NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
32 reportsClear category filter47,640 miles · Dec 13, 2005
Service Brakes, Hydraulic
DT: THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS LESS THAN 10 MPH, THE ABS PUMP ACTIVATED, CAUSING DIFFICULTY IN DEPRESSING THE BRAKE PEDAL. THIS OCCURRED ON DRY ROAD CONDITIONS AND UNDER NORMAL BRAKING. THERE WERE NO WARNING INDICATORS PRIOR TO THE FIRST INCIDENT. HE TOOK THE VEHICLE TO A NEARBY GARAGE, WHO REPLACED THE…
Read full complaint
DT: THE CONTACT STATED WHILE DRIVING AT LOW SPEEDS LESS THAN 10 MPH, THE ABS PUMP ACTIVATED, CAUSING DIFFICULTY IN DEPRESSING THE BRAKE PEDAL. THIS OCCURRED ON DRY ROAD CONDITIONS AND UNDER NORMAL BRAKING. THERE WERE NO WARNING INDICATORS PRIOR TO THE FIRST INCIDENT. HE TOOK THE VEHICLE TO A NEARBY GARAGE, WHO REPLACED THE ABS SENSOR AND THE ABS MODULATOR. THE GARAGE THEN TOOK THE VEHICLE TO THE DEALERSHIP TO HAVE THE CODES PUT IN FOR THE ABS MODULATOR. THE VEHICLE HAD THE SAME PROBLEM AGAIN. THE MANUFACTURER WAS CONTACTED, AND THEY TOLD THE CONTACT TO TAKE THE VEHICLE TO THE DEALERSHIP. NO REPAIRS HAVE BEEN MADE. *AK UPDATED 1/11/2006. *NM
NHTSA ODI #10145089
9,079 miles · Oct 31, 2005
Service Brakes, Hydraulic
DT: THE CONTACT COMPLAINED ABOUT BRAKE FAILURE ON FOUR DIFFERENT OCCASIONS. THERE WERE NO WARNING SIGNS, INDICATING A PROBLEM WITH THE BRAKE SYSTEM. WHEN BRAKES FAIL THERE IS ALSO LOSS OF STEERING CONTROL. WHEN THE BRAKES ARE APPLIED THE PEDAL WILL GO ALL THE WAY TO THE FLOOR. THE ONLY WAY TO STOP THE VEHICLE IS TO APPLY…
Read full complaint
DT: THE CONTACT COMPLAINED ABOUT BRAKE FAILURE ON FOUR DIFFERENT OCCASIONS. THERE WERE NO WARNING SIGNS, INDICATING A PROBLEM WITH THE BRAKE SYSTEM. WHEN BRAKES FAIL THERE IS ALSO LOSS OF STEERING CONTROL. WHEN THE BRAKES ARE APPLIED THE PEDAL WILL GO ALL THE WAY TO THE FLOOR. THE ONLY WAY TO STOP THE VEHICLE IS TO APPLY THE HAND BRAKE. THE DEALER TRIED TO REPAIR THE VEHICLE ON THREE DIFFERENT OCCASIONS. AFTER A PERIOD OF TIME THE BRAKES WILL FAIL AGAIN. THE DEALER SUGGESTED THE PROBLEM COULD BE WITHIN THE POWER BOOSTER PUMP AND THE MASTER CYLINDER. *AK UPDATED 11/19/05. *JB
NHTSA ODI #10141290
48,000 miles · Oct 14, 2005
Service Brakes, HydraulicStructure
DT: WHILE DRIVING DOWN A HILL THE BRAKES WENT OUT. THE CONTACT WAS ABLE TO GET IT SAFELY OFF THE HIGHWAY. THIS OCCURRED ON AUGUST 15, 2005. THE CONTACT TOOK VEHICLE TO A MECHANIC. THEY SAID THAT IT WAS DUE TO THE WAY THAT THE VAN WAS BUILT. HE SAID THAT IT CAUSED THE BATTERY TO LEAK AND BURN A WHOLE IN THE BRAKE LINE. T…
Read full complaint
