NHTSA owner reports · September 18, 2026 snapshot.
What owners actually said
589 reports113,000 miles · May 6, 2019
Air BagsService BrakesCrash
TL* THE CONTACT OWNS A 1995 DODGE INTREPID. WHILE DRIVING 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE VEHICLE DID NOT STOP AND CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE DRIVER'S SIDE AIR BAG DID NOT DEPLOY. THE PASSENGER SIDE AIR BAG DEPLOYED, BUT THERE WAS NO PASSENGER. THERE WERE NO INJURIES. …
Read full complaint
TL* THE CONTACT OWNS A 1995 DODGE INTREPID. WHILE DRIVING 65 MPH, THE BRAKE PEDAL WAS DEPRESSED AND TRAVELED TO THE FLOORBOARD. THE VEHICLE DID NOT STOP AND CRASHED INTO THE REAR OF ANOTHER VEHICLE. THE DRIVER'S SIDE AIR BAG DID NOT DEPLOY. THE PASSENGER SIDE AIR BAG DEPLOYED, BUT THERE WAS NO PASSENGER. THERE WERE NO INJURIES. POLICE REPORT NUMBER: 19-341341 WAS FILED. THE VEHICLE WAS TOWED TO AN INDEPENDENT LOT. THE DEALER AND MANUFACTURER WERE NOT CONTACTED. THE VEHICLE WAS NOT DIAGNOSED OR REPAIRED. THE FAILURE MILEAGE WAS 113,000. *TR*JB
NHTSA ODI #11205691
175,000 miles · Sep 13, 2016
SteeringSuspensionWheels
RACK AND PINION ISSUES. ISSUES WITH FRONT WHEELS AND STEERING. I'VE HAD IT FIXED THREE TIMES, VERY EXPENSIVE. I WAS PULLING OUT OF A PARKING SPACE, WHEN THE STEER STOPPED CONTROLLING THE WHEELS. I'M GRATEFUL I WASN'T ON THE FREE WAY.
NHTSA ODI #10905974
Mileage unknown · Feb 26, 2015
Electrical System
1995 DODGE INTREPID. CONSUMER WRITES IN REGARDS VEHICLE STALLING WHILE DRIVING. *SMD THE CONSUMER STATED WHEN THE VEHICLE STALLED, THE POWER STEERING FAILED AND IT WAS DIFFICULT TO STEER THE VEHICLE. THE VEHICLE WAS TAKEN TO A REPAIR SHOP, WHERE THE IGNITION SWITCH WAS REPLACED. *JB
NHTSA ODI #10669040
115,849 miles · Aug 27, 2014
EngineFuel System, Gasoline
PURCHASED CAR ON 8/11/14, DROVE IT HOME AND ON 8/12/14 STARTED CAR AND SAY GAS SPRAYING OUT OF INJECTORS ON TOP OF MOTOR. ALL INJECTOR SEALS WERE BAD AND HAD TO BE REPLACED, SAME WITH VALVE COVER GASKETS OIL WAS RUNNING DOWN ON EXHAUST MANIFOLDS. BOTH WERE FIRE HAZARDS, 8/27/14, RIGHT SIDE AXLE IS BAD AND BEARING IN DIFFERENTIAL…
Read full complaint
PURCHASED CAR ON 8/11/14, DROVE IT HOME AND ON 8/12/14 STARTED CAR AND SAY GAS SPRAYING OUT OF INJECTORS ON TOP OF MOTOR. ALL INJECTOR SEALS WERE BAD AND HAD TO BE REPLACED, SAME WITH VALVE COVER GASKETS OIL WAS RUNNING DOWN ON EXHAUST MANIFOLDS. BOTH WERE FIRE HAZARDS, 8/27/14, RIGHT SIDE AXLE IS BAD AND BEARING IN DIFFERENTIAL IS BAD. THIS CAR HAS A 4/15 INSPECTION STICKER ON WINDSHIELD, HOW COULD THIS CAR PASS THE VA STATE INSPECTION WITH THIS MANY PROBLEMS? AND ALL BRAKE PADS HAD TO BE REPLACED. THEY WERE WORN OUT TO. *TR
