ON MY WAY TO WORK, AS USUAL, ON A "SLIGHTLY" BUMPY PART OF THE HIGHWAY MY STEERING WHEEL AND FRONT END STARTED VIBRATING SO VIOLENTLY THAT I ALMOST LOST CONTROL. I COULD BARELY HOLD THE STEERING WHEEL; AND COULD NOT STEER AT ALL; ALL I COULD DO WAS START BRAKING AND COME TO A STOP. I GOT OUT AND CHECKED MY TIRES AND FRONT END AN…
Read full complaint
ON MY WAY TO WORK, AS USUAL, ON A "SLIGHTLY" BUMPY PART OF THE HIGHWAY MY STEERING WHEEL AND FRONT END STARTED VIBRATING SO VIOLENTLY THAT I ALMOST LOST CONTROL. I COULD BARELY HOLD THE STEERING WHEEL; AND COULD NOT STEER AT ALL; ALL I COULD DO WAS START BRAKING AND COME TO A STOP. I GOT OUT AND CHECKED MY TIRES AND FRONT END AND EVERYTHING APPEARED NORMAL. I CONTINUED TO WORK AT ABOUT 40 MPH (I HAD GONE TO WORK EARLY SO NO TRAFFIC) . AT 8:00 I CALLED MY LOCAL MECHANIC AND TOOK IT TO HIM TO CHECK OUT WHAT HAPPENED. HE CHECK EVERYTHING AND NOTHING SHOWED. THE NEXT DAY IT HAPPENED AGAIN; THEN AGAIN 2 DAYS LATER. ABOUT 2 WEEKS LATER I TOOK PICKUP IN FOR REGULAR OIL/FUEL/AIR FILTER CHANGE SERVICE. HE TEST DROVE WITH ME ALONG AND I EXPLAINED FURTHER WHAT HAPPENED. HE SAID HE HAS SEEN IT BEFORE WITH DODGE 2500 & 3500 AND IT HAS BEEN LABELED THE "DODGE DEATH WOBBLE". I THANK GOD I WAS NOT IN A BUSY TRAFFIC AREA. *TR
NHTSA ODI #10430142
84,000 miles · Jun 27, 2011
Steering
TL* THE CONTACT OWNS A 2001 DODGE RAM. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE TIE ROD ON THE FRONT DRIVERS SIDE DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE CONTACT EXPRESSED CONCER…
Read full complaint
TL* THE CONTACT OWNS A 2001 DODGE RAM. THE CONTACT STATED THAT WHILE THE VEHICLE WAS PARKED, THE TIE ROD ON THE FRONT DRIVERS SIDE DETACHED FROM THE VEHICLE. THE VEHICLE WAS NOT TAKEN TO HAVE THE FAILURE DIAGNOSED OR REPAIRED. THE MANUFACTURER WAS MADE AWARE OF THE FAILURE, BUT OFFERED NO ASSISTANCE. THE CONTACT EXPRESSED CONCERN OVER A POTENTIAL CRASH IF THE FAILURE OCCURRED WHILE DRIVING. THE FAILURE MILEAGE WAS 84,000. UPDATED 08/31/11 *BF
NHTSA ODI #10409111
270,676 miles · May 18, 2011
Steering
TL*THE CONTACT OWNS A 2001 DODGE RAM. THE CONTACT STATED WHILE DRIVING AT ANY SPEEDS THE VEHICLE DRIFTED FROM SIDE TO SIDE. THE CONTACT STATED THE VEHICLE BECAME DIFFICULT TO CONTROL. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO REPLACED THE STEERING BOX BUT THE STEERING BOX DID NOT REMEDY THE FAILURE. THE STEERING BOX WAS RE…
Read full complaint
TL*THE CONTACT OWNS A 2001 DODGE RAM. THE CONTACT STATED WHILE DRIVING AT ANY SPEEDS THE VEHICLE DRIFTED FROM SIDE TO SIDE. THE CONTACT STATED THE VEHICLE BECAME DIFFICULT TO CONTROL. THE CONTACT TOOK THE VEHICLE TO THE DEALER WHO REPLACED THE STEERING BOX BUT THE STEERING BOX DID NOT REMEDY THE FAILURE. THE STEERING BOX WAS REPLACED FIVE TIMES. THE DEALER STATED THAT THE STEERING BOX WAS DEFECTIVE. THE CONTACT CALLED THE MANUFACTURER AND FILED A COMPLAINT BUT THEY HAVE NOT PROVIDED ANY ASSISTANCE. THE CONTACT STATED THE VEHICLE WAS UNSAFE TO DRIVE. THE FAILURE MILEAGE WAS 270,676.