DT: WHILE DRIVING DOWN A HILL THE BRAKES WENT OUT. THE CONTACT WAS ABLE TO GET IT SAFELY OFF THE HIGHWAY. THIS OCCURRED ON AUGUST 15, 2005. THE CONTACT TOOK VEHICLE TO A MECHANIC. THEY SAID THAT IT WAS DUE TO THE WAY THAT THE VAN WAS BUILT. HE SAID THAT IT CAUSED THE BATTERY TO LEAK AND BURN A WHOLE IN THE BRAKE LINE. THE VEHICLE IS STILL AT THE MECHANIC'S SHOP. THE CONTACT WAS CONCERNED THAT SOMEONE ELSE COULD HAVE AN ACCIDENT DUE TO THE PROBLEM WITH THE VEHCILE'S STRUCTURE. *AK
NHTSA ODI #10139725
36,000 miles · Sep 29, 2005
Air BagsService Brakes, HydraulicCrashInjury
DT: ON AUGUST 30, 2005 THE CALLER'S HUSBAND WAS INVOLVED IN AN ACCIDENT WHILE TRAVELING 25 MPH. UPON IMPACT, THE AIRBAGS DID NOT DEPLOY. THE CALLER'S VEHICLE HIT A SCHOOL BUS. THERE WAS NO INDICATION THAT THE AIR BAG WOULD NOT DEPLOY. CALLER'S HUSBAND WAS INJURED. A POLICE REPORT WAS TAKEN. THE DEALER AND MANUFACTURER WERE NOT…
Read full complaint
DT: ON AUGUST 30, 2005 THE CALLER'S HUSBAND WAS INVOLVED IN AN ACCIDENT WHILE TRAVELING 25 MPH. UPON IMPACT, THE AIRBAGS DID NOT DEPLOY. THE CALLER'S VEHICLE HIT A SCHOOL BUS. THERE WAS NO INDICATION THAT THE AIR BAG WOULD NOT DEPLOY. CALLER'S HUSBAND WAS INJURED. A POLICE REPORT WAS TAKEN. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. CALLER SAID A WEEK BEFORE THE WRECK SHE HAD THE VEHICLE AT THE DEALER FOR BRAKES, SHE SAID THE BRAKES LOCKED AND THE TIRES MADE A SCREECHING SOUND. SHE DID NOT KNOW IF THE BRAKES AND THE ACCIDENT WERE CONNECTED.*AK THE CONSUMER STATED THERE WAS ANOTHER ACCIDENT PRIOR IN WHICH THE AIR BAGS DID NOT DEPLOY. *JB
NHTSA ODI #10135373
40,000 miles · Aug 26, 2005
Service Brakes, HydraulicStructureSuspension
DT: WAS PULLING A TRAILER AT 45 MPH THE VEHICLE STARTED FISH TAILING. WITHOUT THE TRAILER AT 55 MPH THE VEHICLE WILL FISH TAIL. TOOK THE VEHICLE TO CHRYSLER , AND FOUND THAT IT WAS SHAKY. THE TIE RODS ENDS, BALL JOINTS, AND THE CHECK BAR MALFUNCTIONED ON THE FRONT OF THE VEHICLE. ALMOST HAD A WRECK. THIS HAPPENED ON 24, J…
Read full complaint
DT: WAS PULLING A TRAILER AT 45 MPH THE VEHICLE STARTED FISH TAILING. WITHOUT THE TRAILER AT 55 MPH THE VEHICLE WILL FISH TAIL. TOOK THE VEHICLE TO CHRYSLER , AND FOUND THAT IT WAS SHAKY. THE TIE RODS ENDS, BALL JOINTS, AND THE CHECK BAR MALFUNCTIONED ON THE FRONT OF THE VEHICLE. ALMOST HAD A WRECK. THIS HAPPENED ON 24, JUNE 2205. *AK THE CONSUMER STATED THE VEHICLE WAS POORLY DESIGNED, THE FRONT OF THE VEHICLE WAS TOO LIGHT FOR THE WEIGHT OF THE ENGINE. THERE WAS NO GREASE FITTING FOR THE BALL JOINT. THE ROTORS WERE REPLACED.*JB
NHTSA ODI #10129669
Mileage unknown · Mar 17, 2005
Air BagsService Brakes, HydraulicCrashInjury
THE BRAKE PEDAL WENT TO THE FLOOR WHILE TRAVELING ON THE HIGHWAY. THIS CAUSED CONSUMER'S VEHICLE TO REAR END A TRACTOR TRAILER, LOST CONTROL OF THE VEHICLE, AND FLIPPED TWICE , LANDING ON THE SHOULDER OF THE HIGHWAY. UPON IMPACT, BOTH AIR BAGS DID NOT DEPLOY. DRIVER SUSTAINED HEAD AND BACK INJURIES, AND WAS TRANSPORTED BY AMBU…
