29, 2006
Power Train
TOOK MY 1991 EAGLE TALON TSI TO KLABEN CHRYSLER TO BE SERVICED BY THEM PER THE RECALL ON THE CAR. THEY CALLED AND SAID EVERYTHING CHECKED OK. BUT THE TRANSMISSION IS BURNED UP. THAT WEEK A FELLOW TECHNICIAN AND I PULLED THE TRANSMISSION AND TRANSFER CASE AS AN ASSEMBLY AND FOUND THE INSIDES OF THE TRANSFER CASE WERE POWDER AND…
Read full complaint
TOOK MY 1991 EAGLE TALON TSI TO KLABEN CHRYSLER TO BE SERVICED BY THEM PER THE RECALL ON THE CAR. THEY CALLED AND SAID EVERYTHING CHECKED OK. BUT THE TRANSMISSION IS BURNED UP. THAT WEEK A FELLOW TECHNICIAN AND I PULLED THE TRANSMISSION AND TRANSFER CASE AS AN ASSEMBLY AND FOUND THE INSIDES OF THE TRANSFER CASE WERE POWDER AND BLOWN APART INSIDE. THE TRANSFER CASE WAS NOT LEAKING DUE TO NO OIL AT ALL IN THE TRANSFER CASE. I HAVE THE INVOICE ( #CHBS538463) THAT STATES EVERYTHING OK BUT A NOTE THAT SAYS THE TRANSMISSION IS BURNED UP. NINE MILES FROM THE TIME I PICKED UP THE CAR THE TRANSFER CASE LOCKED UP AND THE CAR WAS NOT MOVABLE. WE HAD TO JACK UP THE VEHICLE TO BRING IT INSIDE THE SHOP TO SEE WHAT THE PROBLEM WAS. THIS IS UNACCEPTABLE FOR A POTENTIAL CRASH TO HAPPEN AND THE JUST PUSHED IT OUT THE DOOR LIKE EVERYTHING IS PERFECTLY FINE. *JB
NHTSA ODI #10167013
Mileage unknown · Feb 17, 2004
Power Train
NHTSA RECALL 98V069002 CONCERNING TRANSFER CASE FAILURE.. LOCK UP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION. *AK
NHTSA ODI #10059171
92,000 miles · Oct 21, 2003
Power Train
DEFECT STATED IN THE TRANSFER CASE RECALL 98 V 069 002 OCCURRED AFTER THE RECALL REPAIRS WERE PERFORMED. AS A RESULT, THE BUSHING IN THE EXTENSION HOUSING WORE OUT AND DEVELOPED A LEAK. DEALERSHIP WAS REFUSING TO REPAIR THE BUSHING.*AK
NHTSA ODI #10044378
Mileage unknown · Sep 12, 2002
Power Train
CONTACTED DEALER REGARDING RECALL 98V069002 REMEDY DUE TO TRANSFER CASE LOCKUP. DEALER INFORMED CUSTOMER THAT THEY DID NOT HAVE TO REPLACE TRANSFER CASE BECAUSE IT WAS NOT MANDATED UNDER RECALL CORRECTIVE ACTION.*AK
NHTSA ODI #8018557
Mileage unknown · Aug 15, 2002
Engine And Engine Cooling
TIMING BELT TEETH BROKE AT THE CRANK. THIS ALLOWED PISTONS TO KEEP RUNNING, BUT THE CAM STOPPED. AS A RESULT OF THIS VEHICLE FAILED. REPAIRS WERE DONE IN APRIL 2002, WITH FAILURE REOCCURING IN AUG 2002. MILEAGE ACCUMULATION BETWEEN THE REPAIRS WAS 7,500 MILES. PLEASE DESCRIBE DETAILS. *AK
NHTSA ODI #8016451
Mileage unknown · Jun 19, 2002
Exterior Lighting
SNOW BUILDS UP AROUND HEADLIGHTS AND WILL NOT MELT,HEADLIGHT ILLUMINATION DIMINISHES IN BAD WEATHER CAUSING POOR VISBILITY. *MJ
NHTSA ODI #566158
Mileage unknown · May 15, 2002
Seat Belts
DRIVER'S SEATBELT TIGHTENS TO WHERE CONSUMER FEELS STRANGLED.*AK
NHTSA ODI #8009927
Mileage unknown · Feb 10, 2002
Power Train
I AM THE 2ND ONWER OF THE CAR. CAN I STILL GET A FREE REPLACEMENT OF THE PART? NO SAFETY DEFECT LISTED. *AK
NHTSA ODI #758042
Mileage unknown · Nov 1, 2001
Power Train
CONTACED DEALERSHIP, WERE VERY DIFFICULT SAID NOT TRANSFER CASE SAID IT WAS CLUTCH, WAS REQUIRED TO PAY FOR CLUTCH, THEN CAR STILL DID NOT WORK, THEY THEN PUT ON NEW TRANSFER CASE EVEN THOUGH STATING IT WAS NOT THE CAUSE AND STILL THERE IS REAR WHEELS MAKING NOISE AS IF THERE IS SOMETHING INTHEM. RECALL SHOULD COVER CLUTCH TOO S…
Read full complaint
CONTACED DEALERSHIP, WERE VERY DIFFICULT SAID NOT TRANSFER CASE SAID IT WAS CLUTCH, WAS REQUIRED TO PAY FOR CLUTCH, THEN CAR STILL DID NOT WORK, THEY THEN PUT ON NEW TRANSFER CASE EVEN THOUGH STATING IT WAS NOT THE CAUSE AND STILL THERE IS REAR WHEELS MAKING NOISE AS IF THERE IS SOMETHING INTHEM. RECALL SHOULD COVER CLUTCH TOO SINCE IT WAS TRF CASE CAUSING ALL THE DAMAGE.*AK
