IllustrationThe heat exhaust from the motor heats the forward cab even if all of the vents are closed.
2008 Dodge Grand Caravan
Owner reports · Recalls · Investigations
More warning signs than most Grand Caravan years
Owner complaints for the 2008 Dodge Grand Caravan are substantially higher than the model-year median of 284.
About this comparison →How this year compares
Owner complaints by model year
Compare all Grand Caravan years →Counts vary with age, sales and reporting. They are not failure rates.
What owners reported most
All reported categories
Tap a category to read its complaints. One report may name several components.
When problems were reported
Mileage at the reported incident
1360–25K
13425–50K
15650–75K
17675–100K
172100–150K
54150K+
828 reports with mileage · 464 unknown
NHTSA’s mileage field refers to the reported incident, not necessarily the filing date. This shows report counts, not the likelihood of a failure.
What to inspect
Issues worth paying extra attention to based on owner reports.
- Electrical System. Review the 815 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Air Bags. Review the 293 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
- Service Brakes, Hydraulic. Review the 133 owner reports in this category and discuss these concerns during a pre-purchase inspection. Read reports →
NHTSA owner reports · September 18, 2026 snapshot.
23 crash reports16 fire reports12 injury reports
Engine complaints
117 reportsThe contact owns a 2008 Dodge Grand Caravan. The contact stated that while driving at various speed, the transmission made an abnormal whining sound upon depression of the accelerator pedal. The contact stated that the service engine warning light remained illuminate on the instrument panel. The contact stated that after he pull…
Read full complaint
The contact owns a 2008 Dodge Grand Caravan. The contact stated that while driving at various speed, the transmission made an abnormal whining sound upon depression of the accelerator pedal. The contact stated that the service engine warning light remained illuminate on the instrument panel. The contact stated that after he pulled over and restarted the vehicle, the vehicle resumed normal operation. The contact had taken the vehicle to an independent mechanic who informed him that the transmission needed to be replaced. Neither the dealer nor the manufacturer had been notified of the failure. The vehicle was not repaired. The failure mileage was approximately 110,000. The VIN was not available.
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED WHILE DRIVING 70 MPH AND EXITING THE FREEWAY, WHILE APPROACHING A STOP SIGN, THE VEHICLE STALLED WITH SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROADWAY AND RESTARTED AND THE VEHICLE OPERATED AS DESIGNED. THE CONTACT S…
Read full complaint
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED WHILE DRIVING 70 MPH AND EXITING THE FREEWAY, WHILE APPROACHING A STOP SIGN, THE VEHICLE STALLED WITH SEVERAL UNKNOWN WARNING LIGHTS ILLUMINATED. THE VEHICLE WAS COASTED TO THE SIDE OF THE ROADWAY AND RESTARTED AND THE VEHICLE OPERATED AS DESIGNED. THE CONTACT STATED THAT THE FAILURE RECURRED INTERMITTENTLY. THE VEHICLE WAS NOT TAKEN TO BE DIAGNOSED. THE CONTACT STATED THAT ON SEVERAL OCCASIONS, THE VEHICLE HESITATED WHILE ATTEMPTING TO ACCELERATE. THE VEHICLE INDEPENDENTLY DECELERATED WITHOUT WARNING. BURDICK DODGE CHRYSLER (5885 E CIRCLE DR, CICERO, NY 13039, (315) 699-3846) WAS CONTACTED AND CONFIRMED THAT THE VIN WAS NOT UNDER RECALL. THE MANUFACTURER WAS NOTIFIED OF THE FAILURE. THE FAILURE MILEAGE WAS APPROXIMATELY 125,000.