Read full complaint
THE BRAKE PEDAL WENT TO THE FLOOR WHILE TRAVELING ON THE HIGHWAY. THIS CAUSED CONSUMER'S VEHICLE TO REAR END A TRACTOR TRAILER, LOST CONTROL OF THE VEHICLE, AND FLIPPED TWICE , LANDING ON THE SHOULDER OF THE HIGHWAY. UPON IMPACT, BOTH AIR BAGS DID NOT DEPLOY. DRIVER SUSTAINED HEAD AND BACK INJURIES, AND WAS TRANSPORTED BY AMBULANCE TO A HOSPITAL. THE VEHICLE WAS TOWED. *AK
NHTSA ODI #10115366
Mileage unknown · Dec 28, 2004
Air BagsService Brakes, HydraulicCrash
WHEN THE CONSUMER APPLIED THE BRAKES, THE PEDAL WENT TO THE FLOOR. THE CONSUMER WAS UNABLE TO MAINTAIN CONTROL OF THE VEHICLE AND REAR ENDED ANOTHER VEHICLE. BOTH AIR BAGS DID NOT DEPLOY. NO INJURIES. THE VEHICLE WAS TOWED AND TOTALED BY THE INSURANCE COMPANY. PLEASE FILL IN ADDITIONAL INFORMATION. *JB
NHTSA ODI #10105466
7,380 miles · Dec 22, 2004
Service Brakes, HydraulicSteeringSuspension
THE STEERING WHEEL WAS HARD TO TURN WHILE DRIVING AT A LOW SPEED. THE VEHICLE WANDERED ACROSS THE ROAD. THE VEHICLE HAS BEEN TO THE DEALER ON THREE SEPARATE OCCASIONS. THE DEALER REPLACED THE STEERING BOX ON TWO SEPARATE OCCASIONS AND MADE SOME OTHER REPAIRS, HOWEVER THE PROBLEM CONTINUED. *JB THE CONSUMER STATED THE BRAKES WO…
Read full complaint
THE STEERING WHEEL WAS HARD TO TURN WHILE DRIVING AT A LOW SPEED. THE VEHICLE WANDERED ACROSS THE ROAD. THE VEHICLE HAS BEEN TO THE DEALER ON THREE SEPARATE OCCASIONS. THE DEALER REPLACED THE STEERING BOX ON TWO SEPARATE OCCASIONS AND MADE SOME OTHER REPAIRS, HOWEVER THE PROBLEM CONTINUED. *JB THE CONSUMER STATED THE BRAKES WOULD GRAB, HOWEVER THE MECHANIC INFORMED THE CONSUMER THAT WAS THE WAY ABS WORKED. *JB
NHTSA ODI #10105235
26,000 miles · Jan 15, 2004
Fuel System, GasolineService Brakes, Hydraulic
FRONT BRAKES FAIL AT 20,000 MILES +/-. VEHICLE HAS 53,000 MILES AND IS READY FOR FOURTH SET OF FRONT BRAKES. DEALER CLAIMS THAT THIS IS NORMAL WEAR AND THAT 20,000 MILES IS NORMAL SERVICE LIFE FOR BRAKES.
NHTSA ODI #10070829
12,485 miles · Jul 31, 2003
Service Brakes, Hydraulic
CONSUMER STATES THAT THE BRAKE CALIPERS SEIZED WHILE DRIVING RESULTING IN LOSS OF BRAKE FUNCTION, ALMOST CAUSING A COLLISION. *PH
NHTSA ODI #10031659
Official recalls
9Apr 12, 2004
ON CERTAIN VAN AND WAGON VEHICLES EQUIPPED WITH 4-WHEEL ANTILOCK BRAKE SYSTEMS (ABS), AFTERMARKET BATTERIES MAY LEAK ELECTROLYTE ONTO THE ABS CONTROL MODULE CONNECTOR, WHICH CAN COMPROMISE SEALING INTEGRITY OF THE CONNECTOR.
Consequence & remedy
Consequence: THIS MAY ALLOW DEVELOPMENT OF A SHORT CIRCUIT IN THE CONNECTOR, WHICH COULD EVENTUALLY LEAD TO A FIRE.
