NHTSA owner reports · September 18, 2026 snapshot.
Service Brakes, Hydraulic complaints
133 reportsClear category filter12,000 miles · Oct 4, 2010
Service Brakes, Hydraulic
2008 DODGE GRAND CARAVAN WITH 27,000 MILES ON IT NEEDS TO HAVE ALL FOUR SETS OF BRAKE PADS AND FRONT ROTORS REPLACED FOR THE SECOND TIME. THE FRONT PADS HAVE WERE REPLACED 13,000 MILES AGO AND HAVE ALREADY WORN DOWN SO FAR THAT THEY ARE CUTTING GROOVES INTO THE ROTORS. I AM A PROFESSIONAL MECHANIC AND HAVE NEVER SEEN BRAKES WEAR…
Read full complaint
2008 DODGE GRAND CARAVAN WITH 27,000 MILES ON IT NEEDS TO HAVE ALL FOUR SETS OF BRAKE PADS AND FRONT ROTORS REPLACED FOR THE SECOND TIME. THE FRONT PADS HAVE WERE REPLACED 13,000 MILES AGO AND HAVE ALREADY WORN DOWN SO FAR THAT THEY ARE CUTTING GROOVES INTO THE ROTORS. I AM A PROFESSIONAL MECHANIC AND HAVE NEVER SEEN BRAKES WEAR OUT IN 12,000 MILES. DODGE REFUSES TO REPLACE THE BRAKES CITING THAT THEY ARE WEAR ITEMS. THEY SHOULD WEAR OUT IN 50,000 MILES, NOT 12,000. I FEEL THAT THIS IS A SERIOUS SAFETY PROBLEM AS EVEN WHEN NEW, THE BRAKES ARE SERIOUSLY UNDER ENGINEERED. I HAVE TO PRESS THE PEDAL ALMOST TO THE FLOOR FOR NORMAL STOPS AND IN THE EVENT OF PANIC STOPS, I HAVE HAD MORE THAN ENOUGH NEAR MISSES WHERE THE VAN JUST DIDN'T STOP IN TIME AND I WOUND UP OFF THE ROAD ON THE SHOULDER. *TR
NHTSA ODI #10359159
25,817 miles · Sep 30, 2010
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. AFTER ATTEMPTING TO STOP, THE WHEEL VIBRATED CAUSING DIFFICULTY WHEN THE CONTACT TRIED TO STOP. THE DEALER STATED THAT ALL FOUR ROTORS AND BRAKE PADS HAD FAILED; THE FRONT BRAKE PADS AND ROTORS WERE REPLACED UNDER WARRANTY AND THE REAR PARTS WERE REPLACED AT A REPAIR SHOP AT THE CO…
Read full complaint
TL*THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. AFTER ATTEMPTING TO STOP, THE WHEEL VIBRATED CAUSING DIFFICULTY WHEN THE CONTACT TRIED TO STOP. THE DEALER STATED THAT ALL FOUR ROTORS AND BRAKE PADS HAD FAILED; THE FRONT BRAKE PADS AND ROTORS WERE REPLACED UNDER WARRANTY AND THE REAR PARTS WERE REPLACED AT A REPAIR SHOP AT THE CONTACT'S EXPENSE. THE CONTACT CALLED THE MANUFACTURER WHO STATED THAT THE FAILURE WAS COMMON BUT OFFERED NO ASSISTANCE. THE FAILURE MILEAGE WAS 25,817 AND THE CURRENT MILEAGE WAS APPROXIMATELY 29,000.