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN FRACTURED REAR AXLE CHECK ENGINE WARNING INDICATOR ILLUMINATED, NOT DIAGNOSED BY A DEALER YET THE CONTACT WAS CONCERNED ABOUT THE SUSPENSSION AND REPAIRS PAID BY THE CONTACT THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 40 MPH, A LOUD RATTLING NOISE EMERGING FRO…
Read full complaint
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN FRACTURED REAR AXLE CHECK ENGINE WARNING INDICATOR ILLUMINATED, NOT DIAGNOSED BY A DEALER YET THE CONTACT WAS CONCERNED ABOUT THE SUSPENSSION AND REPAIRS PAID BY THE CONTACT THE CONTACT STATED THAT WHILE TRAVELING APPROXIMATELY 40 MPH, A LOUD RATTLING NOISE EMERGING FROM THE REAR OF THE VEHICLE STARTED. THE VEHICLE WAS DIAGNOSED BY A NEIGHBOR MECHANIC, THAT DETERMINED THAT THE REAR AXLE WAS FRACTIURED AND NEEDED REPLACEMENT. THE VEHICLE WAS NOT TAKEN TO THE DEALER FOR A DIAGNOSTIC. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURE. THE CONTACT ALSO WANTED TO MENTION THAT THE VEHICLE HAD BEEN REPAIRED AT THE DEALER BENITEZ CHRYSLER,DODGE,JEEP, CARRETERA 3, KM 77.2, BO RIO ABAJO, HUMACAO, PR 00791, APPROXIMATELY 6 TIMES FOR THE EGR( EXHAUST GAS RECIRCULATION ). THE VEHICLE WAS REPAIRED FOR THE AXLE. THE APPROXIMATE FAILURE MILEAGE WAS 99,207.
THE TMPI ON A 20008 DODGE GRAND CARAVAN NEEDS TO BE RECALLED. USED CAR LOTS ARE DISCONNECTING THE HORN AND SELLING THE 20008 GRAND CARAVAN FOR UP TO 10,000 DOLLARS TO CUSTOMERS WHO ARE UNAWARE THAT ANY TIME THE CARAVAN WILL BECOME DISABLED WHILE DRIVING ON ANY STREET OR HIGHWAY BECAUSE THE TMPI IS FAULTY AND CARAVAN WIPERS WILL …
Read full complaint
THE TMPI ON A 20008 DODGE GRAND CARAVAN NEEDS TO BE RECALLED. USED CAR LOTS ARE DISCONNECTING THE HORN AND SELLING THE 20008 GRAND CARAVAN FOR UP TO 10,000 DOLLARS TO CUSTOMERS WHO ARE UNAWARE THAT ANY TIME THE CARAVAN WILL BECOME DISABLED WHILE DRIVING ON ANY STREET OR HIGHWAY BECAUSE THE TMPI IS FAULTY AND CARAVAN WIPERS WILL SPRAY CONTINUOUSLY WIPER FLUID ON WINDSHIELD. ( THE HORN WILL BLOW CONTINUOUSLY IF NOT TAMPERED WITH AND DISABLED. AS IN THIS SITUATION WITH THE 20008 DODGE GRAND CARAVAN. RESOURCE '. CUSTOMER REVIEWS AND COMPLAINTS FILED AGAINST DODGE CHRYSLER CORPORATIONS) CARAVAN WILL NOT EXCEL OVER 30 MILES AN HOUR. WHEN CARAVAN IS FINALLY PARKED THE ENGINE WILL NOT TURN OFF. CARAVAN WILL NOT GO INTO DRIVE OR REVERSE. ENGINE CONTINUOUSLY IDLES WHILE ON THE BACK OF THE WRECKER/FLATBED WITH THE KEYS REMOVED AND THEN FINALLY SHUTS ITS SELF OFF. ANOTHER ISSUE.... THE USED CAR LOT OWNER WILL THEN REPOSSESS SAID VEHICLE AND SELL IT TO ANOTHER UNSUSPECTING CUSTOMER WHO WILL BUY THE CARAVAN THAT NEEDS TO BE RECALLED BECAUSE THE COST OF SAID VEHICLE REPAIR PART (TMPI) IS $1,080.00 AND $115.00 LABOR COST TO FIX THE REPAIR AN HOUR. BECAUSE BUYER CANNOT AFFORD THE REPAIR COSTS AND THE CARAVAN PAYMENTS AND FULL COVERAGE INSURANCE ..WHICH DOES NOT PAY TO REPLACE THE ALTERED OR DEFECTIVE TMPI. EVEN THOUGH THERE HAVE BEEN RECALLS ON THE SAME IDENTICAL TMPI PART ON TWO OTHER CHRYSLER/DODGE VEHICLES. NOTE... BATTERY HAS TO BE DISCONNECTED WHILE PARKED.
