WAS DRIVING AND HEADLIGHTS UNEXPECTEDLY WENT OUT. TURNED SWITCH OFF AND BACK ON AND LIGHTS WOULD COME BACK ON EACH TIME, BUT WOULD IMMEDIATELY GO BACK OFF. DID SO THREE CONSECUTIVE TIMES. TURNED ON EMERGENCY FLASHERS TO GET HOME. THEY WENT OFF A TOTAL OF 6 TIMES IN A 3 MILE TRIP. I FOUND A RECALL ON LIGHT DUTY ONLY, BUT NOTHIN…
Read full complaint
WAS DRIVING AND HEADLIGHTS UNEXPECTEDLY WENT OUT. TURNED SWITCH OFF AND BACK ON AND LIGHTS WOULD COME BACK ON EACH TIME, BUT WOULD IMMEDIATELY GO BACK OFF. DID SO THREE CONSECUTIVE TIMES. TURNED ON EMERGENCY FLASHERS TO GET HOME. THEY WENT OFF A TOTAL OF 6 TIMES IN A 3 MILE TRIP. I FOUND A RECALL ON LIGHT DUTY ONLY, BUT NOTHING ON MY TRUCK. THEY NEED TO BE INCLUDED IN THE RECALL. THIS IS VERY HAZARDOUS , ALMOST WRECKED THE TRUCK BECAUSE THIS HAPPENED AT 1130 AT NIGHT WHEN I WENT TO PICK UP MY SON FROM A FOOTBALL GAME. I WAS ON VERY DANGEROUS SWITCH-BACK CURVES WHEN THEY WENT OUT THE THREE CONSECUTIVE TIMES. *TR
NHTSA ODI #10643097
80,000 miles · Dec 4, 2010
Electrical SystemStructure
DASH STARTED TO BRAKE ON MY 1997 DODGE 3500 TRUCK LEAVING SHARP EDGES, I HAVE LOST APPROX 50% OF THE TOP OF DASH EXPOSING ELECTRICAL WIRING AT PRESENT UNABLE TO USE A/C AS SMALL PIECES OF PLASTIC FLY UP OCCASIONALLY I HAVE A DASH MAT AT THE PRESENT TIME AND STILL CANNOT USE A/C SOMETHING NEEDS TO BE DONE CONCERNING THE SAFETY …
Read full complaint
DASH STARTED TO BRAKE ON MY 1997 DODGE 3500 TRUCK LEAVING SHARP EDGES, I HAVE LOST APPROX 50% OF THE TOP OF DASH EXPOSING ELECTRICAL WIRING AT PRESENT UNABLE TO USE A/C AS SMALL PIECES OF PLASTIC FLY UP OCCASIONALLY I HAVE A DASH MAT AT THE PRESENT TIME AND STILL CANNOT USE A/C SOMETHING NEEDS TO BE DONE CONCERNING THE SAFETY OF PEOPLE NO-ONE IN FLORIDA IS COMFORTABLE DRIVING WITH NO A/C AND I DON NOT THINK I SHOULD DRIVE WITH A MAT COVERING THE DASH FOR THE NEXT 5 OR SO YEARS I HAVE COMPLAINED TO DODGE AND THEY JUST IGNORE THE FACT THEY USE DEFECTIVE MATERIAL. *TR
NHTSA ODI #10369210
147,000 miles · Jan 22, 2006
Electrical SystemFire
MY 1997 DODGE RAM 3500 WAS STARTED AND IDLING WHILE MY DAUGHTER RAN TO THE BARN TO GET SOMETHING. UPON HER RETURN (@3 - 5 MINUTES), THE CAB WAS FULL OF SMOKE. SHE JUMPED IN AND TURNED THE TRUCK OFF AND NOTICED FLAMES AT HER FEET; STOMPED THEM OUT AND CALLED 911. TRUCK WAS TOTALLY ENGULFED IN FLAMES WHEN FIRE DEPT. ARRIVED (WE …
Read full complaint
MY 1997 DODGE RAM 3500 WAS STARTED AND IDLING WHILE MY DAUGHTER RAN TO THE BARN TO GET SOMETHING. UPON HER RETURN (@3 - 5 MINUTES), THE CAB WAS FULL OF SMOKE. SHE JUMPED IN AND TURNED THE TRUCK OFF AND NOTICED FLAMES AT HER FEET; STOMPED THEM OUT AND CALLED 911. TRUCK WAS TOTALLY ENGULFED IN FLAMES WHEN FIRE DEPT. ARRIVED (WE LIVE LESS THAN 2 MILES FROM F.D.) INVESTIGATION BY FIREMEN SAID "ELECTRICAL FIRE". *NM
NHTSA ODI #10148326
118,000 miles · Jul 14, 2004
Electrical System
POSITIONING OF THE VEHICLE BATTERY AND BATTERY TRAY PERMITS LEAKING BATTERY ACID TO DRIP DOWN ONTO THE CRUISE CONTROL SERVO, VACUUM LINES, AND ELECTRICAL WIRES.*AK
NHTSA ODI #10081017
Mileage unknown · Nov 25, 2002
Electrical System
CONSUMER CALLED COMPLAINING ABOUT HAVING PROBLEMS WITH SAFETY HEAD LAMP. ALSO STATED THAT THERE WAS A RECALL FOR THE HEADLAMP THAT DID NOT INCLUDE HER VEHICLE BUT IS EXPERIENCING THE SAME PROBLEM. TS
NHTSA ODI #8023245
Mileage unknown · Aug 9, 2001
Electrical System
HEADLIGHTS SWITCHED FROM HI TO LOW AT NIGHT WHILE DRIVING WHEN THE BRAKES WERE APPLIED. DEALER HAS YET TO BE CONTACTED. PLEASE PROVIDE FURTHER DETAILS.*AK
VEHICLE DESCRIPTION: MODEL 3500 LIGHT DUTY TRUCKS ONLY. OPERATION OF THE HEADLAMPS OVER AN EXTENDED PERIOD OF TIME CAN RESULT IN HEADLAMP SWITCH FAILURE, CAUSING THE HEADLAMPS OR PARK LAMPS TO GO OUT.
Consequence & remedy
Consequence: IF THE LIGHTS FAIL, A VISIBILITY PROBLEM COULD OCCUR, INCREASING THE RISK OF A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HEADLAMP SWITCH INCLUDING A RELAY IN THE PARK LAMP WIRING CIRCUIT.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
1
DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
1997 Dodge RAM 3500 Problems, Complaints & Recalls | Skip That Year
Illustration