NHTSA owner reports · September 18, 2026 snapshot.
Visibility complaints
4 reportsClear category filterMileage unknown · Jun 27, 2000
Electrical SystemEngine And Engine CoolingExterior Lighting
HEADLIGHTS GO ON & OFF WITH TILT WHEEL (DEALER FIXED BY REPLACING SWITCH AND TAPING BURNED WIRES :( ). FAN AND POWER WINDOWS FUNCTION WITH KEY REMOVED FROM VEHICLE WITHTILT WHEEL IN UP POSTION REMOVAL OF COLUMN COVER SHOWS BURNED RUBBER EXPOSED WIRES. PROBLEM HAS RENDERED THE UPPER FUSE BOX WITH NO POWER AND NO HEATER OR POWER …
Read full complaint
HEADLIGHTS GO ON & OFF WITH TILT WHEEL (DEALER FIXED BY REPLACING SWITCH AND TAPING BURNED WIRES :( ). FAN AND POWER WINDOWS FUNCTION WITH KEY REMOVED FROM VEHICLE WITHTILT WHEEL IN UP POSTION REMOVAL OF COLUMN COVER SHOWS BURNED RUBBER EXPOSED WIRES. PROBLEM HAS RENDERED THE UPPER FUSE BOX WITH NO POWER AND NO HEATER OR POWER WINDOWS. ALL THESE PROBLEMS OCCURR FROM THE WHEEL PINCHING THE WIRES INSIDE. AT TIME S A BURNING ODOR CAN BE SMELLED.
NHTSA ODI #724628
Mileage unknown · Mar 24, 1997
Visibility
OWNER STATES THAT FRONT WINDSHIELD KEEPS BREAKING, HE ALSO NOTES THAT WHEN DOOR IS SHUT OR WHEN DRIVING ON THE HIGHWAY THE WINDSHIELD CRACKS, DEALER SAID THAT IT WAS STRESS CRACKS. *AK
NHTSA ODI #809045
Mileage unknown · Jul 31, 1995
Visibility
WINDSHIELD BREAKS WITHOUT ANYTHING HITTING IT. HAPPENED FOUR TIMES. TT
NHTSA ODI #969610
Mileage unknown · Jan 4, 1995
Visibility
FRONT WINDSHIELD CRACKED WHILE DRIVING; NO APPARENT REASON; OWNER BELIEVES MANUFACTURING DEFECT WHILE INSTALLING OR WITH GLASS ITSELF. TT
NHTSA ODI #958231
NHTSA investigations
8DP03006 · Seat Back Failure
Opened Sep 23, 2003 · Closed Apr 8, 2004
Status: closed (inferred from source dates) · Seats; Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Additional source detail variants (2)
Seats
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
Seats:front Assembly:recliner
ODI HAS IDENTIFIED 30 INCIDENTS WHERE IT IS ALLEGED THE SEAT BACK COLLAPSED IN A REAR IMPACT CRASH.THESE INCIDENTS ARE ALLEGED TO HAVE CONTRIBUTED TO 23 INJURIES AND TWO DEATHS.THE DATA PRESENTED TO ODI SHOW THAT THE SEAT BACK STRENGTH OF THE FRONT SEATS COMPLY WITH FEDERAL MOTOR VEHICLE SAFETY STANDARD NO. 207. SEATING SYSTEM.ACCORDING TO DAIMLERCHRYLSER THE FRONT SEATS WERE DESIGNED TO COLLAPSE REARWARD IN REAR IMPACT CRASHES AS PART OF THE ENERGY ABSORPTIONCAPABILITIES OF THE SEATING SYSTEM TO REDUCE THE CHANCE OF SERIOUS INJURY TO THE OCCUPANT.RATES OF OCCURANCE WERE COMPARED TO PEER VEHICLES, AND IT WAS SHOWN THAT THE PERFORMACE OF THE SUBJECT VEHICLE WAS COMPARABLE TO THOSE VEHICLES.IN VIEW OF THE FORGOING, IT IS UNLIKELY THAT NHTSA WOULD ISSUE AN ORDER FOR THE NOTIFICATION REMEDY OF A SAFETY DEFECT IN THE SUBJECT VEHICLES AS DEFINED BY THE PETITIONER AT THE CONCLUSION OF THE INVESTIGATION REQUESTED IN THE PETITION.THERFORE, IN VIEW OF THE NEED TO ALLOCATE AND PRIORITIZE THE NHTSA'S LIMITED RESOURCES TO BEST ACCOMPLISH THE AGENCY'S MISSION, THE PETITION IS DENIED.FOR FURTHER DETAILS, REFER TO ODI'S RESPONSE TO THE PETITION PUBLISHED IN THE FEDERAL REGISTER VOL.69, NO. 60 , DATED MARCH 29, 2004.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
PE00048 · Loss Of Throttle Control
Opened Dec 11, 2000 · Closed Mar 7, 2001
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
ALLEGED THAT THE THROTTLE CABLE CAN FRAY OR SEVER DURING NORMAL USE RESULTING IN THE THROTTLE NOT RETURNING TO IDLE OR AN INABILITY TO ACCELERATE.