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO DOUG HENRY JEEP DODGE RAM (4051 W VERNON AVE, KINGSTON, NC 28504) WHERE IT WAS DETERMINED THAT THE VIN WAS INCLUDED IN FOUR PENDING UNKNOWN RECALLS. THE DEALER INFORMED THE CONTACT TH…
Read full complaint
TL* THE CONTACT OWNS A 2008 DODGE GRAND CARAVAN. THE CONTACT STATED THAT THE CHECK ENGINE INDICATOR REMAINED ILLUMINATED. THE VEHICLE WAS TAKEN TO DOUG HENRY JEEP DODGE RAM (4051 W VERNON AVE, KINGSTON, NC 28504) WHERE IT WAS DETERMINED THAT THE VIN WAS INCLUDED IN FOUR PENDING UNKNOWN RECALLS. THE DEALER INFORMED THE CONTACT THAT THERE WAS A STEERING WHEEL SENSOR THAT NEEDED REPLACEMENT, WHICH WOULD BE AT THE CONTACT'S EXPENSE. THE VEHICLE WAS NOT REPAIRED. THE MANUFACTURER WAS NOT NOTIFIED OF THE FAILURES. THE APPROXIMATE FAILURE MILEAGE WAS 210,564.
THEY DID NOT OPEN IN 3 VAN WREAKS - THE FAULTY TIPM FUSE BOXES WERE PUT IN AT THE FACTORY (RECONDITIONED FUSE BOXES) DODGE HAS ADMITTED TO THIS IN THE DODGE DURANGO'S. THERE ARE MANY MANY MORE MODELS IN THE CHRYSLER/DODGE GROUP OF CARS AND TRUCKS WITH THIS SAME PROBLEM BUT THEY ARE MAKING MONEY HAND OVER FIST AT THEIR REPAIR SH…
Read full complaint
THEY DID NOT OPEN IN 3 VAN WREAKS - THE FAULTY TIPM FUSE BOXES WERE PUT IN AT THE FACTORY (RECONDITIONED FUSE BOXES) DODGE HAS ADMITTED TO THIS IN THE DODGE DURANGO'S. THERE ARE MANY MANY MORE MODELS IN THE CHRYSLER/DODGE GROUP OF CARS AND TRUCKS WITH THIS SAME PROBLEM BUT THEY ARE MAKING MONEY HAND OVER FIST AT THEIR REPAIR SHOPS SO WHY FIX IT THERE IS A EASY FIX THEY ARE NOT TELLING YOU ABOUT,THE CAPACITORS IN YOUR CAR,VAN OR TRUCK ARE OVER LOADING TO FIX ALL YOU HAVE TO DO IS DISCONNECT THE BATTERY BOTH THE NEGATIVE AND POSITIVE SIDES FOR 24 THE FIST TIME, THEN 3 HOURS,THEN AGAIN EACH TIME FOR 1 HOUR WHEN YOU SEE A FAULTY LIGHT COME ON OR LIGHTS ON YOU DASH PANEL FLASHING OR YOUR ENGINE SHUTS OFF WHILE DRIVING.THIS SHOULD CLEAR UP AFTER 3 TIMES OF DOING THIS.THIS WORKED FOR ME MY VAN DOES NOT SHUT OFF ANYMORE,NO MORE DASH LIGHTS FLASHING.YOU MAY HAVE TO DO THIS MORE THAN 3 TIMES ?.BUT IT WORKS HAS BEEN OVER A YEAR NOW. HAPPEN WHILE DRIVING AND SITTING STILL.
