TL* THE CONTACT OWNS A 2004 DODGE SPRINTER. THE CONTACT STATED THAT THE VEHICLE CONSISTENTLY MISFIRED. THE DODGE MANUFACTURER INCLUDED THE VEHICLE IN ITS T21 EMISSIONS RECALL FOR THE ENGINE CONTROL UNIT; HOWEVER, THE TOOLS, AN AVAILABLE TECHNICIAN, AND THE PART WAS NOT AVAILABLE TO SCHEDULE THE REPAIR APPOINTMENT. THE FOLLOWING …
Read full complaint
TL* THE CONTACT OWNS A 2004 DODGE SPRINTER. THE CONTACT STATED THAT THE VEHICLE CONSISTENTLY MISFIRED. THE DODGE MANUFACTURER INCLUDED THE VEHICLE IN ITS T21 EMISSIONS RECALL FOR THE ENGINE CONTROL UNIT; HOWEVER, THE TOOLS, AN AVAILABLE TECHNICIAN, AND THE PART WAS NOT AVAILABLE TO SCHEDULE THE REPAIR APPOINTMENT. THE FOLLOWING DEALERS WERE CONTACTED: ED VOYLES CHRYSLER DODGE JEEP RAM (789 COBB PKWY SE, MARIETTA, GA 30060, (844) 715-5921), SHOTTENKIRK CHRYSLER DODGE JEEP RAM (200 LIBERTY BLVD, CANTON, GA 30114, (678) 535-3417), LANDMARK DODGE CHRYSLER JEEP RAM (6850 MT ZION BLVD, MORROW, GA 30260, (770) 968-4900), DON JACKSON CHRYSLER DODGE JEEP RAM (3950 JONESBORO RD, UNION CITY, GA 30291, (770) 969-7229), AND MALL OF GEORGIA CHRYSLER DODGE JEEP (4345 BUFORD DR, BUFORD, GA 30518, (888) 522-5112). THE VEHICLE WAS NOT DIAGNOSED AND WAS NOT BEING DRIVEN DUE TO THE FAILURE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE AND ASSIGNED A CASE MANAGER WHO WAS TO RESPOND WITHIN ONE BUSINESS DAY. THE CONTACT WAS WAITING FOR A RESPONSE FROM THE MANUFACTURER. THE FAILURE MILEAGE WAS NOT AVAILABLE. *TT CONSUMER STATED TODAY IS AUGUST 10,2018 AND WE ARE STILL ATTEMPTING TO RESOLVE OUR RECALL T-21 OF SPRINTER 2004. ALTHOUGH IT HAS TAKEN 3 MONTH TO EVEN ATTEMPT TO GET THIS RECALL RESOLVED. WE WENT TI HAVE THE SITUATION SOLVED ON AUG 7. NOW AFTER A SERVICE MANAGER ASKED HIS OWN PERSONAL COMPUTER TO DO THE UPDATE... WE NOW HAVE A "CHECK ENGINE" LIGHT ON- STILL NOT RESOLVED MANY POOR EXCUSES FROM CIA- CASE# 3646736668. UPDATED 10/9/18*JB
NHTSA ODI #11109603
110,000 miles · Nov 9, 2012
Engine
DRIVING AT FREEWAY SPEED THE VEHICLE LOSSES POWER AND THE SPEED DECREASES TO ABOUT 40 MPH. I CAN PULL OVER AND TURN OF THE MOTOR FOR ABOUT 10 SECONDS AND START UP AND THE VEHICLE WILL RESET AND RUN FINE UNTIL IT DOES IT AGAIN RANDOMLY. THIS IS VERY DANGEROUS ESPECIALLY WHEN YOU ARE IN THE LEFT HAND LANE AND YOU ARE TRYING TO GE…