NHTSA ODI #10628944
92,000 miles · Aug 19, 2014
Fuel/propulsion System
TL* THE CONTACT OWNS A 1995 DODGE INTREPID. WHEN THE CONTACT STARTED THE VEHICLE, FUEL FUMES SEEPED INTO THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED A FUEL LEAK NEAR THE INTAKE MANIFOLD IN THE MOTOR. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE O-RINGS NEEDED TO BE REPLACED, BUT TH…
Read full complaint
TL* THE CONTACT OWNS A 1995 DODGE INTREPID. WHEN THE CONTACT STARTED THE VEHICLE, FUEL FUMES SEEPED INTO THE VEHICLE. THE CONTACT INSPECTED THE VEHICLE AND NOTICED A FUEL LEAK NEAR THE INTAKE MANIFOLD IN THE MOTOR. THE VEHICLE WAS TOWED TO THE CONTACT'S RESIDENCE. THE CONTACT STATED THAT THE O-RINGS NEEDED TO BE REPLACED, BUT THE PARTS WERE NOT AVAILABLE IN ORDER TO REPAIR THE VEHICLE. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE APPROXIMATE FAILURE MILEAGE WAS 92,000. UPDATED 10/10/14*CN UPDATED 3/31/15 *JS
NHTSA ODI #10626440
143,600 miles · Oct 18, 2011
Power Train
TL* THE CONTACT OWNS A 1995 DODGE INTREPID. THE CONTACT STATED THAT THE KEY WOULD BECOME STUCK IN THE IGNITION SPORADICALLY AND THE CONTACT WOULD HAVE TO ABRUPTLY SHIFT INTO PARK. THE CONTACT STATED THAT THE FAILURE DID NOT OCCUR UNTIL HAVING REPAIRS TO THE VEHICLE UNDER NHTSA RECALL CAMPAIGN ID NUMBER: 04V021000 (POWER TRAIN: A…
Read full complaint
TL* THE CONTACT OWNS A 1995 DODGE INTREPID. THE CONTACT STATED THAT THE KEY WOULD BECOME STUCK IN THE IGNITION SPORADICALLY AND THE CONTACT WOULD HAVE TO ABRUPTLY SHIFT INTO PARK. THE CONTACT STATED THAT THE FAILURE DID NOT OCCUR UNTIL HAVING REPAIRS TO THE VEHICLE UNDER NHTSA RECALL CAMPAIGN ID NUMBER: 04V021000 (POWER TRAIN: AUTOMATIC TRANSMISSION: LEVER AND LINKAGE: FLOOR SHIFTER). THE MANUFACTURER STATED THAT THE REPAIR HAD ALREADY BEEN DONE AND COULD NOT BE CORRECTED. THE FAILURE MILEAGE WAS 143,600.
NHTSA ODI #10430682
55,695 miles · Dec 6, 2010
Power Train
DODGE TRANSMISSION ON INTREPIDS, CARAVANS, AND NEONS HAVE A HISTORY OF FAILING AND NEEDING TO BE REPLACED OR REBUILT. MY VEHICLE ONLY HAS 55800 MILES ON IT ALL ORIGINAL. EVEN THOUGH THE CAR IS 15 YEARS OLD IT HAS ALWAYS BEEN MAINTAINED SINCE IT WAS PURCHASED FROM THE DEALER BRAND NEW IN 1995. I BELIEVE THAT IF DODGE IS NOT HELD …
Read full complaint