WHILE DRIVING ON CITY STREET (BETWEEN 20 AND 30 MPH) THE VEHICLE ENGINE SHUT OFF. THE POWER STEERING AND POWER BRAKES ALSO STOPPED MAKING THE VEHICLE DIFFICULT TO STOP OR MANEUVER TO A SAFE STOPPING LOCATION. THERE WAS NO WARNING OF A FAILURE AND THE ONLY INDICATION WAS THE TRACTION CONTROL/STABILITY DASH INDICATOR. AFTER THE…
Read full complaint
WHILE DRIVING ON CITY STREET (BETWEEN 20 AND 30 MPH) THE VEHICLE ENGINE SHUT OFF. THE POWER STEERING AND POWER BRAKES ALSO STOPPED MAKING THE VEHICLE DIFFICULT TO STOP OR MANEUVER TO A SAFE STOPPING LOCATION. THERE WAS NO WARNING OF A FAILURE AND THE ONLY INDICATION WAS THE TRACTION CONTROL/STABILITY DASH INDICATOR. AFTER THE VEHICLE WAS STOPPED IT WAS PLACED IN PARK AND RESTARTED, THEN DROVE FINE. THERE WERE STILL NO INDICATIONS OF A FAILURE (CEL OR SES LIGHT). NO DIAGNOSTIC CODES WERE STORED ON THE COMPUTER. BECAUSE THIS HAPPENS COMPLETELY UNEXPECTED, IF IT WERE TO OCCUR WHILE GOING AROUND A CURVE OR IN AN INTERSECTION THERE IS A SAFETY CONCERN.
I JUST BOUGHT MY VAN USED AND THE TIRE PRESSURE LIGHT STAYS ON (PRESSURE HAS BEEN CHECKED) THE CHECK ENGINE HAS NOW COME ON AND REMAINS ON ALONG WITH ALL THE ABS, TRACTION CONTROL AND BRAKE LIGHTS HAVE COME ON AS WELL. THE TRACTION CONTROL LIGHT FLASHES WHILE DRIVING AND THE VAN WILL DECELERATE WHILE DRIVING. THIS HAPPENS WHILE …
Read full complaint
I JUST BOUGHT MY VAN USED AND THE TIRE PRESSURE LIGHT STAYS ON (PRESSURE HAS BEEN CHECKED) THE CHECK ENGINE HAS NOW COME ON AND REMAINS ON ALONG WITH ALL THE ABS, TRACTION CONTROL AND BRAKE LIGHTS HAVE COME ON AS WELL. THE TRACTION CONTROL LIGHT FLASHES WHILE DRIVING AND THE VAN WILL DECELERATE WHILE DRIVING. THIS HAPPENS WHILE DRIVING THE VEHICLE. EVERY TIME DRIVING THE VEHICLE
WHILE DRIVING AND WHILE STOPPED AT A STOP LIGHT, THE VAN WILL POWER DOWN COMPLETELY. ENGINE TURNS OFF, POWER STEERING FAILS, AND ALL ELECTRICAL. THE EGR VALVE DANGEROUSLY CAUSES THE VEHICLE TO QUIT EVEN WHILE DRIVING IN TRAFFIC. THIS IS A HUGE SAFETY ISSUE. I WAS TRAVELING DOWN THE ROAD AT 40MPH WITH ALL FOUR OF MY KIDS IN TOW…
Read full complaint
WHILE DRIVING AND WHILE STOPPED AT A STOP LIGHT, THE VAN WILL POWER DOWN COMPLETELY. ENGINE TURNS OFF, POWER STEERING FAILS, AND ALL ELECTRICAL. THE EGR VALVE DANGEROUSLY CAUSES THE VEHICLE TO QUIT EVEN WHILE DRIVING IN TRAFFIC. THIS IS A HUGE SAFETY ISSUE. I WAS TRAVELING DOWN THE ROAD AT 40MPH WITH ALL FOUR OF MY KIDS IN TOW, WHEN THE POWER STEERING WENT OUT AND VEHICLE COMPLETELY QUIT. THANKFULLY, I WAS ABLE TO PULL HARD ON THE WHEEL TO PULL OVER. AFTER SEVERAL TRIES, I WAS ABLE TO RESTART THE VAN. THE VALVE IS APPARENTLY FAILING TO SEND FUEL TO THE NECESSARY AREAS OF THE ENGINE CAUSING IT TO SHUT COMPLETELY DOWN. THIS HAS NOW OCCURRED ON NUMEROUS OCCASIONS AND I NO LONGER TRUST THIS VEHICLE AS A SAFE AND DEPENDABLE FAMILY VEHICLE.