NHTSA ODI #10358472
32,000 miles · Sep 29, 2010
Service Brakes, Hydraulic
GOING ON MY 3RD SET OF BRAKES AT 32K MILES. DODGE SERVICE CENTER SAID THEY KNEW OF THIS BEING A PROBLEM ON ALL GRAND CARAVANS 2008 AND LATER. TOLD ME I WAS OUT OF WARRANTY . AT THIS RATE I WILL HAVE OVER $3000 IN BRAKES IN LESS THAN 4 YRS. NEED TO BE A RECALL FOR A LONGER LASTING BRAKE. THIS IS TO DANGEROUS AND COSTLY FOR THE O…
Read full complaint
GOING ON MY 3RD SET OF BRAKES AT 32K MILES. DODGE SERVICE CENTER SAID THEY KNEW OF THIS BEING A PROBLEM ON ALL GRAND CARAVANS 2008 AND LATER. TOLD ME I WAS OUT OF WARRANTY . AT THIS RATE I WILL HAVE OVER $3000 IN BRAKES IN LESS THAN 4 YRS. NEED TO BE A RECALL FOR A LONGER LASTING BRAKE. THIS IS TO DANGEROUS AND COSTLY FOR THE OWNER AND MOTHERS WHO DRIVE THEIR CHILDREN. *TR
NHTSA ODI #10358368
90,000 miles · Sep 28, 2010
Service Brakes, Hydraulic
2008 DODGE GRAND CARAVAN. 90,000 MILES ON VEHICLE. HEARD A GRINDING NOISE COMING FROM REAR WHEN BRAKES ARE APPLIED. INVESTIGATED AND FOUND BOTH REAR WHEELS, INSIDE DISCS PADS WERE COMPLETELY WORN. OUTSIDE PADS WERE STILL GOOD. REPLACED PADS AND ROTORS. BELIEVE ITS THE DESIGN OF THE CALIPERS, NEVER SEEN CALIPER PISTONS THAT TURNE…
Read full complaint
2008 DODGE GRAND CARAVAN. 90,000 MILES ON VEHICLE. HEARD A GRINDING NOISE COMING FROM REAR WHEN BRAKES ARE APPLIED. INVESTIGATED AND FOUND BOTH REAR WHEELS, INSIDE DISCS PADS WERE COMPLETELY WORN. OUTSIDE PADS WERE STILL GOOD. REPLACED PADS AND ROTORS. BELIEVE ITS THE DESIGN OF THE CALIPERS, NEVER SEEN CALIPER PISTONS THAT TURNED OUT WHEN BRAKES ARE APPLIED. HAD TO HAVE A SPECIAL TOOL TO TURN THE PISTONS BACK IN TO REPLACE PADS. I DON'T THINK THAT THE PISTONS CAN RETRACT VERY WELL BECAUSE OF THE DESIGN CAUSING MORE PRESSURE ON THE INSIDE PADS. THE NEW PADS ALSO SMOKED FOR A FEW DAYS AFTERWARDS. AFTER TALKING TO A DEALER NO INFO OR REASON COULD BE FOUND FOR THE EXCESSIVE WEAR. *TR
NHTSA ODI #10357993
29,000 miles · Sep 1, 2010
Service Brakes, Hydraulic
TL*THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE FRONT BRAKES DETERIORATED SOONER THAN NORMAL CAUSING THE FRONT ROTORS TO FAIL. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE FRONT BRAKE PADS AND ROTORS. THE CONTACTED RECEIVED A REFUND FROM THE MANUFACTURER FOR THE FRONT BRAKE DEFECT REGARDING THE MATERIAL PREPARED BY T…
Read full complaint
TL*THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE FRONT BRAKES DETERIORATED SOONER THAN NORMAL CAUSING THE FRONT ROTORS TO FAIL. THE VEHICLE WAS TAKEN TO THE DEALER WHO REPLACED THE FRONT BRAKE PADS AND ROTORS. THE CONTACTED RECEIVED A REFUND FROM THE MANUFACTURER FOR THE FRONT BRAKE DEFECT REGARDING THE MATERIAL PREPARED BY THE FACTORY. THE CONTACT CALLED THE MANUFACTURER TO ADVISE THEM THAT THE REAR BRAKE PADS AND ROTORS ALSO FAILED. A REPORT WAS NOT FILED. THE REAR BRAKE AND ROTORS WERE REPLACED. THE FAILURE MILEAGE WAS 29,000 AND THE CURRENT MILEAGE WAS 32,000.
NHTSA ODI #10353400
12,000 miles · Sep 1, 2010
Service Brakes, Hydraulic
WE BOUGHT A 2008 DODGE CARAVAN BRAND NEW AND AT 12,000 MILES IT NEEDS BRAND NEW BRAKES. THE BRAKES HAVE BEEN MAKING A GRINDING NOISE FOR MONTHS. CHRYSLER HAS EXTENDED THE WARRENTY ON THE BRAKES FOR THAT YEAR. WE BELIEVE THIS SHOULD BE A RECALL! THEY ALSO DON'T HAVE THE PARTS TO FIX THE PROBLEM SO I AM DRIVING ON BAD BRAKES WITH …
Read full complaint
WE BOUGHT A 2008 DODGE CARAVAN BRAND NEW AND AT 12,000 MILES IT NEEDS BRAND NEW BRAKES. THE BRAKES HAVE BEEN MAKING A GRINDING NOISE FOR MONTHS. CHRYSLER HAS EXTENDED THE WARRENTY ON THE BRAKES FOR THAT YEAR. WE BELIEVE THIS SHOULD BE A RECALL! THEY ALSO DON'T HAVE THE PARTS TO FIX THE PROBLEM SO I AM DRIVING ON BAD BRAKES WITH 4 CHILDREN IN THE VEHICLE. *TR
NHTSA ODI #10353262