DODGE TRANSMISSION ON INTREPIDS, CARAVANS, AND NEONS HAVE A HISTORY OF FAILING AND NEEDING TO BE REPLACED OR REBUILT. MY VEHICLE ONLY HAS 55800 MILES ON IT ALL ORIGINAL. EVEN THOUGH THE CAR IS 15 YEARS OLD IT HAS ALWAYS BEEN MAINTAINED SINCE IT WAS PURCHASED FROM THE DEALER BRAND NEW IN 1995. I BELIEVE THAT IF DODGE IS NOT HELD RESPONSIBLE FOR THE PROBLEMS THEN SOMEONE CAN SERIOUSLY GET INJURED FROM THEM. WHETHER IT BE FROM THE TRANSMISSION FAILING ON THE HIGHWAY AND CAUSING ACCIDENTS OR SOMETHING BREAKING WHILE JUST DRIVING AND CAUSING SERIOUS INJURY. *TR
NHTSA ODI #10369402
Mileage unknown · Jul 13, 2010
Electrical SystemEquipment
I WAS DRIVING DOWN THE ROAD WHEN MY CAR JUST DIED. I DIDN'T GET ANY FLASHING LIGHTS, CHECK ENGINE LIGHT OR ANYTHING. IT WAS AS IS SOMEONE HAD TURNED THE CAR OFF WITH OUT MOVING THE KEY FROM THE ON POSITION. ONCE I COME TO A STOP, I CAN SIT FOR A LITTLE BIT AND THEN THE CAR WILL START BACK UP AS IF NOTHING EVER HAPPENED. I HAVE R…
Read full complaint
I WAS DRIVING DOWN THE ROAD WHEN MY CAR JUST DIED. I DIDN'T GET ANY FLASHING LIGHTS, CHECK ENGINE LIGHT OR ANYTHING. IT WAS AS IS SOMEONE HAD TURNED THE CAR OFF WITH OUT MOVING THE KEY FROM THE ON POSITION. ONCE I COME TO A STOP, I CAN SIT FOR A LITTLE BIT AND THEN THE CAR WILL START BACK UP AS IF NOTHING EVER HAPPENED. I HAVE RECENTLY HAD A FEW ISSUES WITH SOME OTHER THINGS THAT WERE RESOLVED BY REPLACING THE IGNITION SWITCH BUT IT DIDN'T SEEM TO FIX THIS ISSUE. I TOOK THE CAR TO A REPAIR SHOP AND HAD THE DIAGNOSTICS RAN ON IT BUT IT DIDN'T COME BACK WITH ANY CODES. I OFTEN DRIVE WITH MY WIFE AND KIDS IN THE CAR SO NOW I FEAR THAT THIS MAY CAUSE US TO GET IN A WRECK. *TR
NHTSA ODI #10342970
195,000 miles · Mar 10, 2010
Steering
TL*THE CONTACT OWNS A 1995 DODGE INTREPID. WHILE DRIVING AT A SPEED OF 40 MPH THE CONTACT HEARD A LOUD POP AND SUDDENLY THE POWER STEERING STOPPED FUNCTIONING. THE CONTACT HAD MINIMAL CONTROL OF THE STEERING WHEEL. THE CONTACT CALLED THE MANUFACTURER AND THEY INFORMED HIM THAT THE WARRANTY EXPIRED AND THAT THERE WERE NO RECAL…
Read full complaint
TL*THE CONTACT OWNS A 1995 DODGE INTREPID. WHILE DRIVING AT A SPEED OF 40 MPH THE CONTACT HEARD A LOUD POP AND SUDDENLY THE POWER STEERING STOPPED FUNCTIONING. THE CONTACT HAD MINIMAL CONTROL OF THE STEERING WHEEL. THE CONTACT CALLED THE MANUFACTURER AND THEY INFORMED HIM THAT THE WARRANTY EXPIRED AND THAT THERE WERE NO RECALLS RELATED TO THE POWER STEERING FOR HIS YEAR, MAKE AND MODEL VEHICLE. THE VIN WAS NOT AVAILABLE. THE FAILURE AND CURRENT MILEAGES WERE 195000.