NHTSA ODI #10401490
47,520 miles · Jul 25, 2005
Steering
DT THE RETURN HOSE TO THE POWER STEERING GOT AGAINST THE POWER STEERING PULLEY AND RUBBED A WHOLE IN THE RETURN HOSE AND IT WAS LEAKING FLUID. WHICH MADE IT HAVE NO POWER STEERING. HAVE CONTACTED THE DEALER THEY ORDERED TWO HOSES THAT WERE THE WRONG ONES. THIS HAPPENED JULY 18, 2005.
NHTSA ODI #10129969
Mileage unknown · Jan 12, 2005
Steering
WHILE ATTEMPTING TO PARK THE TRAILER, THE STEERING BOX DESTROYED THE O-RING GASKET WHICH CAUSED THE CONSUMER TO LOSE CONTROL OF THE VEHICLE. *NM *SC *JB
NHTSA ODI #10109758
7,380 miles · Dec 22, 2004
Service Brakes, HydraulicSteeringSuspension
THE STEERING WHEEL WAS HARD TO TURN WHILE DRIVING AT A LOW SPEED. THE VEHICLE WANDERED ACROSS THE ROAD. THE VEHICLE HAS BEEN TO THE DEALER ON THREE SEPARATE OCCASIONS. THE DEALER REPLACED THE STEERING BOX ON TWO SEPARATE OCCASIONS AND MADE SOME OTHER REPAIRS, HOWEVER THE PROBLEM CONTINUED. *JB THE CONSUMER STATED THE BRAKES WO…
Read full complaint
THE STEERING WHEEL WAS HARD TO TURN WHILE DRIVING AT A LOW SPEED. THE VEHICLE WANDERED ACROSS THE ROAD. THE VEHICLE HAS BEEN TO THE DEALER ON THREE SEPARATE OCCASIONS. THE DEALER REPLACED THE STEERING BOX ON TWO SEPARATE OCCASIONS AND MADE SOME OTHER REPAIRS, HOWEVER THE PROBLEM CONTINUED. *JB THE CONSUMER STATED THE BRAKES WOULD GRAB, HOWEVER THE MECHANIC INFORMED THE CONSUMER THAT WAS THE WAY ABS WORKED. *JB
NHTSA ODI #10105235
40 miles · Nov 22, 2004
Steering
THE CONSUMER WAS UNABLE TO STEER THE STEERING WHEEL IN THE RIGHT DIRECTION. THIS HAS ALMOST CAUSED SEVERAL ACCIDENTS. ANOTHER RAM OWNER INDICATED THAT THEY WERE HAVING THE SAME PROBLEM WHICH WAS DUE TO A FAULTY FACTORY STEERING BOX GEAR, THAT WAS REPLACED. THIS TRUCK IS OWNED BY MONTANA DEPT,. OF FISH WILD LIFE AND PARK. THE OTH…
Read full complaint
THE CONSUMER WAS UNABLE TO STEER THE STEERING WHEEL IN THE RIGHT DIRECTION. THIS HAS ALMOST CAUSED SEVERAL ACCIDENTS. ANOTHER RAM OWNER INDICATED THAT THEY WERE HAVING THE SAME PROBLEM WHICH WAS DUE TO A FAULTY FACTORY STEERING BOX GEAR, THAT WAS REPLACED. THIS TRUCK IS OWNED BY MONTANA DEPT,. OF FISH WILD LIFE AND PARK. THE OTHER TRUCK IN THIS FLEET ARE HAVING THE SAME FAILURE. *JB
NHTSA ODI #10101480
51,296 miles · Jun 24, 2004
Steering
WHILE DRIVING, THE VEHICLE WANDERED. *AK OTHER ISSUES RELATED TO THE STEERING PROBLEM WAS THE TRACK BAR, POWER STEERING/GEAR ASSEMBLY, AND THE CLOCK SPRING. *SC *JB
NHTSA ODI #10071972
49,000 miles · Jan 15, 2004
Steering
BALL JOINTS WORN OUT AT 49,000 MILES 3 MECHANICS SAY THIS IS TYPICAL OF THESE DODGE TRUCKS. IF THIS A RECURING PROBLEM, SHOULDN'T DODGE BE DOING SOMTHING ON THIS
NHTSA ODI #10068720
4,000 miles · Dec 4, 2003
Steering