32,093 miles · Aug 28, 2010
Service Brakes, Hydraulic
PREMATURE BRAKE WEAR. REAR BRAKE PADS REPLACED (15000 MILES). FRONT BRAKE PADS REPLACED TWICE IN 32000 MILES. ROTORS REPLACED AT 32000 MILES. NOW ROTORS ARE WARPED AGAIN. TRAVEL AROUND TOWN AND MINOR HIGHWAY ONLY. NO HEAVY BREAKING, ETC. NO ACCIDENT YET! *TR
NHTSA ODI #10352497
24,000 miles · Aug 18, 2010
Service Brakes, HydraulicCrash
2008 DODGE GRAND CARAVAN HAS A BRAKE DESIGN FLAW WHICH CAUSES THE BRAKES TO FAIL PREMATURELY. THE FIRST SET WORE OUT BEFORE 25K MILES AND CAUSED MY WIFE TO HAVE AN ACCIDENT WHEN SHE COULD NOT STOP THE VEHICLE. BRAKES HAVE BEEN REPLACED AGAIN WITH LESS THAN 30K ADDITIONAL MILES. THIS IS TOO OFTEN FOR BRAKES. *TR
NHTSA ODI #10350434
54,002 miles · Aug 18, 2010
Service Brakes, Hydraulic
BRAKES PADS WEAR OUT FAST AND ROTOR KEEP WARPING. HAVE HAD BRAKES REPLACED 5 TIMES ALREADY. I AM ONLY UP TO 54,000 AND I NEED BRAKES AGAIN. THE LAST BRAKE AND ROTOR JOB WAS AT 39K. *TR
NHTSA ODI #10350371
8,000 miles · Aug 10, 2010
Service Brakes, Hydraulic
NEW 2008 DODGE CARAVAN REAR BRAKES BURN & SQUEAL SINCE NEW. PADS REPLACED SEVERAL TIMES AND CALIPERS TWICE. PROBLEM CONTINUES TO REPEAT USUALLY NO CHARGE SINCE CAR STILL IN WARRANTY (29000 MI). BUT I NEED RELIABLE BRAKES. DEALER SAYS IT IS A KNOWN PROBLEM WITH THE 2008 BUT CAN'T STOP THE PROBLEM FROM RECURRING. RECENTLY THE ABS …
Read full complaint
NEW 2008 DODGE CARAVAN REAR BRAKES BURN & SQUEAL SINCE NEW. PADS REPLACED SEVERAL TIMES AND CALIPERS TWICE. PROBLEM CONTINUES TO REPEAT USUALLY NO CHARGE SINCE CAR STILL IN WARRANTY (29000 MI). BUT I NEED RELIABLE BRAKES. DEALER SAYS IT IS A KNOWN PROBLEM WITH THE 2008 BUT CAN'T STOP THE PROBLEM FROM RECURRING. RECENTLY THE ABS & THE HYDRAULIC MODULES WENT AND I HAD TO BE TOWED. *TR
NHTSA ODI #10348565
Official recalls
8Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
Aug 3, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Equipment:appliance:air Conditioner
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Dec 8, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. THESE VEHICLES MAY EXPERIENCE A WATER LEAK At THE HEATING AND AIR CONDITIONER (HVAC) DRAIN GROMMET WHICH CAN LEAD TO ILLUMINATION OF AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HVAC DRAIN GROMMET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Jun 3, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY 2007 THROUGH SEPTEMBER 2009. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
Consequence & remedy
Consequence: A SHORT CIRCUIT COULD OCCUR INSIDE THE SLIDING DOOR, OVERHEATING THE LATCH, POSSIBLY RESULTING IN A FIRE.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
Sep 11, 2009
ELDORADO NATIONAL IS RECALLING MODEL YEAR 2008-2009 AMERIVAN MOBILITY VEHICLES BUILT ON CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN PLATFORMS VEHICLES. THE REAR BRAKE LINES MAY HAVE BEEN IMPROPERLY ROUTED AND NOT SECURED PROPERLY DURING THE ALTERATION. IF NOT ROUTED AND SECURED PROPERLY, THE BRAKE LINES COULD RUB AGAINST THE VEHICLE CAUSING A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: A BRAKE FLUID LEAK COULD RESULT IN A LOSS OF BRAKING ABILITY, POSSIBLY CAUSING A CRASH.
Remedy: ELDORADO NATIONAL AMERIVAN DEALERS WILL INSPECT THE VEHICLES AND IF THE BRAKE LINES WERE IMPROPERLY ROUTED THEY WILL BE CORRECTLY REINSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 13, 2009. OWNERS MAY CONTACT ELDORADO NATIONAL AT 1-800-955-9086. THESE MINIVANS HAVE BEEN ALTERED INTO WHEELCHAIR ACCESSIBLE VEHICLES BY ELDORADO. THIS RECALL IS NOT BEING CONDUCTED BY CHRYSLER GROUP LLC AND WILL NOT BE PERFORMED AT NO COST BY DODGE OR CHRYSLER DEALERS UNLESS THEY ARE ALSO AN ELDORADO NATIONAL DEALER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Illustration