Read full complaint
DRIVING AT FREEWAY SPEED THE VEHICLE LOSSES POWER AND THE SPEED DECREASES TO ABOUT 40 MPH. I CAN PULL OVER AND TURN OF THE MOTOR FOR ABOUT 10 SECONDS AND START UP AND THE VEHICLE WILL RESET AND RUN FINE UNTIL IT DOES IT AGAIN RANDOMLY. THIS IS VERY DANGEROUS ESPECIALLY WHEN YOU ARE IN THE LEFT HAND LANE AND YOU ARE TRYING TO GET TO A SAFE PLACE TO PULL OVER. THIS HAS HAPPENED SEVERAL TIMES AND I HAVE REPLACED THE TURBO RESONATOR 3 TIME ON THIS TRUCK. THIS IS A PLASTIC PART AND THE BODY CRACKS FROM THE VIBRATION AND PRESSURE. *TR
NHTSA ODI #10483797
Official recalls
0
No recalls in this snapshot.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE04066 · Tire Valve Failure
Opened Sep 21, 2004 · Closed Feb 2, 2005
Status: closed (inferred from source dates) · Tires; Tires:valve
ODI OPENED PE04-066 TO INVESTIGATE FIVE COMPLAINTS ALLEGING TIRE VALVE FAILURE IN MY 2003-04 SUBJECT VEHICLES.SOME OF THE COMPLAINTS ALLEGED MULTIPLE TIRE VALVE FAILURES FOR A SINGLE VEHICLE.ON DECEMBER 16, 2004, DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL (DCMI) NOTIFIED NHTSA OF A SAFETY DEFECT IN APPROXIMATELY 23,000 MY 2002-05 SPRINTER 2500 VEHICLES EQUIPPED WITH TR-600 TIRE VALVES PRODUCED BY ALLIGATOR VENTILFABRICK GMBH (RECALL 04V-600).THE NOTIFICATION IDENTIFIED THE CHEMICAL SPECIFICATION OF THE RUBBER COMPONENTS AND AN UNSTABLE SUPPLIER PRODUCTION PROCESS, WHICH RESULTED IN INADEQUATE MIXING OF THE RUBBER COMPONENTS, AS THE FACTORS CONTRIBUTING TO THIS DEFECT.AS A RESULT OF THESE FACTORS, CRACKS CAN DEVELOP WITHIN THE RUBBER PART OR BETWEEN THE METAL AND THE RUBBER PARTS OF THE VALVE STEM, WHICH CAN LEAD TO A LOSS OF AIR PRESSURE AT THE VALVE STEM AND MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ALTHOUGH THE TR-600 TIRE VALVE IS USED ONLY ON THE 2500 SERIES SUBJECT VEHICLES WITH 16 INCH TIRES, DCMI WILL CONDUCT A SAFETY RECALL FOR ALL SPRINTER 2500 VEHICLES SOLD IN THE U.S. TO REPLACE THE CURRENT TIRE VALVES WITH A TR-600 VALVE, WHICH USES A SINGLE RUBBER COMPONENT FOR THE VALVES.ALL 24 COMPLAINTS AND ALL 43 WARRANTY CLAIMS IDENTIFIED IN THIS INVESTIGATION INVOLVED MY 2002-04 SPRINTER 2500 VEHICLES, WHICH COMPRISE APPROXIMATELY 84 PERCENT OF THE SUBJECT VEHICLE POPULATION.