Remedy: DEALERS WILL INSPECT THE ABS CONTROL MODULE CONNECTOR FOR ELECTROLYTE DAMAGE AND REPLACE THE CONNECTOR AS NECESSARY. THE RECALL WILL BEGIN ON SEPTEMBER 27, 2004. OWNERS SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Feb 7, 2002
ON CERTAIN PICKUP TRUCKS, THE ALTERNATOR WIRE CONNECTION TO THE POWER DISTRIBUTION CENTER (PDC) CAN LOOSEN.
Consequence & remedy
Consequence: THIS COULD CAUSE A VEHICLE FIRE.
Remedy: DEALERS WILL INSPECT THE INSTALLATION OF THE ALTERNATOR WIRE CONNECTION TO THE PDC AND IF NECESSARY, REPOSITION THE WIRE SO THAT THE CRIMP CONNECTION WILL FACE UPWARD AND TIGHTEN THE FASTENER TO THE CORRECT TORQUE SETTING. OWNER NOTIFICATION BEGAN MAY 20, 2002. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Sep 10, 2001
VEHICLE DESCRIPTION: CERTAIN 2500 WAGONS WERE EQUIPPED WITH INCORRECT LOAD RANGE TIRES.
Consequence & remedy
Consequence: THIS COULD CAUSE A TIRE TO BLOW OUT IF THE VEHICLE IS OPERATED AT THE MAXIMUM GROSS VEHICLE WEIGHT. .
Remedy: DEALERS WILL REPLACE THE LOAD RANGE 'D' TIRES WITH CORRECT LOAD RANGE 'E' TIRES. OWNER NOTIFICATION BEGAN SEPTEMBER 24, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Aug 2, 2001
VEHICLE DESCRIPTION: VANS AND WAGONS NOT EQUIPPED WITH POWER FRONT SEATS. IN THE PRESENCE OF ROAD SALT, WATER, AND POSSIBLY OTHER DEBRIS, THE POWER SEAT CONNECTOR LOCATED BENEATH THE DRIVER'S SEAT COULD DEVELOP A HIGH RESISTIVE SHORT CIRCUIT THAT CYCLES THE CIRCUIT BREAKER.
Consequence & remedy
Consequence: IF THE CIRCUIT BREAKER CYCLES FOR AN EXTENDED PERIOD OF TIME, HEAT COULD BUILD UP IN THE CONNECTOR, POSSIBLY RESULTING IN A FIRE.
Remedy: OWNERS WILL RECEIVE INSTRUCTIONS FOR REMOVING THE CIRCUIT BREAKER FROM THE FUSE PANEL. IF AN OWNER DESIRES, THEIR DEALER CAN PERFORM THE REPAIR. OWNER NOTIFICATION BEGAN AUGUST 27, 2001. OWNERS WHO DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jun 5, 2001
VEHICLE DESCRIPTION: VANS. A SUBSTITUTE WHEEL LUG NUT TIGHTENING PROCESS MAY NOT HAVE BEEN SUFFICIENT TO ASSURE PROPER TORQUE OF THE LUG NUTS.
Consequence & remedy
Consequence: IMPROPER WHEEL LUG NUT TORQUE COULD ALLOW A WHEEL TO LOOSEN AND CAUSE A CRASH WITHOUT WARNING.
Remedy: DEALERS WILL INSPECT THE WHEEL LUG NUTS FOR PROPER TORQUE AND CORRECT IF NECESSARY. OWNER NOTIFICATION BEGAN JUNE 4, 2001. ALL OWNERS HAVE BEEN CONTACTED.
May 8, 2001
VEHICLE DESCRIPTION: PICKUP TRUCKS. SOUND DEADENER MATERIAL INSIDE THE STEERING WHEEL COULD BECOME DETACHED FROM THE COVER AND HOUSING. NOTE: THE RAM PICKUP TRUCKS WERE BUILT AT THE WARREN ASSEMBLY PLANT ("S" IN THE 11TH VIN POSITION) FROM MAY 16, 2000 THROUGH OCTOBER 23, 2000; ST. LOUIS NORTH ASSEMBLY PLANT ("J" IN THE 11TH VIN POSITION) FROM MAY 19, 2000 THROUGH OCTOBER 23, 2000; LAGO ALBERTO ASSEMBLY PLANT ("M" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000; AND SALTILLO ASSEMBLY PLANT ("G" IN THE 11TH VIN POSITION) FROM MAY 23, 2000 THROUGH OCTOBER 23, 2000. IMPORTANT: VEHICLES THAT HAVE ALREADY HAD THE PROPER CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN EXCLUDED FROM THIS RECALL. IN ADDITION, 1997-2000 MODEL YEAR VEHICLES THAT HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, ACCORDING TO WARRANTY RECORDS, HAVE BEEN ADDED TO THIS RECALL.