PE99026 · Front Suspension Spring/shock Absorber
Opened Apr 16, 1999 · Closed Aug 31, 1999
Status: closed (inferred from source dates) · Suspension
ALLEGE FAILURE OF THE COIL SPRING/SHOCK ABSORBER BRACKET AT ITS ATTACHMENT TO THE VEHICLE FRAME MAY ALLOW COLLAPSE OF THE FRONT SUSPENSION, AND POTENTIALLY AFFECT STEERING OR BRAKING SYSTEM PERFORMANCE
EA98010 · Headlight Circuit
Opened May 8, 1998 · Closed Dec 10, 1999
Status: closed (inferred from source dates) · Exterior Lighting
THE HEADLAMP SWITCH IN THE SUBJECT VEHICLES CAN OVER-HEAT AND FAIL RESULTING IN LOSS OF HEAD LAMPS AND POSSIBLY OTHER LIGHTS.DAIMLERCHRYSLER CONDUCTED A SERIES OF TESTS AND DETERMINED THAT THE 3500 SERIES IS PRONE TO GENERATING HEAD LAMP SWITCH TEMPERATURES IN EXCESS OF THE SWITCH LUBRICANT THRESHOLD OF 100 DEGREES CENTIGRADE.WHEN THIS OCCURS, THE LUBRICANT SOLIDIFIES AND ADHERES TO THE SWITCH CONTACH SURFACES INCREASING INTERNAL RESISTANCE AND THERFORE, TEMPERATURE.DAIMLERCHRYSLER INFORMED THE NHTSA THAT IT WOULD INITIATE A RECALL OF 79,3665 MODEL YEAR 1994-1997 DODGE 3500 SERIES RAM TRUCKS ONLY BASED ON ADDITIONAL TESTING FROM WHICH IT DETERMINED THAT THE 1500/2500 SERIES VEHICLES NOMINALLY OPERATE SIGNIFICANTLY BELOW THE TEMPERATURE THRESHOLD OF THE SWITCH LUBRICANT.OWNERS OF 1500/2500 SERIES TRUCKS WERE SENT A NOTIFICATION LETTER ADVISING OF THE PROPER METHODS FOR ADDING AFTERMARKET LIGHTING ACCESSORIES.
PE98002 · Headlight Circuit Failure
Opened Jan 14, 1998 · Closed May 8, 1998
Status: closed (inferred from source dates) · Exterior Lighting
There is no summary currently available
PE96044 · Alleged Fuel Tank Leakage
Opened Jun 27, 1996 · Closed Nov 29, 1996
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
IN 1994, CHRYSLER INTRODUCTED A PLASTIC FUEL TANK, THAT WAS SHAPED DIFFERENTLY FROM THE METAL TANK IT REPLACED.DUE TO THE DIFFERENT SHAPE OF THE NEW TANK,GLAVAL HAD SOME PROBLEMS WITH SCREWS, THAT IT INSTALLS, RUPTURING THE FUEL TANK.THIS PROBLEM WAS IDENTIFIED DURING EARLY PRODUCTION AND GLAVAL CORRECTED THE SUBJECT UNITS PRIOR TO SHIPPING.GLAVAL ALSO DESIGNED A NEW TEMPLATE TO CORRECTLY LOCATE THE SCREWS TO MISS THE NEW STYLE TANK.EVIDENTLY A FEW EARLY PRODUCTION VEHICLES WERE NOT CAUGHT OR HAD SCREWS INSTALLED WITH THE WRONG TEMPLATE.ALL BUT ONE OF THESE VEHICLES WERE REPORTED AND CORRECTED UNDER WARRANTY IN 1994.ONLY ONE REPORT HAS BEEN RECEIVED SINCE 1994.NO. CRASH OR FIRE OCCURRED AND GLAVAL PAID FOR THE REPAIR OF THIS SINGLE UNIT.A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.
PE94072 · Trans Hose Separation
Opened Oct 3, 1994 · Closed Mar 22, 1995
Status: closed (inferred from source dates) · Power Train
There is no summary currently available
Illustration