Official recalls
820V396000 · Air Bags:frontal:driver Side:inflator Module; Steering: Steering Wheel/handle Bar
Jul 7, 2020
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence & remedy
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Additional source detail variants (2)
Air Bags:frontal:driver Side:inflator Module
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
Steering: Steering Wheel/handle Bar
Chrysler (FCA US LLC) is recalling certain 2008-2010 Chrysler Town and Country and Dodge Grand Caravan and 2007-2011 Dodge Nitro vehicles. These vehicles may have a loose or missing brand emblem in the center of the steering wheel. The loose emblem or the securing nuts for the emblem within the driver air bag module may become projectiles in the event of a driver air bag deployment.
Consequence: Projectiles as a result of driver air bag deployment in the event of a crash can increase the risk of injury.
Remedy: Chrysler will notify owners, and dealers will replace the driver's air bag cover with a redesigned cover, free of charge. The recall began February 11, 2021. Owners may contact FCA US LLC customer service at 1-800-853-1403. Chrysler's number for this recall is W09.
16V047000 · Air Bags:frontal
Jan 29, 2016
FCA US LLC (Chrysler) is recalling certain model year 2009 Dodge Journey vehicles manufactured December 31, 2007, to August 31, 2008, 2008-2009 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured June 18, 2007, to August 31, 2008. In the affected vehicles, the air bag control units may corrode and fail.
Consequence & remedy
Consequence: If the air bag control unit fails, the air bags may not deploy in the event of a crash, increasing the risk of occupant injury. Additionally, the air bags may inadvertently deploy, increasing the risk of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the air bag control unit, free of charge. The recall began on December 6, 2016. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is S07.
14V373000 · Air Bags; Electrical System:ignition:switch
Jun 26, 2014
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence & remedy
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Additional source detail variants (2)
Air Bags
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
Electrical System:ignition:switch
This defect can affect the safe operation of the airbag system. Until this recall is performed, customers should remove all items from their key rings, leaving only the ignition key. The key fob (if applicable), should also be removed from the key ring. Chrysler Group LLC (Chrysler) is recalling certain model year 2009-2010 Dodge Journey vehicles manufactured June 29, 2007, to June 17, 2010, and 2008-2010 Dodge Grand Caravan and Chrysler Town and Country vehicles manufactured January 26, 2007, to June 17, 2010. Road conditions or some other jarring event may cause the ignition switch to move out of the run position, turning off the engine.
Consequence: If the ignition key inadvertently moves into the OFF or ACCESSORY position, the engine will turn off, which will then depower various key safety systems including but not limited to air bags, power steering, and power braking. Loss of functionality of these systems may increase the risk of crash and/or increase the risk of injury in the event of a crash.
Remedy: Chrysler will notify owners, and dealers will replace the ignition switch and key FOBs, free of charge. The recall began on May 26, 2015. Owners may contact Chrysler customer service at 1-800-853-1403. Chrysler's number for this recall is R03. Note: This is an expansion of recall 11V-139.
14V055000 · SUSPENSION:REAR:AXLE:NON-POWERED Axle Assembly
Feb 11, 2014
Freedom Motors Inc., (Freedom Motors) of Savaria Vehicle Group (formerly The Liberty Motor Company) is recalling one model year 2009 Volkswagen Routan and certain model year 2008-2010 Dodge Grand Caravan and Chrysler Town & Country wheelchair accessible vehicles modified by The Liberty Motor Company from February 2008 through January 2011. Over time and with use, the vehicle's rear axle may develop cracks which could lead to axle failure.