WHILE DRIVING 50-60 MPH, THE CONSUMER NOTICED THE STEERING HAD EXCESSIVE "PLAY." THE TRUCK BEGAN TO SWAY ACROSS THE ROAD. THE TRUCK WAS SERVICED, AND THE STEERING GEAR BOX/TIE ROD AND TRACKING BAR WERE REPLACED. *AK THE MECHANIC FOUND THE POWER STEERING GEAR BOX SLOPPY, THE TIE ROD END/PITMAN ARM LOOSE AND THE TRAC BAR WOR…
Read full complaint
WHILE DRIVING 50-60 MPH, THE CONSUMER NOTICED THE STEERING HAD EXCESSIVE "PLAY." THE TRUCK BEGAN TO SWAY ACROSS THE ROAD. THE TRUCK WAS SERVICED, AND THE STEERING GEAR BOX/TIE ROD AND TRACKING BAR WERE REPLACED. *AK THE MECHANIC FOUND THE POWER STEERING GEAR BOX SLOPPY, THE TIE ROD END/PITMAN ARM LOOSE AND THE TRAC BAR WORN. *SCC *JB
ON CERTAIN VAN AND WAGON VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), AFTERMARKET BATTERIES MAY LEAK ELECTROLYTE ONTO THE ABS CONTROL MODULE CONNECTOR, WHICH CAN COMPROMISE SEALING INTEGRITY OF THE CONNECTOR.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE ABS CONTROL MODULE CONNECTOR FOR ELECTROLYTE DAMAGE AND REPLACE THE CONNECTOR AS NECESSARY. THE RECALL WILL BEGIN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
ON CERTAIN PICKUP TRUCKS, THE ALTERNATOR WIRE CONNECTION TO THE POWER DISTRIBUTION CENTER (PDC) CAN LOOSEN.
Consequence & remedy
Consequence: THIS COULD CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT THE INSTALLATION OF THE ALTERNATOR WIRE CONNECTION TO THE PDC AND IF NECESSARY, REPOSITION THE WIRE SO THAT THE CRIMP CONNECTION WILL FACE UPWARD AND TIGHTEN THE FASTENER TO THE CORRECT TORQUE SETTING. OWNER NOTIFICATION BEGAN MAY 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN 2500 WAGONS WERE EQUIPPED WITH INCORRECT LOAD RANGE TIRES.
Consequence & remedy
Consequence: THIS COULD CAUSE A TIRE TO BLOW OUT IF THE VEHICLE IS OPERATED AT THE MAXIMUM GROSS VEHICLE WEIGHT. .
Remedy: DEALERS WILL REPLACE THE LOAD RANGE 'D' TIRES WITH CORRECT LOAD RANGE 'E' TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: VANS AND WAGONS NOT EQUIPPED WITH POWER FRONT SEATS. IN THE PRESENCE OF ROAD SALT, WATER, AND POSSIBLY OTHER DEBRIS, THE POWER SEAT CONNECTOR LOCATED BENEATH THE DRIVER'S SEAT COULD DEVELOP A HIGH RESISTIVE SHORT CIRCUIT THAT CYCLES THE CIRCUIT BREAKER.
Consequence & remedy
Consequence: IF THE CIRCUIT BREAKER CYCLES FOR AN EXTENDED PERIOD OF TIME, HEAT COULD BUILD UP IN THE CONNECTOR, POSSIBLY RESULTING IN A FIRE.
Remedy: OWNERS WILL RECEIVE INSTRUCTIONS FOR REMOVING THE CIRCUIT BREAKER FROM THE FUSE PANEL. IF AN OWNER DESIRES, THEIR DEALER CAN PERFORM THE REPAIR. OWNER NOTIFICATION BEGAN AUGUST 27, 2001. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: VANS. A SUBSTITUTE WHEEL LUG NUT TIGHTENING PROCESS MAY NOT HAVE BEEN SUFFICIENT TO ASSURE PROPER TORQUE OF THE LUG NUTS.
Consequence & remedy
Consequence: IMPROPER WHEEL LUG NUT TORQUE COULD ALLOW A WHEEL TO LOOSEN AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE WHEEL LUG NUTS FOR PROPER TORQUE AND CORRECT IF NECESSARY. OWNER NOTIFICATION BEGAN JUNE 4, 2001. ALL OWNERS HAVE BEEN CONTACTED.