NHTSA ODI #10318723
133,600 miles · Feb 23, 2010
Electrical SystemEngine And Engine Cooling
I HAVE A 1995 DODGE INTREPID. UNTIL 4 MONTHS AGO, IT NEVER HAD A PROBLEM, ONLY DID ROUTINE MAINTENANCE AND THAT WAS CONSTANTLY DONE. IT HAS A NEW TRANSMISSION AND RADIATOR (UNDER EXTENDED WARRANTY), AND NEW STARTER, ALTERNATOR, AND BATTERY. THE FUEL PUMP WAS REPLACED ABOUT 2-3 YEARS AGO. FOUR MONTHS AGO, THE CAR STARTED TO…
Read full complaint
I HAVE A 1995 DODGE INTREPID. UNTIL 4 MONTHS AGO, IT NEVER HAD A PROBLEM, ONLY DID ROUTINE MAINTENANCE AND THAT WAS CONSTANTLY DONE. IT HAS A NEW TRANSMISSION AND RADIATOR (UNDER EXTENDED WARRANTY), AND NEW STARTER, ALTERNATOR, AND BATTERY. THE FUEL PUMP WAS REPLACED ABOUT 2-3 YEARS AGO. FOUR MONTHS AGO, THE CAR STARTED TO ACT UP. FIRST, I NOTICED A "BURNT OIL OR ANTI-FREEZE" SMELL. I TOOK IT TO MY MECHANIC, WHO I HAVE HAD FOR MORE THAN 15 YEARS. HE COULDN'T FIND ANY LEAKS OR PROBLEMS AND REMINDED ME THAT ALL THE HOSES AND ACCESSORIES WERE REPLACE A YEAR BEFORE. HE SAID THAT HE SAW NOTHING DRIPPING OR BUILDING UP ANYWHERE. A WEEK LATER, I WOULD DRIVE IT SOMEWHERE, GET OUT AND DO WHATEVER IT WAS I NEEDED TO DO, GO BACK AND IT WOULDN'T START. EVERYTHING SOUNDS NORMAL, LIKE IT WANTS TO START, BUT DOESN'T. IF I WAIT 30-90 MINUTES AND TRY AGAIN, IT WILL START RIGHT UP AND A CHECK ENGINE LIGHT WOULD COME ON, BUT GO BACK OFF WITHIN A FEW MINUTES. A MONTH LATER THINGS GOT WORSE. IT STARTED TO DIE WHILE DRIVING. I WOULD BE IN THE CAR FOR LESS THAN 10 MILES AND ALL THE LIGHTS ON THE DASH WOULD "FLASH" AND THE CAR WOULD DIE. IT TAKES BETWEEN 2-3 HOURS BEFORE GETTING IT TO RESTART WHEN THIS HAPPENS. THIS PUTS ME IN SERIOUS DANGER AS THE CAR NO LONGER HAS POWER STEERING OR POWER BRAKES AND I LIVE ON A MOUNTAIN WITH NO WHERE I CAN GET OFF THE ROAD. I HAVE NEARLY BEEN HIT/KILLED WHEN THIS HAS HAPPENED. SINCE THEN, I CAN'T GO 1 MILE WITHOUT IT DYING OR NOT START AGAIN. AS A MATTER-OF-FACT, IF I LEAVE IT IDLING IN MY DRIVEWAY, IT WILL DIE WITH 2-4 MINUTES. I HAVE TAKEN IT TO MY SHOP 4 TIMES AND 2 OTHER ONES TRYING TO FIND OUT WHAT IS WRONG. THEY ALL SAY THAT SINCE THE "CHECK ENGINE" LIGHT ONLY FLASHES AND THEN GOES OFF, THE COMPUTER CAN'T CATCH THE PROBLEM. SOMETIMES THEY THINK IT IS THE FUEL PUMP OR FUEL LINES; SOMETIMES THEY THINK IT IS ELECTRICAL; MOST OF THE TIME THEY JUST HAVE NO IDEA WHAT IS WRONG! *TR
NHTSA ODI #10312947
NHTSA investigations
9DP04007 · Fuel Rail, Brake Fluid, Chassis
Opened Oct 13, 2004 · Closed Oct 27, 2004
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System:fuel Rail; Service Brakes, Hydraulic:fluid; Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Additional source detail variants (3)