Consequence & remedy
Consequence: Failure of the rear axle may increase the risk of a crash.
Remedy: Freedom Motors will notify owners, and dealers will replace the affected axles, free of charge. The recall began on April 1, 2014. Owners can contact Freedom Motors at 1-800-561-9600. Freedom Motors' number for this recall is ENGF0216-3.
11V394000 · Air Bags:frontal; Air Bags:frontal:sensor/control MODULE-INACTIVE ; Equipment:appliance:air Conditioner
Aug 3, 2011
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Additional source detail variants (3)
Equipment:appliance:air Conditioner
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal:sensor/control MODULE-INACTIVE
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
Air Bags:frontal
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER GRAND VOYAGER, TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES MANUFACTURED FROM JUNE 24, 2007, THROUGH JULY 30, 2008. THESE VEHICLES MAY EXPERIENCE A HEATING AND AIR CONDITIONER (HVAC) CONDENSATE LEAK FROM THE HVAC DRAIN GROMMET ONTO THE OCCUPANT RESTRAINT CONTROL (ORC) MODULE, WHICH CAN LEAD TO THE ILLUMINATION OF THE AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT WITHOUT WARNING.
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE AFFECTED AIR BAG MODULE FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
10V611000 · Equipment:appliance:air Conditioner
Dec 8, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 CHRYSLER TOWN AND COUNTRY AND DODGE GRAND CARAVAN VEHICLES. THESE VEHICLES MAY EXPERIENCE A WATER LEAK At THE HEATING AND AIR CONDITIONER (HVAC) DRAIN GROMMET WHICH CAN LEAD TO ILLUMINATION OF AIRBAG WARNING LIGHT AND A POTENTIAL INADVERTENT AIRBAG DEPLOYMENT.
Consequence & remedy
Consequence: AN INADVERTENT AIRBAG DEPLOYMENT COULD RESULT IN INJURY TO THE SEAT OCCUPANT IN FRONT OF THE DEPLOYING AIRBAG AND/OR A VEHICLE CRASH.
Remedy: DEALERS WILL REPLACE THE HVAC DRAIN GROMMET FREE OF CHARGE. THE SAFETY RECALL BEGAN ON JANUARY 14, 2011. OWNERS MAY CONTACT CHRYSLER AT 1-800-853-1403.
10V235000 · Electrical System:wiring
Jun 3, 2010
CHRYSLER IS RECALLING CERTAIN MODEL YEAR 2008 AND 2009 DODGE GRAND CARAVAN AND CHRYSLER TOWN & COUNTRY PASSENGER VEHICLES MANUFACTURED FROM FEBRUARY 2007 THROUGH SEPTEMBER 2009. SOME OF THE VEHICLES MAY HAVE BEEN BUILT WITH AN IMPROPERLY ROUTED WIRE HARNESS THAT MAY HAVE A CONDITION WHERE THE LOWER SLIDING DOOR HINGE BRACKET CAN MAKE CONTACT AND WEAR THROUGH THE WIRE INSULATION.
Consequence & remedy
Consequence: A SHORT CIRCUIT COULD OCCUR INSIDE THE SLIDING DOOR, OVERHEATING THE LATCH, POSSIBLY RESULTING IN A FIRE.
Remedy: CHRYSLER WILL NOTIFY OWNERS AND DEALERS WILL REPAIR THE VEHICLES FREE OF CHARGE. THE SAFETY RECALL BEGAN ON NOVEMBER 15, 2010. OWNERS MAY CONTACT CHRYSLER TOLL-FREE AT 1-800-853-1403.
09V351000 · Service Brakes, Hydraulic
Sep 11, 2009
ELDORADO NATIONAL IS RECALLING MODEL YEAR 2008-2009 AMERIVAN MOBILITY VEHICLES BUILT ON CHRYSLER TOWN & COUNTRY AND DODGE GRAND CARAVAN PLATFORMS VEHICLES. THE REAR BRAKE LINES MAY HAVE BEEN IMPROPERLY ROUTED AND NOT SECURED PROPERLY DURING THE ALTERATION. IF NOT ROUTED AND SECURED PROPERLY, THE BRAKE LINES COULD RUB AGAINST THE VEHICLE CAUSING A BRAKE FLUID LEAK.