Consequence & remedy
Consequence: WHEN THIS OCCURS, THE MATERIAL COULD INTERFERE WITH THE CLOCKSPRING RIBBON AND CAUSE AN OPEN CIRCUIT. THE DRIVER AIR BAG SYSTEM WILL BECOME DISABLED, AND THE AIR BAG WARNING LAMP WILL ILLUMINATE ON THE INSTRUMENT PANEL.
Remedy: DEALERS WILL REPLACE THE CLOCKSPRING ASSEMBLY. OWNER NOTIFICATION BEGAN JUNE 18, 2001. ALSO SOME 1997-200 MODEL YEAR VEHICLES THAT, ACCORDING TO WARRANTY RECORDS, HAVE HAD A SUSPECT REPLACEMENT CLOCKSPRING INSTALLED, WILL ALSO BE INCLUDED IN THIS CAMPAIGN. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Jan 5, 2001
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS EQUIPPED WITH A CAMPER PACKAGE AND OVERLOAD SPRINGS. THE REAR AXLE SPACER PLATE COULD LEAD TO DEFORMATION OF THE UPPER SPRING PLATE DURING ASSEMBLY OF THE AXLE TO THE VEHICLE RESULTING A SOFT JOINT.
Consequence & remedy
Consequence: THE SOFT JOINT COULD CAUSE THE REAR AXLE U-BOLTS TO LOSE CLAMP LOAD, RESULTING IN DISPLACEMENT OF THE REAR AXLE AND A LOSS OF VEHICLE CONTROL. THIS COULD INCREASE THE RISK OF A CRASH.
Remedy: DEALERS WILL REMOVE THE SPACER PLATES AND THE SPRING PLATES WILL BE REPLACED. OWNER NOTIFICATION BEGAN FEBRUARY 5, 2001. OWNERS WHO TAKE THEIR VEHICLES TO AN AUTHORIZED DEALER ON AN AGREED UPON SERVICE DATE AND DO NOT RECEIVE THE FREE REMEDY WITHIN A REASONABLE TIME SHOULD CONTACT DAIMLERCHRYSLER AT 1-800-853-1403.
Nov 9, 2000
VEHICLE DESCRIPTION: CERTAIN PASSENGER VEHICLES, PICKUP TRUCKS AND SPORT UTILITY VEHICLES FAIL TO COMPLY WITH THE REQUIREMENTS OF FMVSS NO. 225, "CHILD RESTRAINT ANCHORAGE SYSTEMS." SOME OF THE OWNER'S MANUALS FOR THESE VEHICLES ARE MISSING INSTRUCTIONS THAT PROVIDE A STEP-BY-STEP PROCEDURE, INCLUDING DIAGRAMS, FOR PROPERLY ATTACHING A CHILD RESTRAINT SYSTEM'S TETHER STRAP TO THE TETHER ANCHORAGE.
Consequence & remedy
Consequence: IN THE EVENT OF A CRASH, THE CHILD SEAT MAY NOT BE PROPERLY ATTACHED INCREASING THE RISK OF INJURY TO THE CHILD.
Remedy: OWNERS WILL BE PROVIDED WITH AN ADDENDUM TO THE OWNER'S MANUALS.
Oct 12, 2000
VEHICLE DESCRIPTION: QUAD CAB PICKUP TRUCKS. THE UPPER CONTROL ARMS ATTACHED WITH CADMIUM COATED NUTS CAN CAUSE THE BOLTS TO STRETCH DUE TO THE APPLICATION OF A HIGHER THAN SPECIFIED CLAMP LOAD. BREAKAGE OF THE UPPER CONTROL ARM FASTENERS COULD CAUSE THE AXLE TO ROTATE FORWARD UNDER BRAKING CONDITIONS.
Consequence & remedy
Consequence: THIS ROTATION COULD TWIST THE STEERING LINKAGE AND POSSIBLY SEPARATE THE BRAKE LINES, INCREASING THE RISK OF A CRASH.
Remedy: DEALERS WILL REPLACE THE UPPER CONTROL ARM BOLTS AND NUTS.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
Illustration