NHTSA ODI #753987
Mileage unknown · Sep 5, 2001
Power Train
CAR HAD SEVERAL TIMES FELT LIKE IT WAS "CUTTING OUT" AND JERKING, ONCE GETTING OFF FREEWAY IT SMELT HEAVILY OF BRAKES AND COULD NOT DETERMINE WHY CAR WAS LAGGING VERY BADLY, CONTINUED TO DRIVE FOR SEVERAL WEEKS THEN WHILE DRIVING 40MPH CAR BEGAN CONVULSING AND JERKING. PULLED OVER BARELY MADE TO GAS STATION. CAR WAS HAVING HARD …
Read full complaint
CAR HAD SEVERAL TIMES FELT LIKE IT WAS "CUTTING OUT" AND JERKING, ONCE GETTING OFF FREEWAY IT SMELT HEAVILY OF BRAKES AND COULD NOT DETERMINE WHY CAR WAS LAGGING VERY BADLY, CONTINUED TO DRIVE FOR SEVERAL WEEKS THEN WHILE DRIVING 40MPH CAR BEGAN CONVULSING AND JERKING. PULLED OVER BARELY MADE TO GAS STATION. CAR WAS HAVING HARD TIME SHIFTING GEARS AND CLUTCH WAS VERY HARD TO PUSH. WHEELS LOCKED UP AND WOULD NOT ROLL OR MOVE PUT IN GEAR AND ATTEMPTED TO MOVE CAR REVVED UP BUT WOULD NOT BUDGE. DISCONNECTED REAR DRIVELINE AND DROVE HOME AS "FRONT WHEEL DRIVE" VEHICLE.TOOK TO CHRYSLER AND HAVEBEEN FIGHTING TO GET RESOLVED.SAYS CLUTCH IS BLOWN OUT AND HAS NOTHING TO DO WITH TRANSFER CASE.*AK
VEHICLE DESCRIPTION: PASSENGER VEHICLES. LOCKUP OF THE TRANSFER CASE CAN OCCUR DUE TO INSUFFICIENT LUBRICATION.
Consequence & remedy
Consequence: THIS CONDITION CAN CAUSE A LOSS OF VEHICLE CONTROL, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL INSPECT THE VEHICLES FOR ADEQUACY OF THE TRANSFER CASE OIL VOLUME, TRANSFER CASE OIL LEAKAGE, AND OPERATIONAL DEGRADATION OF THE TRANSFER CASE MECHANISM. IF OIL VOLUME IS INSUFFICIENT, THE APPROPRIATE AMOUNT OF OIL WILL BE ADDED. IF THERE IS TRANSFER CASE OIL LEAKAGE, AFFECTED COMPONENTS WILL BE REPLACED. IF THE TRANSFER CASE SHOWS OPERATIONAL DEGRADATION, THE TRANSFER CASE WILL BE REPLACED.
THE FRONT SAFETY BELT BUCKLE RELEASE BUTTONS CAN BREAK. THESE RED PLASTIC RELEASE BUTTONS ARE MARKED "PRESS." IF A BUTTON BREAKS, PIECES CAN FALL INTO THE BUCKLE ASSEMBLY CAUSING THE BUCKLE TO OPERATE IMPROPERLY.
Consequence & remedy
Consequence: THE SAFETY BELTS WOULD NOT PROVIDE ADEQUATE PROTECTION TO AN OCCUPANT IN A VEHICLE CRASH.
Remedy: OWNERS SHOULD PROMPTLY CHECK THE CONDITION AND OPERATION OF BOTH FRONT SAFETY BELT BUCKLES AND CAREFULLY INSPECT THE RED RELEASE BUTTON FOR ANY BREAKS OR CRACKS. THEY SHOULD ENSURE THAT BOTH BUCKLES ARE OPERATING PROPERLY BY INSERTING EACH LATCH PLATE INTO ITS BUCKLE, TUGGING ON THE BELT TO MAKE SURE THE LATCH IS SECURELY LOCKED, AND THEN PRESSING THE RELEASE BUTTON. THE LATCH PLATE SHOULD POP OUT OF THE BUCKLE WHEN THE BUTTON IS PRESSED. IF EITHER RELEASE BUTTON SHOWS A SIGN OF BREAKING OR CRACKING OR IF EITHER BUCKLE FAILS TO OPERATE PROPERLY, OWNERS SHOULD PROMPTLY CONTACT THEIR AUTHORIZED DEALER TO SCHEDULE AN APPOINTMENT TO HAVE THE BUCKLE REPLACED OR REPAIRED, FREE OF CHARGE. THE MANUFACTURER IS DEVELOPING A REMEDY DESIGNED TO PREVENT FAILURE OF THE BUTTONS THAT ARE NOT CURRENTLY BROKEN.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
3
EA98002 · Transfer Case Lockup
Opened Jan 30, 1998 · Closed Apr 30, 1998
Status: closed (inferred from source dates) · Wheels
No summary supplied.
Additional source detail variants (2)
Wheels
Wheels
PE97040 · Transfer Case Lockup
Opened Sep 4, 1997 · Closed Jan 30, 1998
Status: closed (inferred from source dates) · Wheels
ALLEGED DRIVETRAIN FAILURE THAT CAN LEAD TO LOCK-UP OF THE REAR OR ALL WHEELS.
PE94074 · Hood FLY-UP
Opened Oct 12, 1994 · Closed Feb 24, 1995
Status: closed (inferred from source dates) · Structure
There is no summary currently available
1991 Eagle Talon Problems, Complaints & Recalls | Skip That Year
Illustration