Consequence & remedy
Consequence: A BRAKE FLUID LEAK COULD RESULT IN A LOSS OF BRAKING ABILITY, POSSIBLY CAUSING A CRASH.
Remedy: ELDORADO NATIONAL AMERIVAN DEALERS WILL INSPECT THE VEHICLES AND IF THE BRAKE LINES WERE IMPROPERLY ROUTED THEY WILL BE CORRECTLY REINSTALLED FREE OF CHARGE. THE SAFETY RECALL BEGAN ON OCTOBER 13, 2009. OWNERS MAY CONTACT ELDORADO NATIONAL AT 1-800-955-9086. THESE MINIVANS HAVE BEEN ALTERED INTO WHEELCHAIR ACCESSIBLE VEHICLES BY ELDORADO. THIS RECALL IS NOT BEING CONDUCTED BY CHRYSLER GROUP LLC AND WILL NOT BE PERFORMED AT NO COST BY DODGE OR CHRYSLER DEALERS UNLESS THEY ARE ALSO AN ELDORADO NATIONAL DEALER.
Model-level recall history does not show whether a particular VIN is affected or has received a repair. Check a VIN with NHTSA ↗
NHTSA investigations
2DP14004 · Totally Integrated Power Module Failure
Opened Sep 25, 2014 · Closed Jul 24, 2015
Status: closed (inferred from source dates) · Electrical System
In a letter dated August 21, 2014, the Center for Auto Safety (CAS) petitioned the National Highway Traffic Safety Administration (NHTSA) to initiate a defect investigation of alleged failures associated with the Totally Integrated Power Module (TIPM) installed in Chrysler SUV?s, trucks, and vans beginning in the 2007 model year. The petitioner alleges that TIPM defects may result in engine stall, airbag non-deployment, failure of fuel pump shutoff resulting in unintended acceleration, fire, and other symptoms. On September 25, 2014, the Office of Defects Investigation (ODI) opened DP14-004 to evaluate the petition for a grant or deny decision. ODI analyzed complaint data provided by CAS as well as complaints submitted to ODI from consumers. In total, there were 296 complaints submitted by the petitioner in the original petition and five supplements, including 271 complaints related to the subject vehicles equipped with TIPM-7. Approximately 3 percent of CAS complaints are related to vehicles equipped with TIPM-6 and ODI?s review of these complaints did not identify any safety defect trends. ODI conducted a detailed review of complaints narratives submitted by CAS and consumers including careful analysis of vehicle repair histories, warranty claims obtained from the manufacturer and any available Customer Assistance Inquiry reports (CAIR). Analysis of the field data indicated that MY2011-2013 Jeep Grand Cherokee and Dodge Durango vehicles exhibited significantly higher complaint rates related to fuel pump relay (FPR) failures than other subject vehicles. In a September 3, 2014 letter to NHTSA, Chrysler submitted a Defect Information Report (DIR) identifying a defect in the FPR within the TIPM-7 which can result in a no start or stall condition in approximately 188,723 model year (MY) 2011 Jeep Grand Cherokee (WK) and Dodge Durango (WD) vehicles manufactured from January 5, 2010 through July 20, 2011 (14V-530).In a February 24, 2015 letter, Chrysler submitted a second DIR expanding the scope of the FPR defect condition to include an additional 338,216 MY 2012 through 2013 Jeep Grand Cherokee vehicles manufactured from September 17, 2010 through August 19, 2013 and MY 2012 through 2013 Dodge Durango vehicles manufactured from January 18, 2011 through August 19, 2013 (15V-115).ODI analysis of the CAS allegations of TIPM defects resulting in stall while driving, airbag non-deployment, unintended acceleration, fire and other faults identified a single defect condition related to 1 of over 60 different circuits in the TIPM assembly. The most common effect of this defect condition, related to the fuel pump relay, was a no-start concern, but it could also result in stall while driving (76 complaints). No valid evidence was presented in support of claims related to airbag non-deployment, unintended acceleration or fire resulting from TIPM faults and these claims were found to be wholly without merit based on review of the field data and design of the relevant systems and components.Except insofar as the petitioner's contentions relate to the defect condition addressed by the Chrysler recalls, the factual bases of the petitioner's contentions that any further investigation is necessary are unsupported. In our view, additional investigation is unlikely to result in a finding that a defect related to motor vehicle safety exists or a NHTSA order for the notification and remedy of a safety-related defect as alleged by the petitioner at the conclusion of the requested investigation. Therefore, in view of the need to allocate and prioritize NHTSA's limited resources to best accomplish the agency's safety mission, the petition is den