Fuel System, Gasoline:fuel Injection System:fuel Rail
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Service Brakes, Hydraulic:fluid
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
Structure:frame And Members
ON SEPTEMBER 5, 2004, MR. ROBERT GALENTY OF ISELIN, NJ, PETITIONED THE AGENCY TO CONDUCT DEFECT INVESTIGATIONS OF CERTAIN MODEL YEAR (MY) 1993-1997 VEHICLES PRODUCED BY DAIMLERCHRYSLER CORPORATION.HIS PETITION IDENTIFIED THREE ISSUES OF CONCERN: 1) FUEL LEAKING FROM THE FUEL INJECTOR RAILS; 2) BRAKE FLUID CONTAMINATION RESULTING IN BRAKE FAILURE; AND 3) SUSCEPTIBILITY OF THE VEHICLE FRAME TO DAMAGE WHILE THE VEHICLE IS BEING TOWED.MR. GALANTY ALLEGED THAT HIS 1996 DODGE INTREPID HAD EACH OF THESE THREE PROBLEMS.CONCERNING FUEL RAIL LEAKAGE, DAIMLERCHRYSLER COMMENCED A RECALL (98V-184) OF APPROXIMATELY 722,600 VEHICLES TO ADDRESS ENGINE FUEL RAIL LEAKS THAT COULD LEAD TO A FIRE, INCLUDING THOSE VEHICLES CITED IN THE PETITION AND THE PETITIONER'S 1996 DODGE INTREPID.ON OCTOBER 7, 1998, NHTSA OPENED A RECALL QUERY INVESTIGATION (RQ98-018) TO EVALUATE THE ADEQUACY OF THE RECALL REMEDY.THAT INVESTIGATION WAS CLOSED ON JULY 8, 2002 WITHOUT REQUIRING FURTHER ACTION BY DAIMLERCHRYSLER.VERY RECENTLY, ON JUNE 9, 2004, NHTSA DENIED A PETITION (RP04-001) TO REOPEN RQ98-018 AFTER FINDING THAT THERE WAS NO NEW INFORMATION THAT WOULD INDICATE ANY BASIS FOR REOPENING IT.THIS IS STILL THE CURRENT POSITION OF NHTSA ON THIS ISSUE.CONCERNING BRAKE FLUID CONTAMINATION AND FRAME ALIGNMENT, A REVIEW OF NHTSA'S DATABASE SHOWS NO OTHER COMPLAINTS ON EITHER ONE OF THESE ISSUES ON THE VEHICLES CITED IN THE PETITION.
EA03011 · Auto Trans IGNITION-PARK Interlock
Opened Jul 17, 2003 · Closed Jan 30, 2004
Status: closed (inferred from source dates) · Power Train:automatic Transmission; Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Additional source detail variants (2)
Power Train:automatic Transmission
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
Power Train:automatic Transmission:lever And Linkage:floor Shift
THE MANUFACTURER REPORTS ABOVE ARE BASED ON DAIMLERCHRYSLER?S (DC) ANALYSIS OF MODEL YEAR (MY) 1998 (POPULATION = 356,384) AND 1999 (POPULATION = 486,948) JA, JX AND LH FAMILY SUBJECT VEHICLE DATA (EARLIER MYS EXCLUDED).THE POPULATION NUMBER INCLUDES ALL MYS.THE PRECISE NUMBER OF DUPLICATES BETWEEN ODI AND DC REPORTS CANNOT BE DETERMINED DUE TO MISSING OR INCOMPLETE INFORMATION.THE FATALITY INCIDENT INVOLVED AN ELDERLY PERSON WHO ATTEMPTED TO STOP A ROLL AWAY VEHICLE AND RECEIVED FATAL INJURIES.ODI ALSO GATHERED INFORMATION ON MY 