Additional source detail variants (2)
Tires
ODI OPENED PE04-066 TO INVESTIGATE FIVE COMPLAINTS ALLEGING TIRE VALVE FAILURE IN MY 2003-04 SUBJECT VEHICLES.SOME OF THE COMPLAINTS ALLEGED MULTIPLE TIRE VALVE FAILURES FOR A SINGLE VEHICLE.ON DECEMBER 16, 2004, DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL (DCMI) NOTIFIED NHTSA OF A SAFETY DEFECT IN APPROXIMATELY 23,000 MY 2002-05 SPRINTER 2500 VEHICLES EQUIPPED WITH TR-600 TIRE VALVES PRODUCED BY ALLIGATOR VENTILFABRICK GMBH (RECALL 04V-600).THE NOTIFICATION IDENTIFIED THE CHEMICAL SPECIFICATION OF THE RUBBER COMPONENTS AND AN UNSTABLE SUPPLIER PRODUCTION PROCESS, WHICH RESULTED IN INADEQUATE MIXING OF THE RUBBER COMPONENTS, AS THE FACTORS CONTRIBUTING TO THIS DEFECT.AS A RESULT OF THESE FACTORS, CRACKS CAN DEVELOP WITHIN THE RUBBER PART OR BETWEEN THE METAL AND THE RUBBER PARTS OF THE VALVE STEM, WHICH CAN LEAD TO A LOSS OF AIR PRESSURE AT THE VALVE STEM AND MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ALTHOUGH THE TR-600 TIRE VALVE IS USED ONLY ON THE 2500 SERIES SUBJECT VEHICLES WITH 16 INCH TIRES, DCMI WILL CONDUCT A SAFETY RECALL FOR ALL SPRINTER 2500 VEHICLES SOLD IN THE U.S. TO REPLACE THE CURRENT TIRE VALVES WITH A TR-600 VALVE, WHICH USES A SINGLE RUBBER COMPONENT FOR THE VALVES.ALL 24 COMPLAINTS AND ALL 43 WARRANTY CLAIMS IDENTIFIED IN THIS INVESTIGATION INVOLVED MY 2002-04 SPRINTER 2500 VEHICLES, WHICH COMPRISE APPROXIMATELY 84 PERCENT OF THE SUBJECT VEHICLE POPULATION.
Tires:valve
ODI OPENED PE04-066 TO INVESTIGATE FIVE COMPLAINTS ALLEGING TIRE VALVE FAILURE IN MY 2003-04 SUBJECT VEHICLES.SOME OF THE COMPLAINTS ALLEGED MULTIPLE TIRE VALVE FAILURES FOR A SINGLE VEHICLE.ON DECEMBER 16, 2004, DAIMLERCHRYSLER MANUFACTURING INTERNATIONAL (DCMI) NOTIFIED NHTSA OF A SAFETY DEFECT IN APPROXIMATELY 23,000 MY 2002-05 SPRINTER 2500 VEHICLES EQUIPPED WITH TR-600 TIRE VALVES PRODUCED BY ALLIGATOR VENTILFABRICK GMBH (RECALL 04V-600).THE NOTIFICATION IDENTIFIED THE CHEMICAL SPECIFICATION OF THE RUBBER COMPONENTS AND AN UNSTABLE SUPPLIER PRODUCTION PROCESS, WHICH RESULTED IN INADEQUATE MIXING OF THE RUBBER COMPONENTS, AS THE FACTORS CONTRIBUTING TO THIS DEFECT.AS A RESULT OF THESE FACTORS, CRACKS CAN DEVELOP WITHIN THE RUBBER PART OR BETWEEN THE METAL AND THE RUBBER PARTS OF THE VALVE STEM, WHICH CAN LEAD TO A LOSS OF AIR PRESSURE AT THE VALVE STEM AND MAY POSE A RISK TO MOTOR VEHICLE SAFETY.ALTHOUGH THE TR-600 TIRE VALVE IS USED ONLY ON THE 2500 SERIES SUBJECT VEHICLES WITH 16 INCH TIRES, DCMI WILL CONDUCT A SAFETY RECALL FOR ALL SPRINTER 2500 VEHICLES SOLD IN THE U.S. TO REPLACE THE CURRENT TIRE VALVES WITH A TR-600 VALVE, WHICH USES A SINGLE RUBBER COMPONENT FOR THE VALVES.ALL 24 COMPLAINTS AND ALL 43 WARRANTY CLAIMS IDENTIFIED IN THIS INVESTIGATION INVOLVED MY 2002-04 SPRINTER 2500 VEHICLES, WHICH COMPRISE APPROXIMATELY 84 PERCENT OF THE SUBJECT VEHICLE POPULATION.
2004 Dodge Sprinter Problems, Complaints & Recalls | Skip That Year
Illustration