RQ14002 · Air Bag Non-Deployment/Engine Stall
Opened Jun 16, 2014 · Closed Mar 2, 2015
Status: closed (inferred from source dates) · Air Bags; Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Additional source detail variants (2)
Air Bags
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972
Electrical System:ignition:module
In March 2011 Chrysler submitted a defect information report for NHTSA Recall No. 11V139 declaring a defect condition that could cause the ignition key to inadvertently move from the RUN to the ACC position on model year (MY) 2010 Dodge Journey, Grand Caravan, and Chrysler Town and Country.The report identified engine stalling as the defect consequence and cited customer complaints and warranty claims, as well as two rear-end collisions, as leading to the recall action.Chrysler determined that a defective WIN module, which is effectively the equivalent of the ignition switch, was the cause of the inadvertent key rotation, and that a new design WIN module would be installed as a remedy.In Spring 2014 ODI conducted outreach to major light vehicle manufacturers regarding ignition key position and its effect on air bag system availability.The outreach was conducted in connection with NHTSA Recall No. 14V047, a recent recall involving inadvertent ignition key rotation and subsequent air bag disablement in certain GM products.During discussions held in April 2014, Chrysler advised ODI that Chrysler air bag systems of this vintage, including the subject vehicles, revert to energy reserve when the ignition key moves to the ACC or OFF position, and that under energy reserve the air bags would only be available for a short period, approximately two tenths of a second (ODI notes this consequence was not identified in the 11V139 recall report).A review of the ODI consumer database conducted after the April 2014 discussions identified complaints alleging that MY 2008-2009 vehicles may have a similar defect as the MY 2010 vehicles, and that some MY 2010 consumers reported experiencing ignition key position concerns after the 11V139 recall remedy was applied.Accordingly this investigation was opened.In response to ODI?s information request letter, Chrysler reported that MY 2008-2009 subject vehicles used the same design WIN module as the recalled vehicles, and also identified 66 consumer reports and one non-injury crash incident potentially related to inadvertent ignition key rotation.Chrysler?s review of the MY 2010 remedy used in 11V139, which involved installation of a Trim Ring as opposed to replacement of the WIN module, showed the remedy did not adequately address ignition key position concerns, and in some use-cases could cause other systems to operate improperly (radio, instrument panel lighting, HVAC fan motor, etc.).Chrysler subsequently filed multiple defect information reports to 1) add the MY 2008-2009 Dodge Grand Caravan and Chrysler Town and Country, and the MY 2009 Dodge Journey to the original recall scope, and 2) stating that the complete WIN module would be replaced with a new design component in all recalled vehicles (including those that had the Trim Ring installed during 11V139).Chrysler?s report also advises of constrained remedy parts availability, see NHTSA Recall No. 14V373 for further details.Accordingly, the investigation is closed based on the recall action Chrysler is undertaking.The ODI reports cited above can be reviewed online at http://www-odi.nhtsa.dot.gov/owners/SearchNHTSAID under the following identification numbers: 10584873, 10583399, 10573295, 10566365, 10546805, 10513060, 10509284, 10503121, 10496599, 10475027, 10456099, 10450629, 10443680, 10422766, 10410447, 10409269, 10402947, 10402751, 10402660, 10396943, 10394957, 10356632, 10315972