1997-99 PROWLER VEHICLES IN THIS INVESTIGATION. THE PROWLER VEHICLES WERE MANUFACTURED WITH A DIFFERENT DESIGN SHIFTER MECHANISM (THE SHIFT LEVER IS SHORTER).THERE ARE NO COMPLAINTS OF PROWLER INTERLOCK FAILURE IN ODI?S DATABASE, AND DC HAS RECEIVED NO REPORTS EITHER.THE PROWLER IS EXCLUDED FROM THE RECALL SCOPE.THE INVESTIGATION INVOLVED A CONDITION WHERE THE INTERLOCK SYSTEM COULD FAIL (OR BE MADE INOPERATIVE BY THE OPERATOR) DURING VEHICLE USE, POSSIBLY INADVERTENTLY.THE INTERLOCK SYSTEM IS REQUIRED UNDER FMVSS 114.WITH THE TRANSMISSION IN THE PARK POSITION AND THE IGNITION KEY OFF, THE COMBINED ACTION OF PRESSING THE SHIFT BUTTON AND PULLING THE SHIFT LEVER REARWARD MAY RESULT IN THE OPERATOR OVERCOMING THE INTERLOCK SYSTEM AND CAUSE THE MECHANICAL LINKAGE OF THE SYSTEM TO DISCONNECT.WHEN THIS OCCURS, THERE IS NO OVERT INDICATION TO AN OPERATOR THAT THE SYSTEM IS DEFEATED, AND AN INCREASED RISK OF VEHICLE ROLL-AWAY EXISTS.UNDER RECALL 04V021, DC WILL REPLACE DAMAGED SHIFT MECHANISMS, AND WILL INSTALL ON ALL VEHICLES A DEVICE WHICH INHIBITS THE OPERATOR?S ABILITY TO OVERCOME THE INTERLOCK AND DEFEAT THE SYSTEM.BEGINNING WITH MY 2000, DC INCORPORATED A BRAKE AND TRANSMISSION SHIFTER INTERLOCK (BTSI) SYSTEM INTO THE SUBJECT VEHICLES.INTRODUCTION OF BTSI INVOLVED DESIGN CHANGES TO THE SHIFT MECHANISM, ONE OF WHICH RESULTED IN REDUCED MECHANICAL ADVANTAGE (RMA) OF THE SHIFT BUTTON.THE RMA SHIFTER REQUIRES INCREASED FORCES TO OVERCOME THE INTERLOCK SYSTEM, MAKING THE SHIFTER LESS SUSCEPTIBLE TO DAMAGE.
DP03002 · Steering Column Separation
Opened May 7, 2003 · Closed Jul 22, 2003
Status: closed (inferred from source dates) · Steering:column
MR. LARRY A. SACKEY SUBMITTED A PETITION TO THE NATIONAL HIGHWAY TRAFFIC SAFETY ADMINISTRATION (NHTSA) BY LETTER DATED APRIL 18, 2003, REQUESTING THAT NHTSAFURTHER INVESTIGATE THE DEFECTIVE COLLAPSIBLE STEERING SHAFT SYSTEM ON 1987-1995 VEHICLES MANUFACTURED BY THE DAIMLERCHRYSLER CORPORATION.IN PART BECAUSE OF 49 CFR ? 30120(G), NHTSA HAS DECIDED TO LIMIT THE SCOPE OF THE PETITION VEHICLES TO 1993-1995 MODELS, EXCLUDING THE 1993 JEEP GRAND CHEROKEE AND 1994-1995 DODGE RAM SERIES TRUCKS THAT WERE RECALLED (93V210 & 96V230) FOR STEERING COLUMN FAILURE.IF THE ANALYSIS OF THESE VEHICLES HAD IDENTIFIED A POTENTIAL PROBLEM, THE SCOPE COULD HAVE BEEN EXPANDED IN AN INVESTIGATION.A REVIEW OF ODI'S DATA BASE SHOWS NO RECENT COMPLAINTS AND A LACK OF A COMPLAINT TREND CONCERNING THE SUBJECT ISSUE ON THE SUBJECT VEHICLES AS A WHOLE OR BY INDIVIDUAL MODELS.THEREFORE, THE PETITION IS DENIED.FOR DETAILS, SEE FEDERAL REGISTER NOTICE VOLUME 68, NO. 130, JULY 8, 2003.