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS EQUIPPED WITH A CAMPER PACKAGE AND OVERLOAD SPRINGS. THE REAR AXLE SPACER PLATE COULD LEAD TO DEFORMATION OF THE UPPER SPRING PLATE DURING ASSEMBLY OF THE AXLE TO THE VEHICLE RESULTING A SOFT JOINT.
Consequence & remedy
Consequence: THE SOFT JOINT COULD CAUSE THE REAR AXLE U-BOLTS TO LOSE CLAMP LOAD, RESULTING IN DISPLACEMENT OF THE REAR AXLE AND A LOSS OF VEHICLE CONTROL. THIS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REMOVE THE SPACER PLATES AND THE SPRING PLATES WILL BE REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS. THE UPPER CONTROL ARMS ATTACHED WITH CADMIUM COATED NUTS CAN CAUSE THE BOLTS TO STRETCH DUE TO THE APPLICATION OF A HIGHER THAN SPECIFIED CLAMP LOAD. BREAKAGE OF THE UPPER CONTROL ARM FASTENERS COULD CAUSE THE AXLE TO ROTATE FORWARD UNDER BRAKING CONDITIONS.
Consequence & remedy
Consequence: THIS ROTATION COULD TWIST THE STEERING LINKAGE AND POSSIBLY SEPARATE THE BRAKE LINES, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE UPPER CONTROL ARM BOLTS AND NUTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
PE08047 · 2000-2001 Dodge RAM Pickup Hood Latch
Opened Jul 25, 2008 · Closed Dec 17, 2008
Status: closed (inferred from source dates) · Latches/locks/linkages:hood:latch; Structure:body:hood:hinge And Attachments
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
Additional source detail variants (2)
Latches/locks/linkages:hood:latch
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
Structure:body:hood:hinge And Attachments
THE AGENCY OPENED THIS INVESTIGATION BASED ON 30 COMPLAINTS ALLEGING THAT THE HOODS ON MODEL YEAR (MY) 2000 AND 2001 DODGE RAM PICKUP TRUCKS FLEW UP AND BLOCKED THE DRIVER'S VISION.THESE VEHICLES HAVE A PRIMARY HOOD LATCH AND A SECONDARY (BACKUP) HOOD LATCH.THE SECONDARY LATCH IS DESIGNED TO SECURE THE HOOD IF THE PRIMARY HOOD LATCH IS NOT PROPERLY CLOSED OR OTHERWISE MALFUNCTIONS.IN THESE COMPLAINTS, THE SECONDARY HOOD LATCH MALFUNCTIONED, APPARENTLY DUE TO CORROSION, AND DID NOT LATCH.DODGE CONDUCTED RECALL 01V-040 IN 1999 TO ADDRESS SIMILAR PROBLEMS ON MODEL YEAR 1994-1997 DODGE RAM PICKUP TRUCKS.THE INFORMATION CHRYSLER PROVIDED IN RESPONSE TO ODI'S INFORMATION REQUEST LETTER INDICATED THAT THE MY 2000 AND 2001 VEHICLES WERE EQUIPPED WITH SECONDARY HOOD LATCHES WITH STAINLESS STEEL RETURN SPRINGS, AS OPPOSED TO THE EARLIER RECALLED TRUCKS THAT HAD ZINC COATED CARBON STEEL RETURN SPRINGS.THE RECALLED COMPONENTS WERE SUSCEPTIBLE TO CORROSION-INDUCED FAILURE DUE TO THE TYPE OF MATERIAL USED, WHEREAS THE CORROSION FAILURES IN THE NEWER MODELS APPEAR TO BE DUE TO LUBRICATION LOSS OVER TIME (REGULAR APPLICATION OF GREASE IS ADVISED PER INSTRUCTIONS IN THE OWNERS' MANUAL). ODI'S REVIEW OF CHRYSLER'S WARRANTY, COMPLAINT, AND INJURY DATA FOR THE 2000 AND 2001 VEHICLES INDICATES THAT THE RATES FOR SUBJECT VEHICLES ARE LOW AND ARE DECLINING.A POTENTIAL DEFECT TREND HAS NOT BEEN IDENTIFIED.THIS INVESTIGATION IS CLOSED.
2001 Dodge RAM Problems, Complaints & Recalls | Skip That Year
Illustration