EA99031 · Steering System Rack And Pinion
Opened Oct 29, 1999 · Closed Sep 13, 2001
Status: closed (inferred from source dates) · Steering
There is no summary currently available
PE99044 · Steering System Rack And Pinion
Opened Jun 28, 1999 · Closed Oct 29, 1999
Status: closed (inferred from source dates) · Steering
SINCE OPENING THE PRELIMINARY EVALUATION (PE), ODI HAS RECEIVED 6 ADDITIONAL COMPLAINTS.DURING THE PE IT WAS DETERMINED MULTIPLE FAILURE MODES ARE INVOLVED IN THIS MATTER.THE WARRANTY CLAIM RATE IS HIGH FOR A STEERING SYSTEM CONCERN.THE ISSUES REPORTED INVOLVE PREMATURE WEAR OUT AT THE RACK AND PINION INTERFACE WITH THE INNER TIE ROD END(S), BINDING AND STICKING OF THE STEERING GEAR, CRACKED OR BROKEN TIE ROD ENDS, SHEARED RACK AND PINION ASSEMBLY BOLTS, AND WEAR OUT OF THE RACK AND PINION MOUNT BUSHINGS.MANY OF THE COMPLAINANTS MENTION STEERING WONDER AND LOOSE STEERING.THREE OF THE MOST RECENT COMPLAINTS ALLEGE A COMPLETE LOSS OF STEERING DUE TO SHEARED BOLTS.ODI IS UPGRADING THIS PE IN ORDER TO PERFORM A THOROUGH TECHNICAL ANALYSIS OF THE VARIOUS SYSTEM FAILURE ALLEGATIONS AND TO QUANTIFY THE EFFECT THAT THESE FAILURES HAVE ON VEHICLE CONTROL.
RQ98018 · Fuel Injection Delivery System Fuel Leak
Opened Oct 7, 1998 · Closed Jul 8, 2002
Status: closed (inferred from source dates) · Fuel System, Gasoline:fuel Injection System
No summary supplied.
EA98007 · Fuel Injector Assembly Leakage
Opened Mar 10, 1998 · Closed Feb 1, 1999
Status: closed (inferred from source dates) · Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings; Fuel System, Gasoline:fuel Injection System; Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Additional source detail variants (3)
Fuel System, Gasoline:delivery:hoses, Lines/piping, And Fittings
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
Fuel System, Gasoline:fuel Injection System:fuel Rail
NITRILE RUBBER SEALS USED IN THE FUEL RAIL ASSEMBLIES OF THE SUBJECT VEHICLES AT THE SUPPLY, RETURN, AND CROSSOVER TUBE FITTINGS, AND AT THE PRESSURE REGULATOR FAIL, RESULTING IN FUEL LEAKAGE IN THE ENGINE COMPARTMENT.ALSO, THE OUTLET (RIGHT) FUEL RAIL MAY LEAK FROM CRACKS AT CERTAIN MOLD GATES IN THE THERMOSET RAIL MATERIAL.CHRYSLER WILL RECALL THE SUBJECT VEHICLES AND STATED THAT IT INTENDS TO REPLACE THE O-RINGS WITH FLUOROCARBON O-RING HAVING GREATER HEAT RESISTANCE CAPABILITY AND ATTACH REINFORCEMENTS TO THE RAIL IN THE AREAS WHERE THE CRACKING CONCERN HAS BEEN KNOWN TO OCCUR MOST FREQUENTLY.RAILS THAT ARE ALREADY CRACKED WILL BE REPLACED BY NEW, REINFORCED RAILS.
EA95028 · Underhood Fuel Leaks
Opened Sep 22, 1995 · Closed Feb 24, 1997
Status: closed (inferred from source dates) · Vehicle Speed Control:linkages
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER USE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT NO SAFETY-RELATED DEFECT EXISTS.THE AGENCY RESERVES THE RIGHT TO TAKE FURTHER ACTION IF WAARRANTED BY THE CIRCUMSTANCES.AN ENGINEERING ANALYSIS CLOSSING REPORT IS INCLUDED IN THE PUBLIC FILE.
EA95023 · Water In Defroster System
Opened Aug 31, 1995 · Closed Dec 31, 1996
Status: closed (inferred from source dates) · Visibility:defroster/defogger/hvac System
A SAFETY-RELATED DEFECT TREND HAS NOT BEEN IDENTIFIED AT THIS TIME AND FURTHER EXPENDITURE OF AGENCY RESOURCES DOES NOT APPEAR TO BE WARRANTED.THE CLOSING OF THIS INVESTIGATION DOES NOT CONSTITUTE A FINDING BY NHTSA THAT A SAFETY-RELATED DEFECT DOES NOT EXIST.THE AGENCY WILL TAKE FURTHER ACTION IF WARRANTED BY THE CIRCUMSTANCES.SEE THE ENGINEERING ANALYSIS CLOSING REPORT (EA95-023)
Illustration